BMW Z4 Service Bulletins
513 manufacturer communications on file.
- January 1, 2016•Document ID: 10151023Service Bulletin/Repair InstructionsEQUIPMENT:APPLIANCE:AIR CONDITIONER
- Mfr Comm. #:
- B650709
- Date Added:
- December 10, 2018
- Manufacturer:
- BMW
SummaryWhistling Noise Coming from the Center Vent - A/C is Off . A very high pitched whistling or beeping noise is heard coming from the center vents. The flow of refrigerant through the expansion valve at certain temperature differentials.
Associated Products (289)Associated Documents - January 1, 2016•Document ID: 10150899Service Bulletin/Repair InstructionsEQUIPMENT ADAPTIVE/MOBILITY; FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS
- Mfr Comm. #:
- B011715
- Date Added:
- December 10, 2018
- Manufacturer:
- BMW
Summary"SI B01 17 15 January 2016 Warranties. This Service Information bulletin supersedes SI B01 17 15 dated December 2015. designates changes to this revision SUBJECT N54T Engine Fuel Injectors - Limited Warranty Extension to 10 Years/120,000 Miles . INFORMATION For the above-referenced vehicles, BMW of North America, LLC (""BMW NA"") is extending the limited warranty for the fuel injectors to: 10 years/120,000 miles as determined by the vehicle's original in-service date. This ""component-specific"" limited warranty extension applies to defects in materials and workmanship and is subject to the applicable vehicle and coverage eligibility requirements, exclusions and limitations that apply to the BMW New Vehicle Limited Warranty for Passenger Cars and Light Trucks."
Associated Products (4)Associated Documents - January 1, 2016•Document ID: 10150898Service Bulletin/Repair InstructionsENGINE; FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS
- Mfr Comm. #:
- B010215
- Date Added:
- December 10, 2018
- Manufacturer:
- BMW
Summary"SI B01 02 15 January 2016 Warranties This Service Information bulletin supersedes SI B01 02 15 dated December 2015. designates changes to this revision SUBJECT N54 Engine Fuel Injectors - Limited Warranty Extension to 10 Years/120,000 Miles . INFORMATION For the above-referenced vehicles, BMW of North America, LLC (""BMW NA"") is extending the limited warranty for the fuel injectors to: 10 years/120,000 miles as determined by the vehicle's original in-service date. This ""component-specific"" limited warranty extension applies to defects in materials and workmanship and is subject to the applicable vehicle and coverage eligibility requirements, exclusions and limitations that apply to the BMW New Vehicle Limited Warranty for Passenger Cars and Light Trucks."
Associated Products (14)Associated Documents - December 1, 2015•Document ID: 10147876Service Bulletin/Repair InstructionsSTRUCTURE:BODY:DOOR; EQUIPMENT
- Mfr Comm. #:
- B513815
- Date Added:
- November 13, 2018
- Manufacturer:
- BMW
SummaryDoor Brake Makes Squeaking Noise. The customer may complain of a squeaking noise when opening or closing either front door. Debris inclusions imbed into the door brake slide mechanism.
Associated Products (8)Associated Documents - December 1, 2015•Document ID: 10147858Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL
- Mfr Comm. #:
- B090615
- Date Added:
- November 13, 2018
- Manufacturer:
- BMW
SummaryNew programming feature: Exclusion of Infotainment Control Units from Programming. Programming with ISTA/P 3.57.4, or a more recent update, displays a new Pop-Up window providing options for systems programming.
Associated Products (63)Associated Documents - December 1, 2015•Document ID: 10147857Service Bulletin/Repair InstructionsEQUIPMENT; EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
- Mfr Comm. #:
- B011715
- Date Added:
- November 13, 2018
- Manufacturer:
- BMW
Summary"N54T Engine Fuel Injectors - Limited Warranty Extension to 10 Years/120,000 Miles. INFORMATION For the above-referenced vehicles, BMW of North America, LLC (""BMW NA"") is extending the limited warranty for the fuel injectors to: 10 years/120,000 miles as determined by the vehicle's original in-service date This ""component-specific"" limited warranty extension applies to defects in materials and workmanship and is subject to the applicable vehicle and coverage eligibility requirements, exclusions and limitations that apply to the BMW New Vehicle Limited Warranty for Passenger Cars and Light Trucks.This bulletin is notice of a ""limited warranty extension."" This is NOT a notice of a Recall or Service Action. There is no immediate repair required unless the BMW vehicle is currently experiencing this problem. Customer Notification Letter - VIN and Component-specific Warranty Extension Even though this is NOT a Recall, BMW NA will be sending VIN-specific customer notification letters in a phased release during the first quarter of 2016."
Associated Products (4)Associated Documents - December 1, 2015•Document ID: 10147853Service Bulletin/Repair InstructionsEQUIPMENT; EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
- Mfr Comm. #:
- B010215
- Date Added:
- November 13, 2018
- Manufacturer:
- BMW
Summary"N54 Engine Fuel Injectors - Limited Warranty Extension to 10 Years/120,000 Miles. INFORMATION For the above-referenced vehicles, BMW of North America, LLC (""BMW NA"") is extending the limited warranty for the fuel injectors to: 10 years/120,000 miles as determined by the vehicle's original in-service date This bulletin is notice of a ""limited warranty extension."" This is NOT a notice of a Recall or Service Action. There is no immediate repair required unless the BMW vehicle is currently experiencing this problem. Customer Notification Letter - VIN and Component-specific Warranty Extension Even though this is NOT a Recall, BMW NA will be sending VIN-specific customer notification letters in a phased release during the first quarter of 2016. ELIGIBLE BMW VEHICLES To assist you in identifying the eligible vehicles, the DCSnet Warranty Vehicle Inquiry will be updated shortly with the ""Vehicle Comment"" shown below: BMW NA has extended the limited warranty for the engine fuel injectors on this vehicle to 10 years/120,000 miles as determined from the original in-service date. This component-specific limited warranty extension is subject to all the applicable vehicle and coverage eligibility requirements, exclusions and limitations that apply to the BMW New Vehicle Limited Warranty for Passenger Cars and Light Trucks. Please see SI B01 02 15. Note: Always check the DCSnet Warranty Vehicle Inquiry ""Vehicle Comments"" and the ""Repair History (Claims)"" sections first, before performing any repairs."
Associated Products (11)Associated Documents - September 1, 2015•Document ID: 10147242Service Bulletin/Repair InstructionsSERVICE BRAKES, HYDRAULIC; SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC
- Mfr Comm. #:
- B340414
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummaryDiagnosis of Compound Brake System Complaints in M Vehicles This Service Information bulletin supersedes SI 34 04 14 dated December 2014. Designates changes to the bulletin. INFORMATION 1.Visible cracks are caused by high thermal stresses during rapid heating and cooling of the brake discs. Braking from high speed with cold brake components (less than 212 degrees F) increases the likelihood of cracks to form. These surface hairline cracks are usually spread over the entire brake disc friction area, and have no negative influence on the durability or braking performance. The rotors should not be replaced only for their appearance reasons.When performing routine service on the brake system (pad replacement due to wear), the brake discs should be replaced if surface cracks are found to be greater than 13 mm, or if the brake disc thickness is below the minimum thickness. Always replace brake discs in pairs (per axle). Install new brake pads when replacing discs. By doing this, the service life of the friction pad surface is increased, and an even material loss is ensured. 2. Vibrations and/or steering wheel torsional vibrations during braking are caused by applying the brakes on discs with minimal to heavy corrosion. These vibrations are most noticeable when braking from high speeds with cold brake components (less than 212 degrees F), and will diminish with normal everyday operation. Parts replacement is not required. 3.After high brake loads, running noises can be heard when applying the brakes, and may also be heard to a limited extent after the brakes are released. (See the note in the Owner's Manual). These noises are reduced during normal everyday operation, due to further erosion of the brake pad friction lining. Visible surface cracks or craterlike recesses on the brake pad surface are caused by a minor difference in the material of the pad lining, which will decrease with further operation and should not be replaced due to their appearance.
Associated Products (100)Associated Documents - September 1, 2015•Document ID: 10147235Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING:EXHAUST SYSTEM; ENGINE
- Mfr Comm. #:
- B111615
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary?N20 and N26 engine: Smoke from Exhaust when Starting a Cold Engine. When starting a cold engine, blue smoke can be seen emitting from the exhaust tailpipe for approximately 10-20 seconds. No turbo charger boost faults are stored and no drivability issues can be detected. Engine oil leakage into the induction system and/or the turbo charger assembly.
Associated Products (73)Associated Documents - August 1, 2015•Document ID: 10151399Service Bulletin/Repair InstructionsENGINE
- Mfr Comm. #:
- B111315
- Date Added:
- December 10, 2018
- Manufacturer:
- BMW
SummaryThe plastic oil filter housing may fail and lead to an internal and/or external engine oil or coolant leak.
Associated Products (67)Associated Documents - July 1, 2015•Document ID: 10147214Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL; ELECTRICAL SYSTEM:SOFTWARE; EQUIPMENT
- Mfr Comm. #:
- B840215
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummaryCannot Update Bluetooth Software (KISU Data). The vehicle does not accept the KISU (Customer Initiated Software Update) software update.
Associated Products (8)Associated Documents - July 1, 2015•Document ID: 10147206Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; ELECTRICAL SYSTEM:SOFTWARE
- Mfr Comm. #:
- B611515
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummaryCAS Module Fails Programming with CoAPI Error 2082. During vehicle programming, the CAS (Car Access System) module fails to program with CoAPI error 2082 displayed. Refer to the attachment, which lists the affected CAS serial numbers. The following part numbers are affected: 61 35 9 287 534 61 35 9 226 238 61 35 9 227 053 61 35 9 287 535
Associated Products (12)Associated Documents - July 1, 2015•Document ID: 10147202Service Bulletin/Repair InstructionsEQUIPMENT:OTHER:LABELS
- Mfr Comm. #:
- B511615
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary"Affected vehicles in dealer inventory must not be retailed or delivered until the label is removed. Vehicles at ports of entry will be remedied prior to dealer delivery. On affected vehicles, there is an incorrect label regarding the appropriate engine oil. Affected vehicles can be identified with a ""Vehicle Comment"" in the DCS Warranty Vehicle Inquiry or ISPA Light. Remove the engine oil label (located in the front or rear of the hood)."
Associated Products (143)Associated Documents - July 1, 2015•Document ID: 10146945Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING; EQUIPMENT
- Mfr Comm. #:
- B111315
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummaryThe plastic oil filter housing may fail and lead to an internal and/or external engine oil or coolant leak.
Associated Products (67)Associated Documents - July 1, 2015•Document ID: 10146944Service Bulletin/Repair InstructionsENGINE
- Mfr Comm. #:
- B111012
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummaryN20 Engine: Repeated Juddering or Surging While Accelerating. The vehicle judders or surges repeatedly while accelerating in hot ambient temperatures between 3,000 RPM and 5,000 RPM. The Service Engine Soon lamp is not illuminated, and no fault codes are stored in the vehicle memory related to this complaint. CAUSE The EPDW (electropneumatic pressure convertor) for the turbocharger wastegate valve is binding internally.
Associated Products (35)Associated Documents - July 1, 2015•Document ID: 10058986Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- 11 13 15
- Date Added:
- January 8, 2016
- Manufacturer:
- BMW
SummaryTHE PLASTIC OIL FILTER MIGHT FAIL WHICH WILL CAUSE A LEAKAGE TO THE INTERNAL AND /OR EXTERNAL ENGINE OIL OR COOLANT
Associated Products (4)Associated Documents - July 1, 2015•Document ID: 10058975Service Bulletin/Repair InstructionsENGINE
- Mfr Comm. #:
- 11 10 12
- Date Added:
- January 6, 2016
- Manufacturer:
- BMW
SummaryWHEN ACCELERATING, IN HOT AMBIENT TEMPERATURES, BETWEEN 3,000 RPM AND 5,000 RPM, CAUSES JUDDERS OR SURGES IN VEHICLE, REPEATEDLY, DUE TO THE ELECTROPNEUMATIC PRESSURE CONVERTOR. *MA
Associated Products (3)Associated Documents - June 1, 2015•Document ID: 10147724Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- B650215
- Date Added:
- November 13, 2018
- Manufacturer:
- BMW
SummaryiDrive Controller Trim Peeling. The chrome ring on the iDrive controller is peeling. Poor chrome material adhesion.
Associated Products (77)Associated Documents - June 1, 2015•Document ID: 10147714Service Bulletin/Repair InstructionsPOWER TRAIN:AUTOMATIC TRANSMISSION
- Mfr Comm. #:
- B240215
- Date Added:
- November 13, 2018
- Manufacturer:
- BMW
Summary8HP: Transmission Fluid Loss from Cooler Lines Connections. There is a transmission fluid leak in the area around the oil cooler lines (on the transmission side). CAUSE Damaged o-rings due to unfavorable cooling line connection tolerances
Associated Products (38)Associated Documents - June 1, 2015•Document ID: 10058551Service Bulletin/Repair InstructionsPOWER TRAIN:MANUAL TRANSMISSION; POWER TRAIN:AUTOMATIC TRANSMISSION
- Mfr Comm. #:
- SIB-24-02-15
- Date Added:
- October 7, 2015
- Manufacturer:
- BMW
SummaryBMW: ON TRANSMISSION SIDE, IN SOME VEHICLES, THE TRANSMISSION FLUID IS LEAKING AROUND THE AREA OF THE OIL COOLER LINES CAUSING UNFAVORABLE COOLING LINE CONNECTION TOLERANCES TO DAMAGE O RINGS. MODEL E84 (X1), E89 (Z4), F22 & 23 (2 SERIES), F30 & 31 (3 SERIES), F32 & 33 (4 SERIES), F34 (GRAN TURISMO), F36 (GRAN COUPE). *PE
Associated Products (9)Associated Documents