Volkswagen Passat Complaints (2003)

637 consumer complaints on file.

#10265532April 15, 2009
ENGINE AND ENGINE COOLING
9/2002 PURCHASED 2003 VOLKSWAGEN PASSAT 1.8 TURBO. 2005- 48,000 ENGINE FAILED DUE TO SLUDGE. TOWED TO COMMONWEALTH MOTORS SANTA ANA, CA AFTER 2 MOS INSTALLED NEW OIL PUMP, WE EACH PAID HALF EVEN THOUGH IT IS A KNOWN DESIGN FLAW WITH OIL PUMP. 2007 SAME THING HAPPENED( BUT I WAS AWAY AND CAR TOWED TO LOCAL GARAGE) MECHANIC STATED THAT NO WARRANTY WOULD COVER PROBLEM. ESTIMATED 95. FINAL $2,569 TO REPLACE OIL PUMP AND TURBO PICKED UP CAR IN MARCH 2008, IN DEC 2008 ENGINE FAILED AGAIN TOWED TO MESA WEST WHO SUGGESTED DEALER SHOULD BE CALLED. DEALER ACCEPTED RESPONSIBILITY ON PHONE SINCE THEY HAD DONE ORIGINAL REPAIR, 4 MONTHS LATER CAR NEEDS NEW ENGINE IS STILL AT DEALER. OIL PUMP CANNOT PROCESS PROPERLY. VW AWARE OF CHRONIC PROBLEM BUT WON'T STAND BY PRODUCT UNLESS ALL RECEIPTS FROM OIL CHANGES ARE AVAILABLE. CAR NEED $6000.00 OF WORK AND DEALER DOING NOTHING TO ASSIST REGARDLESS OF PROMISES MADE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10263610March 30, 2009
LATCHES/LOCKS/LINKAGES
WHILE OPENING MY TRUNK LID, THE PASSENGER SIDE HINGE BROKE. THE LID, DROPPED, DOWN AND I CAUGHT IT, WITH OUT HARM. BUT IT COULD HAVE EASILY HURT MY HAND OR HEAD. I CALLED THE DEALER TO ORDER A REPLACEMENT PART, HE INDICATED IT WAS VERY POPULAR. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10263688March 30, 2009
SEATS
VEHICLE WAS HIT FROM THE REAR BY ANOTHER VEHICLE. DRIVERS SEAT SLID ALL THE WAY FORWARD IN ITS TRACKS AND THE SEAT BACK COLLAPSED ALL THE WAY FLAT. SEAT INTEGRITY SHOULD BE MAINTAINED IN THIS TYPE OF INCIDENT. *TR
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10263558March 29, 2009
ENGINE AND ENGINE COOLING:COOLING SYSTEM, POWER TRAIN:AUTOMATIC TRANSMISSION, EQUIPMENT:APPLIANCE:AIR CONDITIONER, EQUIPMENT:MECHANICAL
PURCHASE CAR IN FL, NOW LIVE IN IOWA DUE TO JOB TRANSFER. A/C UNIT CONTINUES TO NOT BLOW COLD AIR IN A DEPENDABLE METHOD. HAVE TO SHUT OFF VEHICLE AND RESTART TO SOMETIMES GET IT STARTED AGAIN. NOW TORQUE CONVERTER LIGHT CAME ON JUST AFTER POWERTRAIN WARRANTY EXPIRED 1 MONTH OUTSIDE OF WARRANTY. GOT IN CONTACT WITH VW OF AMERICA. WOULD NOT ASIST, BUT INSTEAD SENT $2,000 GOOD FAITH VOUCHER TOWARDS TO PURCHASE OF A NEW VEHICLE TO MAKE AN ATTEMPT TO HELP ME WITH THE PROBLEMS. PLEASE HELP. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10262985March 24, 2009
ENGINE AND ENGINE COOLING:ENGINE
APPARENT ENGINE OIL SLUDGE PROBLEM. THE OIL LIGHT CAME ON WITH A WARNING TO STOP THE ENGINE. THE CAR IS CURRENTLY IN THE SHOP AWAITING EVALUATION OF THE EXTENT DAMAGE. I PURCHASED THE CAR USED AND HAVE NO RECORD OF THE PREVIOUS OWNERS MAINTENANCE. I MAINTAIN MY OWN VEHICLE THEREFORE DO NOT HAVE RECEIPTS TO PROVE EACH OIL CHANGE ACCORDING TO THE SCHEDULE. VW RECOMMENDS CHANGES EVERY 5,000 MILES; I CHANGED IT EVERY 3,000. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10262438March 19, 2009
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
DEALER REFUSES TO FIX RECALL UNLESS I ACCEPT RESPONSIBILITY FOR ANY DAMAGE TO AFTERMARKET PARTS OCCURRING WHILE REPLACING HEAT SHIELD ON EXHAUST SYSTEM. THERE IS A POTENTIAL FOR FIRE IF ORIGINAL HEAT SHIELD IS NOT REPLACED. RECALL R5, CRITERIA 1. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10262042March 16, 2009
ENGINE AND ENGINE COOLING, FUEL SYSTEM, GASOLINE, ELECTRICAL SYSTEM
I HAVE HAD MY 2003 VW PASSAT FOR 7 MONTHS NOW AND HAVE ALREADY HAD IT IN THE SHOP 3 TIMES. RIGHT AFTER I BOUGHT IT USED FROM A VW DEALERSHIP THE TURBO WENT OUT. I HAD TO PAY FOR THAT. I THEN DROVE THE CAR ABOUT 150 MILES FOR A TOURNAMENT AND WHEN ALMOST THERE A LIGHT CAME ON SAYING TO STOP AND TURN OFF THE ENGINE. TOOK IT TO VW DEALERSHIP AND IT WAS COVERED BY VW. IT HAD SOMETHING TO DO WITH SLUDGE FROM OIL. GOT IT BACK AND 3 DAYS LATER A LIGHT CAME ON. IT WAS THE MIL LIGHT. I TOOK IT IN TO THE VW DEALERSHIP. STILL WAITING TO HEAR WHAT THE PROBLEM IS THIS TIME. I HAVE NOW HAD MY OIL CHANGED 3 TIMES IN 5 THOUSAND MILES DUE TO REPAIRS. IT HAS BEEN ONE THING AFTER ANOTHER WITH THIS CAR SO FAR. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10260783March 5, 2009
SERVICE BRAKES, ELECTRIC
ABS CONTROL MODULE FOR A 2003 VW PASSAT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10259671February 23, 2009
FUEL SYSTEM, GASOLINE
WHILE DRIVING MY 2003 VW PASSAT DOWN THE HIGHWAY AT 35 MILES PER HOUR, THE ENGINE SIMPLY CEASED OPERATING. FORTUNATELY, I WAS ABLE TO GET OUT OF TRAFFIC AND GLIDE INTO A SHOPPING CENTER PARKING LOT. THE VEHICLE WOULD NOT RESTART AND HAD TO BE TOWED, AND THE FUEL PUMP REPLACED. THE PASSAT HAD ONLY 51,764 MILES WHEN THIS BREAKDOWN OCCURRED. WHILE SEARCHING THROUGH THE INTERNET, I HAVE SEEN NUMEROUS COMPLAINTS OF THIS SAME MAKE MODEL AND YEAR VEHICLE WITH A FUEL PUMP FAILURE. VW HAS ONLY RECALLED CERTAIN VIN NUMBERS FOR THIS FUEL PUMP. MY PASSAT DOES NOT FALL WITHIN THE RECALL VINS AND VW REFUSES TO ACKNOWLEDGE A GLOBAL PROBLEM WITH THESE FUEL PUMPS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10258660February 14, 2009
SUSPENSION:FRONT
CAR WENT IN FOR BRAKE JOB AT 39,000 MILES. MECHANIC FOUND THAT BOTH FRONT CV JOINTS WERE CRACKED AND FRONT AXLES AND CV BOOTS WOULD NEED REPLACEMENT. THIS WAS CLOSE TO A $1,000.00 REPAIR JOB ON A CAR WITH UNDER 40,000 MILES. APPARENTLY THIS IS A NOT UNCOMMON PROBLEM WITH 5TH GENERATION PASSAT VEHICLES. I FEEL VOLKSWAGEN SHOULD DO A RECALL ON THIS PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10258613February 13, 2009
SERVICE BRAKES, HYDRAULIC, POWER TRAIN:DRIVELINE:CONSTANT VELOCITY JOINT, STRUCTURE:BODY:HOOD:HINGE AND ATTACHMENTS, ENGINE AND ENGINE COOLING, STEERING:HYDRAULIC POWER ASSIST SYSTEM
TL*THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT A NEW PAIR OF RARE BRAKES FAILED ON HER VEHICLE AFTER 14,952 MILES. SHE USUALLY GETS OVER 36,000 MILES ON A PAIR OF BRAKES. SHE STATED THAT THE BRAKE PADS FAILED AND DAMAGED THE ROTORS. THE CONTACT FEELS THAT THE PADS ARE DEFECTIVE AND SHOULD HAVE LASTED LONGER THAN 14,000 MILES. SHE ALSO FEELS THAT THE DEALER SHOULD COVER THE COST OF THE NEW PADS. THE CURRENT AND FAILURE MILEAGES WERE 95,100. UPDATED 04/21/09. *LJ THE SERPENTINE BELT WAS CRACKED, THE POWER STEERING FLUID WAS LOW, THE VC BOOT AND HOOD STRUT WAS REPLACED.. UPDATED 04/21/09.*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10257151February 2, 2009
AIR BAGS
FOLLOWING ROUTINE MAINTENANCE OF MY VEHICLE, (TUNE-UP, INCLUDING REPLACEMENT OF SPARK PLUGS AND IGNITION HARNESSES) MY REPAIR SHOP MECHANIC REPORTED THAT THE AIRBAG WARNING LIGHT CAME ON AND STAYED ON. HE SAID HE WAS UNABLE TO TURN IT OFF. I THEN TOOK THE VEHICLE TO A FACTORY-AUTHORIZED VW DEALER AND WAS TOLD THE PROBLEM WAS CAUSED BY LOW VOLTAGE TO THE AIRBAG UNIT, THAT THE BATTERY TESTED LOW AT 12.04 VOLTS AND THEY COULD NOT RESET THE CODE WITHOUT REPLACING THE BATTERY. I APPROVED NEW BATTERY PURCHASE, BUT DEALER WAS UNABLE TO MAKE WARNING LIGHT GO OUT, DESPITE RECODING THE CONTROLLER . DEALER CLAIMED FURTHER TESTING REVEALED AIRBAG UNIT CONTROLLER HAD FAILED AND WOULD REQUIRE REPLACEMENT AT PARTS COST OF $798.00. I DECLINED TO PAY THAT AMOUNT. IN REPLY TO MY QUESTION, SERVICE REP SAID HE WAS UNABLE TO CONFIRM THAT AIRBAG(S) WOULD DEPLOY IN CASE OF AN ACCIDENT. SINCE THEY I HAVE DRIVEN VEHICLE FOR ABOUT ONE MONTH, AND EACH TIME I START VEHICLE A WARNING SOUNDS, THE "AIRBAG FAILURE" NOTICE COMES UP ON THE DASHBOARD AND THE AIRBAG WARNING SIGNAL STAYS ON CONSTANTLY. I TELEPHONED VW CUSTOMER SERVICE TO COMPLAIN AND WAS TOLD THERE WAS NO RECALL ON THIS PROBLEM AND THAT SINCE VEHICLE WAS NEARLY 6 YEARS OLD AND OUT OF WARRANTY I WOULD NEED TO ASSUME COST OF REPAIR/UNIT REPLACEMENT. I SAID I THOUGHT THIS WAS A SAFETY FAILURE WITH VEHICLE BECOMING OUT OF COMPLIANCE WITH FEDERAL SAFETY REQUIREMENTS THROUGH NO FAULT OR MALPRACTICE OF THE OWNER (MYSELF) AND THAT VW SHOULD ASSUME COST OF REPAIRS. CUSTOMER SERVICE REP SAID THEY WOULD LOOK INTO IT AND REPLY. SO FAR NO RESPONSE. VEHICLE CONTINUES TO DISPLAY AIRBAG WARNING LIGHT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10256502January 27, 2009
ELECTRICAL SYSTEM, ENGINE AND ENGINE COOLING, INTERIOR LIGHTING, EXTERIOR LIGHTING, AIR BAGS, LATCHES/LOCKS/LINKAGES, POWER TRAIN:AUTOMATIC TRANSMISSION, EQUIPMENT:ELECTRICAL
BRAKE FAILURE LIGHT APPEARS EVEN AFTER MULTIPLE BRAKE REPAIRS. DRIVER?S SIDE REAR UPPER BRAKE LIGHT REPLACED FOR 29TH TIME IN LESS THAN 2 YRS. MULTIPLE COOLANT LEAKS STILL PRESENT EVEN AFTER REPAIR AND WATER PUMP REPLACEMENT. RADIO/AMPLIFIER NOT FUNCTIONING EVEN AFTER REPLACEMENT (RADIO WAS ONLY USED TWICE IN VEHICLE?S LIFETIME). DIAGNOSTICS SHOW AIRBAG MALFUNCTION. REGULATOR PIN ON REAR PASSENGER SIDE WINDOW KEEPS BREAKING (3RD REPLACEMENT SINCE 2003). ENGINE COVER BELOW CAR KEEPS FALLING OFF DUE TO RUSTED BOLTS. HOMELINK SYSTEM KEEPS MALFUNCTIONING. FUSES KEEP BLOWING OUT. DASHBOARD PANEL LIGHTS OUT (ODOMETER, FUEL GAUGE, ETC.). CCM MODULE KEEPS BREAKING DOWN. CAR NEEDS TO BE JUMPSTARTED WHEN NOT IN USE FOR OVER 48 HRS. CLIMATE CONTROL (A/C AND HEATER) WORKS ONLY SPORADICALLY. ALL REPAIRS PERFORMED BY VW DEALERSHIP, YET SAME ISSUES KEEP REAPPEARING JUST A FEW WEEKS AFTER REPAIRS. REPAIRS PERFORMED IN PAST 2 YEARS: ECU UNIT REPLACED, BRAKE LIGHT SWITCH REPLACED 3 TIMES, A/C COMPRESSOR UNIT REPLACED, ABS MODULE REPLACED, ALTERNATOR REPLACED, BRAKES REPLACED 3 TIMES. *TR
Crash:
No
Fire:
No
Injuries:
2
Deaths:
0
#10255877January 21, 2009
SERVICE BRAKES, HYDRAULIC, ELECTRONIC STABILITY CONTROL (ESC)
I OWN A 2003 VW PASSAT. RECENTLY. I TOOK MY CAR FOR REPAIR AS MY BRAKES WERE NOT RESPONDING ON TURNS. THE VW DEALER INVESTIGATED THE ISSUE AND I WAS TOLD THAT THE "ABS CONTROL MODULE" IS NOT COMMUNICATING FOR SOME REASON. THEY SUGGESTED I REPLACE THE ABS CONTROL MODULE FOR AROUND $2,216 I CALLED VW AND ASKED THEM TO LOOK INTO THE ISSUE AND SEE IF THEY CAN COVER THE EXPENSES OF THE REPAIR SINCE THIS IS NOT A NORMAL TEAR AND WEAR ISSUE. THEY RESPONDED BY SAYING THAT SINCE THE CAR IS NOT WITHIN THE WARRANTY PERIOD, THEY CANNOT COVER THE EXPENSES OF THIS REPAIR. I FEEL THAT IS A SAFETY ISSUE THAT VW OF AMERICA NEEDS TO COVER THE REPAIR FOR. IN FACT I THINK THEY SHOULD HAVE BEEN MORE PRO-ACTIVE AND INVESTIGATE THE ABS CONTROL MODULE IN MY CARE AFTER THEY REPLACE IT TO SEE IF THERE IS A MAJOR ISSUE THAT CAN RESULT IN A RECALL. I UNDERSTAND THAT MY CAR IS NOT WITHIN WARRANTY; BUT GIVEN THE FACT THAT THIS IS A SAFETY ISSUE, I THINK VW SHOULD COVER IT AND PAY THE REPAIR COST. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10255782January 20, 2009
SEATS
TURNED ON DRIVER SIDE HEATER TO LEVEL 3. FELT A BURNING ON THE LEFT SIDE OF THE SEAT AND SMELLED A BURNING ODOR APROX 30 SECONDS AFTER STARTING CAR. STOPPED CAR AND FOUND A SMALL HOLE BURNED THROUGH THE SEAT ON THE LEFT REAR SIDE. M2 RECALL HAD ALREADY BEEN CHECKED AT THE DEALER. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10254014January 6, 2009
VISIBILITY
FRONT WINDSHIELD DEFROST/DEFOGGER NOT OPERATING/BLOWING ON WINDSHIELD. IF WINDSHIELD BEGAN TO FOG OR FROST, THERE MAY NOT BE ENOUGH AIRFLOW TO CLEAR THE WINDSHIELD, RESULTING IN REDUCED DRIVER VISIBILITY AND A POSSIBLE CRASH WITHOUT PRIOR WARNING. MANUFACTURER REFUSING TO FIX UNDER SAFETY WARRANTY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10253800January 5, 2009
ELECTRICAL SYSTEM
TL*THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. WHILE DRIVING 65 MPH, THE VEHICLE SUDDENLY LOST POWER. THE VEHICLE WAS DRIVEN TO THE CONTACT'S HOME AND THEN TOWED TO THE DEALER. THE DEALER DISCOVERED THAT THE IGNITION COIL FAILED AND WILL MAKE THE REPAIR AT THE COST OF $250. THE CONTACT PREVIOUSLY TRADED IN HIS VOLKSWAGEN JETTA DUE TO THE IDENTICAL COIL FAILURE. THE VIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 55,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10253041December 29, 2008
FUEL SYSTEM, GASOLINE
TL*THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE FUEL PUMP FAILED IN HIS VEHICLE. THE VEHICLE STUTTERED WHILE DRIVING 60 MPH, STALLED, AND THEN COMPLETELY LOST POWER. THE VEHICLE RESTARTED FOR A FEW SECONDS, BUT THEN LOST POWER AGAIN WHEN HE ATTEMPTED TO ACCELERATE. THE VEHICLE WAS TOWED TO AN INDEPENDENT REPAIR SHOP AND THE CONTACT WAS INFORMED OF NHTSA CAMPAIGN ID NUMBER 07V375000 (FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP). TWO DIFFERENT DEALERS STATED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER AGREED WITH THE DEALERS. THE CURRENT MILEAGE WAS 76,455 AND FAILURE MILEAGE WAS APPROXIMATELY 76,440.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10251930December 16, 2008
ENGINE AND ENGINE COOLING
VW PASSAT 2003, PURCHASED01/09/03, 4 MOTION SEDAN, FOR $32,766.50. ON 10/7/2004, I WENT THROUGH A 2" OR LESS, RAIN PUDDLE. BECAUSE OF THE AIR INTAKE ON THE PASSAT LOCATION BEING VERY LOW, THE ENGINE WAS DAMAGED DUE TO THE WATER INTAKE IN THE AIR INTAKE PORTION OF THE VEHICLE. THE ENGINE HAD TO BE REPLACED AND COST $11,077.53. THE CAR MILEAGE WAS 29,143. VW REFUSED TO PAY, SAYING IT WAS NOT THEIR FAULT. MY INSURANCE COMPANY REFUSED TO PAY BECAUSE THEY SAID IT WAS A DEFAULT IN THE VEHICLE. AS A RESULT, I HAD TO PAY THE $11,077.53 TO KEEP A VEHICLE THAT I HAD PURCHASED NEW IN 2003. IT WAS 1/3 THE COST OF THE NEW VEHICLE WITH ONLY 29,143 MILEAGE. THE AMOUNT OF RAIN CAN BE DETERMINED ON THE DAY IT HAPPENED, IN MIDDLEBURY, IN. I DID CONTACT CARTALK, AFTER NO RESULT FROM VW, AND THEY STATED THAT THEY HAD BEEN CONTACTED BY OTHER PEOPLE EXPERIENCING THE SAME PROBLEM. IT OBVIOUSLY WAS NOT ENOUGH TO POST A RECALL, BUT IT IS STILL SOMETHING I SHOULD BE REIMBURSED, EVEN THOUGH IT HAPPENED IN 2004. I DO STILL OWN THE CAR, BECAUSE OF MY INVESTMENT, WHICH WOULD HAVE BEEN OVER $44,000, BECAUSE I CANNOT AFFORD ANOTHER VEHICLE COMPARED TO THIS ONE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10251193December 9, 2008
FUEL SYSTEM, GASOLINE
TL*THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. WHILE DRIVING APPROXIMATELY 20 MPH, THE VEHICLE SUDDENLY SHUT OFF. THE VEHICLE WAS TOWED TO AN AUTO REPAIR SHOP AND THE MECHANIC STATED THAT THE FUEL PUMP FAILED. HE CALLED THE LOCAL DEALER TO INQUIRE ABOUT RELEVANT RECALLS AND WAS INFORMED THAT THERE WERE NONE. THROUGH RESEARCH, THE CONTACT FOUND NHTSA CAMPAIGN ID NUMBER 07V375000 (FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP), BUT WAS INFORMED THAT HIS VIN WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER STATED THAT THEY COULD NOT OFFER ANY ASSISTANCE; THEREFORE, THE CONTACT WOULD HAVE TO PAY FOR THE REPAIRS. THE VIN WAS UNKNOWN. THE CURRENT MILEAGE WAS APPROXIMATELY 46,100 AND FAILURE MILEAGE WAS APPROXIMATELY 46,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volkswagen Passat