Chevrolet · Model Report
Showing safety data for the 1986 model year only.
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
THE PUSH PULL HEADLIGHT SWITCH MAY HAVE ELECTRICAL CONTACTS WHICH ALLOW AN INTERMITTENT HEADLIGHT CIRCUIT CAUSING HEADLIGHT TO FLICKER OR SUDDENLY GO OUT. CONSEQUENCE OF DEFECT: SUDDEN LOSS OF THE HEADLIGHTS UNDER SEVERE WEATHER OR NIGHTTIME DRIVING CONDITIONS COULD REDUCE DRIVER VISIBILITY WHICH MIGHT RESULT IN A VEHICLE CRASH WITHOUT PRIOR WARNING.
THE PUSH-PULL HEADLIGHT SWITCH MAY HAVE ELECTRICAL CONTACTS WHICH ALLOW AN INTERMITTENT HEADLIGHT CIRCUIT CAUSING HEADLIGHT TO FLICKER OR SUDDENLY GO OUT. CONSEQUENCE OF DEFECT: SUDDEN LOSS OF THE HEADLIGHTS UNDER SEVERE WEATHER OR NIGHTTIME DRIVING CONDITIONS COULD REDUCE DRIVER VISIBILITY WHICH MIGHT RESULT IN A VEHICLE CRASH WITHOUT PRIOR WARNING. NOTE: ALSO, SEE NHTSA CAMPAIGN NUMBER 86V131000.
NAR 02/10/2003. THE CONSUMERS SON WAS INVOLVED IN AN ACCIDENT WHERE ALL 4 OCCUPANTS DIED. ACCORDING TO A PREVIOUS COMPLAINT, THE VEHICLE FLIPPED OVER AND CAUGHT ON FIRE. NO MENTION OF POSSIBLE DEFECT. *JB
AFTER BEING IN AN ACCIDENT VEHICLE STARTED TO FLIP. AFTERWARDS VEHICLE CAUGHT ON FIRE. DEALERSHIP COULD NOT FIND OUT WHY VEHICLE CAUGHT ON FIRE. CONTACTED DEALER, AND THE DEALER WAS NOT WILLING TO DO ANYTHING.*AK
TRANSMISSION FAILS TO COME OUT OF LOCK UP CAUSING CAR TO STALL AND SHIFT ERRATICALLY WHEN RESTARTED. I FAILURE ANALIZED THE PSOLENOID WHICH WAS REMOVED AND FOUND THE MAL-FUNCTION TO BE CAUSED BY A BLISTERING OF THE PHENALIC CORE MATERIAL DUE TO OVERHEATING THUS CAUSING THE SOLENOID PISTON TO STICK OPEN AND NOT ALLOWING THE FEFLOW OF FLUID TO THE PROPER NON LOCK UP AREAS. I AM NOT ALONE .... THIS IS A FACTORY DESIGN DEFECT IN THE 400 TRANSMISSION. MY SOLUTION WAS TO DECREASE THE POWER ACROSS THE SOLENOID BY 20% BY ADDING A 4 OHM 1 WATT RESISTOR IN THE POWER FEED CIRCUITRY FROM THE NORMALLY CLOSED BRAKE SWITCH POWER FEED. ACTUALLY , GM HAS AN INCORRECT DESIGN HERE AND PERHAPS SHOULD HAVE USED A TEFLON CORE MATERIAL WHICH WOULD NOT HAVE BLISTERED OR HAD A DIFFERENT POWER TYPE UNIT WHICH WOULD NOT HAVE BEEN DEGRADED BY THE HEAT. PROBABLY NOT MANY 96'S AROUND BUT AT OVER A HUNDRED BUCKS A FIX AND POSSIBLE ACCIDENTS .... YOU MIGHT LOOK INTO. THANKS
No injuries · No fire · No crash
SEAT BELT SHOULDER HARNESS HANGS UP ON TOP HOLDER WHEN TRYING TO EXTRACT TO USE IT.
No injuries · No fire · No crash
WHEEL FELL OFF OF VEHICLE AND COLLIDED WITH TWO OTHER VEHICLES.
No injuries · No fire · No crash