Chrysler · Model Report
Showing safety data for the 2003 model year only.
CURT MFG IS RECALLING CERTAIN CLASS 3 RECEIVER HITCHES, P/N 13347, SOLD AS AFTERMARKET EQUIPMENT FOR USE ON 1997-2007 CHRYSLER TOWN AND COUNTRY VANS, 1996-2007 DODGE CARAVANS, AND 1996-2004 PLYMOUTH VOYAGER VANS. WHEN THE HITCH IS LOADED TO THE MAXIMUM RATING, THE HITCH MAY FRACTURE OR BREAK AT THE BEND LOCATION WHERE THE MAIN BODY OF THE HITCH MEETS THE HITCH MUFFLER STRAP.
CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK.
ON CERTAIN MINIVANS, THE POWER LIFTGATE (PLG) LATCH MAY NOT ENGAGE THE STRIKER ALLOWING THE LIFTGATE TO OPEN WHILE DRIVING.
ON CERTAIN MINIVANS EQUIPPED WITH 3.3 OR 3.8L V-6 ENGINE, THE UPPER POWER STEERING COOLER HOSE MAY SPLIT AND CAUSE A FLUID LEAK.
CERTAIN AFTERMARKET REPLACEMENT FUEL FILTERS, MODELS WIX FILTER PART NUMBERS 33576, 33577, 33734; NAPA FILTER PART NUMBERS 3576, 3577, 3734; AND CARQUEST FILTER PART NUMBERS 86576, 86577, 86734 USED ON 1996-2000 DAIMLERCHRYSLER TOWN & COUNTRY, DODGE CARAVAN, AND PLYMOUTH VOYAGER VEHICLES, CAN CAUSE THE FUEL LINES TO LEAK.
While driving the van in town it completely shut off. I was driving straight at 35 mph. It would not restart and had to be towed to service garage. When it shut off the first time all of the dash warning lights came on for a second then shut off. The garage said the ignition switch had to be replaced and the main computer. Then the Chrysler dealership had to flash the computer. They said they did and I drove the van 20 miles at 55 mph and it shut off again. No codes were shown when tested. I was able to get it started again after 20 minutes of sitting and tried to drive it again and it kept shutting off while driving 65 mph on the interstate. After several shut offs and finally getting it restarted I was able to get the van to a safe place to have it towed. Now it sits in my driveway because I am afraid to try and drive it again and get into a wreck when it shuts off because there is no warning at all. It just shuts off like someone turns off the key. This is a big safety issue and I am amazed it has not been addressed. I have seen a lot of people posting about their exact same issue with this van.
No injuries · No fire · No crash
eLECTRICAL ISSUSES ILLINOIS AND INDIANNA POLICE RPORTS VEHICLE SHUT DOWN ON THE ROAD
No injuries · No fire · No crash
Quit starting
No injuries · No fire · No crash
Power steering failure and water pump failure smoking under hood and power steering fluid all on the exhaust system almost caught fire.
No injuries · No fire · No crash
VEHICLE POOR DESIGN ON THE ALTERNATOR BRACKET. CAN'T FIND A BRAND NEW PART AND EVERY USED PART I FIND IT HAS THE EXACT SAME BREAK IN THE SAME SPOT.
No injuries · No fire · No crash