BMW of North America, LLC (BMW) is recalling certain 2000-2005 323iT, 325iT, 325xiT, 320i, 323i, 325i, 325xi, 328i, 330i and 330xi and 2000-2006 323Ci, 325Ci, 328Ci, 330Ci, M3 Coupe, 323Cic, 325Cic, 330Cic, and M3 Convertible vehicles equipped with non-desiccated frontal Takata PSAN inflators and PSPI passenger frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) propellant that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
BMW of North America, LLC (BMW) is recalling certain model year 2002-2005 325i, 325xi, 330i, and 330xi Sedans, and 325xi and 325i Sportswagons, 2002-2006 330Ci, 325Ci, and M3 Convertibles and 325i, 330i, and M3 Coupes, 2002-2003 M5, 540i, 525i Sedan, and 530i Sedans, and 540i and 525i Sportswagons, and 2003 X5 3.0i and 4.4i Sports Activity Vehicles. Please note that the 5-series and X5 vehicles are only included if they are equipped with the optional sports steering wheel. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
The contact owns a 2004 BMW 325 CI. The contact stated that while driving at an undisclosed speed, the driver's side rear turn signal light became inoperable while attempting to make a turn. There was no warning light illuminated. The contact stated that the rear turn signal light failed to function properly. The vehicle was taken to an independent mechanic, where it was diagnosed that the rear tail lamp functions had failed and needed to be replaced. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 250,000.
No injuries · No fire · No crash
The TAKATA airbags were replaced April 8, 2021, by Reeds Import, Tampa FL. Please save a tree and stop sending recall notices. Thank you. Mark
No injuries · No fire · No crash
AFTER RECALLED AIR BAGS REPLACED, ABOUT 6 MONTHS LATER NEW AIR BAG SENSOR LIGHT CAME ON AND DIAGNOSED AS PASSENGER SEAT AIR BAG SENSOR MAT NEEDS TO BE REPLACED. JUST RANDOMLY THE LIGHT CAME ON AND STAYED ON. I SEE THIS HAS BEEN A PROBLEM IN BMWS AND THERE WAS AN EXTENDED WARRANTY FOR OTHER MODELS. THIS SHOULD BE A RECALL AS IT IS A SAFETY ISSUE AS BAGS WILL NOT DEPLOY.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2004 BMW 325CI. THE CONTACT STATED THAT UPON MAKING A RIGHT TURN AND A STOP, HE NOTICED THAT HIS RIGHT TURN SIGNAL HAD FLASHED ERRATICALLY UPON ACTIVATION. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHO INFORMED HIM THAT THERE WAS A RECALL ON HIS VEHICLE UNDER NHTSA CAMPAIGN NUMBER: 11V438000 (EXTERIOR LIGHTING). THE CONTACT CALLED CHAPMAN BMW CHANDLER (7455 W ORCHID LN, CHANDLER, AZ 85226) WHERE HE MADE AN APPOINTMENT TO HAVE THE VEHICLE REPAIRED UNDER THE RECALL. THE DEALER CALLED BACK AND INFORMED HIM THAT HIS VEHICLE WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND CONFIRMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER THEN REFERRED HIM TO NHTSA FOR ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000.
No injuries · No fire · No crash
2004 BMW 325CI. CONSUMER WRITES IN REGARDS TO PASSENGER SIDE AIRBAG SAFETY RECALL. *LD *JS
No injuries · No fire · No crash