Chevrolet Cavalier Complaints (2004)

330 consumer complaints on file.

#10861095April 23, 2016
ELECTRICAL SYSTEM
INSTRUMENT PANEL DOES NOT WORK. THEREFORE DO NOT KNOW THE SPEED IN WHICH IS BEING TRAVELED, TEMPERATURE OF ENGINE, AMOUNT OF FUEL OR ANYTHING. CHECK GUAGES LIGHT COMES ON AND GOES OFF LIKE EVERY WEEK. HAVE NO CLUE WHY IT STOPPED WORKING AND PERSONAL MECHANIC IS APPALLED AT THE ISSUE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10854186April 7, 2016
ELECTRICAL SYSTEM, SEAT BELTS
2 ISSUES. FIRST, TEMPERATURE GAUGE READ HIGHER AND HIGHER EACH TIME THE CAR WAS STARTED UNTIL THE NEEDLE WENT ALL THE WAY AROUND TO THE SPEEDOMETER AND KEPT THE SPEEDOMETER FROM READING THE SPEED. ENTIRE GAUGE CLUSTER WAS REPLACED. SECOND ISSUE WAS PASSENGER FRONT SEAT BELT WOULD PERIODICALLY LOCK, NOT ALLOWING THE PASSENGER TO USE THE SEAT BELT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10853643April 5, 2016
ELECTRICAL SYSTEM
MY TEMPERATURE GAUGE HAS MALFUNCTIONED AND IS STUCK AT 195 DEGREES WHEN I TURN MY CAR ON. IT THEN RISES JUST AS NORMAL BUT STOPS AT 260 DEGREES WHICH IS IN THE RED ZONE
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10818422January 6, 2016
STEERING
TL* THE CONTACT OWNS A 2004 CHEVROLET CAVALIER. WHILE DRIVING APPROXIMATELY 2 MPH AND MAKING A TURN, THE POWER STEERING FAILED WITHOUT WARNING. THE STEERING WHEEL BECAME EXTREMELY DIFFICULT TO MAVNUEVER. THE FAILURE WAS PERMANENT. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08E063000 (STEERING). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10811841December 23, 2015
UNKNOWN OR OTHER
THE SPEEDOMETER AND TACHOMETER REGISTER BELOW ZERO WHEN STOPPED OR IN MOTION. NO WAY TO TELL THE SPEED OR RPM. THIS IS A SAFETY ISSUE TO ALL ON THE ROAD. IF CONTROLLING SPEED IS NOT A SAFETY ISSUE WORTH RECALLING WHY DO WE HAVE SPEED LIMITS? NHTSA NEEDS TO TAKE THIS SERIOUSLY AND LAUNCH A RECALL AS THIS IS A MAJOR ISSUE AND NOT ISOLATED ITS VERY WIDESPREAD AND THE FACT THEY HAVE NEGLECTED IT SHOWS THERE REAL LACK OF CONCERN FOR SAFETY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10811156December 18, 2015
STEERING, SUSPENSION
THE VEHICLE STEERING IS NOT TIGHT AND I AM NOT ABLE TO TIGHTLY CONTROL THE MOVEMENT COMPLETELY WHEN GOING OVER BUMPS OR MAKING TURNS. THE WHEEL STEERING FEELS LOOSE AND UNSECURED. WHEN DRIVING THE SPEED LIMIT ON THE HIGHWAY, THE VEHICLE DRIFTS REGARDLESS IF I HAVE CONTROL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10809295December 9, 2015
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2004 CHEVROLET CAVALIER. THE CONTACT STATED THAT THE INSTRUMENT PANEL FAILED TO FUNCTION PROPERLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE AND VIN WERE NOT AVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10789816November 11, 2015
UNKNOWN OR OTHER
THE CLUSTER IS OUT AND I CAN'T TELL HOW MUCH FUEL, THE SPEEDOMETER IS OUT AND ALSO THE TEMP GAGE AS WELL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10748651August 14, 2015
STEERING
AROUND 4:00PM AFTER GETTING OFF WORK. I WAS DRIVING HOME AND I WENT TO MAKE A LEFT TURN, MY STEERING WHEEL MOVED UP THEN DOWN DIAGONALLY ABOUT A INCH; INCH AND A HALF. IT DOES IT EVERY TIME NOW WHEN ANY KIND OF UPWARD PRESSURE IS PUT ON THE STEERING WHEEL. I DON'T KNOW HOW SERIOUS OF A PROBLEM THIS IS, BUT IT DOES SEEM IF IT GETS ANY WORSE IT COULD EFFECT YOUR DRIVING ABILITY OF THE CAR.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10735069July 20, 2015
STEERING, ELECTRICAL SYSTEM
FOR SEVERAL YEARS NOW, THE INTERIOR LIGHT HAS BEEN COMING ON INTERMITTENTLY WHEN I HIT A BUMP IN THE ROAD. LAST YEAR I WENT SHOPPING, GOT BACK INTO MY CAR & STARTED IT, OR RATHER TRIED TO START IT, BUT IT SHUT DOWN QUITE QUICKLY. THINKING IT WAS A FLUKE, I TRIED TO START IT SEVERAL MORE TIMES WITH THE SAME RESULTS. NOT EVEN PUSHING ON THE GAS COULD KEEP IT GOING. AFTER TOWING THE CAR & HAVING IT SIT AROUND FOR A WHILE BEFORE SOMEONE COULD FINALLY FIND THE ELECTRICAL ISSUE, IT WAS 'REPAIRED'. THE ISSUE WAS THE WIRING FOR THE IGNITION SWITCH. THE REPAIR COMPLETED WAS A CHEAPER ROUTE THAN REPLACING THE ACTUAL SWITCH. WHAT I DIDN'T KNOW UNTIL TOO LATE LAST YEAR WAS THE 'SERVICE W/WRENCH' AND 'THEFT SYSTEM' LIGHTS WERE THE WARNING THAT THE SWITCH WAS ABOUT TO GO OUT. THE INTERIOR LIGHT HAS BEEN DOING THE SAME THING AGAIN & THE THEFT & SERVICE LIGHTS CAME ON AGAIN LAST WEDNESDAY, 7/15/15, AND NOW I KNOW I HAVE NO CHOICE BUT TO REPLACE THE IGNITION SEITCH. LAST YEAR I CONTACTED GM BUT THEY ONLY WANTED TO MAKE A NOTE ABOUT IT. I'M SURE THAT AS TIME GOES ON OTHERS WILL HAVE ISSUES TOO. HOW CAN WIRES COME LOOSE OR BREAK BEHIND A STEERING WHEEL? PLUGS, HOSES & THINGS LIKE THAT I CAN FULLY UNDERSTAND, BUT NOT SOMETHING THAT IS HIDDEN & SUPPOSEDLY SAFE BEHIND A STEERING WHEEL
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10733490July 12, 2015
STRUCTURE:BODY
THE GARNISH MOLDING-WINDSHIELD PILLAR-DRIVER'S SIDE FELL PARTLY OFF BLOCKING MY VISIBILITY WHILE DRIVING HOME FROM WORK. IT WAS NEVER TOUCHED AND FOR NO REASON IT FELL OFF AND TO THIS DAY I AM UNABLE TO REATTACH IT..
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10731076June 29, 2015
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2004 CHEVROLET CAVALIER. WHILE DRIVING APPROXIMATELY 30 MPH OVER A BUMP IN THE ROAD, THE VEHICLE BEGAN TO SHAKE. THE CONTACT ALSO NOTICED THAT THE VEHICLE FAILED TO START PROPERLY ON MULTIPLE OCCASIONS. THERE WERE NO WARNING LIGHTS ILLUMINATED; HOWEVER, THE INTERIOR LIGHTS WOULD NOT ILLUMINATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10726245June 19, 2015
STEERING
TL* THE CONTACT OWNS A 2004 CHEVROLET CAVALIER. WHILE DRIVING APPROXIMATELY 60 MPH, THE STEERING SUDDENLY MALFUNCTIONED. THE VEHICLE SPUN OUT AND CRASHED INTO A SECOND VEHICLE. NO INJURIES WERE REPORTED AND A POLICE REPORT WAS FILED. THE VEHICLE WAS TAKEN TO A DEALER, BUT THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 100,000.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10717248May 19, 2015
EXTERIOR LIGHTING:TURN SIGNAL, VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 2004 CHEVROLET CAVALIER. WHILE DRIVING APPROXIMATELY 25 MPH, THE VEHICLE EXPERIENCED UNINTENDED ACCELERATION EVEN THOUGH THE BRAKE PEDAL WAS ENGAGED. THE CONTACT MENTIONED THAT THE TURN SIGNAL LIGHTS ALSO FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS UNKNOWN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10712311April 22, 2015
FUEL/PROPULSION SYSTEM, ELECTRICAL SYSTEM:IGNITION:SWITCH
AT TIMES, DURING THE PAST SEVERAL MONTHS THIS VEHICLE HAS BEEN HARD TO START. HAD THE FUEL PUMP AND IGNITION SWITCH REPLACED, BUT DID NOT SEEM TO SOLVE THE PROBLEM. RECENTLY, THE CAR STALLED OUT WHILE DRIVING AND TOOK 15 MINUTES TO FINALLY RE-START. I HAVE READ ONLINE WHERE THIS HAS BEEN A PROBLEM FOR OTHER OWNERS OF CHEVY CAVALIERS- HARD TO START AND STALLS OUT SOMETIMES. NOT SURE WHAT IS CAUSING THE PROBLEM, BECAUSE THE CHECK ENGINE LIGHT DOES NOT COME ON AND THERE IS NO CODE TO DIAGNOSIS/READ. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10703449April 3, 2015
POWER TRAIN
BOUGHT USED HAD 109000 FIRST TIME THE CLUTCH WENT OUT ON ME I WAS EXHILARATING TO MOVE INTO HEAVY FREEWAY TRAFFIC AND IT GOES OUT, ESPECIALLY AS A YOUNG WOMAN I WAS VERY SCARRED FOR MY LIFE TO THIS DAY I HAVE NIGHTMARES, GOT IT FIXED BUT NO REALLY CAUSE IT STILL DOES IT WE JUST HAVE TO KEEP PUTTING DOT 3 AT THE CLUTCH LINE. ITS ANNOYING, A WASTE OF TIME, WASTE OF MY MONEY, AND HAS CAUSED DOMESTIC DISPUTES. COME ON DO SOMETHING PLEASE!! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10694745March 17, 2015
STRUCTURE:BODY
I LEFT THE VEHICLE RUNNING IN DRIVEWAY FOR LESS THAN 5 MINUTES. VEHICLE WAS FULL OF BLACK SMOKE AND WITHIN MINUTES WAS TOTALLY ENGULFED IN FLAMES. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10691973March 4, 2015
ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL
WHILE DRIVING DOWN THE ROAD MY SPEEDOMETER FOR STUCK. I KNOW I WAS GOING 60 WHEN IT HAPPENED BECAUSE THAT'S WHAT IT IS STUCK AT.IT ISN'T THE FIRST TIME THIS HAS HAPPENED. MY CAR HAS HAD MULTIPLE PROBLEMS WITH THE WINDSHIELD WIPERS, WINDOWS, AND ENGINE LIGHT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10680134January 31, 2015
ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL (ESC), SERVICE BRAKES
THE INSTRUMENT CLUSTER BOARD HAS STOPPED, WORKING AND APPEARS TO BE AN ONGOING ISSUE WITH GM ON SEVERAL MODELS (CAR AND TRUCK) BETWEEN 1998-2009. ALSO THE ABS, TRACTION CONTROL, SERVICE ENGINE LIGHTS WILL NOT GO OFF. WINDOW DOORS ARE NOT WORKING AND APPEARS TO ALL RELATED TO THE CLUSTER PANEL. I HAVE REPLACED ALL ABS SENSORS, NEW BRAKES PADS, ROTORS, AND EVEN FRONT BEARINGS. THE ENGINE ITSELF WORKS GREAT AND IS FINE AND APPEARS THAT GM HAS DONE A GREAT JOB IN THIS PART. THE CLUSTER PANEL AND WIRING IS A SERIOUS SAFETY ISSUE AND NEEDS TO BE REVIEWED IN THESE MODELS. POOR GROUND WIRING AN CLUSTER PANELS CAN CAUSE CONSUMERS TO SPEND THOUSANDS OF DOLLARS IN REPAIRS AND STILL RESULTING IN THE SAME PROBLEM. CLUSTER PANEL REPLACEMENT CAN BE FROM $300 TO $800 DEPENDING ON YOUR LOCAL MECHANIC. THIS IS A SERIOUS ISSUE SINCE ABS AND TRACTION CONTROL ARE NOT WORKING DUE TO THE LONG LIST OF ISSUES. I RECOMMEND A RECALL ON CLUSTER PANELS FOR ALL CAVALIERS AND MODULES, WIRING AS WELL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10671512January 9, 2015
ELECTRICAL SYSTEM
THE PROBLEM ORIGINALLY STARTED WITH THE TEMPERATURE GAUGE (SHOWED THAT THE CAR WAS ALWAYS OVERHEATING) AND THEN EVENTUALLY STOPPED MOVING AT ALL. NEXT, THE RPMS STOPPED MOVING AND THE SPEEDOMETER BEGAN SHOWING THAT WE WERE GOING 100 WHEN WE COULDN'T HAVE BEEN GOING MORE THAN 35. NOW THE SPEEDOMETER DOESN'T MOVE AT ALL. SO, AT THIS POINT IS IMPOSSIBLE TO KNOW HOW FAST I AM GOING, IF THE CAR IS OVERHEATING, OR WHAT THE RPMS ARE. CURRENTLY THE FUEL GAUGE WORKS MOST OF THE TIME, BUT OCCASIONALLY AFTER FILLING UP THE TANK THE GAUGE WILL MOVE TO THE FAR RIGHT (AS IF IT'S TELLING US THAT THE TANK IS OVERFILLED), TO WHERE IT WOULD INTERFERE WITH THE OTHER GAUGES (IF THEY WERE WORKING). I FEEL THIS IS A BIG SAFETY PROBLEM AND AT THE VERY LEAST IS VERY ANNOYING (ALREADY BEEN PULLED OVER TWICE FOR GOING 10 MILES OVER, BECAUSE I HAD NO IDEA HOW FAST I WAS GOING). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Cavalier