Toyota RAV4 Complaints (2020)

652 consumer complaints on file.

#11714677January 31, 2026
STRUCTURE:BODY:HATCHBACK/LIFTGATE:HINGE AND ATTACHMENTS
Rear hatch were repaired new actuators but still malfunctioning now hinges are defective dealer won't honor extended warranty suggest take to body shop have defective hinges replaced at my cost
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11713174January 25, 2026
POWER TRAIN, ELECTRICAL SYSTEM, STEERING
When trying to start my vehicle this morning, the car was having a noticeable issue the minute I turned on the vehicle. It was making some weird noises under the hood, and it was starting to lose power. Then the engine would cut out and a warning would appear on my dash that read, "Engine Stopped, Steering Power Low" Thank God this happened while I was at home. What if this had happened while I was driving down the road, at a red light. I would have been a sitting duck in the middle of the road and would not want to put my kids or I in jeopardy of being hit.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11703741December 8, 2025
AIR BAGS
I received recall notice December 2023 for defect in front passenger seat airbag that could cause the airbag to fail to deploy in the event of a crash. I have contacted the dealer several times and have been told each time that there is no remedy (yet). It has been two years and the risk to passengers in my vehicle has not been remedied. Fortunately, I have not had any collisions but the danger and safety concerns remain, and there has been NO ACTION BY TOYOTA ON THIS SERIOUS RECALL NOTICE The Recall Notice stills says “no remedy” and it has not been updated in the past year. This is a serious, potentially dangerous and life-threatening defect, a recall has been issued, and yet NOTHING has been done to remedy the defect FOR TWO YEARS. What remedies are available to me as a customer? Will action be taken on this complaint? Please let me know when I can expect a response.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702215December 1, 2025
STRUCTURE:BODY
The door lock actuators required repair on all my doors for the RAV4 2020. They stopped working after the 3 year warranty was up. This is a safety issue. I had to manually lock and unlock my doors, which left in a dangerous position at night. Over the course of a year all 4 doors needed to have the actuators replaced. This happrened in 2024.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11698785November 11, 2025
STRUCTURE:BODY, UNKNOWN OR OTHER
The paint on my 2020 Toyota RAV4 (Blueprint color) is peeling and deteriorating prematurely, on the hood. The vehicle has been properly maintained and has not been in any accidents. The paint started peeling without any external cause. I’ve noticed similar complaints from other 2020 Toyota RAV4 owners, especially those with the Blueprint color, reporting the same issue. This suggests a widespread paint or clear coat defect from the manufacturer. The peeling paint not only affects appearance but also exposes the metal body to rust and corrosion, which could eventually compromise the vehicle’s safety and structure. Toyota has not issued a recall or offered repairs for this known problem, and many owners are being asked to pay out of pocket for costly repainting. I am requesting that NHTSA investigate this issue as a potential manufacturing defect and urge Toyota to take corrective action through a recall or warranty extension for affected vehicles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11698828November 11, 2025
STEERING
unknown power steering issues
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11698059November 7, 2025
ELECTRICAL SYSTEM
The screens will flicker and then dim on its own while driving.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11698263November 7, 2025
SUSPENSION
The contact owns a 2020 Toyota Rav4 Hybrid. The contact stated while driving 50 MPH, there was an abnormal knocking sound coming from the suspension. The traction control warning light was illuminated. The contact stated that the sound was intermittent. The vehicle was taken to an unknown dealer, where it was determined that the front lower suspension arms were damaged and needed to be replaced. The vehicle was not repaired due to the cost. The contact stated that while coming to a stop on another occasion, there was an abnormal grinding sound coming from the brake area. The vehicle was not repaired after the most recent failure. The manufacturer was not informed of the failure. The contact researched and related the failure to NHTSA Campaign Number: 20V286000 (Suspension); however, the VIN was not included. The failure mileage was approximately 120,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11692924October 12, 2025
ENGINE
Engine light shows on in dash. Stopped to fuel up Car stalled, would not restart Diagnosed fuel pump No prior history of engine issue
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11691251October 3, 2025
STEERING
For the last 2 months, a code comes up it says loss of electric power steering assist. It came up 15 times in two months. What happens is a steering wheel ceases up for a second or two and then the code goes away. This is something that could happen anytime especially if I have my grandchildren with me and ex steering wheel could freeze up and I wouldn’t be able to steer around an accident at an intersection or something. This is very hazardous to me and my family. There was a recall on some of the 2020 Toyota RAV4’s in the past. I’m telling you I’m not a liar. I do get this coming up this way too many times.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11690288September 29, 2025
ENGINE
What component or system failed or malfunctioned, and is it available for inspection upon request? The flow shut-off valve (coolant leak) failed. This exact component was later included in Toyota’s official recall. The defective part was diagnosed by a mobile mechanic and replaced at a licensed independent auto repair shop. The failed component itself is no longer available, but all receipts and repair documentation are available upon request. How was your safety or the safety of others put at risk? The failure of the flow shut-off valve caused a coolant leak that created a significant safety hazard, as it affected the vehicle’s performance and drivability. This posed a risk to both my safety and the safety of others on the road, which is why I had the repair completed immediately before the recall was issued. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. The issue was first diagnosed by a mobile mechanic and then confirmed by a reputable independent auto repair shop, who identified the flow shut-off valve coolant leak as the root cause. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No inspection was conducted by Toyota, police, or insurance representatives. However, Toyota later issued a recall for this same component, confirming it as a known safety defect. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Yes. The vehicle experienced noticeable performance issues prior to the failure, which prompted me to call a mechanic. I did have multiple warning message and coolant leaking in addition to the performance issues of the vehicle. These symptoms appeared several months before Toyota’s recall notice for the flow shut-off valve coolant leak arrived.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11690447September 29, 2025
UNKNOWN OR OTHER
Power rear hatch does not always open all the way, sometimes stops after 1" of rise. I must then manually close the rear hatch and try again and again.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11690056September 27, 2025
UNKNOWN OR OTHER
We bought a 2020 Toyota Rav4 Limited with Sunroof. When we were driving in freeway, we noticed that a glass shattered somewhere in my car. We realized that the sunroof was completely shattered. There was no accident, just a heavy rain. We didn't know what to do, we didn't know if we have to call police in a matter as it was a potential safety hazard. We have seen a lot of complaint about this and there is no option to completely sealed it off or get rid of sunroof. We are now scared of driving this car in long distance, we will be trading this vehicle soon because of the incident.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11687947September 17, 2025
ENGINE, ELECTRICAL SYSTEM
Bought the car with 114k on it now with 115k and I brought it in to Toyota because I have a “engine maintenance required” on the dash now they are trying to charge me almost $1000 because my car has over 100k miles on it and they said they won’t cover it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11687639September 16, 2025
ELECTRICAL SYSTEM
The contact owns a 2020 Toyota Rav4. The contact stated that while driving at an undisclosed speed, the message “Engine Maintenance Required” was displayed. The vehicle was taken to an independent mechanic, where it was diagnosed, and determined that the heater control valve had failed and needed to be replaced. The vehicle was repaired. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 47,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11683443August 27, 2025
ENGINE, ELECTRICAL SYSTEM
Shorted Coolant Bypass Valve, only 14500 miles on my 2020 Rav4, Class action Suit and dealerships want you to pay $800-$1000 to fix problem with a leaky defective plastic poorly designed valve that eventually leaks into the electrical connectors and shorts circuits the valve. There is no recall for this fix and Toyota won't honor the repair. This is a common issue and Toyota Turns a Blind Eye. Error Message: Engine Maintenace Required Call Toyota Dealership. I Did and they give me a song and Dance stating there is no recall for this issue. If i run the heater in the car the message for a few a minutes, then shut off vehicle maintenance warning will reset, once I turn on the AC it will come back on. So, I guess I have to keep the heater on all summer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11683500August 27, 2025
AIR BAGS
The contact owns a 2020 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); for over a year. The contact stated that the vehicle was taken for routine maintenance, and the contact requested information on the possible recall repair and was informed that the manufacturer was working on the recall repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not informed. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11680127August 12, 2025
STRUCTURE:BODY
The hinges for the rear door/hatch broke. The door became unaligned and would not close and I had to drive my vehicle to a repair shop with the rear door ajar. This has not been inspected by manufacturer, no police or insurance inspection either. There is no reason these hinges should be worn and literally torn after 5 years.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11679756August 11, 2025
STRUCTURE, STRUCTURE:BODY:DOOR
The contact owns a 2020 Toyota Rav4. The contact stated that during inclement weather, moisture entered the vehicle through the front passenger side and the rear driver side doors. The contact stated that upon opening both the front passenger’s and the rear driver’s side doors, there was a water swishing sound coming from inside the doors. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 58,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11679002August 7, 2025
SEAT BELTS
Rear seat seat belt warning and chimes comes up even when no one sitting in the back and no stuff is put on the back seat. It start chiming randomly and even when all 3 seat belts are buckled the chime comes up. It is security risk as the sudden sound of warnings can distract drive when driving and can cause accident. This model of Rav 4 does not have option to disable this feature, and cause lot of annoyance when random warning chimes start blaring through the vehicle without any reason and resolution. Toyota is refusing to do anything about it in spite of multiple forums reported this issue with various Toyota models. NHTSA need to take action on Toyota for this safety issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota RAV4