Ford F-150 Complaints (2022)

583 consumer complaints on file.

#11609046August 16, 2024
VISIBILITY/WIPER
The vents stop pushing air, regardless of setting, so windshield defroster does not work to clear the windshield of fog. Happens while driving and no adjustments to climate control change airflow unless I turn the car off and back on. Occurs infrequently and without clear cause. Dealership failed to reproduce the problem when I took it in.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11608998August 16, 2024
ELECTRICAL SYSTEM
While driving A/C unit will slowly stop blowing cold air. It is very random when this happens and the vehicle has to sit a for a while before it starts working again. Vehicle was purchase in August 2023 and the issue did not start until about 2 months ago and has now happened 4 times. First time I drover for hours before it happened, this last time I was only driving for 20 minutes. I think this is related to the Ford TBS 22-2089. I am just over the 36,000 mile Warranty, but under the 3 year Ford Warranty, so I will probably have to pay for this out of pocket. This should be a recall for affected vehicles as this is a very expensive fix to have on a 2 year old truck that was no fault of the owners.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11608562August 14, 2024
STRUCTURE:BODY
The contact owns a 2022 Ford F-150. The contact stated that the vent clips had detached from all the air vents. The vehicle had been taken to the dealer where the clips had been replaced under warranty; however, the failure occurred. The contact stated that the failure would occur in warmer weather. The vehicle was returned to the dealer; however, the vehicle was not repaired. The manufacturer was made aware of the failure, and it was confirmed that the VIN was not under recall for the failure or covered under warranty. The manufacturer had referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 15,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11608448August 14, 2024
POWER TRAIN
The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (Power Train); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. The VIN was not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11607698August 10, 2024
ELECTRICAL SYSTEM, EQUIPMENT:APPLIANCE:TV/RADIO/SPEAKERS
This complaint was already documented here: NHTSA ID Number: 11487857 Turned my truck on to hear a LOUD pop, scared everyone inside. Speakers continued to crackle and pop, at a lower volume. No audio or music played. Thinking it would go away, I continued out of our neighborhood. When it didn't, I stopped and turned the truck off, as well as locking the vehicle, with the same crackling noise coming from the speakers despite everything being shut off. Turned the truck back on and went through audio settings. The only thing that made it stop was switching from "Stereo" to "Surround" mode in the settings.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11607345August 8, 2024
ENGINE, FIRERELATED
The front of the truck started smoking when it was pulled over at a gas station on 07/26/2024, the hood was too hot to open, and the front of the truck proceeded to start on fire. It took the fire department 20 minutes to arrive on the scene at which point there was not much left of the front of the truck. Everyone was able to get out of the vehicle and no injuries occurred. The truck is obviously totaled, but we are unaware as what caused this truck to blow up.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11606516August 5, 2024
UNKNOWN OR OTHER
Fresh air intake cowling allows small debris to build up and does not allow consumer ability to clean/service it. This results in water backing up and spilling to AC filter and blower motor, thus leaking into passenger side of cab. Dealer and Ford state this is a non-warrantable item, and that the consumer should be aware to maintain it themselves despite being able to. Dealership also does not clean this during routine service, nor notify the consumer about it condition.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11605276July 29, 2024
UNKNOWN OR OTHER
The attached document will explain in details about the back up failing on multiple occasions and Ford Motor Company has no fixes for this at this time. It is a SAFETY concern due to the back up camera with small children around. This is the third APIM module since Jan 2024. Now Ford says tells their dealers not to do anything with them to wait until around October or November and they will send out another bulletin on how to handle this problem. Then once that is done who knows how long it take. Big Safety issue here. F150 is the number one selling truck on the road as Ford says so that makes this even a bigger issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11605010July 28, 2024
ELECTRICAL SYSTEM, EQUIPMENT:APPLIANCE:TV/RADIO/SPEAKERS
This morning, as soon as I started the vehicle and started backing down the driveway, an unbelievably loud popping sound emitted from the speakers. I immediately slammed on the brakes having no idea what had just happened. This has happened previously but have not heard in a few months so I thought the problem was corrected. It is the loudest noise I have ever experienced and is extremely dangerous as it happens at different times and is just ear splitting. My ears are still ringing and it happened at 8:45am this morning.
Crash:
No
Fire:
No
Injuries:
2
Deaths:
0
#11603924July 22, 2024
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM, VISIBILITY/WIPER
The computer/s that control every piece of equipment does not function as designed! The cruise control adjusted the speed (upward) without touching the controls. The lane keeping function will drag the truck into a turnout lane, left or right especially on a two lane highway with turn out lanes. The windshield wiper control has to be constantly manipulated to keep the windshield clean during snow and or rain storms. The instrument panel constantly changes which distracts the driver as so does the computer screen. The pre collision equipment works only sometimes. All the computers installed affect the function of other computers which causes driver distraction, like txt and driving.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11601483July 12, 2024
POWER TRAIN
Rear end differential bearing failure, second time. Result in high vibration and substantial metal flacks in differential oil. Ford reporting rebuild is required again.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11600566July 9, 2024
POWER TRAIN
The contact owns a 2022 Ford F-150. The contact stated while driving at various speeds on several occasions, the transmission would only shift from first through fourth gear and the vehicle was hesitating. There were no warning lights illuminated. The vehicle was taken to a dealer where it was diagnosed that the TCM software update needed to be performed. The vehicle was repaired but the failure persisted. The vehicle was taken to another dealer where it was diagnosed that the transmission needed to be replaced. The vehicle was repaired but the failure persisted in second gear. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 9,271.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11597324June 27, 2024
POWER TRAIN
The contact owns a 2022 Ford F-150. The contact stated that while driving at an undisclosed speed, the vehicle independently decelerated. The contact stated that the transmission shifted from 10th gear to 5th gear unexpectedly. The vehicle was taken to the dealer where it was diagnosed with a failed CDF drum assembly. The contact was informed that the CDF drum assembly needed to be replaced. The contact stated that the failure reoccurred. The contact stated while driving 80 MPH, the vehicle decelerated independently. The contact stated that the transmission shifted from 10th gear to 5th gear unexpectedly. In addition, the contact stated that several unknown warning lights were illuminated. The vehicle was taken to the dealer; however, the failure could not be duplicated. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 27,882.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11597184June 27, 2024
UNKNOWN OR OTHER
Cover for transmission/exhaust/engine on underside of vehicle tears at mount pint and hangs down and could completly tear away causing potential vehicle damge or damage to other vehicles on road. Problem is noted on internet forums as Ford's saggy diaper problem. Cover is made of a non durable foam-fabric material and is mounted by 4 screws and tears away by mount points and hangs down. This is 2nd time happening on truck, first time was replaced under warranty. Picutre is taken after I pushed it back into place but is still torn by mounting bolt and hangs down when driving. I ordered a replacement from Amazon for $99.99 and will attempt to repair myself.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11596627June 25, 2024
ELECTRICAL SYSTEM, EXTERIOR LIGHTING, VEHICLE SPEED CONTROL
Since I have purchased the 2022 Ford F-150 I have had several incidents where the cruise control has set itself. A couple incidents have resulted in me slamming on the brakes to avoid collision. I have taken it to the dealer a few times and they have replaced everything that has to do with the cruise control and it still sets itself from time to time but it's sporadic. The dash lights/instrument cluster has went completely out 2-3 time and came back on. When it does come back on the drive mode disabled light is on and I can't change the drive modes. The entertainment/map screen has froze up several time. The map will freeze and I can't change the music or do anything on the screen.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11595732June 21, 2024
POWER TRAIN
Starting at roughly 2000 on the odometer the truck began shifting very harshly, missing gears, slipping gears, lurching forward during shifts. Upon acceleration through the first four or so gears, there is a very loud "thunking" sound presumably upon shift. There have been 4-5 times I was turning across traffic at a safe distance, and the truck would not accelerate, missing several gears. I was almost hit hard several times because of the truck failing to drive. Dealership turned me away 3 times, saying they would not be able to diagnose anything without a CEL code. Since the truck doesn't throw any fault codes they would not take it in for troubleshooting or attempt to reproduce the issue. The issues were reproduced by a local shop I took the truck to for a third party opinion. The loud thunk was thought to be too low a lubricant level on the slip yoke where the drive shaft meets the transmission. The shop checked and there was sufficient lubricant. They reproduced the thunk sound driving slowly with several technicians witnessing the issue standing within sight distance. These known and reproducible issues with the 10R80 transmission and there have been an exorbitant number of reports of this behavior in owner message groups, all with the same lack of resolution. Dealerships either don't fix the issue, won't troubleshoot without a CEL code, or say the transmission is working as designed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11594597June 15, 2024
SUSPENSION, WHEELS
The wheel wells on the front of my vehicle do not properly fit the well. One has been replaced twice the other once and recently the dealer made the decision to cut the wheel wells so they would no longer rub. I was told it was the best they could do. The other choice is to keep replacing them when they fail. I am concerned that somthing from the road may fly up in their and get lodged in the exposed under section. I feel there should be another alternative but Ford doesn't want to pay to get a resolution. If those well covers were not needed they wouldn't have them n their in the 1st place. So I know they are needed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11594099June 13, 2024
FUEL/PROPULSION SYSTEM
Vehicle lost power while driving on highway requiring vehicle to be guided to shoulder. Once on shoulder, truck died and would not restart. After being towed to dealership, the vehicle was found to have a failed fuel pump. At the time of the incident, vehicle had 27671 miles on odometer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11593857June 12, 2024
STRUCTURE:BODY
Weatherstripping on sunroof is deteriorating. This could affect the safety of the driver as well as any passengers in the vehicle if it was to start leaking. Furthermore, if water entered the cabin it could affect any electrical components that might interfere with the driving of the vehicle thus causing a safety hazard to any vehicles that would be nearby if this was to happen. The vehicle was taken to the local Ford dealership on 5/29/2024 for inspection. The repair was denied because the whole sunroof would need to be replaced in order to fix the weatherstripping. No one else has looked at the weatherstripping. It was first noticed on 5/24/2024.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11592422June 4, 2024
UNKNOWN OR OTHER
Ear-splitting static-like noise upon starting the truck. Followed by loud static that would persist even when audio was turned off. Extremely distracting while driving. Took to dealer who said nothing to be done until Ford figures out a fix. Told me to keep checking back. No warning lamps or messages. I wish Ford to put a higher priority on fixing this issue. 2022 F150.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150