Ford F-150 Complaints (2016)

2,093 consumer complaints on file.

#11683676August 28, 2025
LATCHES/LOCKS/LINKAGES
The contact owns a 2016 Ford F-150. The contact stated that on several occasions while driving at various speeds, all four doors unexpectedly opened. The vehicle was initially taken to a dealer, where it was diagnosed and determined that the four-door latches were faulty and needed to be repaired or replaced. The vehicle was repaired, but the failure recurred approximately four years later while making a right turn, and the driver's door unexpectedly opened. The contact stated that wearing the seat belt had potentially prevented him from falling out of the vehicle. The contact had to hold the door closed while driving until safely arriving at the residence. The vehicle was then taken to the same dealer, where it was determined that the driver’s door latch needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 70,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11683785August 28, 2025
POWER TRAIN
Transmission shift radically and causing car to jump like running over something. When hauling transmission might down shift from 5th speed to 2nd speed at 50-60 miles per hour.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11683357August 27, 2025
POWER TRAIN
My wife and toddler were returning from dropping off our older child at school this morning. As she approached an intersection, the rear wheels suddenly seized, causing an abrupt stop. A transmission failure code flashed on the digital gauges. The engine shut off, but the electronics remained on, as if in accessory mode. She was able to turn the truck off and then back on, which seemed to reset the system and allow her to drive forward.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11682738August 24, 2025
ENGINE, POWER TRAIN
My truck has 140,000 miles and I have maintained it to the specs provided by Ford My vehicle began to unexpectedly overheat when I was in 6th gear cruising at a low RPM. I had the coolant fluid tested for exhaust gasses. Exhaust gasses were detected and it was determined I had a blown head gasket. After taking to mechanics, other owners all over the internet, and Ford dealership employees at the dealership I purchased ny truck from. Everyone said the same thing. The 2.7L EcoBoost motor is prone to blowing a head gasket. My own father who has the same truck, just a younger older than mine decided to just replace the whole motor because he too blew a head gasket. This head gasket issue is pervasive and I would not be surprised if over 20% of this generation of motor has the same problem. I
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11682466August 22, 2025
STRUCTURE:BODY, SUSPENSION
The frame is rotting through. It was on a lift for a new starter; this resulted in the frame bending. It will not pass inspection. Ford refuses to repair /replace the frame as it is past their 5 year rust warranty. The vehicle has only 15000 miles. It has never been immersed in fresh or saltwater. The undercarriage has been sprayed off regularly when driven in the winter.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11682201August 21, 2025
POWER TRAIN
Truck went into an uncontrolled downshift from fifth to first gear while in traffic, causing a large speed reduction in traffic. Risk of being rearended by driver behind me. Dealer confirmed this issue was due to connections in transmission shorting out due to exposed connections and particles in transmission fluid (same as 2014 F-150 recall). There was no warning that this was going to occur. Wrench light came on when it occurred. Part is not available for inspection.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11682222August 21, 2025
BACK OVER PREVENTION
The contact owns a 2016 Ford F-150. The contact stated that on several occasions, while activated, the rear-view camera started flashing, with stripes going from the top of the screen to the bottom of the screen. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 140,785.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11681915August 20, 2025
UNKNOWN OR OTHER
2016 F150, 6R80 Transmission - threw codes P0720 and P0722, dealer indicated known issue under recall 24S37, but my VIN is not included, but should be. Unexpected downshift to first gear, check engine light, truck enters "limp" mode, only allowing 3rd and 5th gear - real safety issue - especially if Ford knows it has a fix - although parts are in short supply (molded lead frame)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11681613August 19, 2025
POWER TRAIN
Lead frame issue where truck downshifted hard as I was driving then was stuck in a higher gear. Had to have it towed into Ford for repair. Cost about $2,000
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11681615August 19, 2025
ENGINE
Engine shut off on me in the middle of the road. Found out the water pump sheared off causing the timing chain to not function properly, bending valves and requiring a engine rebuild
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11681248August 18, 2025
POWER TRAIN, STEERING, SERVICE BRAKES
While driving today, my Ford F150 manual light came on while I was driving and then break assistance. Light came on, and it told me to check the brake system. And immediately immediately the truck slammed on the brakes while driving. I almost wrecked with my [XXX] daughter who is [XXX] in the vehicle. This needs to be fixed ASAP. This is very dangerous and could’ve been a lot worse this morning. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11681304August 18, 2025
POWER TRAIN
The contact owns a 2016 Ford F-150. The contact stated that while depressing the accelerator pedal, the vehicle failed to respond as intended for several seconds before the vehicle responded as intended. The contact stated that while at a stoplight, there was an abnormal banging sound coming from the transmission. The contact stated that the 4-WD warning light was illuminated. A dealer was contacted. The vehicle was taken to the dealer to be diagnosed; however, the result was not provided. The vehicle was not repaired. The manufacturer was notified of the failure and opened a case. The approximate failure mileage was 144,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11681361August 18, 2025
POWER TRAIN
Transmission has a shutter issue with torch converter. Shops are indicating this is a known issue and some models have had previous recalls for our year but our VIN is not showing a recall for that. It does have a power train control module recall # 24E03
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11680300August 13, 2025
ENGINE
My manifolds have warped on my truck and is a common issue with Ford trucks. They use 8 bolts instead of 11 and know this will eventually cause the manifolds to warp. The dealership wants $5200 to fix it. Its not affordable so will have to drive it. Unfortunately exhaust can get into the passenger area and is dangerous. This has to be covered as Ford knew it would happen then gouge the consumer and could harm them. Thank you! [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11679780August 11, 2025
ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER
Odometer Fraud. The contact purchased a 2016 Ford F-150. The contact discovered a mileage discrepancy after purchasing the vehicle. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 136,900. The contact later discovered that the mileage on the title was 189,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11679838August 11, 2025
POWER TRAIN
The contact owns a 2016 Ford F-150. The contact stated that while driving at various speeds, the transmission unexpectedly downshifted to first gear with the gear shifter indicator light flashing. The vehicle was jerking while depressing the accelerator pedal, and the contact was forced to shift into neutral(N) before shifting back to drive(D) to resume normal driving. The failure persisted until arriving at the intended destination. The dealer was notified of the failure, and the contact was informed that there were no recalls on the VIN related to the failure. The contact was referred to the manufacturer and was provided with the same information. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 158,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11678723August 6, 2025
VISIBILITY/WIPER
THE WINDSHIELD HAS TINY SPEC BETWEEN THE GLASS NOT A SCRATCH ON WINDOW OR CHIPS WHEN ITS REALY SUNNY OUT YOU CANT SEE IT REALLY HARD.THIS SHOULD BE A RECALL AT NO CHARGE.ITS AN ACCIDENT READY TO HAPPEN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11678452August 5, 2025
POWER TRAIN, ENGINE
The contact owns a 2016 Ford F-150. The contact stated that while driving at various speeds, the vehicle suddenly decelerated, and the warning messages "Service Advance Track" and "Hill Brake Assist Unavailable" were displayed. The power train warning light was illuminated. The vehicle was taken to the local dealer to be diagnosed, but the cause of the failure could not be determined. The local independent mechanic was contacted and advised the contact that the vehicle was likely experiencing a throttle body failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 132,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11678373August 4, 2025
ELECTRICAL SYSTEM
When you turn ignition off, pull key out of ignition and open driver door. The doors unlock but the tailgate will not. It won't even make the sound of it unlocking or locking. Its stuck shut, handle won't do anything.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11678010August 2, 2025
POWER TRAIN
Transmission abruptly downshifts without warning. Cluster displays wrench icon and see manual but does not store a code in OBDII. Truck runs in “limp mode” restarting seems to clear the issue. Ford states no code no problem. I have video of issue happening.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150