Ford Expedition Complaints (2018)

383 consumer complaints on file.

#11416492May 13, 2021
ENGINE
2018 EXPEDITION MAX LIMITED WITH 91K MILES OVERHEATED AND BLEW A HEAD GASKET SITTING IN A HOME DEPOT PARKING LOT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11415481May 6, 2021
POWER TRAIN
I PULLED OUT OF MY DRIVEWAY TAKING A LEFT AND AS I PRESSED THE GAS TO ACCELERATE UP THE HILL IT SEEMED AS THOUGH MY CAR WENT INTO NEUTRAL. IT WOULD NOT GO. I TOOK MY FOOT OFF THE GAS AND WAITED A SECOND OR TWO AND THEN PUSHED DOWN ON THE ACCELERATOR AGAIN AND THEN THE CAR TOOK OFF AS NORMAL. SINCE THAT FIRST TIME THIS SITUATION HAS BEGUN HAPPENING ALMOST DAILY SOMETIMES SEVERAL TIMES A DAY. I HAVE TAKEN MY VEHICLE TO THE DEALERSHIP AND OF COURSE THEY CAN NEVER GET IT TO DUPLICATE WHAT IT DOES TO ME. CONCERNING TO ME IS IF THIS HAPPENS WHEN I PULL INTO TRAFFIC AND CAN'T GET OUT OF THE WAY OF AN ONCOMING VEHICLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11405997April 1, 2021
SUSPENSION
TOLD NEEDED TO REPLACE REAR STRUTS WHEN TOOK INTO SERVICE AT 46,690 MILES. NEVER HAD TO DO THIS BEFORE. SAW FORD HAS A SAFETY MESSAGE (SSM 47624) ON THIS FOR 2017 AND 2018 EXPEDITIONS. NEVER HAD TO DO THIS SO EARLY IN A VEHICLE'S LIFE. I DON'T TOW OR GO OFF ROAD. WAS NOT COVERED BY EXTENDED PREMIUM WARRANTY
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11399251March 5, 2021
SERVICE BRAKES, ELECTRICAL SYSTEM, EXTERIOR LIGHTING
UNDER WARRANTY, MOISTURE WAS PRESENT IN ALL THE REAR BRAKE LIGHTS. THE UPPER (THIRD) BRAKE LIGHT HAD THE MOST CONDENSATION. AN AUTHORIZED FORD DEALER REVIEWED THE ISSUE AND ADVISED FORD DOES NOT COVER MOISTURE WITHIN A LIGHT AS THE MOISTURE WILL DISSIPATE OVER TIME. I ADVISED THE UPPER BRAKE LIGHT WAS NEVER DRY, THEY INSISTED WARRANTY WOULD NOT COVER THE ISSUE. I COULD REPLACE THE LIGHT, I RECEIVED A QUOTE AT THAT TIME. NOW THE UPPER BRAKE LIGHT HAS LESS THAN 2 LED'S WORKING AND THE VISIBILITY IS NEXT TO NOTHING. REVIEWING FORUMS, THIS IS AN ISSUE THAT HAS BEEN PRESENT IN THE FORD EXPEDITIONS SINCE THE NEW VEHICLE DESIGN CHANGE. MY CONCERN IS VERY SIMPLE, THAT BRAKE LIGHT IS IMPORTANT IN THE SAFETY OF OUR PASSENGERS, THOSE AROUND THE VEHICLE AND THE VEHICLE ITSELF. WE HAVE NOT BEEN IN A REAR END COLLISION WITH THIS VEHICLE, BUT IT IS DIFFICULT TO SEE BRAKING OF THIS VEHICLE AHEAD WHEN THE VEHICLE IS ONE CAR AHEAD OF YOU BASED ON WHAT I HAVE SEEN WHEN DRIVING BEHIND THIS VEHICLE MYSELF. I CONSIDER THIS BRAKE LIGHT A SIGNIFICANT COMPONENT OF THE SAFETY FEATURES IN OUR VEHICLE. TIMING OF THE ISSUE WAS OVER A PERIOD OF TIME. FIRST PHASE WAS MOISTURE NOT DISSIPATING, SECOND PHASE HAS BEEN THE LED LIGHTING CONTINUES TO STOP WORKING, A FEW LED'S AT FIRST, NOW ONLY A FEW ARE OPERATIONAL, AND DIM AT BEST DUE TO THE CONTINUED MOISTURE IN THE UPPER REAR BRAKE LIGHT ASSEMBLY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11399280March 5, 2021
POWER TRAIN
TL* THE CONTACT OWNS A 2018 FORD EXPEDITION. THE CONTACT STATED THAT AFTER STARTING THE VEHICLE, A RATTLING SOUND WAS PRESENT COMING FROM UNDER THE HOOD OF THE VEHICLE. THE VEHICLE WAS EXAMINED BY AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE TRANSMISSION VTC SOLENOID AND CAM-PHASER WERE FAULTY AND NEEDED TO BE REPLACED AND REPROGRAMMED. THE VEHICLE WAS NOT REPAIRED. THE LOCAL DEALER FORD COLLEGE STATION LOCATED AT 1351 EARL RUDDER FWY, COLLEGE STATION, TX 77845 AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE CONTACT WAS INFORMED THAT A MANUFACTURES FIELD SERVICE CAMPAIGN WAS AVAILABLE FOR THE FAILURE HOWEVER, THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 69,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11398204February 27, 2021
POWER TRAIN, EQUIPMENT:MECHANICAL
WE HAVE A 20018 FORD EXPEDITION PLATINUM, 2WD (REAR WHEEL DRIVE). BOUGHT BRAND NEW. FOR THE PAST MONTH WE'VE BEEN HAVING WHAT SEEMS LIKE TRANSMISSION ISSUES. CAR HAS 45,000 MILES ON IT. A FEW TIMES A DAY THE TRANSMISSION FAILS TO SHIFT AT ALL; ESSENTIALLY GOES IN-BETWEEN GEARS, REVS HIGH, BUT ABSOLUTELY NO MOVEMENT. USUALLY SOON AFTER MOVING FROM A START, SO MAYBE 2ND TO 3RD GEAR OR 3RD TO 4TH GEAR. IT HAPPENS WITHOUT ANY WARNING. HAS NOTHING TO DO WITH THE CARE BEING HOT OR COLD. IT IS VERY SCARY BECAUSE ONE OF THE TIMES, I HAD PULLED OUT FROM A GAS STATION ONTO A HIGHWAY, ACCELERATING NORMALLY TO KEEP UP WITH ONCOMING TRAFFIC WITH I LOST ALL POWER TO THE WHEELS. ENGINE CONTINUED REVVING. THERE WAS NO TIRE SLIPPING - JUST NO MOVEMENT WHATSOEVER. TOOK IT INTO THE FORD DEALER (GOLDEN CIRCLE FORD) IN JACKSON TN WHERE THEY EVALUATED THE VEHICLE AND FOUND NOTHING WRONG WITH IT. THEY APPARENTLY PUT IT ON THE COMPUTER AND DROVE IT; AND WERE UNABLE TO DUPLICATE THE PROBLEM. THEY GAVE ME A RIDICULOUS EXPLANATION THAT THE VEHICLE IS 'LEARNING' (AKA "ADAPTING") TO MY DRIVING STYLE AND THAT IT WAS NORMAL BEHAVIOR. THAT WAS LAST WEEK. SINCE THEN, THE SHIFTING BETWEEN LOW GEARS HAS BECOME SOMEONE ROUGHER/ WITH SOME HESITANCY. I DID RESEARCH THESE VEHICLE AND APPARENTLY THERE MAY BE AN ISSUE WITH THE 10 SPEED AUTOMATIC TRANSMISSIONS NOW BEING USED IN THE F150 TRUCKS WITH MANY PEOPLE DESCRIBING SIMILAR TRANSMISSION PROBLEMS. I JUST WANTED TO LET YOU KNOW THAT THERE IS A POTENTIAL ISSUE, THAT CAN ALSO BE VERY DANGEROUS IF THE CAR STOPS MOVING IN THE MIDDLE OF THE ROAD WITH ONCOMING TRAFFIC. THANK YOU.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11397992February 25, 2021
ENGINE
I UNDERSTAND THE WELDS FOR HIGH PRESSURE FUEL PUMP MAY FRACTURE. I HAVE ALREADY HAD REPAIRED, RUNNING ROUGH ON START UP PLUS WHITE SMOKE FROM TAIL PIPE. I BELIEVE THERE IS ANOTHER PROBLEM OCCURRING, AS BEFORE IN APRIL 2019. IT IS FEBRUARY 2021, AND AND RUNNING AS BEFORE. THEY TORN MY ENGINE DOWN, KEEPING FOR 4-5 DAYS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11397858February 25, 2021
ENGINE
OUR 208 FORD EXPEDITION PLATINUM 4X4 PUTS OUT A VERY HIGH AMOUNT OF CARBON MONOXIDE, TO THE POINT THAT IT MAKES MY CHILDREN SICK. AFTER VERY LITTLE RESEARCH, IT APPEARS AS THOUGH OUR VEHICLE IS HAVING THE SAME ISSUE THOUSANDS OF PEOPLE HAD WITH THEIR FORD EXPLORERS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11389552January 23, 2021
POWER TRAIN
EXPEDITION WILL NOT TOW BUMPER PULL TRAILER, 2000LBS. ENTIRE TRUCK SHAKES TERRIBLY, DEALER CANNOT FIX AFTER MULTIPLE TRIES INCLUDING LAST WEEK, CROSSROADS FORD, DOESN'T KNOW THE CAUSE, AGREES ITS TERRIBLE, UNUSABLE, DANGEROUS.HAS BEEN WORKED ON FOR OVER A YEAR. I HAVE A FARM, CANNOT GET HAY ETC. CANNOT TRAILER HORSES, ETC. HAVE TRIED MULTIPLE TRAILERS, SAME PROBLEM. $65,000 TRUCK THAT CAN'T MEET MY BUSINESS NEEDS. WHAT WILL FORD DO ABOUT THIS?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11387127January 8, 2021
SUSPENSION
FRONT STRUTS ARE LEAKING AT 38,000 MILES. VEHICLE WAS NEVER TAKEN OFF ROAD. DRIVER IS MILD AT USE OF VEHICLE. FEEL THAT THE STRUTS SHOULD NOT FAIL BEING THIS NEW OF VEHICLE AND LOW MILEAGE. REPLACEMENT OF THIS PART TAKES TIME TO RECEIVE, THERE ARE BACKORDERS. IS THERE A DEMAND FOR THIS PART THROUGH THE COUNTRY THAT THERE MAY BE A LARGER PROBLEM WITH THIS PART WHICH CONTROLS THE STABILITY OF THE VEHICLE. IS FORD TRYING TO SWEEP UNDER THE RUG A PART PROBLEM WHICH WOULD REQUIRE ANOTHER RECALL. INCIDENT WAS REPORTED TO FORD BUT THEY SAID IT IS NOT COVERED BY BUMPER TO BUMPER WARRANY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11385366December 28, 2020
ENGINE, POWER TRAIN
MY 2018 FORD EXPEDITION MAX 4X4 WAS DIAGNOSED WITH THE ISSUE DESCRIBED IN TCB-20-2315 IN AUG 2019. THE REPAIR WAS DONE PER THE TCB AND COMPLETED IN OCT 2019. THE VEHICLE WAS IN THE SHOP FOR 10 WEEKS AND I HAD TO RETURN IT 4 TIMES FOR ADDITIONAL REPAIRS UNTIL THE ISSUE WAS TEMPORARILY RESOLVED. THE PROBLEM REOCCURED IN JUL 2020 AND IT TOOK OVER 5 VISITS TO THE DEALERSHIP AND INTERVENTION FROM FORD CUST SERVICE TO GET THE VEHICLE REPAIRED IN DEC 2020. I HAVE ALREADY RETURNED THE VEHICLE AGAIN THIS TIME BECAUSE THE ISSUE WAS NOT RESOLVED AND NOW WILL NEED TO RETURN THE VEHICLE A THIRD TIME. THIS WILL MAKE 7 TOTAL ATTEMPTS TO GET THE VEHICLE FIXED FOR THE SAME ISSUE. FORD REFUSES TO REPLACE THE VEHICLE AND DENIED MY BUYBACK REQUEST. THIS VEHICLE IS A LEMON PLAIN AND SIMPLE. I FOLLOWED THE PROCEDURES PER STATE LAW IN NOTIFYING FORD AND ALLOWING THEM TO REPAIR THE VEHICLE. CLEARLY, THE ROOT CAUSE OF THE ISSUE HAS NOT BEEN DETERMINED AND THE REPAIR JUST COMPLETED IS JUST A REPEAT OF THE FIRST. THIS TIME, I WAS ON VACATION WITH MY FAMILY IN THE MOUNTAINS OF WEST VIRGINIA IN THE DEAD OF WINTER WITH WINDCHILLS OF MINUS 15 DEGREES. THE CHECK ENGINE LIGHT AND POWER TRAIN LIGHTS CAME ON, THE TURBO SHUT DOWN, AND WHITE SMOKE STARTED BILLOWING OUT OF THE TAILPIPE. WE COULD BARELY MAINTAIN SPEED ON INCLINES AND HAD TO STOP FOR LOW OIL PRESSURE MULTIPLE TIMES. WE COULD HAVE BEEN STRANDED IN THE MIDDLE OF NOWHERE WITH NO CELL RECEPTION. A PROBLEM I ANTICIPATED AND EXPRESSED TO FORD WHEN I RETURNED THE VEHICLE FOR THE SIXTH ATTEMPT. I WANT THE VEHICLE REPLACED WITH THE SAME VEHICLE THAT IS NOT DEFECTIVE. THAT IS ALL. WHY IS THIS SUCH A CHALLENGE FOR FORD TO SOLVE? I HAVE LITERALLY INVESTED HUNDREDS OF HOURS ATTEMPTING TO NAVIGATE THIS NIGHTMARE. ATTACHED IS THE LETTER I SENT FORD IN SEP 2020. THE VEHICLE CANNOT BE OPERATED SAFELY AND IS STUCK IN MY DRIVEWAY. I AM NOW WITHOUT A CAR.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11382822December 10, 2020
STRUCTURE:BODY
THIS IS OUR SECOND WINTER WITH THIS VEHICLE AND BOTH SEASONS DURING WINTER TEMPERATURES THE RIGHT REAR DOOR WILL NOT LATCH TO STAY SHUT. WE HAVE SMALL CHILDREN THAT RIDE IN THE REAR OF THIS VEHICLE, SO THIS MAKES THIS MUCH MORE OF A CONCERN. MY HUSBAND IS A MECHANIC AND TRIES EVERYTHING TO MAKE IT WORK AND IT HAS BEEN A HUGE HASSLE. ESPECIALLY FOR SUCH A NEW, EXPENSIVE VEHICLE. THE VEHICLE IS STATIONARY WHEN THIS HAPPENS AS WE ARE UNABLE TO GO ANYWHERE WITH A DOOR THAT WILL NOT SHUT!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11377263December 1, 2020
AIR BAGS, SEATS, LANE DEPARTURE: BLIND SPOT DETECTION
FORD EXPEDITION WAS TRAVELLING AT 50-60KM/HR WHILE PASSING AN EMERGENCY VEHICLE ON A HIGHWAY. THE EXPEDITION WAS STRUCK FROM BEHIND BY A UTILITY VAN TRAVELLING AROUND 110KM/HR. BOTH FRONT SEATS SLID FORWARD AND ALSO RECLINED ON IMPACT. THIS CAUSED BOTH FRONT PASSENGERS TO SUSTAIN BRUISING ON THEIR CALF'S DUE TO THE SEATS SLIDING FORWARD AND WHIPLASH FROM BOTH FRONT SEATS RECLINING. BOTH FRONT SEATS TRAPPED CHILDREN IN THEIR CAR SEATS IN THE 2ND ROW FORM BEING RECLINED. NO AIR BAGS DEPLOYED IN THE ACCIDENT AS WELL!
Crash:
Yes
Fire:
No
Injuries:
4
Deaths:
0
#11362789October 5, 2020
SUSPENSION
WITH 39,402 MILES AT ALMOST EXACTLY 2 YEARS OLD,, THE RIGHT REAR STRUT HAS LEAKED ALL FLUID. NO ACCIDENTS, NO TOWING, NO DAMAGE TO THE STRUT. PER THE DEALER, THEY HAVE HAD TO REPLACE SOME ON THIS YEAR AND MODEL VEHICLE UNDER WARRANTY. FORD IS NOT COVERING THIS IF NO LONGER UNDER WARRANTY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11355264September 15, 2020
ENGINE
25000 MILES. PREVIOUSLY QUIET ON STARTUP. STARTED MAKING A RATTLING SOUND IF VEHICLE SAT OVERNIGHT A MONTH AGO. INITIALLY LASTED 1-2 SECONDS. MORE RECENTLY SOUND HEARD ON STARTUP AFTER SITTING ONLY A FEW HOURS, AND LASTS 4-5 SECONDS. SIMILAR TO COMPLAINTS REPORTED ON ISSUE 15-0131 ON 2015-ERA FORD PRODUCTS NEEDING CAM PHASER, TIMING CHAIN REPLACEMENT AND SCAN TOOL REPROGRAMMING. NOISE IS LOUD ENOUGH NOW THAT I FEAR ACCELERATING TIMING CHAIN DAMAGE POSSIBLE FAILURE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11349031August 13, 2020
SUSPENSION
I TOOK MY 2018 EXPEDITION (WITH 40K MILES ON IT) IN LAST WEEK BECAUSE THE RIDE HAS BEEN REALLY BOUNCY LATELY DURING NORMAL STREET AND HIGHWAY DRIVING AND MY WIFE AND KIDS HAVE COMPLAINED. I HAVE NOTICED THE BOUNCINESS TOO WHILE DRIVING. THIS IS A NEW PHENOMENON FOR MY VEHICLE BUT IN RESEARCHING ONLINE IS NOT A NEW ISSUE AND FORD IS AWARE, JUST NOT DOING ANYTHING ABOUT IT. THERE ARE 7 (NOW 8) COMPLAINTS ABOUT STRUTS/SUSPENSION FOR THE 2018 FORD EXPEDITION. MORE DETAIL IS BELOW. THE DEALER CALLED ME TODAY (SIX DAYS AFTER DROPPING IT OFF) AND SAYS ALL FOUR OF THE STRUT ASSEMBLIES NEED TO BE REPLACED BECAUSE THEY ARE LEAKING AND IT WILL COST ~$1700 PLUS TAX. I SAID STRUTS ARE COVERED UNDER MY PREMIUM CARE EXTENDED WARRANTY (NOT TO MENTION I AM JUST PAST 36K MILES FOR NORMAL WARRANTY - SO IT COULD BE AN AFTER WARRANTY ITEM TOO AS I'VE NEVER REPLACED STRUTS ON ANY CAR). WHEN THE SERVICE DEPARTMENT WENT TO ENTER THE STRUT CODE INTO THE EXTENDED WARRANTY SYSTEM, STRUTS AREN'T AN OPTION CODE, BUT SHOCKS ARE. THE PROBLEM IS SHOCKS AREN'T COVERED AND THEY CAN'T FIND A CODE TO GET THE STRUT ASSEMBLY COVERED. THE ONLY PARTS THAT FORD SELLS FOR THE SUSPENSION ARE LABELED SHOCK ABSORBERS, AND STRUTS ARE NOT A SOLD OPTION. THE DEALER THINKS FORD SHOULD COVER AS THEY BELIEVE IT FALLS UNDER THE WARRANTY .MY PREMIER CARE CONTRACT AND THE PREMIER CARE BROCHURE SAYS STRUTS ARE COVERED, AS WELL. IT APPEARS FORD IS TRYING TO AVOID RESPONSIBILITY. SO I HAVE AUTHORIZED THE REPAIR SO THE CAR IS DRIVEABLE (I AM GETTING BRAKES AND NORMAL MAINTENANCE DONE TOO). NOT TO MENTION I AM SUPPOSED TO DRIVE MY SON TO COLLEGE ON FRIDAY. THIS IS CAUSING ME TO RENT A SUBURBAN AND SHELL OUT ANOTHER $400 FOR THAT PLEASURE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11341425July 25, 2020
POWER TRAIN
POWER TRAIN FAILURE INDICATOR LIGHT CAME ON ABOUT 800 MILES INTO A ROAD TRIP. VEHICLE WAS BEING DRIVEN ON CITY STREETS IN EXTREME STOP AND GO TRAFFIC AFTER RECENTLY EXITING THE INTERSTATE. VEHICLE STARTED DOWNSHIFTING EXTREMELY ROUGHLY, JERKING THE ENTIRE VEHICLE FORWARD AND TRANSMISSION STARTED TO OVERHEAT. VEHICLE HAS ALWAYS BEEN A LITTLE ROUGH UP SHIFTING SINCE PURCHASE BUT THIS WAS THE FIRST TIME ANY INDICATOR LIGHTS CAME ON. VEHICLE WAS TAKEN TO FORD DEALERSHIP WHERE WE WERE TOLD TRANSMISSION NEEDED TO BE REPLACED. VEHICLE HAS 36,000 MILES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11340103July 18, 2020
AIR BAGS, SERVICE BRAKES
WAS HIT BY A VEHICLE WHILE MAKING A LEFT HAND TURN ON A CITY STREET. TRIED TO STOP THE CAR. BREAKS WOULD NOT WORK AND JUST WENT TO THE FLOOR BOARD. VEHICLE SPED UP. JUMPED 2 CURBS AND HAD TO THROW THE CAR IN PARK IN ORDER TO STOP. AIR BAGS DID NOT DEPLOY.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11325630May 22, 2020
SUSPENSION
AT 20,000 MILES OF HIGHWAY DRIVING, BOTH FRONT END STRUTS WERE LEAKING AND REQUIRED WARRANTY REPLACEMENT BY DEALER. I HAVE SINCE READ ABOUT MANY PROBLEMS WITH FORD EXPEDITION STRUTS FALLING PREMATURELY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11324175May 11, 2020
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
THE VEHICLE HAS AN INTERMITTENT ELECTRICAL PROBLEM WHICH CAUSES A CROSS TRAFFIC SYSTEM FAULT, BLIND SPOT SYSTEM FAULT AND THE LIFTGATE OR LIFTGLASS TO INDICATE THAT IT IS AJAR. HEN THESE FAULT THE SAFETY SYSTEMS ARE INOPERATIVE AND POSE A SAFETY CONCERN. THIS OCCURS WHILE IN MOTION AT BOTH ON BOTH CITY STREETS AND AT HIGHWAY SPEEDS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Expedition