Country Coach Inspire Recalls

9 recalls on file.

• Recall08V327000July 18, 2008
  ENGINE AND ENGINE COOLING:ENGINE:DIESEL

  COUNTRY COACH IS RECALLING CERTAIN MOTOR HOMES EQUIPPED WITH CATERPILLAR C9 DIESEL ENGINES. THE FUEL PUMP OUTLET CHECK PLUG MAY BE CRACKED WHICH COULD CAUSE FUEL TO SPRAY AND LEAK.

  Remedy

  COUNTRY COACH IS WORKING WITH CATERPILLAR (PLEASE SEE 08E042). CATERPILLAR WILL REPLACE THE FUEL PUMP PLUG FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2008. OWNERS MAY CONTACT CATERPILLAR AT 1-800-447-4986 OR COUNTRY COACH AT 1-800-452-8015.

• Recall08V210000May 8, 2008
  SUSPENSION

  COUNTRY COACH IS RECALLING 26 MY 2008-2009 INSPIRE AND MY 2008 TRIBUTE MOTOR HOMES EQUIPPED WITH SAF-HOLLAND ADL SERIES REAR SUSPENSIONS. IN SOME INSTANCES THE TRANSVERSE BEAM WAS NOT PROPERLY WELDED WHICH COULD RESULT IN A FAILURE OF THE WELD.

  Remedy

  COUNTRY COACH IS WORKING WITH SAF-HOLLAND TO HAVE A VISUAL INSPECTION OF THE ADL TRANSVERSE BEAM PERFORMED. IF A WELD DEFECT IS IDENTIFIED, SAF-HOLLAND WILL PROVIDE A SERVICE REPLACEMENT KIT THAT CONTAINS A NEW TRANSVERSE BEAM, ALL NECESSARY INSTALLATION HARDWARE, BEAM REPLACEMENT, AND INSTRUCTIONS FREE OF CHARGE (PLEASE SEE 08E031). THE RECALL BEGAN ON MAY 20, 2008. OWNERS MAY CONTACT SAF-HOLLAND AT 1-231-773-3271 OR COUNTRY COACH AT 1-800-547-8015.

• Recall07V446000September 21, 2007
  ENGINE AND ENGINE COOLING:ENGINE:DIESEL

  ON CERTAIN MOTOR HOMES EQUIPPED WITH CATERPILLAR C9 DIESEL ENGINES, A FUEL PUMP FAILURE WILL DILUTE THE ENGINE OIL WITH FUEL AND MAY CAUSE THE TURBOCHARGER TO FAIL AND CAUSE LOSS OF THROTTLE CONTROL WITH WARNING.

  Remedy

  COUNTRY COACH IS WORKING WITH CATERPILLAR TO HAVE THE FUEL PUMP REPLACED FREE OF CHARGE (PLEASE SEE 07E053). OWNERS MAY CONTACT CATERPILLAR AT 309-675-6496 OR COUNTRY COACH AT 541-998-3720.

• Recall07V241000June 14, 2007
  EXTERIOR LIGHTING

  CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE SIDE MARKER LIGHTS IN THE COMBINATION HEADLIGHT AND TAIL LIGHT ASSEMBLIES DO NOT MEET THE MINIMUM PHOTOMETRIC VALUE AND 45 DEGREES AS SPECIFIED IN THE STANDARD.

  Remedy

  DEALERS WILL REPLACE THE MARKER LIGHTS ON THE SIDE AS CLOSE AS REASONABLE TO THE FRONT AND REAR CORNERS AND WIRED INTO THE PARK LIGHT SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON MARCH 19, 2008. OWNERS MAY CONTACT COUNTRY COACH AT 1-800-547-8015.

• Recall04V463000September 21, 2004
  EQUIPMENT:RECREATIONAL VEHICLE/TRAILER

  ON CERTAIN MOTOR HOMES, LIQUID PROPANE (LP) GAS COOK TOPS WERE INSTALLED USING A FLEXIBLE RUBBER HOSE THAT COULD BURN OR MELT.

  Remedy

  DEALERS WILL REPLACE THE COOK TOP RUBBER HOSE WITH COPPER TUBING. THE RECALL BEGAN ON NOVEMBER 8, 2004. CUSTOMERS CAN CONTACT COUNTRY COACH AT 1-541-998-3720.

• Recall04V464000September 21, 2004
  ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS

  ON CERTAIN MOTOR HOMES, A CIRCUIT BREAKER IN THE CLEARANCE LIGHT CIRCUIT DOES NOT PROTECT THE CIRCUIT FROM A TOO HIGH AMPERAGE DRAW CAUSED BY A TOWED PASSENGER VEHICLE.

  Remedy

  DEALERS WILL REPLACE THE DEFECTIVE CIRCUIT BREAKERS. THE RECALL BEGAN ON NOVEMBER 8, 2004. CUSTOMERS CAN CONTACT COUNTRY COACH AT 1-541-998-3720.

• Recall04V259000June 7, 2004
  STEERING

  ON CERTAIN MOTOR HOMES EQUIPPED WITH AN INDEPENDENT FRONT SUSPENSION (IFS) GEN II BUILT BY HOLLAND USA, THE GEAR PLATE SUPPORT GUSSETS WERE REMOVED. THIS CAN ALLOW THE PLATE TO FLEX DURING A STATIC STEER CONDITION.

  Remedy

  HOLLAND USA IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. A BOLT-ON STRENGTHENING OF THE STEERING GEAR PLATE WITH U-BOLTS CONNECTING THE CROSS MEMBER TO EACH SIDE OF THE GEAR PLATE AT THE REAR PLUS A TUBE SUPPORT IN THE FRONT WITH J-BOLTS TO THE GEAR PLATE WILL BE INSTALLED. OWNERS SHOULD CONTACT HOLLAND USA CUSTOMER SERVICE AT 1-888-396-6501 FOR INFORMATION AND INSTRUCTIONS FOR WHERE CUSTOMERS CAN TAKE THEIR VEHICLES TO HAVE THE REPAIRS DONE FREE OF CHARGE.

• Recall04E040000May 28, 2004
  STEERING

  HOLLAND INDEPENDENT FRONT SUSPENSIONS P/N 90547917 IFS-114 WITH THE 90547978 SUBFRAME FOR USE ON CERTAIN COUNTRY COACH VEHICLES AND SHIPPED BETWEEN MARCH 5, 2003, AND JUNE 28, 2004. EARLY IFS-114 UNITS WITH P/N 90546687 USED A DIFFERENT SUBFRAME, P/N 90546691 THAT IS NOT AFFECTED BY THIS RECALL. THE NEW SUBFRAME DID NOT HAVE GUSSETS THAT HELP SUPPORT THE STEERING GEAR MOUNTING PLATE. THE LACK OF GUSSETS ALLOWS EXCESSIVE FLEXING OF THE STEERING GEAR MOUNTING PLATE WHICH MAY LEAD TO FATIGUE CRACKS.

  Remedy

  HOLLAND WILL NOTIFY COUNTRY COACH'S CUSTOMERS AND PROVIDE REMEDY FREE OF CHARGE. OWNER NOTIFICATION BEGAN JULY 28, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HOLLAND USA CUSTOMER SERVICE AT 1-888-396-6501.

• Recall04V198000April 26, 2004
  EQUIPMENT:OTHER:LABELS

  CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THE FRONT TIRES COLD INFLATION PRESSURES ARE INCORRECT. THE CORRECT COLD TIRE PRESSURE SHOULD BE 120 PSI THAT WILL SUPPORT 13,220 POUNDS.

  Remedy

  DEALERS WILL REMOVE AND REPLACE NEW TIRE LABELS. OWNER NOTIFICATION BEGAN APRIL 30, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT COUNTRY COACH AT 1-800-547-8015.