Ford Five Hundred Complaints (2006)

364 consumer complaints on file.

#10347937August 7, 2010
POWER TRAIN, VEHICLE SPEED CONTROL
ON JULY 17, 2010, MY 2006 FORD 500 BEGAN TO LURCH/SURGE FORWARD/ BACKWARD DEPENDING ON WHETHER I WAS IN DRIVE OR REVERSE. TOOK THE CAR TO FORD IMMEDIATELY. THEY REPROGRAMMED THE PCM. IT WAS NOT COVERED BY THE EXTENDED WARRANTY. YESTERDAY, AUGUST 6, 2010, MY CAR BEGAN DOING THE SAME THING. TOOK CAR BACK TO SAME DEALER. THEY SUGGESTED IT MIGHT BE THE THROTTLE BODY. RESEARCH SHOWING THIS IS A COMMON PROBLEM WITH THIS VEHICLE (AND HAS BEEN FOR SOME TIME). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10346894August 2, 2010
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. THE CONTACT WAS DRIVING AT 45 MPH. THE CONTACT DEPRESSED THE BRAKE PEDAL AND WHEN RELEASED, THE VEHICLE BEGAN TO ABNORMALLY ACCELERATE. IN ADDITION, THE VEHICLE WOULD ABNORMALLY JERK WHEN ATTEMPTING TO PARK. THE DEALER ADVISED THAT THE THROTTLE BODY WOULD NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 44,000. THE CONSUMER STATED THE TRANSMISSION WOULD BANG INTO DRIVE AND REVERSE. THE DEALER FOUND THE THROTTLE BODY CAUSING THE ISSUE, WHICH WAS REPLACED. UPDATED 10/26/10
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10346683August 1, 2010
ENGINE AND ENGINE COOLING
PURCHASED A FORD FIVE-HUNDRED BRAND NEW IN 2006. AT LESS THAN 45K MILES THE A/C NO LONGER IS FUNCTIONAL, UNLESS DRIVEN AT HIGHER SPEEDS (SUCH AS THE CASE ON HIGHWAYS). I HAVE HAD BOTH LOW AND HIGH SIDE PRESSURE VALVES CHECKED, THERMOSTAT REPLACED, AND A/C UNIT FLUSHED TO NO AVAIL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10345833July 28, 2010
VEHICLE SPEED CONTROL
MANY MONTHS AGO MY 2006 FORD FIVE HUNDRED BEGAN JERKING FORWARD (ACCELERATING) WHEN SWITCHING GEARS FROM REVERSE TO DRIVE. OVER THE MONTHS THE PROBLEM HAS GOTTEN WORSE AND ACCELERATES VERY QUICKLY WHEN GOING INTO DRIVE GEAR. IT ACCELERATES SO QUICKLY IT COULD EASILY CAUSE ME TO RUN INTO SOMETHING. TOOK TO FORD SERVICE STATION AND TOLD THE THROTTLE (THROTTLE BODY MAYBE?) NEEDED TO BE REPLACED AND THAT IT WAS UNSAFE TO DRIVE UNTIL FIXED. THE PART IS ON BACK ORDER FOR TWO MONTHS! THE PART IS $800. NOW I'M PAYING FOR A CAR THAT I CAN'T EVEN DRIVE FOR TWO MONTHS. MANY PEOPLE HAVE COMPLAINED ONLINE ABOUT THE SAME TYPE OF PROBLEM AND APPARENTLY THERE IS A BIG PROBLEM WITH IT IF THE PART IS ON BACKORDER FOR 2 MONTHS SINCE SO MANY PEOPLE HAVE ORDERED IT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10346004July 28, 2010
FUEL SYSTEM, OTHER, POWER TRAIN
MY 2006 FORD 500 LUNGES INTERMITTENTLY WHEN SHIFTING FROM PARK TO DRIVE OR REVERSE. THE CAR WAS TAKEN TO A REPAIR SHOP WHO COULD NOT REPRODUCE THE LUNGING AND SAID NOTHING APPEARED WRONG. SINCE IT ONLY OCCURS INTERMITTENTLY, IT IS DIFFICULT TO EVEN GET IT FIXED. IT APPEARS MANY OTHER FORD 500'S ARE HAVING THE SAME PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10345230July 26, 2010
POWER TRAIN:AUTOMATIC TRANSMISSION
I OWN A 2006 FORD FIVE HUNDRED. CAR SURGES FORWARD EVEN WHEN THE BRAKE PEDAL IS PRESSED. IT DOES THIS IN REVERSE ALSO - EVEN WHEN THE BRAKE PEDAL IS PRESSED. I HAVE FOUND THAT THE CAR DOES THIS MAINLY WHEN THE AIR CONDITIONING IS TURNED ON. IT IS EXTREMELY DANGEROUS TO TRY TO PARK THE CAR WHEN THE AIR CONDITIONING IS ON. THE CAR SURGES FORWARD AND I HAVE ALMOST RUN INTO OTHER CARS WHEN TRYING TO PARK. THE DEALER RETRIEVED THE CODE FROM THE COMPUTER. THEY APPLIED THE LATEST UPDATES TO THE COMPUTER AND CLEARED THE CODE. THE DEALER TOLD ME IF THAT DID NOT SOLVE THE PROBLEM, I WOULD HAVE TO GET A NEW THROTTLE BODY AT APPROX. $400. SEVERAL WEEKS HAVE GONE BY AND THE PROBLEM IS GETTING WORSE. IT IS SCARY! I CALLED THE DEALER AND ASKED THEM TO ORDER A NEW THROTTLE BODY. IT APPEARS TO BE ON BACKORDER UNTIL 8/31/10. SO I AM ON A WAITING LIST. THIS IS A MAJOR SAFETY PROBLEM THAT FORD MOTOR COMPANY NEEDS TO TAKE CAR OF. THIS SHOULD BE A RECALL!!! FORD MOTOR COMPANY SHOULD MAKE THIS RIGHT. I AM DISAPPOINTED IN FORD. I HAVE OWNED FORD VEHICLES FOR 20 YEARS AND HAVE NEVER BEEN SO DISSATISFIED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10342273July 9, 2010
ENGINE AND ENGINE COOLING:ENGINE
MY FORD 500 HAS BEEN LUNGING FORWARD AND BACKWARD WHILE IN DRIVE AND REVERSE. IT HAS DONE IT SEVERAL TIMES IN DRIVE ALMOST CAUSING ME TO HIT THE CAR IN FRONT OF ME. IT DOES ESPECIALLY WHEN THE AIR CONDITIONER IS ON. I HAVE NOT HAD THE CARE REPAIRED AS OF THIS DATE. RESEARCH SHOW THAT THIS CURRENTLY HAPPENING TO MORE THAN A NORMAL AMOUNT OF FORD 500 OWNERS. I HAVE EMAIL FORD ABOUT THIS PROBLEM AND I AM WAITING ON A RESPONSE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10342041July 8, 2010
VEHICLE SPEED CONTROL
TL*THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE VEHICLE SURGED FORWARD WHILE HIS FOOT WAS ON THE BRAKE PEDAL. THE RPMS ALSO INCREASED AND CAUSED THE VEHICLE TO LUNGE FORWARD. WHEN THE VEHICLE BEGAN TO SLOW DOWN THE RPMS INCREASED AND CAUSED THE VEHICLE TO STALL. THE DEALER STATED THAT THE FAILURE WAS CAUSED BY THE THROTTLE BODY. THE DEALER ALSO STATED THAT AT THIS TIME FORD DOES NOT HAVE THE PART TO REPAIR THE VEHICLE. THE CONTACT DID NOT HAVE THE VIN WHEN THE COMPLAINT WAS FILED. THE FAILURE MILEAGE AND CURRENT MILEAGES WERE 74000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10340755June 30, 2010
POWER TRAIN
WHEN SHIFTING INTO GEAR, OR WHEN TAKING FOOT OFF OF BRAKE AFTER SITTING FOR A BRIEF PERIOD, CAR LUNGES FORWARD (OR BACKWARDS) WITHOUT TOUCHING THE GAS PEDAL. THIS HAS CAUSED MANY NEAR ACCIDENTS INVOLVING BUILDINGS, OTHER AUTOS, AND PEDESTRIANS, VERY VERY DANGEROUS. FORD DEALERS CLAIM THEY CAN NEVER DUPLICATE THE PROBLEM WHILE IT IS IN THEIR SHOP. SOMEONE IS GOING TO GET HURT DUE TO FORD AND THEIR INABILITY TO DO THE RIGHT THING AND MAKE PROPER REPAIRS AT THEIR EXPENSE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10335095June 7, 2010
VEHICLE SPEED CONTROL
TL*THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE SHIFTING INTO REVERSE OR DRIVE, THE ENGINE WOULD REV AND MOVE BACKWARD AT A QUICK RATE. ALSO WHEN IDLING IN TRAFFIC, IF THE CONTACT TURNED THE STEERING WHEEL LEFT OR RIGHT, THE ENGINE WOULD ALSO REV AND SHE WOULD HAVE TO DEPRESS THE BRAKE PEDAL WITH GREAT FORCE TO KEEP THE VEHICLE FROM HITTING ANOTHER ONE. THE VEHICLE STALLED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP WHERE THE CONTACT WAS INFORMED THAT THE THROTTLE BODY NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS APPROXIMATELY 62,000. THE CURRENT MILEAGE WAS APPROXIMATELY 99,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10332788May 26, 2010
ELECTRICAL SYSTEM:WIRING: REAR COMPARTMENT/TRUNK
REFERENCE ORIGINAL VOQ#10301954. MY CAR HAD A FIRE IN THE TRUNK WHILE WE WERE DRIVNG. THE TRUNK WAS LOADED WITH CLOTHES AND OTHER ITEMS. A FIRE OCCURED AND TOTALED THE CAR. UPON INSPECTION BY A FIRE FORENSIC INVESTIGATOR, IT WAS DETERMINED THE FIRE ORIGINATED FROM A WIRING HARNES ON THE RIGHT REAR SIDE OF THE TRUNK THAT GOES TO THE REAR LIGHTS. THE WIRING HARNESS CHAFED AGAINST THE BODY CAUSING A SHORT TO GROUND THAT LED TO THE FIRE.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10330711May 16, 2010
STRUCTURE
WHENEVER IT RAINS, THE REAR DOORS FILL UP WITH WATER. YOU CAN ONLY GET SO MUCH WATER OUT SO IT PROBABLY IS FORMING MOLD AND RUSTING THE CAR DOOR FROM THE INSIDE. THIS HAS BEEN GOING ON FOR THE LAST COUPLE YEARS WHENEVER IT RAINS OR THE CAR IS WASHED IN THE CARWASH. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10329521May 10, 2010
STRUCTURE:BODY
EVERY TIME IT RAINS, MY REAR PASSAGE DOOR FILLS WITH WATER. WHEN THERE IS A HEAVY RAIN, WATER ALSO GOES INTO THE PASSENGER FRONT FLOOR PAN AREA. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10329487May 9, 2010
STRUCTURE:BODY:DOOR
THE 2006 FORD 500 WE OWN HAS PROBLEMS WITH BOTH REAR DOORS. WHENEVER IT RAINS, THE DOORS FILL UP WITH WATER AND IT'S ALMOST IMPOSSIBLE TO GET THE WATER OUT. SOME CAN BE RELEASED BY SHAKING THE DOOR BUT MOST STAYS IN THE DOOR. I AM WORRIED ABOUT MOLD FORMING AS WELL AS FAILURE OF THE ELECTRONIC WINDOWS AND DOOR LOCK MECHANISMS. THIS HAS BEEN OCCURRING FOR SOME TIME. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10328068April 29, 2010
STRUCTURE:BODY, STRUCTURE:FRAME AND MEMBERS
THE REAR PASSENGER DOOR OF MY 2006 FORD 500 FILLS WITH WATER EVERYTIME IT RAINS. I CANNOT FIND WAY TO RELEASE THE WATER AND THE DOOR IS VERY HEAVY NOW. I AM WORRIED THE DOOR WILL BE DAMAGED AND MY BABY'S CAR SEAT IS NEXT TO IT. I ACTUALLY NOTICED WATER IN THE DOOR QUITE SOME TIME AGO, BUT JUST REALIZED HOW BAD IT HAS GOTTEN AFTER OUR LATEST BAD THUNDERSTORMS/HEAVY RAINS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10324517April 8, 2010
PARKING BRAKE, SERVICE BRAKES, HYDRAULIC
REAR BRAKES PREMATURELY WEAR DOWN TO LESS THAN 2MM OF PAD REMAINING AFTER 11K MILES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10317077March 5, 2010
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. THE THROTTLE BODY DOES NOT OPERATE NORMALLY WHEN DRIVING AT 30 MPH. THE VEHICLE WILL DRAG AND WHEN THE ACCELERATOR PEDAL IS DEPRESSED THERE IS NO ACCELERATION. AT 15 MPH A WARNING LIGHT WILL ILLUMINATE BEFORE THE VEHICLE REDUCES SPEED. THE CHECK ENGINE LIGHT STAYS ON ALL THE TIME. THE VEHICLE WAS TAKEN TO THE DEALER TWICE AND THEY STATED THEY HAVE CHECK AND RECHECKED AND ARE UNABLE TO REMEDY THE FAILURE. THE VEHICLE WAS ALSO TAKEN TO TWO ANOTHER DEALER AND THE CONTACT WAS TOLD THAT IT IS THE THROTTLE BODY AND IT WILL COST $1000 FOR REPAIRS. THE FORD MANUFACTURER WAS NOT CALLED IN REGARDS TO THIS FAILURE. THE FAILURE MILEAGE WAS 68,000 THE CURRENT MILEAGE IS 88,000. UPDATED 4/23/10 *CN THE CONSUMER STATED THE ACCELERATION PROBLEMS WERE NOT CORRECTED BY CHANGING THE THROTTLE. UPDATED 05/28/10. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10311337February 17, 2010
AIR BAGS, SERVICE BRAKES, HYDRAULIC
TRAVELING SOUTH ON I-26 ACROSS THE TN/NC BORDER THROUGH SAM'S GAP ON A SNOWY DAY LED ME TO DRIVE VERY SLOW AND COME TO A STOP AT THE TRUCK INFORMATION AREA AT THE TOP OF THE HILL. WHEN I SAW A LARGE TRANSFER TRUCK PULL OUT ONTO THE ROAD AND PROCEED DOWN THE HILL I FELT IT WAS SAFE TO FOLLOW. THIS TRUCK WAS MOVING A LOT FASTER THAN I WAS AND I WAS "COVERING THE BRAKE" AND TAPPING IT OCCASIONALLY DOWN THE STEEP INCLINE, BUT THERE WAS ICE ON THE ROAD AND WHEN I TAPPED THE BRAKES THE CAR BEGAN TO SPIN AND HIT THE CONCRETE MEDIAN ON ALL 4 CORNERS OF THE VEHICLE WITH PRETTY STRONG FORCE. THE SEAT BELT CORRECTLY LOCKED DOWN ON THE DRIVER SIDE, BUT THE AIR BAG DID NOT DEPLOY PROPERLY. THE AIR BAG LIGHT WAS ILLUMINATED AND I COULD SMELL LIKE SOMETHING WAS BURNING. I ASSUMED THIS WAS THE COMPOUND USED IN THE AIR BAG. WHEN THE POLICE ARRIVED, I WAS GIVEN A CITATION FOR DRIVING TOO FAST FOR THE CONDITIONS AND ANOTHER BECAUSE THE INSURANCE RECENTLY LAPSED. THE TOW TRUCK DRIVER TOOK THE CAR TO THE BOTTOM OF THE HILL (DRIVING TOO FAST FOR THE CONDITIONS BY THE WAY) AND DECLARED THE CAR DRIVABLE SINCE THERE WERE NO FLUIDS LEAKING AND THE CAR WOULD STILL CRANK. THE FUEL SYSTEM HAD TO BE RESET, BECAUSE IT CORRECTLY SHUT OFF DUE TO THE IMPACT. THE SEATBELT WAS LOCKED DOWN COMPLETELY AND WOULD NOT RELEASE. SINCE THERE WAS NO SNOW BEYOND THE SAM'S GAP AREA, I DECIDED TO DRIVE HOME AND PARK THE CAR BECAUSE I DID NOT HAVE MONEY FOR A HOTEL OR FOR ADDITIONAL TOWING AND THE PERSON AT THE NC WELCOME CENTER SAID WE WERE EXPERIENCING BLIZZARD CONDITIONS. SO RATHER THAN FREEZE TO DEATH OR ASK SOMEONE ELSE TO PUT THEMSELVES IN DANGER TO COME GET ME I DROVE HIM WITH THE AIRBAG / SEATBELT LIGHTS ALARMING. THE BODY SHOP PERSON I SPOKE WITH SAID THAT I NEEDED TO DETERMINE WHAT IS WRONG WITH THE RESTRAINT/AIRBAG SYSTEM BEFORE THEY CAN WORK ON IT BECAUSE OF THE RISK OF THE SYSTEM DEPLOYING WITHOUT WARNING. *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10301954January 22, 2010
ELECTRICAL SYSTEM
1. TRAVELING OUT OF TOWN ON A SPECIAL 40TH ANNIVERSARY CELEBRATION IN A 2006 FORD 500( HAS APPRX. 64,000 MILES ON IT). 2. WHILE TRAVELING WE NOTICE THE SMELL OF SMOKE, THOUGHT IT WAS COMING FROM A SOURCE OUTSIDE, NO SMOKE IN VEHICLE, PULLED OVER TO INVESTIGATE, LOOKED UNDER THE HOOD AND THERE WAS NO SMELL OF SMOKE, PROCEEDED TRAVELING AND THE SMELL OF SMOKE CONTINUE, PASSENGER NOTICE A SMALL AMOUNT OF SMOKE COMING FROM THE TRUNK WHILE LOOKING AT THE REAR WINDOW, DRIVER PULLED OVER AND POPPED THE TRUNK, THE VEHICLE BECAME ENGULFED IMMEDIATELY...80-85% OF CAR WAS DESTROYED. 3.NOTHING. FORD DEALERSHIP THAT HAS SERVICED THE VEHICLE ( OVER 25 TIMES DURING OWNERSHIP) IS DENYING ANY RESPONSIBILITY. *TR UPDATED 05/26/10 *BF ACCORDING TO THE FIRE REPORT, THE FIRE'S ARE OF ORGIN WAS IN THE REAR SECTION OF THE VEHICLE. UDATED 06/17/10 *JB
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10297510December 30, 2009
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 2006 FORD FIVE HUNDRED. WHILE DRIVING APPROXIMATELY BETWEEN 45-50 MPH HE APPLIED PRESSURE TO THE ACCELERATOR PEDAL, BUT THE VEHICLE WOULD NOT ACCELERATE. THEN THE VEHICLE BEGAN TO RAPIDLY ACCELERATE. THE FAILURE OCCURRED FREQUENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION. THE FAILURE WAS RELATED TO THE THROTTLE BODY. THE TECHNICIAN STATED THE PART WAS UNAVAILABLE UNTIL JANUARY 22,2010. THE FAILURE MILEAGE WAS 45,800. THE CURRENT MILEAGE WAS 46,200.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Five Hundred