Ford F-150 Complaints (2021)

1,308 consumer complaints on file.

#11703294December 5, 2025
ELECTRICAL SYSTEM, SERVICE BRAKES, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
My truck thinks my parking brake is engaged so it constantly flashes the “brake” light, constantly chimes while driving and says parking break malfunction, talk to dealer. I brought it to Webber family Ford in Detroit lakes MN 56501 and they checked it over including the safety recall location for recall 23S35. They said it was not the recall location and I would have to bring it in Monday for another appointment. When I got it home that day I crawled under to check that location. I see visible green which usually means corrosion and the protection around the harness seems warm. I also noticed the "recall" was not completed how it is shown on fords recall paperwork using the zip tie as a wear location so it isn't the harness itself. That is not how mine is. I have photos to prove that. I spoke with corporate ford today and they said they can't re open the recall because it has been closed and it is past its 12 month warranty being it was done in October of 2023 before my ownership and at a different dealer. I don't believe it is fair to me the current owner to pay for the cost of a rerepair of a recall that was done incorrectly.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11703204December 5, 2025
POWER TRAIN
The contact owns a 2021 Ford F-150. The contact stated that while driving at undisclosed speeds, there was an abnormal sound coming from the rear end of the vehicle. There were no warning lights illuminated. The contact received notification of NHTSA Campaign Number: 23V896000 (Power Train). The vehicle was previously taken to the local dealer, where it was diagnosed and determined that the rear axle bolt was fractured. The vehicle was repaired, but the failure recurred. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 46,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702916December 4, 2025
POWER TRAIN
The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (Power Train); however, the part to do the recall repair was not yet available. The local dealer was contacted three times. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and informed the contact that parts would not be available until the third quarter of 2026. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702877December 3, 2025
UNKNOWN OR OTHER
The rear windshield spontaneously exploded while the vehicle was stationary. I confirmed this was not caused by any impact or debris. There have been several other reports on various websites of this issue, across multiple models including the F150 and Bronco, and potentially being caused by faulty wiring of the rear defroster. Ford has not issued a recall and will not accept responsibility for this defect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702789December 3, 2025
FUEL/PROPULSION SYSTEM
The truck stalled while driving on back road in the middle of the night we thought it was pout of gas but we still had 100 miles 2nd night same thing but had 250 miles left 3rd day while hearting up in the morning it began to sputter and then quit will not restart now Ford does not seemed concerned nor will offer any help
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702695December 3, 2025
EXTERIOR LIGHTING
The quad LED headlamps keep going out on the truck. It is the vertical side of the light that goes out. I have seen many other F150 with the same issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702437December 2, 2025
EXTERIOR LIGHTING
Daytime running lamp failure and fog light failure. Daytime running lamp failure causes poor visibility and the failure defect defeats its entire purpose for use. Fog light failure creates poor visibility during fog conditions and could result in not being visible to other drivers.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702403December 2, 2025
STRUCTURE:BODY, SUSPENSION, UNKNOWN OR OTHER
A certified independent inspection company discovered welding on the main chassis of my Ford F-150. The welding is located on the front left frame area. I purchased the vehicle brand new, and it has never been in any accident or collision. This welding on a critical structural part creates a serious safety risk. Frame integrity may be compromised in normal driving or in the event of an impact. I transport my children daily in this vehicle, and I am afraid to drive it due to the possibility of structural failure. The official Ford dealer inspected the vehicle and kept it for approximately three weeks but provided no explanation or repair. The regional Ford office has delayed their technical report for more than five months with no response. The defect has been confirmed and is permanent. No warnings or lights appeared prior to discovering the issue. This is a manufacturing-related structural defect affecting vehicle safety, stability, and integrity. A proper safety resolution is required.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702253December 1, 2025
ELECTRICAL SYSTEM
My Ford F150 was traveling on I95 North in Maryland when an emergency notice on the dashboard told be to pull over. The truck would not restart and had to be towed to a Ford dealer. I have since been told a controller module caught fire and damaged the hybrid battery and both would need to be replaced at a cost of over $10,000. This is a know issue and other Ford F150 Hybrid trucks as well as other Ford cars have already been recalled. Ford claims that my VIN was not included in the recall even though I experienced exactly what the recall was suppose to prevent. My wife and I could have been killed while traveling on the highway at 70 MPH and the vehicle was on fire without our knowledge.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11701745November 26, 2025
POWER TRAIN
The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (Power Train). The contact stated while driving at an undisclosed speed, the vehicle lost drive power in the middle of the road. The contact stated that the failure occurred while crossing a four-lane highway. The contact stated that the contact's brother and the contact's son were additional occupants of the vehicle. The contact and the contact's brother pushed the vehicle across the road to a nearby parking lot. The vehicle was towed to the dealer, where it was confirmed that the failure was due to the unrepaired recall. In addition, the contact was informed that the parts were not available. The contact stated that the vehicle had been at the dealer for more than five and a half months. The contact stated that the NHTSA.GOV website indicated that the parts were available; however, the dealer and the manufacturer advised that the parts were not available to repair the vehicle. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure, but there was no more communication from the manufacturer. The failure mileage was approximately 19,500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11701590November 25, 2025
POWER TRAIN
The transmission will downshifting and the transmission starts jerking then the engine starts missing for about 30 seconds to a minute but the ford dealership said it's not showing any codes so it's not happening now I can't get it fixed they didn't think having a vehicle that starts missing for no reason isn't a problem but the torque converter won't throw codes and it's attached directly to the crankshaft so it's messing with the engine to get it to start missing
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11700117November 18, 2025
EXTERIOR LIGHTING
DRLs have partially failed on both headlights, vehicle is available for inspection. This seems to be a common problem for similary F-150 according forums and personal observations of other vehicles. The DRLs are a safety feature and not functions DRLs create a safety issue, as on coming drivers are not able to see the vehicle as clearly. Has not been reproduced or confirmed by dealer. Has not been inspected by manufacturer, police or insurance. I did report to Ford Customer Service but was told there was nothing they could do about it. No lights, messages or warnings. Problem has been visible for a least a year, but have not experienced further failure. Only way to fix is to replace the entire headlight assembly with a total cost of around $4000 for both assemblies.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699993November 17, 2025
UNKNOWN OR OTHER
Catalytic converter has failed and needs replaced
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699900November 17, 2025
FUEL/PROPULSION SYSTEM
Fuel pump went out while driving causing the vehicle to sputtering and so running while driving up a hill. Couldn't restart and stick in park that prevented it from being moved out of roadway. Vehicle had only 64000 miles but wasn't included in recent 2025 recall that covered other vehicles with the dave fuel pump issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699709November 16, 2025
POWER TRAIN
The transmission shifts hard from 1st to 3rd during the first few minutes of operations. When I make the turn out of my resident each morning, it nearly fishtails due to the fat that the transmission stays in 1st gear until around 2500-3000 rpms, then shifts violently to 3rd gear. The tires actually spin. After a few stop and goes, and the transmission has cycled through the gears several times, it shifts normally. I have taken it to the Ford dealer in Royal Palm Beach, FL. They said that there were no recalls, despite there being several complaints from other truck owners about the same issue. Ford knows that the 10 speed transmission in the F150 has shifting issues.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699703November 16, 2025
ELECTRICAL SYSTEM, POWER TRAIN, VEHICLE SPEED CONTROL
Transmission downshift to first gear on the highway
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699365November 14, 2025
BACK OVER PREVENTION
The contact owns a 2021 Ford F-150. The contact stated the infotainment center was frozen or blacked out intermittently, preventing the contact from being able to access the cameras and systems controlled through the infotainment system. The contact received notification of NHTSA Campaign Number: 25V315000 (Back Over Prevention); however, when the dealer was contacted, it was confirmed that the vehicle was not included. A second dealer was contacted, McClary Ford Inc (1104 US Hwy 72 E, Athens, AL 35611) and it was confirmed that the VIN was not included. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 95,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699336November 14, 2025
EXTERIOR LIGHTING
right running light has went out. yes, it will be available for inspection. lack of lighting causes trouble seeing at night while driving. brought to the dealership was told they would need to change the entire headlight. that woul cost around $2000.00. (both sides are now out). from research the 2021 ford f150 running lights are known for going off. $2000.00 all the time get to be big. the running lights do dim a little right before they go completely out. the running lights are all connected to the head light. there is no way to replace the running lights with out change a $2000.00 head light. not to may people have $4000.00 to replace headlights on a 4 year old truck.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699164November 13, 2025
VISIBILITY/WIPER
The windshield wipers on my 2021 Ford F-150 are inoperable. The wipers suddenly stopped working with no warning. The vehicle had already received Recall 23S10, which was supposed to replace the defective wiper motor arm. However, the wipers have failed again, suggesting the recall remedy was inadequate or that defective components are still being used. Ford and the servicing dealer refuse to reopen the recall or provide coverage, even though this is clearly the same safety issue. Without functioning wipers, the vehicle is unsafe to drive in rain or snow. I request that NHTSA investigate whether Ford’s recall 23S10 remedy is effective and whether additional corrective action or a new recall should be issued to address continued wiper motor failures on these vehicles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699062November 12, 2025
FUEL/PROPULSION SYSTEM, ENGINE
I started smelling gas in the cabin of the truck when I came to a stop. As I was driving on the freeway I noticed my gas gauge going down rapidly. Within minutes I ran out of gas. Got the truck towed to Ford dealer. After diagnosing the issue I was made aware by Ford service department that one of the high pressure fuel injector cracked and was spraying gas out which caused me to run out of gas. With gas spraying in the engine I was at severe risk of a fire. No warning lights or messages appeared when this happened. After investigating I noticed Ford has a recall for this issue for other vehicles but not the F-150.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150