Jeep Cherokee Service Bulletins (2016)

450 manufacturer communications on file.

September 7, 2016•Document ID: 10223855
Service Bulletin/Repair Instructions
VISIBILITY/WIPER
Mfr Comm. #:
05152029
Date Added:
October 17, 2022
Manufacturer:
CHRYSLER
Summary
Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform the this inspection. Inspect the sensor for a fluid coating on the sensor pins. Orange colored rain repellant can cause this fluid build-up. Clean the pins, drain the reservoir, and fill with Mopar approved washer fluid. Check to determine if the issue has been resolved. Continue with repair if necessary. Also, please inform the customer not to use Rain-X in the system to avoid this issue. Please contact Chuck Hood at cell (248) 613-7591 if you have questions or need additional information. Thank you.
Associated Products (183)
2018 Alfa Romeo 4C 2018 Alfa Romeo Stelvio 2018 Chrysler 200 2018 Chrysler 300 2018 Chrysler Pacifica 2018 Chrysler Town and Country 2018 Dodge Challenger 2018 Dodge Charger 2018 Dodge Durango 2018 Dodge Grand Caravan 2018 Dodge Journey 2018 Fiat 124 Spider 2018 Fiat 500 2018 Fiat 500X 2018 Jeep Cherokee 2018 Jeep Compass 2018 Jeep Grand Cherokee 2018 Jeep Patriot 2018 Jeep Renegade 2018 Jeep Wrangler+ 163 more
Associated Documents
- Download MC-10223855-0001.pdf↗
September 7, 2016•Document ID: 10223819
Service Bulletin/Repair Instructions
ELECTRICAL SYSTEM; POWER TRAIN
Mfr Comm. #:
0300516
Date Added:
October 17, 2022
Manufacturer:
JEEP
Summary
Drivetrain Control Module (DTCM) This bulletin involves replacing and reconfiguring the Drivetrain Control Module (DTCM) with the latest available software. Some vehicles may experience a constant high pitched whine coming from rear axle area.
Associated Products (1)
2016 Jeep Cherokee
Associated Documents
- Download MC-10223819-0001.pdf↗
September 3, 2016•Document ID: 10223816
Service Bulletin/Repair Instructions
ELECTRICAL SYSTEM; POWER TRAIN
Mfr Comm. #:
1801416
Date Added:
October 17, 2022
Manufacturer:
JEEP
Summary
Flash: 2.4L Powertrain Diagnostic And System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software.
Associated Products (1)
2016 Jeep Cherokee
Associated Documents
- Download MC-10223816-0001.pdf↗
August 31, 2016•Document ID: 10121723
Service Bulletin/Repair Instructions
POWER TRAIN; EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Mfr Comm. #:
21-013-16 REV. B
Date Added:
November 3, 2017
Manufacturer:
JEEP
Summary
948TE 9 Speed Transmission Quick Learn Procedure This bulletin provides information on how to perform the new scan tool based transmission Quick Learn procedure. This procedure is required after certain transmission repairs or to improve a customer?s concern of poor shift quality. Customers may indicate that their transmission shift quality may be erratic.
Associated Products (8)
2016 Chrysler 200 2016 Fiat 500X 2016 Jeep Cherokee 2016 Jeep Renegade 2015 Chrysler 200 2015 Jeep Cherokee 2015 Jeep Renegade 2015 Ram Promaster City
Associated Documents
- Download MC-10121723-0001.pdf↗
August 30, 2016•Document ID: 10121726
Service Bulletin/Repair Instructions
STRUCTURE; STRUCTURE:BODY:TAILGATE
Mfr Comm. #:
23-040-16
Date Added:
November 3, 2017
Manufacturer:
JEEP
Summary
Liftgate Tail Lamps Underflush To The Body Mounted Tail Lamps This bulletin involves adding washers behind the liftgate tail lamps to bring them flush to the body mounted tail lamps. Liftgate tail lamps look underflush to body mounted tail lamps.
Associated Products (2)
2016 Jeep Cherokee 2015 Jeep Cherokee
Associated Documents
- Download MC-10121726-0001.pdf↗
August 24, 2016•Document ID: 10224872
Service Bulletin/Repair Instructions
EQUIPMENT
Mfr Comm. #:
68264880A
Date Added:
October 31, 2022
Manufacturer:
JEEP
Summary
Parts.
Associated Products (9)
2016 Chrysler 200 2016 Dodge Dart 2016 Jeep Cherokee 2015 Chrysler 200 2015 Dodge Dart 2015 Jeep Cherokee 2014 Dodge Dart 2014 Jeep Cherokee 2013 Dodge Dart
Associated Documents
- Download MC-10224872-0001.pdf↗
August 24, 2016•Document ID: 10130085
Service Bulletin/Repair Instructions
SEAT BELTS
Mfr Comm. #:
68264880A$
Date Added:
March 13, 2018
Manufacturer:
DODGE
Summary
Occupant Restraint Controller (ORC) For PF, KL or UF Vehicles ONLY:~ Prior to replacing ORC part numbers, please contact FCA engineering if ANY of the following Diagnostic trouble codes are Stored or Active in the ORC module:~ DTC: B223D-00 - OCM DTC Present~ DTC: B0050-13 - Driver Seatbelt Sensor-Circuit Open~ DTC: B0052-13 - Passenger Seatbelt Sensor-Circuit Open~ DTC: B00B5-13 - Driver Seat Track Position Restraints Sensor-Circuit Open~ DTC: B00C5-13 - Passenger Seat Track Position Restraints Sensor-Circuit Open~ DTC: B0028-13 - Right Side Seat Deployment Squib 1-Circuit Open~ DTC: B0020-13 - Left Side Seat Deployment Squib 1-Circuit Open~ Execute DealerCONNECT / TechCONNECT Diagnostic Procedures to assess potential defects to devices connected to the ORC Module depending on the active or stored Diagnostic Trouble Code. If no defects are detected, verify wiring connectivity between the ORC Module and the component associated with the Diagnostic Trouble Code. Investigate connector pins and wire harness terminals for bent, corroded, or spread conditions. If no response within 15 minutes, proceed with repair.~ FCA Engineering Contacts:~ Jay Nagle (ORC Module, Driver/passenger seat track position sensor for PF, KL or UF Vehicles ONLY) @ cell (248) 420-4294 or [email protected]~ Malcolm Whitehouse (OCM Module - PF,KL, or UF Vehicles ONLY)@248-462-4703 or [email protected].~ Bill Winfrey (Driver/Passenger Buckle Switch, Passenger/Driver Seat Thorax Airbags) @ cell (248) 941-9221 or [email protected]~
Associated Products (9)
2016 Chrysler 200 2016 Dodge Dart 2016 Jeep Cherokee 2015 Chrysler 200 2015 Dodge Dart 2015 Jeep Cherokee 2014 Dodge Dart 2014 Jeep Cherokee 2012 Dodge Dart
Associated Documents
- Download MC-10130085-0001.pdf↗
August 17, 2016•Document ID: 10217748
Service Bulletin/Repair Instructions
EQUIPMENT; ELECTRICAL SYSTEM; SEAT BELTS
Mfr Comm. #:
68264880A
Date Added:
August 15, 2022
Manufacturer:
DODGE
Summary
Occupant Restraint Controller (ORC) For PF, KL or UF Vehicles ONLY:~ Prior to replacing ORC part numbers, please contact FCA engineering if the following Diagnostic trouble codes are Stored or Active in the ORC module:~ DTC: B223D-00 - OCM DTC Present~ DTC: B0050-13 - Driver Seatbelt Sensor-Circuit Open~ DTC: B0052-13 - Passenger Seatbelt Sensor-Circuit Open~ DTC: B00B5-13 - Driver Seat Track Position Restraints Sensor-Circuit Open~ DTC: B00C5-13 - Passenger Seat Track Position Restraints Sensor-Circuit Open~ DTC: B0028-13 - Right Side Seat Deployment Squib 1-Circuit Open~ DTC: B0020-13 - Left Side Seat Deployment Squib 1-Circuit Open~ Execute DealerCONNECT / TechCONNECT Diagnostic Procedures to assess potential defects to devices connected to the ORC Module depending on the active or stored Diagnostic Trouble Code. If no defects are detected, verify wiring connectivity between the ORC Module and the component associated with the Diagnostic Trouble Code. Investigate connector pins and wire harness terminals for bent,corroded,or spread conditions. If no response within 15 minutes, proceed with repair.~ FCA Engineering Contacts:~ Jay Nagle (ORC Module, OCM module, Driver/passenger seat track position sensor for PF, KL or UF Vehicles ONLY) @ cell (248) 420-4294 or [email protected]~ Bill Winfrey (Driver/Passenger Buckle Switch, Passenger/Driver Seat Thorax Airbags) @ cell (248) 941-9221 or [email protected]
Associated Products (8)
2016 Chrysler 200 2016 Dodge Dart 2016 Jeep Cherokee 2015 Chrysler 200 2015 Dodge Dart 2015 Jeep Cherokee 2014 Dodge Dart 2014 Jeep Cherokee
Associated Documents
- Download MC-10217748-0001.pdf↗
August 17, 2016•Document ID: 10135124
Service Bulletin/Repair Instructions
SEATS; SEAT BELTS; ELECTRICAL SYSTEM
Mfr Comm. #:
68264880A$
Date Added:
May 7, 2018
Manufacturer:
CHRYSLER
Summary
Occupant Restraint Controller (ORC) For PF, KL or UF Vehicles ONLY:~ Prior to replacing ORC part numbers, please contact FCA engineering if the following Diagnostic trouble codes are Stored or Active in the ORC module:~ DTC: B223D-00 - OCM DTC Present~ DTC: B0050-13 - Driver Seatbelt Sensor-Circuit Open~ DTC: B0052-13 - Passenger Seatbelt Sensor-Circuit Open~ DTC: B00B5-13 - Driver Seat Track Position Restraints Sensor-Circuit Open~ DTC: B00C5-13 - Passenger Seat Track Position Restraints Sensor-Circuit Open~ DTC: B0028-13 - Right Side Seat Deployment Squib 1-Circuit Open~ DTC: B0020-13 - Left Side Seat Deployment Squib 1-Circuit Open~ Execute DealerCONNECT / TechCONNECT Diagnostic Procedures to assess potential defects to devices connected to the ORC Module depending on the active or stored Diagnostic Trouble Code. If no defects are detected, verify wiring connectivity between the ORC Module and the component associated with the Diagnostic Trouble Code. Investigate connector pins and wire harness terminals for bent,corroded,or spread conditions. If no response within 15 minutes, proceed with repair.~ FCA Engineering Contacts:~ Jay Nagle (ORC Module, OCM module, Driver/passenger seat track position sensor for PF, KL or UF Vehicles ONLY) @ cell (248) 420-4294 or [email protected]~ Bill Winfrey (Driver/Passenger Buckle Switch, Passenger/Driver Seat Thorax Airbags) @ cell (248) 941-9221 or [email protected]
Associated Products (8)
2016 Chrysler 200 2016 Dodge Dart 2016 Jeep Cherokee 2015 Chrysler 200 2015 Dodge Dart 2015 Jeep Cherokee 2014 Dodge Dart 2014 Jeep Cherokee
Associated Documents
- Download MC-10135124-0001.pdf↗
August 17, 2016•Document ID: 10129039
Service Bulletin/Repair Instructions
ELECTRICAL SYSTEM
Mfr Comm. #:
68264880A$
Date Added:
February 21, 2018
Manufacturer:
DODGE
Summary
Occupant Restraint Controller (ORC) For PF, KL or UF Vehicles ONLY:~ Prior to replacing ORC part numbers, please contact FCA engineering if the following Diagnostic trouble codes are Stored or Active in the ORC module:~ DTC: B223D-00 - OCM DTC Present~ DTC: B0050-13 - Driver Seatbelt Sensor-Circuit Open~ DTC: B0052-13 - Passenger Seatbelt Sensor-Circuit Open~ DTC: B00B5-13 - Driver Seat Track Position Restraints Sensor-Circuit Open~ DTC: B00C5-13 - Passenger Seat Track Position Restraints Sensor-Circuit Open~ DTC: B0028-13 - Right Side Seat Deployment Squib 1-Circuit Open~ DTC: B0020-13 - Left Side Seat Deployment Squib 1-Circuit Open~ Execute DealerCONNECT / TechCONNECT Diagnostic Procedures to assess potential defects to devices connected to the ORC Module depending on the active or stored Diagnostic Trouble Code. If no defects are detected, verify wiring connectivity between the ORC Module and the component associated with the Diagnostic Trouble Code. Investigate connector pins and wire harness terminals for bent,corroded,or spread conditions. If no response within 15 minutes, proceed with repair.~ FCA Engineering Contacts:~ Jay Nagle (ORC Module, OCM module, Driver/passenger seat track position sensor for PF, KL or UF Vehicles ONLY) @ cell (248) 420-4294 or [email protected]~ Bill Winfrey (Driver/Passenger Buckle Switch, Passenger/Driver Seat Thorax Airbags) @ cell (248) 941-9221 or [email protected]
Associated Products (8)
2016 Chrysler 200 2016 Dodge Dart 2016 Jeep Cherokee 2015 Chrysler 200 2015 Dodge Dart 2015 Jeep Cherokee 2014 Dodge Dart 2014 Jeep Cherokee
Associated Documents
- Download MC-10129039-0001.pdf↗
August 1, 2016•Document ID: 10119607
Service Bulletin/Repair Instructions
VISIBILITY
Mfr Comm. #:
S57
Date Added:
October 21, 2017
Manufacturer:
JEEP
Summary
Customer Satisfaction Notification S57 Front Wiper Arms The front wiper arm(s) on about 126,700 of the above vehicles may become loose resulting in the wiper blades contacting the body and/or the wipers blades/arms contacting each other. The front wiper arms must be inspected for proper operation and position, correct if necessary, and then tighten the wiper arm nuts to the proper torque specification.
Associated Products (1)
2016 Jeep Cherokee
Associated Documents
- Download MC-10119607-0001.pdf↗
July 20, 2016•Document ID: 10121685
Service Bulletin/Repair Instructions
ENGINE AND ENGINE COOLING
Mfr Comm. #:
68103198A$
Date Added:
November 3, 2017
Manufacturer:
DODGE
Summary
A/C Compressor This applies to 2015 and 2016 KL, UF and PF. Before replacing the AC compressor for noise, leaks , or for an inop condition:~ After these questions have been answered please call one of the individuals below.~ 1) Check all AC plumbing connection for leaks with UV light. Any leaks found?~ 2) Does compressor pulley and clutch hub turn freely, or are they seized?~ 3) What was the amount of the recovered refrigerant?~ After these questions have been answered please call one of the individuals below:~ Stev at cell (248) 867-0061~ Mark Briolat at cell (248) 345-0127~ If no response in 15 minutes, please continue with repair.~ If the compressor is replaced, then:~ 4) Drain oil from compressor. What was quantity of oil recovered?
Associated Products (6)
2016 Chrysler 200 2016 Dodge Dart 2016 Jeep Cherokee 2015 Chrysler 200 2015 Dodge Dart 2015 Jeep Cherokee
Associated Documents
- Download MC-10121685-0001.pdf↗
July 13, 2016•Document ID: 10121669
Service Bulletin/Repair Instructions
EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
Mfr Comm. #:
68249986A$
Date Added:
November 3, 2017
Manufacturer:
FIAT
Summary
MY16 RA3 & RA4 Replacement Radios All MY16 RA3 and RA4 replacement radios must be ordered through the exchange process at United Radio. DO NOT order a NEW radio from Mopar. Go back and order a "Z" level part number. (example: Z8249986A$) The MY16 replacement radios must be reconfigured by United Radio to the wireless network provider in order for Uconnect Apps to work properly.
Associated Products (30)
2016 Chrysler 200 2016 Chrysler 300 2016 Chrysler 300C 2016 Chrysler Pacifica 2016 Chrysler Town and Country 2016 Dodge Avenger 2016 Dodge Challenger 2016 Dodge Charger 2016 Dodge Dart 2016 Dodge Durango 2016 Dodge Grand Caravan 2016 Dodge Journey 2016 Dodge Viper 2016 Fiat 500 2016 Fiat 500e 2016 Fiat 500L 2016 Fiat 500X 2016 Jeep Cherokee 2016 Jeep Compass 2016 Jeep Grand Cherokee+ 10 more
Associated Documents
- Download MC-10121669-0001.pdf↗
July 7, 2016•Document ID: 10121645
Service Bulletin/Repair Instructions
EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.; ELECTRICAL SYSTEM
Mfr Comm. #:
08-024-16 REV. B
Date Added:
November 3, 2017
Manufacturer:
JEEP
Summary
Flash: Radio Frequency Hub Module (RFHM) Enhancement This bulletin involves updating the RFHM with the latest available software. Customers may describe the instrument cluster is illuminating by itself after the ignition has been off for an extended period of time (ten minutes or more).
Associated Products (3)
2016 Jeep Cherokee 2015 Jeep Cherokee 2014 Jeep Cherokee
Associated Documents
- Download MC-10121645-0001.pdf↗
July 6, 2016•Document ID: 10121657
Service Bulletin/Repair Instructions
ENGINE AND ENGINE COOLING
Mfr Comm. #:
68232614A$
Date Added:
November 3, 2017
Manufacturer:
CHRYSLER
Summary
Intake Manifold Gasket Intake Manifold Gaskets on Pentastar Upgrade (Sales Code ERC/ERF) are reusable provided they are not cut, torn or melted. The gaskets are not required by warranty to be replaced like they are on Pentastar Classic (ERB/EHB). The new gaskets are not interchangeable with Pentastar Classic Intake Manifold Gaskets.
Associated Products (57)
2017 Chrysler 200 2017 Chrysler 300 2017 Chrysler 300C 2017 Chrysler Pacifica 2017 Chrysler Town and Country 2017 Dodge Challenger 2017 Dodge Charger 2017 Dodge Durango 2017 Dodge Grand Caravan 2017 Dodge Journey 2017 Dodge Viper 2017 Fiat 124 Spider 2017 Fiat 500 2017 Fiat 500e 2017 Fiat 500X 2017 Jeep Cherokee 2017 Jeep Compass 2017 Jeep Grand Cherokee 2017 Jeep Patriot 2017 Jeep Renegade+ 37 more
Associated Documents
- Download MC-10121657-0001.pdf↗
July 6, 2016•Document ID: 10121654
Service Bulletin/Repair Instructions
EQUIPMENT:APPLIANCE:AIR CONDITIONER; VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
Mfr Comm. #:
68018109A$
Date Added:
November 3, 2017
Manufacturer:
RAM
Summary
Actuator- A/C Heater Before replacing this actuator call Matt Sasina at cell (248) 464-4982. If no response in 15 minutes, continue with repair.
Associated Products (12)
2016 Chrysler 200 2016 Jeep Cherokee 2016 Jeep Compass 2016 Jeep Wrangler 2016 Ram 1500 2016 Ram 2500 2015 Chrysler 200 2015 Jeep Cherokee 2015 Jeep Compass 2015 Jeep Wrangler 2015 Ram 1500 2015 Ram 2500
Associated Documents
- Download MC-10121654-0001.pdf↗
June 30, 2016•Document ID: 10080543
Service Bulletin/Repair Instructions
ELECTRICAL SYSTEM:SOFTWARE; POWER TRAIN
Mfr Comm. #:
18-076-16
Date Added:
September 20, 2016
Manufacturer:
JEEP
Summary
"FLASH: 2.0L POWERTRAIN DIAGNOSTIC AND SYSTEM IMPROVEMENTS THIS BULLETIN INVOLVES REPROGRAMMING THE POWERTRAIN CONTROL MODULE (PCM) WITH THE LATEST AVAILABLE SOFTWARE. A SMALL NUMBER OF CUSTOMERS MAY EXPERIENCE A MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION. UPON FURTHER INVESTIGATION, THE TECHNICIAN MAY FIND ONE OR MORE OF THE FOLLOWING DIAGNOSTIC TROUBLE CODES (DTCS): · P0335 - CRANKSHAFT POSITION SENSOR CIRCUIT. · U0402 - IMPLAUSIBLE DATA RECEIVED FROM TCM. · U1424 - IMPLAUSIBLE ENGINE TORQUE SIGNAL RECEIVED."
Associated Products (1)
2016 Jeep Cherokee
Associated Documents
- Download MC-10080543-0001.pdf↗
June 30, 2016•Document ID: 10080541
Service Bulletin/Repair Instructions
ELECTRICAL SYSTEM:SOFTWARE
Mfr Comm. #:
08-069-16
Date Added:
September 20, 2016
Manufacturer:
JEEP
Summary
"RADIO SOFTWARE ENHANCEMENT THIS BULLETIN INVOLVES UPDATING THE RADIO WITH THE LATEST AVAILABLE SOFTWARE. THE FOLLOWING SOFTWARE ENHANCEMENT IS AVAILABLE: · BROUGHT IN PHONE - INCREASED CONNECTIVITY."
Associated Products (2)
2016 Jeep Cherokee 2015 Jeep Cherokee
Associated Documents
- Download MC-10080541-0001.pdf↗
June 29, 2016•Document ID: 10080440
Service Bulletin/Repair Instructions
STRUCTURE:BODY:DOOR
Mfr Comm. #:
1SZ34AXRA$
Date Added:
September 19, 2016
Manufacturer:
JEEP
Summary
"EXTERIOR DOOR HANDLE FOR KL MODELS ONLY; IF REPLACING THE DRIVERS EXTERIOR DOOR HANDLE, PLEASE REPLACE BOTH THE HANDLE AND CAP AS LONG AS THIS TECHTIP IS ACTIVE. THIS IS NEEDED TO TRY TO ROOT CAUSE THE ENTIRE HANDLE FOR A SPECIAL STUDY."
Associated Products (1)
2016 Jeep Cherokee
Associated Documents
- Download MC-10080440-0001.pdf↗
June 22, 2016•Document ID: 10218271
Service Bulletin/Repair Instructions
ELECTRICAL SYSTEM
Mfr Comm. #:
68066351A
Date Added:
August 22, 2022
Manufacturer:
RAM
Summary
Keyfob 2016 Vehicle Keyfobs with Passive Entry Keyless Go Feature - Engineering is investigating a keyfob unable to program or no function or low keyfob coin battery condition.~ Prior to replacing keyfob on MY16 vehicles, please contact Raja Charabuddi on cell (248) 202-7313. If no response within 15 minutes, proceed with repair.
Associated Products (30)
2016 Chrysler 200 2016 Chrysler 300 2016 Chrysler 300C 2016 Chrysler Pacifica 2016 Chrysler Town and Country 2016 Dodge Avenger 2016 Dodge Challenger 2016 Dodge Charger 2016 Dodge Dart 2016 Dodge Durango 2016 Dodge Grand Caravan 2016 Dodge Journey 2016 Dodge Viper 2016 Fiat 500 2016 Fiat 500e 2016 Fiat 500L 2016 Fiat 500X 2016 Jeep Cherokee 2016 Jeep Compass 2016 Jeep Grand Cherokee+ 10 more
Associated Documents
- Download MC-10218271-0001.pdf↗

← Back to Jeep Cherokee