Ford Explorer Complaints (2025)

95 consumer complaints on file.

#11734781April 30, 2026
POWER TRAIN
2025 Hybrid PIU/Explorer) for a CEL with PCM codes P0A1E:00:A8 for a starter/generator control module fault.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11734777April 30, 2026
POWER TRAIN
Vehicle shut down while driving. Stop safely now, red triangle on IC, and engine disabled. PCM code P1A0C:00:28 Hybrid Powertrain Control Module - Engine Disabled.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11734686April 29, 2026
UNKNOWN OR OTHER
I was driving on the Highway and all the sudden for absolutely no apparent reason the Passenger side door window completely shattered into small bits of glass. I check the vehicle for any damage other than the window not a scratch on the door at all I have no idea what caused the window to shatter.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11729375April 6, 2026
VISIBILITY/WIPER
Front side windows (driver and passenger side) have a quality issue that creates a distorted, wave-like view when looking out the window. This results difficulty viewing objects seen in the side mirrors. Also, when viewing anything out the side windows (ie. cross traffic) the view is distorted. Further, this makes the driver and passenger nauseated. The issue is constant and does not depend of environment, temperature, weather, or time of day. No warning lamps or messages appear. The dealer confirmed the issue, but stated nothing could be done because other Ford Explorers on-site also have the issue. The issue has also been confirmed on other Explorers in the market.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11729217April 4, 2026
SUSPENSION
Alignment went bad 23489 miles and took to dealer. It was inspected and found out the front cam bushings and bolts were already worn out and had to be replaced both sides. Plus realignment after. Cost was 544.00 dollars had to pay because alignment from factory only goes to 12000 miles , how convenient on fords part , nothing would wear out that soon or shouldn't under normal wear. So , I had to pay. asked my service advisor and he said he has gone round and round with ford and to no end , basically ford said to bad. My advisor said ford knows and knew of this for the last few years on explorers , broncos and f150 trucks and doesn't care to want to cover the cost of repairs and or fix the problem. here's the main point , my advisor said ford knows they put less quality , inferior parts made from less strength material made parts and doesn't care. My advisor told me the after market parts are made of better material and better quality and I will never have this problem again. That said , YES , this is a safety problem if , the parts were to break or come apart , could cause an accident , crash and worse case could kill someone if this were to fail on the highway at high speeds. So , I feel Ford needs to correct this , recall all the vehicles involved and , I and many others so far should be repaid for customers having to fix this problem. As my advisor said , many others so far and ford corp doesn't care. WHERES THE RECALL. Before someone gets killed! No option but to fix as to replace the parts and get realignment to save the tires from wearing out and having to be replaced , of course at my cost! Per my work order of inspection and required repairs.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11729079April 3, 2026
STEERING, LANE DEPARTURE: ASSIST
My 2025 Ford Explorer pulls hard to the left, the steering wheel feels heavy, stiff, and gets hard to steer my wife and I are constantly fighting with the car to get it to steer right and stay in the lane. If I let it, I can keep the steering wheel straight and the car will just veer to the left Into the left lane, it’s dangerous, my wife won’t even drive it anymore. Then there are times while driving on curvy roads, the wheel or the cars steering will get stuck and if I wanted to, it will stay turning on its own around corners or curves. Also when we take a turn onto another street sometimes it gets stuck again, doesn’t come back like most cars do. We have had it in the shop more than 3 times for these problems. They have replaced the steering rack/gear, done alignments, but the problem still persists we are afraid that the steering is going to get stuck, that we won’t be able to pull it back into our lane and cause a major accident. We have brought it to the dealer but say they have done what they can and need direction from Ford. I don’t know if it’s related but there has been warning lights but it said it was for the parking brake. I have even been on rides with a service manager from a ford dealership and it has happened but, without an answer from ford they could not do anything. This problem has going on for months now and the dealership can’t fix it I bought it September 2nd, 2025 I can’t remember when it started exactly, October or November but it has gotten worse and worse it seems by the day. The first time we brought it in was in December 31st, 2025 that’s when the dealership changed the steering rack/steering gear I tried to upload files to this form but they are too big
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11722319March 5, 2026
ENGINE
The contact owns a 2025 Ford Explorer. The contact stated that while driving at an undisclosed speed, the vehicle started shaking violently. The check engine warning light came on, and the vehicle lost motive power and stalled. The contact used a scanner to identify an error code. The contact was able to restart the vehicle and drove to the residence while driving 20 MPH with the vehicle shaking abnormally. Upon arriving at the residence, the vehicle lost power. The contact called Ford Customer Service and spoke with a Ford Roadside Assistance representative to retrieve the vehicle from the residence. An appointment was scheduled for the dealer to pick up the vehicle at the residence. The vehicle was taken to Ciocco Ford, but was not diagnosed or repaired; however, the spark plugs were replaced but the failure persisted. The manufacturer was made aware of the issue. The approximate failure mileage was 9,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721660March 3, 2026
VEHICLE SPEED CONTROL, POWER TRAIN
On March 2nd 2026, while operating my 2025 Ford Explorer ST at highway speeds of approximately 78 MPH, the vehicle experienced a sudden, uncommanded shift from Drive into Neutral. This resulted in an immediate and total loss of motive power in live traffic, creating a life-threatening safety hazard as I was unable to maintain speed or accelerate away from surrounding vehicles. Notably, the dashboard displayed no warning lights, wrench icons, or error messages during or after the event. I was forced to coast across lanes of traffic to reach the shoulder. This is the 7th significant warranty-related issue this vehicle has experienced since purchase in May 2025, representing a substantial impairment to the vehicle's safety, use, and market value under Wisconsin Lemon Law.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11717439February 11, 2026
ELECTRICAL SYSTEM, ENGINE, SERVICE BRAKES
I am writing to formally report a series of catastrophic and life-threatening mechanical and electronic failures in my 2025 Ford Explorer Active (VIN: [XXX] ]), purchased in Bogotá, Colombia. Despite immediately notifying the Ford Post-Sales Support Line after the first incident, the technical response was insufficient, leading to a second, more severe event that nearly resulted in a fatal high-speed collision on February 9, 2026. Incidents Summary: 1. Total Power Loss: Engine and all electrical systems shut down while in motion (40 km/h), losing steering and braking assistance. 2. Brake System Failure: At 70 km/h, The vehicle presented a multi-system failure of sensors, audible alarm and illumination of warning lights (ABS, Traction Control, Pre-collision Assistant, hill start assist not available, check brake system, BRAKE, ESC check, driving modes not available). the vehicle experienced a total loss of brake pedal response followed by a sudden, uncontrolled autonomous "hard braking" event. This happened on a high-traffic highway (Autopista Norte). Global Safety Concern: I am formally requesting a Global Technical Investigation into this unit and the 2025 Explorer Active series. The failure of the electronic brake booster and the total system shutdown represent a "Product Liability" risk that could lead to mass-casualty events. I demand: • Direct intervention from Ford Global to Ford Colombia. • A formal safety alert or recall investigation for similar units. Sincerely, [XXX] MAIL [XXX] bogota colombia phone [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11716635February 9, 2026
UNKNOWN OR OTHER, FORWARD COLLISION AVOIDANCE: WARNINGS, BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING
The vehicle failed the inspection related to Recall 25C42. Since owning the vehicle, I have experienced repeated intermittent failures of multiple safety and driver-assistance systems, which raise serious safety concerns. The Pre-Collision Assist system has activated without any apparent reason on four separate occasions, including situations where there were no vehicles, pedestrians, or obstacles present. These unexpected activations are alarming and could increase the risk of a collision. I fear for my safety when driving the vehicle due to these unpredictable safety system activations. Additionally, the Rear Cross Traffic Alert system functions intermittently and does not activate consistently when vehicles are present, further reducing confidence in the vehicle’s safety systems. While driving, the vehicle’s phone connectivity system has disconnected unexpectedly, and during these events the GPS/navigation system became unavailable, preventing the use of turn-by-turn directions. These failures occur while the vehicle is in motion and contribute to driver distraction and safety concerns. The vehicle was inspected for Recall 25C42, and I was informed that the required repair cannot be completed because the replacement part is on backorder until June. As a result, the vehicle continues to be operated with known and unresolved safety-related defects for an extended period of time. These issues occur intermittently and without warning, making them difficult to reproduce or diagnose. Due to the ongoing malfunction of critical safety systems and the delay in recall repairs, I fear for my safety while driving this vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11716094February 6, 2026
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING, LANE DEPARTURE: ASSIST
While using Ford Blue Cruise, the Blue Cruise system failed to maintain lane control and fought the driver's steering wheel input, resulting in the vehicle colliding with a traffic cone. I have had 3 other instances where Blue Cruise has randomly jerked me toward the shoulder or an exit ramp, this is the first time colliding with anything. Only damage to the vehicle from this incident is a ripped fender well liner, there are some markings on tire sidewall but no damage. Certainly could have been worse. The cone collision happened on Interstate 79 Northbound at MM101 in West Virginia. I have had lane jerking happen with Blue Cruise twice Northbound at MM105, and once Southbound at MM118. The system is on by default, I am trying to figure out how to turn it off to prevent future safety issues.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11715207February 3, 2026
SERVICE BRAKES, ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Ever since I bought that vehicle, it's had system malfunctions. I received three letters directly from Ford explaining the problems this vehicle had or could have. But he and the dealerships, where I took my vehicle for repairs, never did them. They always denied that it had any problems and said that my vehicle was new and had nothing wrong with it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11714872February 1, 2026
FUEL/PROPULSION SYSTEM
Car was parked on a driveway, decent grade, with 50 miles left to empty (no low fuel light on). Facing downward. Car did not turn over. Had to use manual override to put vehicle into neutral and coast to a more level area and start it up. Seen this issue posted on the Explorer ST Facebook group multiple times, so I was lucky I knew what the issue is. Most other people would be stranded. There is a flaw in the Explorer's fuel tank system that will not allow the car to start if fuel level gets below a certain threshold when parked facing down a steep street or driveway.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11712187January 20, 2026
FORWARD COLLISION AVOIDANCE
The contact owns a 2025 Ford Explorer. The contact stated that on the first day after the vehicle was purchased, the pre-collision camera failed to function as intended. The contact stated that the alarm failed to beep as intended when a person or an object was in front of or passing by the vehicle. There was no warning light illuminated. The vehicle was taken to the dealer; however, no cause for the failure was found. A diagnostic test was performed, and it was determined that the pre-collision camera worked as designed. The contact stated that the manager at the dealer took the vehicle home and confirmed that the pre-collision camera sensor had failed to function as intended; however, the vehicle was not repaired. The vehicle was taken to Biener Ford; however, no cause for the failure was found. The contact stated that on a separate occasion, while driving at an undisclosed speed in the snow, the message "Pre-collision Camera Blocked" was displayed. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was made aware of the issue. The failure mileage was approximately 11.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11710897January 14, 2026
VISIBILITY/WIPER
Since new. Thousands of dots or specs are visible in the window upon sun up of sun down. This is not the snow flake safety campain that Ford has. Others have the same complaint on social media.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709936January 9, 2026
ELECTRICAL SYSTEM, EXTERIOR LIGHTING
First, we took this vehicle to a dealer because the rear window buttons were not working. They wouldn't roll down. Second, the dome lamps inside only work part of the time, when we take the vehicle to the dealer or another Ford dealer that we decided to try, they say they can't do anything because they see no issue as the lights are working AT THAT TIME. Third, while connected to a trailer, an error message appears several times stating that the trailer has been disconnected. It just flashes and pings, and then disappears. This is a safety issue, as it has caused me to make sudden stops as I am made to believe that the trailer has became disconnected. All these things are stated in the recall we received on this vehicle, and we just want the body control module replaced as it says they should do, but both dealers(Bruce Walters Ford - Pikeville KY) and the dealer we switched to to try and remedy the issue (Freedom Ford of Wise VA) say that there is no issue, and refuse to do the control module replacement. This vehicle has been inspected at the least 6 different times for these issues, and still nothing has been fixed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11708298January 2, 2026
POWER TRAIN
Parked vehicle on snowy driveway, went to back to unload personal items from liftgate, and vehicle began sliding backwards towards me. Ran to the driver‘s door, got in, put on brakes, started vehicle and pulled it forward. Put it in park, and as I was exiting the vehicle, it began sliding backwards again. Rear wheels were locked. However, the front wheels were rolling. Apparently the transmission park pawl did not engage. I took pictures of the tires after the last roll. Front tracks show clear tread in the snow (rolling); rear show lines and pushed show (sliding)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707558December 29, 2025
STRUCTURE:BODY
I brought my 2025 Explorer in on 12/19/2025 for a recall check. I mentioned to the Service Advisor that the left rear inner wheel well skirt was detached from the quarter panel. After the car was looked at, he came to me and said that they can be replaced at a cost of $600...XXX. He said it is from the snow and ice tearing them because of the larger tires on the vehicles now....NO XXX..we live in WNY. This is a brand new-ish vehicle with 15,000 miles. How is this something that is my cost, there is obviously a problem with parts or engineering. Basically I will have to replace these after every winter season for the reason that was given....AGAIN...why is this not covered. I regress, he did say Ford MAY help the first time...REALLY?? What happens the next winter and the one after that?? $40K+ for the vehicle and this
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11706328December 20, 2025
AIR BAGS
Front and side curtain air bags failed. Was side swiped and hit a guard rail head on at 60-70 mph. I was going on the far left lane on the interstate 85. When a lady in the center lane hit the side of my car not paying attention that I was in my lane.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11704952December 14, 2025
SERVICE BRAKES
My remote start would not work from inside of a restaurant so I went out to manually start the car. It started fine. It was very cold out so I thought that I would drive up next to the building to get close to the entrance. The parking lot was not slippery at all , when I applied the brakes I had absolutely no brakes and the car bumped into the building. No damage to the building but my license plate bracket was broken and the bumper had minor damage.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Explorer