Volvo XC90 Complaints (2016)

197 consumer complaints on file.

#11677323July 30, 2025
ENGINE
Piston ring failure, excessive oil consumption. There was an extended warranty regarding the issue, but it has since been closed. I know there have been multiple lawsuits regarding this issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11663205May 27, 2025
UNKNOWN OR OTHER
The back door, or liftgate, closes automatically (without me pressing the close button). This is inconsistent, as it doesn't happen all the time. Each time the car has been off, and maybe it's on some kind of timer. It's happened 3 times, at random, where each time it caught me off guard. One time it hit me on the back of the head. The next time my kids were sitting in the back and I had to yell for them to tuck their legs inside. The third time, was just last week, and I had to run out from under it. There is no beeping or warning, and I'm afraid it's only a matter of time before it causes serious injury. I've had this vehicle for about 12 months, and it's only happened 3 times, but I can't figure out what the causes it.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11654041April 11, 2025
ELECTRICAL SYSTEM, STRUCTURE
The contact owns a 2016 Volvo XC90. The contact stated that water had been leaking into the vehicle on rainy days. The contact stated that the water intrusion was causing several warning lights to illuminate and unknown vehicle safety equipment failures. The contact stated that the front and rear carpets and the spare tire were saturated with water. The contact had taken the vehicle to a local dealer, where it was determined that water was leaking into the vehicle, but the dealer was unable to determine the point of intrusion. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 168,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11649980March 23, 2025
SEAT BELTS
Safety belt will not retract in pillar when unbuckled.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11640401February 3, 2025
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Loaded children into second row of vehicle, confirmed all doors closed. Began driving, passenger rear door swung open. Child DID NOT engage door handle. Pulled over to attempt to close door. Door latch would not engage, could not close or lock door. Still unable to close and lock door.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11639662January 30, 2025
ENGINE
The contact owned a 2016 Volvo XC90. The contact stated that while her daughter was driving at an unknown speed, white smoke began to emit from the vehicle as fellow motorists alerted her daughter that a fire had started underneath the vehicle. The contact's daughter immediately pulled over as all occupants exited the vehicle. The contact called the authorities as the vehicle was quickly incinerated by the fire. The contact stated that her youngest grandson suffered emotional distress as a result of the fire. No physical injuries were reported and a police report was filed(police report unavailable). The fire department extinguished the fire once they arrived. The vehicle was towed to an independent tow yard; the vehicle was deemed a total loss. The manufacturer had yet to be notified of the failure. The failure mileage was unknown. The VIN was not available.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11632722December 27, 2024
VISIBILITY:SUN/MOON ROOF ASSEMBLY, STRUCTURE:BODY
The contact owns a 2016 Volvo XC90. The contact stated that water was entering the vehicle through the sunroof. There was an abnormal odor of mold inside the vehicle. The carpet was not wet. There was an abnormal swishing sound detected inside the vehicle. After it rained, the contact noticed that the passenger side front floorboard had an accumulation of water a quarter inch deep. The contact noticed the water was leaking on the airbag from the exterior A-pillar. The contact moved the headliner, and the rubber boot was intact. The call/SOS warning light was illuminated. The contact called the local dealer, who informed about diagnostic testing and scheduled an appointment. The manufacturer was not contacted. The approximate failure mileage was 80,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11629994December 10, 2024
ENGINE, FUEL/PROPULSION SYSTEM
I have a 2016 XC90 T6 Inscription. The issue started after refill the engine oil and led to malfunction in engine system. The engine list the power and slowed down the car while driving. I brought the car to the dealer 2 times already and had been fine for 3 months. However, the engine oil light showed up to refill after 3 months. I am aware that other Volvo owners are facing the same issue and it is due to defect of piston and piston ring.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11628794December 4, 2024
LATCHES/LOCKS/LINKAGES:DOORS:LOCK
The rear doors get stuck closed. No unlocking or releasing child lock solves this issue. Had the passenger rear door unavailable for over 6 months and then it opened again only for the other side to quit working now. Volvo does not cover this issue despite clear danger to riders in accident or emergency in need to exit vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11614985September 17, 2024
ENGINE AND ENGINE COOLING, SERVICE BRAKES, EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
The contact owns a 2016 Volvo XC90. The contact stated that while driving at various speeds, the oil light illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 19V308000 (Engine and Engine Cooling). The vehicle was taken to an independent mechanic, where it was diagnosed that an oil change was needed. The vehicle was repaired. The vehicle was taken to another local dealer, who informed the contact that the vehicle was consuming oil and informed the contact about an oil consumption test. The contact was informed that a spark plug had exploded in the engine. The engine was replaced. The contact noticed that water was entering inside the vehicle. There was water dripping on the entertainment center, and the pixels were half out. The vehicle was taken to the local dealer, where it was diagnosed that the infotainment screen needed to be replaced. The vehicle was repaired. While driving at unknown speeds, the brakes became inoperable. While at a car wash, the fenders detached. After driving for several hours, the turn off engine message was displayed. The contact added additional coolant, but the coolant depleted quickly. The vehicle was taken back to the local dealer, where it was diagnosed that the engine line had split open. The vehicle was repaired. The manufacturer was contacted, and opened a case but no assistance was provided. The failure mileage was approximately 140,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11613659September 9, 2024
ENGINE
Started getting high coolant temperature warning, indicating to slow down and then after a short while to stop the vehicle. The vehicle now cannot be driven without the warning showing up after several minutes of driving after sitting. Of course comes on much sooner if it's been running before that. We had to pull over and wait several times during interstate travel. No codes are present using a code reader. It reads the temp at around 215 degrees when warning comes on to slow down. Continues to increase until warning to stop vehicle. I inspected the engine. A lot of symptoms were inline with a bad thermostat. Changed that with no luck. I again inspected the engine and found the broken tube. It was inline with where it's supposed to be attached, so it was missed the first time. I researched online and found recall 19V308 related to a previous version of the part. The newer version is installed (Volvo part 31238231), yet the same exact conditions are present that the replacement was supposed to avoid. Seems reasonable that if that's the case, it should also be covered by another safety recall. The pics also include coolant accumulation in that area as well as corroded plastic conduit for what looks like some type of wire for electrical component. I'm not sure what that part is, but I've sent a pic also of where it goes into the engine. Seems like the higher heat that the coolant can reach eventually melted/corroded the conduit. The wire inside is also not in good shape, but is intact still.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11611314August 28, 2024
ENGINE
There is a engine coolant leak from the plastic coolant line connector going into the motor
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11607823August 11, 2024
ENGINE
The exhaust manifold and supercharger on my 2016 Volvo XC90 have malfunctioned. The exhaust manifold has a visible crack, and the supercharger has seals that are leaking exhaust gases. Both components are available for inspection upon request and have been diagnosed by an independent mechanic who conducted a smoke test revealing these issues. The malfunction poses a significant safety risk as exhaust gases are leaking into the cabin, creating a dangerous environment that could lead to carbon monoxide poisoning. This condition represents a serious health hazard to anyone in the vehicle. Yes, the problem has been confirmed by an independent service center. They diagnosed the issue with the P0171 code indicating the engine is running lean due to a vacuum leak. They also conducted a smoke test that identified the cracked manifold and leaking supercharger seals. The vehicle has not yet been inspected by the manufacturer, police, or insurance representatives. It has been inspected by an independent mechanic. Yes, prior to the failure, the vehicle displayed a warning light for the P0171 code indicating that the engine was running lean. Other symptoms included unusual oil consumption and excessive oil in the intake system, which were previously diagnosed by a Volvo dealer as a factory defect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11606575August 5, 2024
ELECTRICAL SYSTEM, ENGINE, FUEL/PROPULSION SYSTEM
The hybrid motor periodical will hesitate when accelerating from a stop, specifically it'll start accelerating then lose power for up to a couple of seconds before regaining power. This poses a safety risk if you start pulling out into traffic and suddenly and unpredictably lose power while there's oncoming vehicles. The problem just occurred for the first time about a week ago and coincidentally just a few days after taking the car in for its annual service, since then it has happened more frequently and I can't find any rhyme or reason as to why it happens. The vehicle will be going in to be checked out shortly. There have been no warning lights any time this has happened.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11603169July 18, 2024
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, FORWARD COLLISION AVOIDANCE: WARNINGS, STRUCTURE:BODY
Same issue as complaint #11416043. Leak in sunroof has caused several electrical issues with the car. I had noticed occasional drips from the rear view mirror but had no idea that water was pooling under the spare tire in the trunk where several electrical components are located. When I originally brought it to the dealer (when I noticed the occasional drips) they said I needed to replace a major part of the sunroof which would have cost around $2,000. They did not mention that the water could/would reach the under carriage (not sure if that is the correct term) and could cause major electrical issues. I've since noticed that many others with this vehicle have had issues with the sunroof. I also had multiple times when my battery had to be replaced in the rear of the car when it should have been fine (was relatively new) which looking back could have been a result of the sunroof leak.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11600070July 8, 2024
ENGINE
The contact owns a 2016 Volvo XC90. The contact stated that after starting the vehicle, the vehicle failed to accelerate above 15 MPH while depressing the accelerator pedal. The contact stated that a turtle warning symbol appeared on the instrument panel along with an "Engine System Reduced Performance" message displayed. The contact called the dealer and had the vehicle towed to the dealer location. After two days of diagnostic testing, the contact was informed that the engine needed to be replaced due to engine failure. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 175,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11599703July 7, 2024
ENGINE
Excessive Oil consumption. Volvo knowingly allows for the sale and resale of their 2013-2016 vehicles all makes and models even though they know there is an engine issue causing excessive oil consumption due to bad pistons and o rings in the engine. They’ve tried to hide this for years and since has covered a limited number of vehicles to be repaired based on stringent requirements eliminating most of the vehicles that actually should be covered. This oil consumption issue is dangerously causing vehicle to over consumption oil possibly causing the engine to seize or costly repairs up to but not limited to $13,000. This issue has cost me excessive oil changes and oil purchases in just a matter of months since its purchase date. A warranty was issued for this issue but Grubbs Volvo of Grapevine Texas has stated that due to the requirements my vehicle does not qualify to be covered because of the time limitations Volvo put on the repairs. This is a manufacturing issue with defective engine parts which should have been a recall not a warranty allowance. Volvo is deceiving consumers. Not only is this an issue for repairs, this could potentially cause accidents should and engine seize while operating on a roadway and who knows how many lives are at stake. The years 2013-2016 should be cover 100% by recall no matter what if vehicle falls in the all models 2013-2016 manufacturer dates. This has caused me excessive oil change purchases of $189.00 and 1 liter of oil weekly after just driving 1500 miles in 3 weeks. This is a huge problem and is well documented and should be recalled and corrected.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11593127June 7, 2024
ENGINE
We are a repair facility and the vehicle arrived for a concern with a weak battery and a battery warning light. The battery was testing bad and was replaced but the other issues persisted. The vehicle was scanned for codes and the codes present in the computer were B139F11, P26DC00 & P059700. After researching these codes we discovered a technical service bulletin related to the same issue and codes (Ref. No: TJ 30268.6.0). The bulletin states "If any of above DTC´s are set in the ECM or CEM for the pre-heated thermostat in the cooling system, and/or if the customer complains of a charging system warning message in the Driver’s Information Module (DIM), follow advice under SERVICE". The bulletin then describes the required service "Replace the thermostat according to instructions in VIDA and erase DTC. Not replacing the thermostat can cause consequential damages". After reading this we followed the service in the bulletin and replaced the thermostat but the issue persist. At this point we have replaced multiple components in compliance with the service bulletin but the battery warning light is still displayed as well as auto start stop disabled & the A/C blower not operating correctly. The bulletin also states that if the issue persist to "submit a vehicle report using function group 2627" but it does not state where the report can be submitted.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11592531June 4, 2024
POWER TRAIN, ENGINE, FUEL/PROPULSION SYSTEM
The vehicle exhibits excessive oil consumption due to defective oil control rings, as highlighted by Quality Bulletin P10186. Additionally, the sunroof leaks, as noted in Technical Journal 31272 and TJ 35503.3.0, and there are further issues with the windshield wiper/turn signal system, the parking brake system, and the steering wheel module. Yes, the vehicle is available for inspection upon request. The excessive oil consumption and related engine issues can lead to engine damage and potential failure while driving, posing a serious safety risk. The sunroof leakage could impair visibility and cause electrical failures. The persistent dashboard warning messages and system malfunctions further distract and endanger the driver and others on the road. Yes, the problem has been reproduced and confirmed by various dealers and independent service centers, as indicated by numerous customer cases, court rulings, and a class-action lawsuit. Yes, the vehicle has been inspected by the manufacturer and documented in various technical journals and bulletins. There is no specific mention of inspection by police or insurance representatives. Yes, there were several warning lamps and messages, including the low oil light, Check Engine light, and messages related to the parking brake and windshield wiper/turn signal system. Symptoms such as slow acceleration, loss of power, higher tailpipe emissions, and a foul odor from the exhaust were also observed. These issues appeared shortly after acquiring the vehicle and persisted despite multiple repair attempts. The incident is primarily caused by engineering flaws and faulty materials, particularly the defective oil control rings leading to excessive oil consumption. Despite engine replacements, the problem persisted, indicating a fundamental design flaw. The sunroof leakage and other system malfunctions further suggest widespread safety and durability issues in the vehicle, rendering it unsafe to operate.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11590302May 23, 2024
ENGINE AND ENGINE COOLING
The contact owns a 2016 Volvo XC90. The contact stated that after arriving at his workplace and parking the vehicle, he was alerted that the vehicle was smoking. The contact became aware that coolant was leaking from underneath the front of the vehicle and was puddling underneath the vehicle. The contact drove the vehicle to a local dealer, where it was diagnosed and determined that the coolant hose had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not informed of the failure. The contact researched online and related the failure to NHTSA Campaign Number: 19V308000 (Engine and Engine Cooling). The failure mileage was approximately 110,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volvo XC90