Lincoln Corsair Service Bulletins (2023)
160 manufacturer communications on file.
- September 28, 2023•Document ID: 10243653Service Bulletin/Repair InstructionsSERVICE BRAKES, AIR:ANTILOCK:WHEEL SPEED SENSOR; EQUIPMENT
- Mfr Comm. #:
- SSM 51948
- Date Added:
- October 6, 2023
- Manufacturer:
- FORD
SummarySome 2023 Escape, Corsair, Bronco Sport and Maverick vehicles built on 01-May-2023 and through 22-Sep-2023 may exhibit a squeal and/or grinding noise and/or vibration from the front brakes while braking. This may be due to excessive wheel hub lateral runout. To correct this condition, remove the front brake disc(s) of the affected wheel(s). Refer to the Workshop Manual (WSM), Section, 206-03. Clean the raised ring-like surface of the front wheel hub near the wheel studs. Using a dial indicator, slowly rotate the wheel hub and measure the runout on the ring-like surface. If the total runout exceeds 0.001 inch (0.03mm), replace the wheel hub. Refer to the WSM, Section 204-01. Document the measured run out in the warranty claim. For claiming use the causal part number 1104 and applicable labor operations in Section 01 of the Service Labor Time Standards (SLTS)
Associated Products (4)Associated Documents - September 26, 2023•Document ID: 10243444Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL:INFOTAINMENT:SOFTWARE; UNKNOWN OR OTHER
- Mfr Comm. #:
- SU4 P1 Corsair
- Date Added:
- October 3, 2023
- Manufacturer:
- LINCOLN
Summary"Software Update SU4 P1 for 2023 Corsair vehicles is now available. Quality Improvements include: - Various Apple Carplay quality improvements"
Associated Products (1)Associated Documents - September 20, 2023•Document ID: 10242858Service Bulletin/Repair InstructionsBACK OVER PREVENTION:SOFTWARE
- Mfr Comm. #:
- TSB 23-2292
- Date Added:
- September 26, 2023
- Manufacturer:
- LINCOLN
SummarySome 2023 Corsair vehicles equipped with a 2.5L plug-in hybrid electric vehicle (PHEV) engine built on or before 07-Sep-2023 may exhibit an illuminated powertrain malfunction (wrench) indicator with diagnostic trouble code (DTC) U1010 stored in the secondary on-board diagnostic module-B (SOBDMB). This concern typically happens after a plug-in charging event. This may be due to the software in the SOBDMB.
Associated Products (1)Associated Documents - September 7, 2023•Document ID: 10243482Service Bulletin/Repair InstructionsSTRUCTURE:BODY:HATCHBACK/LIFTGATE; STRUCTURE:BODY:DOOR; STRUCTURE:BODY:HOOD; LATCHES/LOCKS/LINKAGES
- Mfr Comm. #:
- SSM 51908
- Date Added:
- October 4, 2023
- Manufacturer:
- FORD
SummarySome 2020-2023 Escape/Corsair vehicles may exhibit a door ajar warning indicator or higher than expected efforts to fully close doors. Verify the hood/liftgate are not open. Confirm all doors are fully closed and latches are fully engaged. Doors will not fully close when lightly letting go of the door or letting it swing closed from a short distance under its own weight. Push/pull effort must be applied to doors while closing to fully engage latch and turn off the ajar signal warning. If doors are still not fully latching closed, manually adjust door striker position to allow for proper alignment and engagement to the door latch. The door hang position may also need to be slightly adjusted to achieve the same effect. Refer to Workshop Manual (WSM), Section 501-03.
Associated Products (8)Associated Documents - September 4, 2023•Document ID: 10243479Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 51903
- Date Added:
- October 4, 2023
- Manufacturer:
- FORD
SummarySome 2021-2023 Ford and Lincoln vehicles may exhibit DTCs U2100 and/or U3002 stored in the cruise control module (CCM), side obstacle detection control module LH (SODL), side obstacle detection control module RH (SODR), side obstacle detection control module C (SODCMC) and/or side obstacle detection control module D (SODCMD) after a module replacement. DTC U2100 may set when the module has not been properly configured after replacement. DTC U3002 may set when the module has been configured with the incorrect VIN. To correct this condition, verify that the module storing the DTC has been installed following the applicable Workshop Manual (WSM) Removal and Installation procedure. If the DTC is still stored, download and run the Vehicle Identification Number (VIN) Write application found under Toolbox, Multi-Module tab in the Ford Diagnosis and Repair System (FDRS).
Associated Products (16)Associated Documents - August 30, 2023•Document ID: 10241546Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:SOFTWARE; POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
- Mfr Comm. #:
- TSB 23-2275
- Date Added:
- September 1, 2023
- Manufacturer:
- LINCOLN
SummarySome 2023 Escape/Corsair vehicles built on or before 25-May-2023 equipped with a 2.0L EcoBoost engine may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P0300 and/or P0316. This may be due to the software in the powertrain control module (PCM). To correct this condition, follow the Service Procedure to reprogram the PCM.
Associated Products (2)Associated Documents - August 30, 2023•Document ID: 10241545Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- TSB 23-2274
- Date Added:
- September 1, 2023
- Manufacturer:
- FORD
SummarySome 2022-2023 Bronco Sport/Escape vehicles equipped with a 1.5L engine and 2022-2023 Corsair vehicles equipped with a 2.5L engine, built on 01-Sep-2022 and through 06-Apr-2023, may exhibit a low coolant level with engine oil in the coolant and/or coolant in the engine oil. This may be caused by an internal oil cooler leak. To correct this condition, follow the Service Procedure to test and replace the oil cooler.
Associated Products (6)Associated Documents - August 7, 2023•Document ID: 10240726Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL
- Mfr Comm. #:
- SSM 51847
- Date Added:
- August 14, 2023
- Manufacturer:
- LINCOLN
SummarySome 2023 Corsair vehicles equipped with a 2.5L plug-in hybrid electric vehicle (PHEV) engine may exhibit an illuminated powertrain malfunction indicator (wrench) lamp with DTC U1010 stored in the secondary on-board diagnostic module-B (SOBDMB). This concern typically happens after a plug-in charging event. This condition does not affect vehicle durability and no additional diagnosis or service is required for this condition at this time. Inform customers that engineering is currently working on a solution for this condition that is expected in October 2023. Replacement or reprogramming of the SOBDMB is not recommended for this condition. Monitor OASIS for additional information and schedule service appointments for customers once the repair becomes available..
Associated Products (1)Associated Documents - August 2, 2023•Document ID: 10241627Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 51838
- Date Added:
- September 4, 2023
- Manufacturer:
- FORD
SummaryIn various 2017-2023 Ford and Lincoln vehicles, customers may receive a message in the FordPass or LincolnWay App stating Feature Unavailable. Since this is a fleet vehicle, it cannot access the (SYNC Connect) FordPass or LincolnWay app through the TCU Embedded Modem. If this message appears, the vehicle may be equipped with a fleet telematics module. Replacement of the TCU or TCU related repairs will not prevent this message from appearing. Refer the customer to in app FordPass Guides or LincolnWay Concierge Teams to aid with fleet telematics removal. Open app, select Account > Help > CHAT or CALL option.
Associated Products (127)2023 Ford Bronco2023 Ford Bronco Sport2023 Ford Edge2023 Ford Escape2023 Ford Expedition2023 Ford Explorer2023 Ford F-1502023 Ford F-2502023 Ford F-3502023 Ford F-4502023 Ford F-5502023 Ford Maverick2023 Ford Mustang2023 Ford Mustang Mach-E2023 Ford Ranger2023 Ford Transit2023 Lincoln Aviator2023 Lincoln Corsair2023 Lincoln Nautilus2023 Lincoln Navigator+ 107 moreAssociated Documents - August 1, 2023•Document ID: 10240577Service Bulletin/Repair InstructionsPOWER TRAIN; EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL; UNKNOWN OR OTHER
- Mfr Comm. #:
- SSM 51823
- Date Added:
- August 11, 2023
- Manufacturer:
- FORD
SummarySome 2019-2023 Edge/Nautilus, 2020-2023 Escape/Corsair, 2021-2023 Bronco Sport, 2022-2023 Maverick vehicles equipped with all wheel drive (AWD) may exhibit chatter/shudder during low speed turning events. This may be due to fluid contamination in the rear drive unit (RDU). Drain and refill the RDU, refer to Workshop Manual Section (WSM) 205-02. Drive for 5 miles (8 km) in stop and go conditions with right and left turns and re-evaluate. If the issue is still present, continue with normal WSM diagnostics. For claiming, use base (4000) causal part.
Associated Products (26)2023 Ford Bronco Sport2023 Ford Edge2023 Ford Escape2023 Ford Maverick2023 Lincoln Corsair2023 Lincoln Nautilus2022 Ford Bronco Sport2022 Ford Edge2022 Ford Escape2022 Ford Maverick2022 Lincoln Corsair2022 Lincoln Nautilus2021 Ford Bronco Sport2021 Ford Edge2021 Ford Escape2021 Lincoln Corsair2021 Lincoln Nautilus2020 Ford Edge2020 Ford Escape2020 Lincoln Corsair+ 6 moreAssociated Documents - July 12, 2023•Document ID: 10239477Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 51783
- Date Added:
- July 18, 2023
- Manufacturer:
- FORD
SummarySome 2021-2023 Ford and Lincoln vehicles may exhibit a condition where the high voltage battery stops charging when connected to level 1 or level 2 chargers with an illuminated malfunction indicator lamp (MIL) and diagnostic trouble code (DTC) P2C94 stored in the secondary on-board diagnostic control module A (SOBDM). To restore charging capability, disconnect the off-board charging station charge handle from the vehicle charge port and reconnect. This condition does not affect vehicle durability and no additional diagnosis or service is required for this condition at this time. Inform customers that they can continue to drive the vehicle and engineering is currently working on a solution for this condition that is expected in August 2023. Replacement of the SOBDM will not resolve this condition. Monitor OASIS for additional information.
Associated Products (16)2023 Ford Escape2023 Ford F-1502023 Ford Mustang Mach-E2023 Ford Transit2023 Lincoln Aviator2023 Lincoln Corsair2022 Ford Escape2022 Ford F-1502022 Ford Mustang Mach-E2022 Ford Transit2022 Lincoln Aviator2022 Lincoln Corsair2021 Ford Escape2021 Ford Mustang Mach-E2021 Lincoln Aviator2021 Lincoln CorsairAssociated Documents - July 6, 2023•Document ID: 10239098Service Bulletin/Repair InstructionsEQUIPMENT; BACK OVER PREVENTION: CAMERA SYSTEM
- Mfr Comm. #:
- SSM 51776
- Date Added:
- July 12, 2023
- Manufacturer:
- LINCOLN
SummarySome 2021-2023 Mustang Mach-E/F-150, 2022-2023 Expedition/Navigator and 2023 Corsair vehicles may exhibit a Driver Monitoring Camera Blocked message and/or DTCs B115E:97, B15E1:97 and/or B15E2:97 stored in the driver status monitor camera module (CMR). These DTCs should be disregarded unless it is a DTC with a status byte 8F. Other status bytes should be disregarded as they may be caused by a camera obstruction such as driver position, aftermarket devices or dust on the camera. To clear the DTCs, remove anything obstructing the view of the camera and light emitting diodes (LEDs), place the steering wheel in the center position and close the driver door. Connect Ford Diagnosis and Repair System (FDRS) and clear the DTCs. Turn the ignition off and wait 10 seconds. Turn the ignition on and wait 1 minute. Perform the CMR self-test and reevaluate if DTCs persist.
Associated Products (11)Associated Documents - July 3, 2023•Document ID: 10238461Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:SOFTWARE; EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
- Mfr Comm. #:
- SSM 51762
- Date Added:
- July 3, 2023
- Manufacturer:
- FORD
SummarySome 2021-2023 Ford and Lincoln vehicles equipped with SYNC 4 may exhibit the navigation feature in the center display screen only displaying imperial units and not being able to change to metric. This may be due to the software level of the SYNC module (APIM). This issue does not affect vehicle durability and no additional diagnosis or service is required for this condition at this time. Inform customers that engineering is currently working on a solution for this condition and will be released via Ford Power-Up software updates delivered over-the-air (OTA) expected in September 2023. Software will update automatically if vehicle connectivity is enabled in the vehicles settings. Schedule a service visit for customers who have disabled vehicle connectivity or who report that they did not receive the update in September 2023. Monitor OASIS for additional information.
Associated Products (25)2023 Ford Bronco2023 Ford Escape2023 Ford Expedition2023 Ford F-1502023 Ford Transit2023 Lincoln Corsair2023 Lincoln Nautilus2023 Lincoln Navigator2022 Ford Bronco2022 Ford Expedition2022 Ford F-1502022 Ford F-2502022 Ford F-3502022 Ford F-4502022 Ford F-5502022 Ford F-6002022 Ford F-6502022 Ford F-7502022 Ford Transit2022 Lincoln Nautilus+ 5 moreAssociated Documents - June 2, 2023•Document ID: 10237587Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:SOFTWARE; ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
- Mfr Comm. #:
- SSM 51676
- Date Added:
- June 8, 2023
- Manufacturer:
- LINCOLN
SummarySome 2023 Corsair vehicles may exhibit a continuous memory diagnostic trouble code (CMDTC) U0100 stored in the audio front control module (ACM) and/or instrument panel cluster (IPC) after a self test is performed with Ford Diagnosis and Repair System (FDRS) scan tool. If the vehicle does not exhibit any observable symptoms, these DTCs can be ignored. If any observable symptoms are present, refer to normal Workshop Manual (WSM) diagnostics.
Associated Products (1)Associated Documents - May 19, 2023•Document ID: 10236579Service Bulletin/Repair InstructionsLATCHES/LOCKS/LINKAGES
- Mfr Comm. #:
- TSB 23-2156
- Date Added:
- May 31, 2023
- Manufacturer:
- FORD
SummarySome 2020-2023 Escape/Corsair, 2021-2023 Bronco Sport and 2022-2023 Maverick vehicles may exhibit a condition where the door(s) do not open using the exterior door handle(s). This may be due to an enabled permanent engagement inertia lock within the exterior door handle, this condition occurs when the doors are closed or opened with excessive force. To correct this condition, follow the Service Procedure to properly disengage the permanent engagement inertia lock clip to allow the exterior door handle(s) to fully extend and open the door(s) from the exterior.
Associated Products (13)Associated Documents - May 3, 2023•Document ID: 10236036Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- TSB 23-2139
- Date Added:
- May 17, 2023
- Manufacturer:
- LINCOLN
SummaryThis article supersedes TSB 22-2278 to update the vehicle model years affected and the part list. For 2020-2023 Escape/Corsair vehicles, the roof opening panel frame mechanism kits have been released for service. These components can now be serviced separately and no longer require replacement of the entire roof opening panel frame. To correct the condition, follow the Service Procedure to install the roof opening panel frame mechanism kit.
Associated Products (8)Associated Documents - April 4, 2023•Document ID: 10235153Service Bulletin/Repair InstructionsSTRUCTURE
- Mfr Comm. #:
- SSM 51536
- Date Added:
- May 4, 2023
- Manufacturer:
- LINCOLN
SummaryFor 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to cause errors and is not recommended. It is also not recommended to order a replacement module using a vehicle identification number (VIN) from a different vehicle. Most modules on these affected vehicles are VIN/vehicle specific and hardware variations between modules do exist. Swapping a module from a vehicle or ordering a module using a different vehicle/VIN can cause ineffective repairs and additional vehicle down time. Make sure all appropriate Workshop Manual (WSM) procedures are followed when diagnosing the condition prior to all module replacements and only order modules using the correct VIN.
Associated Products (350)2023 Ford Bronco2023 Ford Bronco Sport2023 Ford Edge2023 Ford Escape2023 Ford Expedition2023 Ford Explorer2023 Ford F-1502023 Ford F-2502023 Ford F-3502023 Ford F-4502023 Ford F-5502023 Ford F-6502023 Ford F-7502023 Ford Maverick2023 Ford Mustang2023 Ford Mustang Mach-E2023 Ford Ranger2023 Ford Transit Connect2023 Lincoln Aviator2023 Lincoln Corsair+ 330 moreAssociated Documents - March 27, 2023•Document ID: 10233921Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 51513
- Date Added:
- April 6, 2023
- Manufacturer:
- LINCOLN
SummarySome 2021-2023 Ford and Lincoln vehicles may exhibit a condition where the high voltage battery stops charging when connected to level 1 or level 2 chargers with an illuminated malfunction indicator lamp (MIL) and diagnostic trouble code (DTC) P2C94 stored in the secondary on-board diagnostic control module A (SOBDM). To restore charging capability, disconnect the off-board charging station charge handle from the vehicle charge port and reconnect. This condition does not affect vehicle durability and no additional diagnosis or service is required for this condition at this time. Inform customers that they can continue to drive the vehicle and engineering is currently working on a solution for this condition that is expected in June 2023. Replacement of the SOBDM will not resolve this condition. Monitor OASIS for additional information.
Associated Products (16)2023 Ford Escape2023 Ford F-1502023 Ford Mustang Mach-E2023 Ford Transit2023 Lincoln Aviator2023 Lincoln Corsair2022 Ford Escape2022 Ford F-1502022 Ford Mustang Mach-E2022 Ford Transit2022 Lincoln Aviator2022 Lincoln Corsair2021 Ford Escape2021 Ford Mustang Mach-E2021 Lincoln Aviator2021 Lincoln CorsairAssociated Documents - November 21, 2022•Document ID: 10226769Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 51215
- Date Added:
- November 30, 2022
- Manufacturer:
- LINCOLN
SummarySome 2020-2023 Lincoln Aviator and 2020-2022 Lincoln Corsair vehicles may exhibit courtesy lamps not illuminating with a door open or always on. Also, ambient lighting may be inoperative or always on. If this concern occurs, check the center console cup holder area for evidence of liquid intrusion first. Liquid can short the local interconnect network (LIN) circuit. Temporarily disconnect the console inline connector(s) during diagnosis to isolate circuit shorts. Search Wiring Diagram (WD) for *cup holder ambient* to display the related connectors. If a short is found in cup holder ambient light ring light emitting diode (LED) connector, repair as necessary. If no evidence of liquid intrusion is found, continue with normal Workshop Manual (WSM) diagnostics.
Associated Products (8)Associated Documents - August 10, 2022•Document ID: 10217839Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- SSM 51011
- Date Added:
- August 15, 2022
- Manufacturer:
- FORD
SummarySome 2018-2022 Ford and Lincoln vehicles equipped with the 8F35 transmission built on or before 16-Mar-2022 may exhibit transmission slip during acceleration from a stop when hot. This may be due damaged internal case half pump seals (7N265). To correct the condition, remove the transmission and replace the internal case half pump seals. Refer to Workshop Manual (WSM), Section 307-01.
Associated Products (28)2023 Ford Bronco Sport2023 Ford Escape2023 Lincoln Corsair2022 Ford Bronco Sport2022 Ford Edge2022 Ford Escape2022 Ford Maverick2022 Ford Transit Connect2022 Lincoln Corsair2022 Lincoln Nautilus2021 Ford Bronco Sport2021 Ford Edge2021 Ford Escape2021 Ford Transit Connect2021 Lincoln Corsair2021 Lincoln Nautilus2020 Ford Edge2020 Ford Escape2020 Ford Transit Connect2020 Lincoln Corsair+ 8 moreAssociated Documents