Ford F-150 Complaints (2002)

821 consumer complaints on file.

#10628366August 26, 2014
UNKNOWN OR OTHER
TL* THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT STATED THAT WHILE PARKED, THE VEHICLE IGNITED INTO FLAMES. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE VEHICLE WAS DESTROYED AND REMAINED AT THE RESIDENCE. THE VIN WAS UNAVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10626514August 20, 2014
VEHICLE SPEED CONTROL
WHILE DRIVING ON THE HIGHWAY, I PUSHED THE ON BUTTON FOR THE CRUISE CONTROL AND PUSHED THE SET/EXCEL BUTTON AT 70 MPH. AFTER A MINUTE OR SO I LOOKED DOWN AND WAS GOING 75 AND ACCELERATING. I TAPPED THE BREAK WHICH HAD NO EFFECT. I TAPPED THE BREAK SEVERAL MORE TIME BUT THE TRUCK KEPT ACCELERATING. I PUSHED THE OFF BUTTON SEVERAL TIMES WHILE CONTINUING TO PUMP THE BREAK. THE CRUISE CONTROL FINALLY WENT OFF. SEVERAL MILES DOWN THE ROAD I TRIED TO USE THE CRUISE CONTROL AGAIN WITH THE SAME RESULTS. MY TRUCK IS A 4.2L V6 AND HAS HAD THE RECALL TAKEN CARE OF SEVERAL YEARS AGO. THIS APPEARS TO HAVE HAPPENED TO SEVERAL OTHER PEOPLE AND COULD HAVE HAD A DISASTROUS OUTCOME. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10626614August 20, 2014
ENGINE, VEHICLE SPEED CONTROL
ON MARCH 22, 2014, THE TRUCK WAS PARKED IN A LOCAL PARKING LOT, THE IGNITION KEY WAS REMOVED AND THE TRUCK WAS LOCKED. THE DRIVER RETURNED TO THE TRUCK TO FIND THAT WHILE IT WAS PARKED, A FIRE HAD BEGUN IN THE ENGINE COMPARTMENT OF THE TRUCK, AND THE FIRE DEPARTMENT AND POLICE DEPARTMENT WERE ON THE SCENE PUTTING OUT THE FIRE. BECAUSE OF THE QUICK ACTIONS OF AN INDIVIDUAL PARKED NEARBY WHO USED A FIRE HOSE TO CONTAIN THE FIRE UNTIL THE FIRE DEPARTMENT ARRIVED, THE CABIN AND THE BODY OF THE TRUCK WERE SPARED, AND THE DAMAGE WAS LOCALIZED TO THE ENGINE COMPARTMENT. THE CAUSE OF THE FIRE WAS THE SPEED CONTROL DEACTIVATION SWITCH.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10616954July 28, 2014
ELECTRICAL SYSTEM
ODOMETER WORKED INTERMITTENTLY, SOMETIMES WOULD GO OUT AND THEN COME BACK ON. NOW NOT WORKING AT ALL. AIRBAG LIGHT STAYS ON. UPDATED 4/24/2015 *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10614561July 18, 2014
ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY
TL* THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT STATED THAT WHILE AT A STOP, THERE WAS AN ABNORMAL NOISE COMING FROM THE ENGINE WITHOUT WARNING. THE CONTACT MENTIONED THAT THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE RADIATOR SUPPORTS WERE RUSTED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 73,000 AND THE CURRENT MILEAGE WAS 74,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10610469July 14, 2014
SERVICE BRAKES
TL* THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT STATED THAT THE VEHICLE CAUGHT FIRE WHILE PARKED. THE FIRE ORIGINATED AT THE BRAKE BOOSTER AREA AND SPREAD TO THE INTERIOR OF THE VEHICLE. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 193,000. UPDATED 9/18/14*CN UPDATED 2/3/2015 *JS
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10604848June 20, 2014
AIR BAGS
TL* THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT STATED THAT THE AIR BAGS FAILED TO DEPLOY AFTER A HEAD-ON CRASH OCCURRED. THE VEHICLE WAS TOWED TO AN INDEPENDENT LOT WHERE THE INSURANCE COMPANY DEEMED THE VEHICLE WAS DESTROYED. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED MINOR INJURIES AND REQUIRED MEDICAL ATTENTION. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 105,000.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10596842June 7, 2014
ENGINE
SPARK PLUG BLEW ON MY F150 KING RANCH. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10592788May 20, 2014
POWER TRAIN, SERVICE BRAKES
TL* THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT STATED WHILE DRIVING 55 MPH, THE BRAKE PEDAL BECAME STUCK AND THE VEHICLE ACCELERATED TO 70 MPH. WHEN THE VEHICLE VEERED TO THE RIGHT IT RESUMED TO A NORMAL SPEED OF 55 MPH. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT AND OFFERED NO REMEDY. THE FAILURE WAS NOT DIAGNOSED. THE FAILURE MILEAGE WAS 200,000. THE VIN WAS NOT AVAILABLE. THE CURRENT MILEAGE WAS 275,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10586315May 3, 2014
SEATS, SEAT BELTS
DRIVERS SEATBELT UNLATCHED. HAPPENS OFTEN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10583166April 16, 2014
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT STATED THAT WHILE PARKED, THE VEHICLE BURST INTO FLAMES AFTER THE ALARM SOUNDED. THE CONTACT PERSONALLY EXTINGUISHED THE FLAMES. THE VEHICLE WAS DESTROYED. THE CONTACT ALSO MENTIONED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER 05V388000 (VEHICLE SPEED CONTROL). THE VEHICLE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 138,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10578127April 7, 2014
ENGINE
ON MORE THAN ONE OCCASION SPARK PLUG AND COIL FOR #4 CYLINDER HAS BLOWN OUT. FEW TIMES I WAS ABLE TO TIGHTEN DOWN THE PLUG AND REPLACE THE COIL. LAST TIME IT HAPPENED IT MESSED UP THE THREADS. HAD TO BUY A SPECIAL PLUG TO PUT IN ALONG WITH A RETHREAD PART. NOW I CAN NOT EVERY REPLACE THAT SPARK PLUG DO TO HAVING THE THREADING HOUSING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10573475March 19, 2014
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 2002 FORD F150. THE CONTACT STATED THAT THE VEHICLE WAS PARKED AND NOT OPERATING WHEN IT CAUGHT ON FIRE. THE FIRE DEPARTMENT WAS ABLE TO EXTINGUISH THE FIRE. THE CONTACT INDICATED THAT THE VEHICLE WAS DESTROYED AND ONLY THE BED OF VEHICLE REMAINED. NO ADDITIONAL INFORMATION WAS AVAILABLE REGARDING THE INCIDENT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 150,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10573041March 18, 2014
SEAT BELTS
TL* THE CONTACT OWNS A 2002 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE DRIVER'S SIDE SEAT BELT BUCKLE INDEPENDENTLY UNLATCHED. THE BUCKLE WOULD NOT REMAIN CLOSED EVEN AFTER SEVERAL ATTEMPTS. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 131,600.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10564953February 19, 2014
ENGINE
TL* THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 65-75 MPH, THE ENGINE WOULD HESITATE THEN SURGE FORWARD WHEN THE CONTACT WAS ATTEMPTING TO ACCELERATE. THE FAILURE WAS RECURRING. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC, WHO STATED THAT THE EGR SENSOR WOULD NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURE WAS NOT ALERTED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 58,730. THE VIN WAS NOT AVAILABLE. . ..UPDATED 03-12-14 *BF
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10561630January 27, 2014
ENGINE
ENGINE THREW A SPARK PLUG OUT OF THE HOLE, BROKE THE MOUNT FOR THE COIL PACK. THIS IS THE THIRD TIME I HAVE HAD THIS ISSUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10560585January 19, 2014
SERVICE BRAKES, WHEELS
FRONT BRAKE CALIPER MOUNTING BRACKET SEIZED ON THE SLIDE BOLTS THAT ALLOW THE BRAKES TO MOVE IN AND OUT WHEN PRESSED AND RELEASED. THE SLIDE BOLTS THAT ALLOW THE CALIPER TO MOVE HAVE SEIZED CAUSING THE VEHICLE TO PULL VERY HARD TO ONE SIDE OF THE ROAD. IN MY CASE I WAS TOWING A 20' COMMERCIAL LANDSCAPE TRAILER EQUIPPED WITH DUAL AXLE TRAILER BRAKES. I APPROACHED A TRAFFIC LIGHT AND PROCEEDED TO MAKE A LEFT TURN GOING A SPEED OF APPROXIMATELY 15 TO 20 MPH WHEN I PRESSED THE BRAKE DURING THE TURN THE TRUCK PULLED EXTREMELY HARD TO THE LEFT RESULTING IN MY TRAILER JACK KNIFING INTO THE LEFT SIDE OF THE TRUCK CAUSING MAJOR DAMAGE TO MY BED AND REAR WHEEL ON MY TRUCK. LATER AFTER INVESTIGATING THE CAUSE OF THE SUDDEN PULL FOUND THAT THE LEFT BRAKE CALIPER MOUNTING BRACKET HAD ONE OF THE BOLTS SEIZED WHILE THE OTHER WAS MOVING PROPERLY ALLOWING THE BRAKE TO MOVE A LITTLE BUT NOT PROPERLY CAUSING THE BRAKE TO DRAG AGAINST THE ROTOR ON THE INNER BRAKE PAD. WHEN THE BRAKE IS PRESSED THE PRESSURE PULLS THE TRUCK TO THE LEFT EXTREMELY HARD. REPLACING THE SLIDE BOLTS AND THE BRAKE CALIPER MOUNTING BRACKET FIXED THIS ISSUE AND I HAVEN'T HAD ANY ISSUES AFTER REPLACEMENT. I KNOW THIS MAY BE A LITTLE HARD TO UNDERSTAND AS MY DESCRIPTION MAY NOT BE THE BEST, BUT THE UPPER BRAKE CALIPER BOLT WAS SEIZED WHILE THE LOWER BOLT WAS MOVING FREELY, WHEN THE BRAKE PEDDLE WAS PRESSED CAUSED THE LEFT BRAKE CALIPER TO GRAB HARDER THAN THE RIGHT SIDE CAUSING THE TRUCK TO PULL EXTREMELY HARD TO THE LEFT. THE TRAILER BRAKE WAS SET ON 7 AT THE TIME AND WORKED PROPERLY. THE TRUCK PULLED SO HARD TO THE LEFT CAUSED THE TRAILER TO BE AT SUCH A TIGHT ANGLE IT BEGAN TO SLIDE AND WHEN I REALIZED WHAT WAS HAPPENING IT WAS TO LATE TO CORRECT IT. THE BED IS STILL DAMAGED FROM THIS. BTW I BOUGHT MY FORD IN 2002 BRAND NEW WITH 5.4 V8 AND I AM AT 271,000 MILES AND IT RUNS LIKE THE DAY I PURCHASED IT! I LOVE IT! *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10555086December 6, 2013
ENGINE
TL* THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE VEHICLE MADE A LOUD NOISE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THERE WAS A BLOWN SPARK PLUG THAT NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 170,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10554836December 4, 2013
FUEL/PROPULSION SYSTEM
THE SPARK PLUG BLEW OUT OF THE ENGINE AND CAUSED THE ENGINE TO BECOME DAMAGED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10552997November 19, 2013
SEAT BELTS
I'M JUST DRIVING DOWN THE ROAD AND THE SEATBELT RELEASES ON ITS OWN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150