BMW X4 Service Bulletins (2021)
168 manufacturer communications on file.
- October 1, 2022•Document ID: 10227547Service Bulletin/Repair InstructionsFUEL SYSTEM, GASOLINE; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
- Mfr Comm. #:
- B160322
- Date Added:
- December 12, 2022
- Manufacturer:
- BMW
SummaryThe Check Engine Light is on (MIL). After checking faults and diagnosis there is raw fuel found in the charcoal canister and the NVLD pressure switch (in R/R wheel well). Possible faults stored in the DME: 190F08 - Fuel tank venting system: Malfunction 191C02 - Fuel tank venting system,2. discharge point: Malfunction The vent line inside the fuel tank is disconnected.
Associated Products (4)Associated Documents - September 1, 2022•Document ID: 10225127Service Bulletin/Repair InstructionsLANE DEPARTURE
- Mfr Comm. #:
- B662719
- Date Added:
- October 31, 2022
- Manufacturer:
- BMW
SummaryThe Lane Change Warning (LCW) yellow triangle symbol on either one, or both the exterior side view mirrors does not illuminate to alert the driver when it should.
Associated Products (15)Associated Documents - September 1, 2022•Document ID: 10225126Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL
- Mfr Comm. #:
- B662419
- Date Added:
- October 31, 2022
- Manufacturer:
- BMW
SummaryVehicle cannot be opened or closed using comfort access, engine start is not possible, and the vehicle may not start when placing the key against the steering column.
Associated Products (51)Associated Documents - September 1, 2022•Document ID: 10225121Service Bulletin/Repair InstructionsVISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
- Mfr Comm. #:
- B640422
- Date Added:
- October 31, 2022
- Manufacturer:
- BMW
SummaryAn interference noise (groaning noise) can be heard from within the heating and air-conditioning unit in the center of the instrument panel.
Associated Products (26)Associated Documents - September 1, 2022•Document ID: 10225114Service Bulletin/Repair InstructionsVISIBILITY:SUN/MOON ROOF ASSEMBLY
- Mfr Comm. #:
- B540421
- Date Added:
- October 31, 2022
- Manufacturer:
- BMW
SummaryThe front sunroof glass seal has shrunk, creating a gap which can cause wind noise or excess water entry.
Associated Products (12)Associated Documents - August 1, 2022•Document ID: 10224210Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL
- Mfr Comm. #:
- SIB650922
- Date Added:
- October 17, 2022
- Manufacturer:
- BMW
SummaryThe sound output intermittently drops out entirely. This can be reproduced with all audio sources as well as telephone and voice output.
Associated Products (67)Associated Documents - August 1, 2022•Document ID: 10224186Service Bulletin/Repair InstructionsEQUIPMENT; STRUCTURE
- Mfr Comm. #:
- SIB011219
- Date Added:
- October 17, 2022
- Manufacturer:
- BMW
SummaryComponent-Specific Limited Warranty Extension. For the eligible vehicles, BMW of North America, LLC (BMW NA) is extending the limited warranty for the vehicle's Radiator Grille Upper and Lower Active Air Flaps to: 15 years/150,000 miles as determined by the vehicle's original in-service date. 1. Air flap control (link) active, upper (G12, G30 and G32) 2. Air flap control (drive), active, upper 3. Air flaps, upper (assembly) 4. Air flaps, lower (assembly) For eligible MY 2017 BMW 530i (B460) vehicles that are currently registered in the State of California (CA) or a State that has fully adopted the State of California PZEV/SULEV regulation (CT, ME, MD, MA, NJ, NY, RI, and VT), the standard emission-related coverage for the Radiator Front Grille Air Vent Flaps is15 years/150,000 miles. This component-specific limited warranty extension applies to defects in materials or workmanship.' This coverage is subject to the same vehicle eligibility requirements, limitations, and exclusions that apply to the BMW New Vehicle Limited Warranty for Passenger Cars and Light Trucks. A check control message or MIL (Malfunction Indicator Lamp) may be illuminated with faults stored related to the upper and/or lower active air flap(s). Potential causes include: Faulty upper air flap link (G12, G30, G32) Faulty upper air flap actuator (G01, G02, G12, G30, G32) Faulty upper flap assembly (G01, G02, G12, G30, G32) Faulty lower air flap assembly (G01, G02, G12, G30, G32) Software error in the DME affecting the upper flap (G01, G02 only) Or: Upon visual inspection, the passenger side upper active air flaps are either stuck open or closed, and they will not move and there are no faults stored for the active air flaps (With no check control message or check engine light or displaying)
Associated Products (8)Associated Documents - August 1, 2022•Document ID: 10224185Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- SIB010921
- Date Added:
- October 17, 2022
- Manufacturer:
- BMW
SummaryComponent-Specific Limited Warranty Extension. For the eligible vehicles, BMW of North America, LLC (BMW NA) is extending the limited warranty for the vehicle's Leak Diagnosis Module with hose assembly (NVLD, shown) to: 15 years/150,000 miles as determined by the vehicle's original in-service date. For eligible MY 2017 BMW 530i Sedan and xDrive (B460) vehicles that are currently registered in the State of California (CA) or a State that has fully adopted the State of California PZEV/SULEV regulation (CT, ME, MD, MA, NJ, NY, RI, and VT), the standard component-related coverage for the NVLD is 15 years/150,000 miles. This component-specific limited warranty extension applies to defects in materials or workmanship. This coverage is subject to the same vehicle eligibility requirements, limitations, and exclusions that apply to the BMW New Vehicle Limited Warranty for Passenger Cars and Light Trucks. Over time, the Leak Diagnosis Module (NVLD) (with connected hose) component material may fail, this can create a fine leak to develop in the Evaporative Emission Control System (EVAP). Should this occur, corresponding fault codes will be stored in the DME memory and the MIL (Malfunction Indicator Lamp) will illuminate.
Associated Products (7)Associated Documents - July 1, 2022•Document ID: 10218413Service Bulletin/Repair InstructionsSUSPENSION:FRONT:MACPHERSON STRUT; SUSPENSION
- Mfr Comm. #:
- SIB510522
- Date Added:
- August 22, 2022
- Manufacturer:
- BMW
SummaryBMW AG has issued a Delivery Stop (effective March 28, 2022) on certain Model Year 2022 BMW vehicles that were produced between March 1, 2022 and March 8, 2022 because the torsion struts may not have been installed at the plant. Do not deliver to a customer, a New, Certified Pre-Owned or Used vehicle subject to a Delivery Stop, until the vehicle is repaired. Do not use or sell replacement equipment/parts subject to a Delivery Stop.
Associated Products (4)Associated Documents - June 1, 2022•Document ID: 10218384Service Bulletin/Repair InstructionsEQUIPMENT; ELECTRICAL SYSTEM
- Mfr Comm. #:
- SIB662419
- Date Added:
- August 22, 2022
- Manufacturer:
- BMW
SummaryVehicle cannot be opened or closed using comfort access, engine start is not possible, and the vehicle may not start when placing the key against the steering column. Note: Opening, closing and starting via the BMW Digital Key or the Digital Key Card are not affected.
Associated Products (34)Associated Documents - June 1, 2022•Document ID: 10218381Service Bulletin/Repair InstructionsAIR BAGS; ELECTRICAL SYSTEM
- Mfr Comm. #:
- SIB650122
- Date Added:
- August 22, 2022
- Manufacturer:
- BMW
SummaryA check control message for the restraint system appears. In the instrument cluster, the red air bag warning light lights up permanently. One of the following fault codes is stored in the ACSM (air bag control unit): 930949 - Knee airbag, driver: short circuit to negative terminal 93094F - Knee airbag, front passenger: short circuit to negative terminal.
Associated Products (4)Associated Documents - May 1, 2022•Document ID: 10215751Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING; EQUIPMENT
- Mfr Comm. #:
- SIB170122
- Date Added:
- July 18, 2022
- Manufacturer:
- BMW
SummaryThe Check Control message below appears even though the coolant level is not below minimum when the engine is cold. Check Control message (ID 166): Top up coolant.
Associated Products (10)Associated Documents - May 1, 2022•Document ID: 10215750Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:SOFTWARE; ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM):SOFTWARE
- Mfr Comm. #:
- SIB090121
- Date Added:
- July 18, 2022
- Manufacturer:
- BMW
SummaryBMW offers a new special ISTA Installation made available for Roadside Assistance / Mobile Service technicians. The new ISTA Version is also able to be used in case of a Remote Software Upgrade (RSU) programming failure to get the customer car reprogrammed on site. In case of a Remote Software Upgrade failure, the engine start is prevented for safety reasons until the vehicle is programmed correctly. Most of the errors occur when only one control unit fails to program correctly.
Associated Products (42)Associated Documents - May 1, 2022•Document ID: 10214991Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:ADAS:HUD:CAMERA/SENSOR; ELECTRICAL SYSTEM:ADAS:BLINDSPOT:SENSORS; ELECTRICAL SYSTEM:ADAS:DRIVER MONITORING:CAMERA/SENSOR; ELECTRICAL SYSTEM:ADAS:HILL DESCENT ASSIST:SENSOR; ELECTRICAL SYSTEM:ADAS:PARKING ASSIST:SENSORS
- Mfr Comm. #:
- SIB660620
- Date Added:
- July 5, 2022
- Manufacturer:
- BMW
SummaryThe functionality of the right front SRR sensor could be reduced which would display the "Driving Assistance" Check Control Message.
Associated Products (8)Associated Documents - May 1, 2022•Document ID: 10214990Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- SIB651312
- Date Added:
- July 5, 2022
- Manufacturer:
- BMW
SummaryThe Headunit High (HU-H), also called NBT, began replacing the Car Information Computer (CIC) on certain MY2013 vehicles with option 609 (as of 7/2012 production). This uses map North America NEXT. The Headunit High 2 (HU-H2), also called NBT-EVO, superseded the NBT HU and was introduced in 3/2014. This uses map North America EVO. The Headunit High 4 (HU-H4, also called MGU21) superseded the MGU starting with certain MY2021 vehicles with option code 6U3 Live Cockpit Professional. This uses map North America JOY. The ENTRY Media/Navigation (HU-B) is the low line business version of the navigation system and was introduced in 3/2014. This uses map North America ROUTE. The ENTRY NAV EVO (HU-B2) replaced Entry Media/Navigation as the low-line business version and was introduced in certain MY2018 vehicles. This uses map North America WAY.
Associated Products (56)Associated Documents - May 1, 2022•Document ID: 10214989Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- SIB640222
- Date Added:
- July 5, 2022
- Manufacturer:
- BMW
SummaryMist formation on the windshield inside surface may occur at departure or after MSA (automaticstart/stop). Acoustic abnormality in the area of the recirculated air flap (recirculation flap closing and opening severaltimes). The above may occur individually or in combination.
Associated Products (44)Associated Documents - May 1, 2022•Document ID: 10214985Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL
- Mfr Comm. #:
- SIB610822
- Date Added:
- July 5, 2022
- Manufacturer:
- BMW
SummaryWhen using the Key Reader to retrieve information from the customer's key, no current vehicle data is available.
Associated Products (13)Associated Documents - May 1, 2022•Document ID: 10214984Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL
- Mfr Comm. #:
- SIB610722
- Date Added:
- July 5, 2022
- Manufacturer:
- BMW
SummaryCheck Control Message (CCM) displays "Vehicle key missing" after engine start.
Associated Products (37)Associated Documents - May 1, 2022•Document ID: 10214981Service Bulletin/Repair InstructionsSTRUCTURE
- Mfr Comm. #:
- SIB510722
- Date Added:
- July 5, 2022
- Manufacturer:
- BMW
SummaryThis bulletin outlines known areas of possible functional issues, operational noise, or wind noise for the vehicles listed above. It serves only as a diagnostic resource in troubleshooting complaints pertaining to the doors, windows, and mirrors. This bulletin and the associated attachments are designed to provide one single diagnostic resource for troubleshooting all known issues related to the door, windows, and mirrors of BMW Sports Activity Vehicles which have quality improvement measures already in place.
Associated Products (10)Associated Documents - April 1, 2022•Document ID: 10214266Service Bulletin/Repair InstructionsAIR BAGS; LANE DEPARTURE
- Mfr Comm. #:
- SIB650122
- Date Added:
- June 21, 2022
- Manufacturer:
- BMW
SummaryA check control message for the restraint system appears. In the instrument cluster, the red air bag warning light lights up permanently.
Associated Products (10)Associated Documents