Chevrolet · Model Report
Showing safety data for the 1996 model year only.
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
THESE VEHICLES WERE ASSEMBLED WITH THE THROTTLE CABLE CONTACTING THE DASH MAT WHICH COULD BIND THE THROTTLE. THIS DOES NOT MEET WITH THE MAXIMUM RETURN TIMES REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, "ACCELERATOR CONTROL SYSTEMS."
TL* THE CONTACT OWNS A 1996 CHEVROLET TAHOE EQUIP WITH DEXTEERO DHT2 TIRES, SIZED: P265/75R/16, DOT 01BTHBAC00420, AND LINE: NOT AVAILABLE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH AND MAKING A LEFT TURN THE FRONT DRIVERS SIDE TIRE SUDDENLY EXPERIENCED A BLOW OUT CAUSING THE DRIVER TO LOOSE CONTROL OF THE STEERING AND CRASHED INTO A GUARD RAIL. NO INJURIES WERE REPORTED. NO POLICE REPORT WAS TAKEN AND THE VEHICLE WAS TOWED AWAY. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE LOCAL DEALER WALMART LOCATED AT 10404 6TH ST RANCH CUCAMONGA CA. NOTIFIED. THE MANUFACTURER WAS NOT NOTIFIED. THE SAME FAILURE MILEAGE WAS APPROXIMATELY 100 FOR THE TIRE. *LN* *BF *TR
I HAVE A 1996 CHEVY TAHOE WHICH I HAVE BEEN THE ORIGINAL OWNER SINCE NEW. I RECENTLY HAD MAINTENANCE PERFORMED ON THE VEHICLE AND HAD THE SHOP CHECK THE DRIVERS SIDE AIR BAG BECAUSE THE CHECK AIR BAG INDICATOR LIGHT WAS COMING ON DURING THE OPERATION OF THE VEHICLE. THE REPAIR SHOP INDICATED TO ME THAT THE SENSOR NEEDED TO BE REPLACED BUT THE SENSOR WAS NO LONGER AVAILABLE EVEN AFTER A STATES WIDE SEARCH WAS PERFORMED. I CONTACTED GENERAL MOTORS ONLY TO FIND OUT THE PART HAS BEEN DISCONTINUED AND NO REPLACEMENT PART IS AVAILABLE. THE PART NUMBER FROM GM IS #16162465 AND THERE IS NO AFTER MARKET PARTS. IS GENERAL MOTORS STILL RESPONSIBLE FOR A REPLACEMENT PART FOR THIS REQUIRED SAFETY ITEM OR WHAT DO YOU SUGGEST I DO TO CORRECT THIS PROBLEM? *TR
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 1996 CHEVROLET TAHOE. WHILE DRIVING APPROXIMATELY 5 MPH AND PUSHING ANOTHER VEHICLE, THE BRAKES FAILED WHEN THE BRAKE PEDAL WAS DEPRESSED. AS A RESULT, BOTH VEHICLES CRASHED INTO A WALL. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.
MY HUSBAND WAS DRIVING OUR 1996 TAHOE WHEN IT JUST STOPPED! WE FOUND THAT THE KEY HAD SHUT OFF WHILE DRIVING. WE WERE IN THE MIDDLE OF A THRUWAY WHEN EVERYONE WAS DRIVING 60 MPH. A VERY DANGEROUS SITUATION INDEED. THIS HAS HAPPENED 3 TIMES IN THE YEAR I'VE OWNED THE VEHICLE. WE ARE ALSO HAVING A PROBLEM WITH THE WIPERS WORKING INTERMITTENTLY AND SOMETIMES GET STUCK IN THE MIDDLE OF THE WINDSHIELD OR JUMPING ACROSS THE WINDSHIELD POP, POP, POP.ETC. *TR
No injuries · No fire · No crash
VEHICLE STOP SHUT DOWN COMPLETE WITH JERKING BEFORE SHUTTING DOWN STOP PULLING AND LOST ALL POWER NOW SERVICE ENGINE LIGHT IS ON AND ANTI-LOCK BRAKE LIGHT IS ON AND WANT SHIFT INTO SECOND GEAR AS IF SOMETHING IS WRONG WITH TRANSMISSION. *TR
No injuries · No fire · No crash