Ford Edge Complaints (2018)

850 consumer complaints on file.

#11763813September 12, 2026
ENGINE
Ford admits "known manufacturing defect" on Eco-Boost 2.0 engine. Coolant intrusion into engine. Coolant getting into combustion chamber, at only 28K miles on my own Ford Edge. Complaints all over the internet & "[XXX]" about this. Known to cause engine fires. Requires EXPENSIVE "long block assembly replacement". Page after page of complaints about this on your own NTSB website. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11763271September 10, 2026
ENGINE
Coolant intrusion on cylinder 1.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11763295September 10, 2026
ENGINE AND ENGINE COOLING, ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:SEALS/GASKETS
The contact owns a 2018 Ford Edge. The contact stated that upon starting the vehicle, the vehicle made an abnormal knocking sound with smoke coming from the tailpipe. The check engine warning light and overheating warning light were illuminated, and the contact became aware of an abnormal odor during the failure. The vehicle was taken to a dealer, where it was diagnosed that the head gasket had failed, causing coolant intrusion into the engine cylinders and engine failure. The vehicle was repaired. The contact associated the failure with NHTSA Action Number: DP26008 (Engine and Engine Cooling). The manufacturer, Ford Motor Company, was notified of the failure by phone and provided partial assistance for the repair. The failure mileage was approximately 71,224.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11763388September 10, 2026
ENGINE AND ENGINE COOLING
The contact owns a 2018 Ford Edge. The contact stated that while driving 60 MPH, the coolant temperature warning light illuminated. The contact stated that immediately after the failure, the vehicle failed to accelerate and sputtered abnormally. The vehicle was restarted and taken to a service center to be diagnosed. The contact was informed that coolant was leaking into the engine block, causing engine failure. The contact was informed that the engine needed to be replaced. The failure mileage was approximately 120,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11763455September 10, 2026
POWER TRAIN
The car is 8 years old, well maintained and has mileage of @ 57,000 miles. The "engine check" lighted up in July 2026. Initial check simply required a replacement of spark plug and ignition coil. It was done immediately. However, the engine check light that initially disappeared returned 2 weeks after. When brought to a Ford Dealer, the diagnostic is TSB22-2229 (coolant intrusion in the engine). I was quoted to replace then engine by Ford at the cost of $13,000 or trade it in for $2,500!!! I read many reports of engine stall/overheating due to this problem, and it has become a major safety issue specially that this issue is proven to be a legally established engine design flaw. I do not recall that Ford, over the years, properly inform users of this coolant intrusion into the engine. As I saw safety incidents report regarding this, I made the decision to report this given that I belong to the apparent @500,000 Ford vehicles affected by this. The engine check was on and off and I could have been into a major accident, not knowing the engine can possibly stall while on a high speed. Seeking your help and attention as I believe this is a Safety Recall that Ford should have done years ago. Ford Edge continues to be traded in the secondary market. Kindly think those who may purchase this vehicle without knowing the engine has safety issues with coolant intrusion.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11763166September 9, 2026
ENGINE
Coolant reservoir is disappearing and I have a check engine light on with a misfire code
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11763080September 9, 2026
POWER TRAIN
I have the 2.0 Ecoboost that is the subject of internal coolant leak with a potential diagnosis that matches the TRB on this issue. The car has 50K miles and is a 2018 Edge. If this is the issue it should be fixed by Ford without the need for me as an owner to foot the bill for their poor design especially since it was know for a couple years prior by Ford before I purchased this vehicle new. NHTSA should certainly force a recall. At this point it was noted by the dealer during servicing that we were low on coolant.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11762824September 8, 2026
POWER TRAIN
When started vehicle shook violently. Check engine light came on and we took the vehicle to two different mechanics. Both stated engine failure do to coolant intrusion. Needed to replace long block and quoted at least $7000 in repairs. This has been a known issue with these motors yet no recall has been issued. We also contacted our local Ford dealer and they also said we needed a new motor. We reached out to Ford for assistance in covering the cost and were told there was nothing they could do for us. This is our childs school car and I do not feel safe with her driving even to and from school. We have been the owners for 2 years. 2018 Ford Edge Titanium 2.0 Ecoboost engine. 120k miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11762927September 8, 2026
ENGINE
I had my engine replaced due to coolant intrusion on my 2018 ford edge in 2023 at Serra Ford in Sylacauga, Alabama.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11761512September 2, 2026
SERVICE BRAKES
Rear drivers side brake line ruptured, leaving the vehicle unsafe to drive. The ruptured happened at a bend in the hard brake line at the top of the gas tank.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11761437September 1, 2026
ENGINE
On the dash board, it displayed a severe warning regarding "engine over temprature" that caused due to the engine coolant intrusion in to the cylinder 2 and caused it to misfire and the engine light to be displayed. After time and money consuming rigorous effort, each and individual parts of the engine checked based on the codes displayed. And, I realized that the engine itself was actually causing the such internal critical issue. Finally, I brought it to the Ford dealership and they told me that the engine has design defect that actually causes the coolant intrusion into the cylinder that shouldn't happen in the first place. And I was told the engine must be replaced. Detailed analysis of the issue discloses that Ford models between 2015-2018 have the same critical issues. However, Ford Motor Company never issues a recall safety issue for such potential engine issue that affected millions of Americans who have these models. I can't afford to pay $10k to replace a long block engine according to the dealer final solution to fix the internal engine problem. The car is disabled and parked out side for almost close to two years now. I am seeking justice. Help.me please!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11760575August 29, 2026
ENGINE
Engine developed a bad skip, dealer service originally said it was a faulty spark plug or coil on cylinder 2so they replaced those for a cost of $414 on 6/4/26. This did not fix the problem. The second diagnosis identified the engine defect that was causing the skip. They recommended an engine replacement and contacted Ford to request assistance since it's a know manufacturing defect. This request was declined. Campbell Auto Repair replaced the engine on 8/19/2026 at a cost of $6,601.68. We feel that Ford should bear the cost of these repairs.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11759496August 25, 2026
SERVICE BRAKES
I am filing a formal complaint for a Safety issue regarding Brakes. When turning, the "Brake Fluid Low" light would flash on for 2 seconds. It did not stay on. Brake pedal seemed normal. When inspected, there was no fluid in the Master Cylinder. No leak was detected. Fluid was in the Brake Booster. They indicated both would need to be replaced. There are 28,000 miles on the 2018 Ford Edge. My Safety and passengers was put at risk because there was no fluid and brakes could fail at any time. The Low fluid light did not stay on. This problem was confirmed at an independent service center. I am taking the vehicle to the Ford Dealer Service Department on 8.26.26 Only when turning a corner did a light come on Low Brake Fluid for 2 seconds. It is not on otherwise. I have had the oil changed and vehicle inspected and used Ford Service at the dealer "The Works" package where supposedly the brakes fluid and breaks were inspected at appropriate intervals and this was last done on 3.11.26 and it was rated as "good" by the Dealership. Based on the fact the Master Cylinder should be good for around 90,000 miles it seems defective and a safety issue. We have 28,000 miles, garage kept, well maintained vehicle Ford has issued massive safety recalls for exactly this issue on 2015–2018 Ford Edge vehicles (specifically Recall 20V-332 / Ford Campaign 20S31) However our vehicle does not fall within the date range. Our vehicle was made of 3/2018. I have called Lasco Ford Dealership and Ford Customer Service. This is our only vehicle and now we cannot drive it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11759091August 24, 2026
ENGINE
Yes, cracked cylinder wall. Coolant into engine. Known problem -The 2018 Ford Edge with the 2.0L EcoBoost engine is known for a critical design defect where coolant leaks into the cylinders due to a cracked cylinder wall or head gasket failure. This typically requires a full short-block or long-block engine replacement,
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11758494August 21, 2026
SERVICE BRAKES, SERVICE BRAKES, HYDRAULIC
The contact owns a 2018 Ford Edge. The contact stated that while driving 30-35 MPH with her children inside the vehicle and making a turn, while attempting to stop on a hill, the brakes suddenly became inoperable, but the contact was able to avoid a crash. The brake fluid was low prior to the failure. Additionally, fluid was added, but the failure persisted, and the contact’s husband added more brake fluid to the reservoir. No warning lights were illuminated. The vehicle was taken to a tire center, which determined that all four brake hoses had ruptured, and there was an associated recall, NHTSA Campaign Number: 20V469000 (Service Brakes, Service Brakes, Hydraulic); however, the VIN was not included. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and provided an address to send all concerns, but no assistance was provided. The failure mileage was approximately 110,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11758577August 21, 2026
ENGINE AND ENGINE COOLING
The contact owns a 2018 Ford Edge. The contact stated that while attempting to start the vehicle, the “Service Engine” warning light illuminated. A dealer was contacted. The vehicle was taken to a dealer where it was diagnosed and determined that there was coolant leaking into the cylinders and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The approximate failure mileage was 67,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11757751August 18, 2026
ENGINE
The contact owns a 2018 Ford Edge. The contact stated that while the vehicle was parked on several occasions, the vehicle was idling roughly, and the check engine warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed and determined that two vacuum fittings needed to be replaced. The vehicle was repaired, but the failure reoccurred in less than a week. The vehicle was taken back to the independent mechanic, where it was diagnosed that there was coolant intrusion into cylinder one and the entire long block needed to be replaced. The vehicle was not repaired. The vehicle was then taken to a dealer but was not yet diagnosed; however, the contact was informed that the long block needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 23,500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11757823August 18, 2026
ENGINE, POWER TRAIN
<67,000 miles Engine needs rebuilt. Available for inspection. Safety - possible cause of accident or at least having one. Has been confirmed by 2 local mechanics but has not been inspected by manufacturer. In October 2025, the check engine light came on, we took it to our mechanic; he replaced the coil pack and spark plugs ($342.89 see enclosed). It was good for a few months. Then approximately April 2026 the check engine light came back on and the overheating light came on. We filled the coolant and it was ok for a month or so. This July (2026) driving down the highway on my way home the car started jerking and jolting and the check engine light started flashing. It was nearly impossible to drive. I got it home by coasting and dealing with the shaking in short spurts and pulling over off the road when cars were coming. The mechanic has now informed us that the whole motor needs replaced.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11757094August 15, 2026
ELECTRICAL SYSTEM, ENGINE, FUEL/PROPULSION SYSTEM
In addition, this car has a coolant issue
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11757191August 15, 2026
SEAT BELTS, SEATS
- Seat back and seatbelts. Vehicle totaled. - Fractured right humerus and nose, Radial Nerve Palsy, unemployment - 4 vehicles involved (report attached) - no warnings - Broken driver's seat back (my weight 140lbs)
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
0

← Back to Ford Edge