Ford · Model Report
Showing safety data for the 1996 model year only.
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE CERTIFICATION LABELS ON THE INVOLVED VEHICLES HAS INCORRECT REAR TIRE INFLATION PRESSURE DESIGNATIONS. THIS DOES NOT COMPLY WITH FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
THE CROSSMEMBER FRAME GUSSETS WERE INSTALLED WITH UNDERSIZED THREADED FASTENERS FOLLOWING A BREAKDOWN OF THE PRODUCTION RIVET GUN THAT IS GENERALLY USED. THIS GUSSET IS THE ATTACHMENT POINT FOR THE REAR STRAP OF THE MID-SHIP FUEL TANK.
TL* THE CONTACT OWNS A 1996 FORD F-350. THE CONTACT STATED THAT AIR WAS CONSTANTLY LEAKING FROM THE TIRES. THE DEALER STATED THAT THE RIMS WERE DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 97,000.
No injuries · No fire · No crash
I HAVE A FORD F-350 7.3L TURBO DIESEL. WHILE DRIVING ON THE FREEWAY AT 70 MPH., THE CHECK ENGINE LIGHT CAME ON AND THE ENGINE POWER WAS REDUCED BY HALF. AFTER I PULLED OVER THE LIGHT WENT OUT AND THE ENGINE RETURNED TO NORMAL. TWO WEEKS LATER THE SAME THING HAPPENED AGAIN. I TOOK IT TO A MECHANIC WHO FOUND THE FUEL FILTER, THE FUEL PUMP, AND THE FUEL PICKUP SCREENS CLOGGED WITH RESIDUE FROM THE LINER OF THE FUEL TANKS. *TR
No injuries · No fire · No crash
CRACKING SIDEWALLS CAUSING BLOWOUT WHILE DRIVING BOTH DRIVERS SIDE AND PASS. SIDE. *TR
No injuries · No fire · No crash
1. BEGAN SMELLING DIESEL FUEL IN CAB. THEN NOTICED DRIPS ON DRIVEWAY. 2. WENT TO SAWGRASS FORD ON DATE BELOW WHERE I WAS TOLD THIS IS THE FUEL FILTER/WATER SEPARATOR DRAIN VALVE, AND IT IS HAPPENING FREQUENTLY AND PART IS ON BACK-ORDER. THEY SAW LEAK IS ALMOST A STREAM ESPECIALLY WITH ENGINE RUNNING. 3. TWO WEEKS AND NO CALL FROM DEALER. *TR
No injuries · No fire · No crash
ON 1/30/09 I EXPERIENCED A FIRE IN THE ENGINE COMPARTMENT ON MY FORD F-350 DUE TO A FAULTY SPEED CONTROL DEACTIVATION SWITCH. I JUST HAPPENED TO WALK OUT TO THE VEHICLE THAT WAS PARKED IN MY DRIVEWAY, NOT RUNNING, TO SEE A GLOW UNDERNEATH THE TRUCK. I OPENED THE HOOD AND REALIZED THAT THERE WAS A FIRE COMING FROM THE BRAKE MASTER CYLINDER. AFTER EXTINGUISHING THE FIRE, AND BURNING MY HANDS, I COULD SEE THAT THE RESERVOIR WAS MELTED AND THE SPEED CONTROL DEACTIVATION SWITCH IS WHERE THE FIRE WAS COMING FROM. *TR