AIRSTREAM · Model Report
AIRSTREAM Safari2005
Showing safety data for the 2005 model year only.
Recalls
Checking records…
Complaints
Checking records…
Investigations
Checking records…
Service Bulletins
Checking records…
AIRSTREAM · Model Report
Showing safety data for the 2005 model year only.
AIRSTREAM IS RECALLING 2,052 MY 2002-2009 BAMBI, INTERNATIONAL, SAFARI, 75TH ANNIVERSARY, DWR, AND OCEAN BREEZE TRAVEL TRAILERS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE TRAVEL TRAILERS WERE BUILT WITHOUT REAR REFLEX REFLECTORS.
AIRSTREAM IS RECALLING 4,450 MY 2004-2007 SAFARI, INTERNATIONAL, INTERSTATE, LAND YACHT, CLASSIC, MY 2004-2006 SKYDECK, AND MY 2006 PARKWAY TRAVEL TRAILERS AND MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
ON CERTAIN TRAVEL TRAILERS, THE 110-VOLT RECEPTACLE IN THE GALLEY AREA OF THE UNIT IS REQUIRED TO BE PROTECTED BY A GROUND FAULT INTERRUPTER (GFI) RECEPTACLE OR BY A GFI TYPE BREAKER IN THE PANEL BOARD. THE 110-VOLT GALLEY RECEPTACLE UNIT DOES NOT HAVE THIS PROTECTION.
ON CERTAIN MOTORHOMES, THE OUTER WHEEL BEARING IN THE HUB OF THE AXLE MAY FAIL, LEADING TO UNEXPECTED SEPARATION OF THE WHEEL FROM THE AXLE. THIS FAILURE MAY BE DUE TO AN INADEQUATE AMOUNT OF GREASE IN THE HUB ASSEMBLY OR THE GREASE IN THE HUB MAY BREAK DOWN UNDER NORMAL OPERATING CONDITIONS INTO A LIQUID THAT INADEQUATELY LUBRICATES THE OUTER BEARING. INADEQUATE LUBRICATION OF THE OUTER BEARING CAN BEGIN A CHAIN OF EVENTS THAT COULD LEAD TO WHEEL SEPARATION.
TL*THE CONTACT OWNS A 2005 AIRSTREAM SAFARI BAMBI TRAILER. WHILE DRIVING 75 MPH, THE BRAKES FAILED AND THE CONTACT LOST CONTROL OF THE TRAILER. THE TRAILER WAS TAKEN TO THE DEALER, BUT THEY WERE UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE DEALER RECONNECTED THE BRAKE WIRES. UPON FURTHER INVESTIGATION, THE CONTACT WAS ABLE TO DETERMINE THAT THE STEEL PLATE THAT HOLDS THE BRAKE ASSEMBLY WAS NOT WELDED TO THE AXLE HOUSING, WHICH CAUSED THE BRAKE WIRES TO BE TORN FROM THE BRAKE ASSEMBLY. THE CONTACT CALLED THE MANUFACTURER AND WAS INFORMED TO SUBMIT PICTURES. THE PICTURES WERE SENT AND THE CONTACT WAS INFORMED NOT TO PULL THE TRAILER BECAUSE IT WAS UNSAFE. NO COMPENSATION WOULD BE MADE BECAUSE THE WARRANTY WAS EXPIRED. THE TRAILER IS CURRENTLY BEING REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE UNKNOWN.
No injuries · No fire · No crash
TL*THE CONTACT OWNS A 2005 AIRSTREAM SAFARI. THE CONTACT STATED THAT THE TREAD ON BOTH REAR TIRES IS SEPARATING. HE NOTICED THAT THE TIRES ARE 30.5 INCHES HIGH IN DIAMETER, WHEN THEY SHOULD BE 28.5 INCHES. THE PASSENGER SIDE REAR TIRE, WHICH WAS A SPARE, FAILED AT 2,500 MILES AND THE DRIVER SIDE REAR TIRE FAILED AT 12,500 MILES. THE TIRES ARE GOODYEAR MARATHON (SIZE ST225/75 R15) AND BOTH TIRES HAVE 65 PSI. THE CONTACT CAN PROVIDE PICTURES AND THE ACTUAL TIRES IF NEEDED. THE CURRENT AND FAILURE MILEAGES WERE 12,500. NO OTHER VEHICLE INFORMATION WAS AVAILABLE.
No injuries · No fire · No crash
ON FRIDAY, JUNE 17, 2005, WHILE TRAVELING THROUGH CHICAGO, OUR AIRSTREAM TRAVEL TRAILER BRAKES BEGAN INTERMITTENTLY LOCKING WHILE BRAKING. LATER, WHILE DRIVING SOUTH ON I-57, BREAK CONTROLLER BEGAN PERIODICALLY REPORTING AN OPEN CIRCUIT AND WHEN THE BREAKS WERE APPLIED, THE CONTROLLER REPORTED SHORT CIRCUIT. WE ARRIVED AT AN AIRSTREAM DEALER WHERE A TECHNICIAN WAS ABLE TO PERFORM A VISUAL INSPECTION OF THE AIRSTREAM BREAK WIRES. AFTER REMOVING THE BREAK DRUMS, THE TECHNICIAN OBSERVED THAT THE THREE METAL CLIPS WHICH HOLD THE TWO WHITE WIRES FOR THE MAGNETIC BREAK WERE NOT SECURED TO THE BREAK ARMATURE. FURTHER, OBSERVATION REVEALED THAT THE BREAK PADS ON THE RIGHT REAR WHEEL HAD RUST DEPOSITS INDICATING THAT THE BREAKS MAY NOT HAVE BEEN IN OPERATION FOR A LONG PERIOD OF TIME. UPON CLOSER EXAMINATION, TECHNICIAN DISCOVERED THAT THE INSULATION ON ONE OF THE WHITE WIRES HAD WORN THROUGH FROM THE CHAFING OF THE BREAK MECHANISM, WHICH ULTIMATELY WAS MAKING CONTACT WITH METAL CAUSING A SHORT CIRCUIT. TEMPORARY REPAIR WAS MADE UNTIL A REPLACEMENT PART COULD BE OBTAINED.
No injuries · No fire · No crash