Hyundai Santa Cruz Complaints (2023)

77 consumer complaints on file.

#11560565December 17, 2023
ELECTRICAL SYSTEM
11/14, 2023 Drove about 2-3 miles when all warning lights on the dash came on like a Christmas tree. I was coming to a 4 way stop, both roads were 55 mph speed limits. There was a car behind me and another coming to a stop from the left. I wanted to get across the intersection to pull over and assess the situation. While trying to get across the intersection there was no response to the throttle pedal, ended up idling through the intersection at 4 mph. After getting across I pulled over and turned the truck off, let it sit for maybe a minute or so. Then I restarted and the only warning light that stayed on was the service engine warning light. The throttle showed response at that time, I started driving slowly and eventually felt it was ok to gain speed. Was able to drive at posted speed limits. 11/1582023 I took truck to Hyundai service department. 11/17/2023 Hyundai service advisor called and stated the tech support line told them to try replacing the wire harness because of erratic readings. The harness was on backorder until 11/27/23. 12/4/2023 Service advisor told me the harness was now on national backorder until 12/7/23. Again he said he will contact me when the part comes in. Truck went into service on Nov 15, 2023 and now Dec 17, 2023 tech line suggested wire harness to be replaced is still not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11555981November 20, 2023
ELECTRICAL SYSTEM, ENGINE, FUEL/PROPULSION SYSTEM
Rough Idle, Loss of engine power, and cylinder misfire on 2023 Santa Cruize Limited approx. 26,700 miles(currently) purchased new 04-28-2023 at Hyundai in North Knoxville, TN. Vehicle is stored in insulated garage at all times when not in use. 1) Approx. 2k-4k mi vehicle was having rough idling upon start up & have to sit, wait several minutes to allow vehicle ample time to warm up like a cold natured, carbureted engine. Dealer was unable to replicate at vehicle service intervals(60 miles away from home). 2) During Oct 23 approx. 24k-25k experienced 3 occurrences of loss of power while accelerating to merge into traffic, toggled through drive modes, put in manual, then back. Power came back each time. 3) 11/12/2023 Second start of the day, immediately upon startup was running extremely rough in idle, very little response. Check engine light is on, made video of issue & documented miles: 26,121. Turned off, then back on, issue was resolved. 4) 11/15/2023 26,373 miles: Second start of the day, same issue described in "#3", extremely rough idle, check engine light, & sounds coming from tailpipe that can be identified as "drone". Opened hood, inspected intake components, removed engine cover to check for burned or odd colored wires to injectors & coil packs, but no evidence of fouled or damaged wires. Turned vehicle off, then back on & the issue cleared. Contacted dealer where purchased, advised to bring vehicle in for diagnostic evaluation. 5) 11/16/2023 26,606 miles: Again, second start of the day, check engine light, extremely rough idle & louder "drone" sound. Left vehicle in the state that it was in, drove to dealer from work(25miles away) to be diagnosed while issues were occurring. While driving vehicle had very little power, experienced odor while driving, shudder, & jolting during accelerations. Diagnostic eval. revealed misfire in cylinder #3, dealer inspected coil packs, wires, & removed spark plug. Currently being serviced, issued loaner by dealer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11555358November 15, 2023
TIRES:SIDEWALL
Tire size Michelin 245/50. R20. Multiple tire flats right rear vehicle has 8368 miles. Last flat was puncture in sidewall requiring replacement of tire. Suspect tire rubber faulty as appears odd color and extremely difficult to clean also has odor or odd smell when cleaning. All flats were displayed on the pressure dash warning it is unknown to me why multiple flats could be a malfunction of all wheel drive system rt wheel turning different from rest of wheels?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11552363October 28, 2023
ENGINE, POWER TRAIN
Vehicle has multiple engine misfires, resulting from faulty fuel injectors. Unable to maintain speed, vehicle controls become hard to control due to vehicles engine misfires. Vehicle has less ten 20,000 miles. Dealership unable to obtain new fuel injectors due to manufacture not having supply. Vehicle in shop longer for 30 days. Contacted Hyundai USA told that Hyundai knows about problem but has so plan to rectify situation.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11549949October 14, 2023
VEHICLE SPEED CONTROL, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
The Highway Drive Assist (HDA) designed to auto change cruise speed according to posted speed limit signs - at 80mph limit will auto change to 83mph and 85mph limit will auto change to 95mph. Hyundai has said this is not available to inspect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11549576October 12, 2023
TRAILER HITCHES
The contact owns a 2023 Hyundai Santa Cruz. The contact received notification of NHTSA Campaign Number: 23V181000 (Trailer Hitches) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11549028October 9, 2023
EXTERIOR LIGHTING, SERVICE BRAKES
On 04/26/23 a lamp assy-rear comb outside Qty: 1 installed 92402-K5000, was replaced due to condensation inside the taillight. On 09/22/23 both taillights, lamp assy-rear comb outside Qty: 1 installed 92401-K5000, was replaced and lamp assy-rear comb outside Qty: 1 installed 92402-K5000, were replaced due to condensation inside the taillights. Should the condensation in the taillights cause the brake and or turn signal lights to fail this could cause a serious accident! I have an appointment at 1:00 PM at my dealership Hyundai of Anderson in Anderson, SC to have both taillights inspected for the third time, tomorrow on 10/10/2023 because of condensation inside them. I might add that the condensation has occurred when there has been no rain on the vehicle and the vehicle has not been washed. My Santa Cruz is also housed in a completely enclosed garage.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11548311October 4, 2023
TRAILER HITCHES
The contact owns a 2023 Hyundai Santa Cruz. The contact received notification of NHTSA Campaign Number: 23V181000 (Trailer Hitches) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11545498September 19, 2023
POWER TRAIN
Vehicle has 2k miles on it and it experiences a loss of power from a stop when accelerating. The vehicle shakes as if it is not getting enough gas similar to a manual transmission if you took your foot off the clutch when the vehicle was in 1st gear. It happens about once a week at random times, no codes produced. Dealership advises with no codes displayed and their inability to recreate the concern there is nothing the manufacturer will allow them to do. Dealership has had the vehicle for over 3 weeks. This is becoming a more common issue, yet nothing is being done by manufacturer to address for consumers. If my wife or I are operating the vehicle and cannot get out of the way of an oncoming vehicle due to a sudden loss of acceleration this poses a great risk for serious bodily harm or injury.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11540441August 23, 2023
VISIBILITY/WIPER
Rain sensor wiper function. On this setting, even in consistent rain, the system will jump to slow wiper intervals all the way to the fastest setting...with no change in the amount or rain hitting the windshield. It seems confused and searching for the proper speed. It becomes dangerous when it arrives at a very slow intermittent setting for rain that requires a faster interval for adequate removal for the driver to see properly.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11539757August 21, 2023
ENGINE, ELECTRICAL SYSTEM
Car will not start properly and shuts itself off after which a strong odor of burning plastic is present in the vehicle. It will periodically do this almost once a day if not every other day. I have taken it in to the dealer 4 times last time they had my car for two weeks and could not replicate porblem because they only drive it 5 miles and it will not happen unless vehicle is being daily driven. I have found numerous other owners with the same complaint. Hyundai will not authorize shop to work on car and advises them to release it to me each time. They only attempted to fix once and gave it back to me all over times. The car is at the dealer again and they will not work on it till october to try to find the problem again. I will not drive this car due to risk of car deciding to turn it self off or start on fire due to whatever is melting when this happenns car is still at red mcombs northwest as of today.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11535042July 28, 2023
UNKNOWN OR OTHER
I went to my Hyundai dealer because the tunneau cover is taking in a lot of water when it rains. All sides are taking in the water. This even occurs when I go to the car wash. The whole person of the cover is to keep things dry and from things flying out of the bed of the truck. The dealer spent four hours trying to resolve it and contacted Hyundai tech line for assistance. They were told that they know of the issue, but there is no fix for it because enough people have not registered a complaint about this situation. While it might not be a hazard, it makes the bed unable to be used. I have to have it shop vacuumed to be able to put things into it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11530760July 6, 2023
POWER TRAIN
My new 2023 Santa Cruz lost power on freeway. The dealer performed a transmission software update; however, the issue was significantly worse after the upgrade, causing me to lose power again on a busy freeway. The vehicle was towed back to dealer. Today I was told the transmission needs replacement. Transmission failure is a dangerous safety issue. It’s my understanding that the 2022 Santa Cruz was recalled for transmission issues. Please do the same for the 2023 model so others don’t experience the terror of suddenly dropping power while surrounded by 65 mph+ cars. Thank you.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11529402June 28, 2023
POWER TRAIN
The dual clutch transmission frequently, though not consistently, malfunctions under acceleration. Typically, when accelerating from a stop, when the transmission shifts from 1st to 2nd gear, the clutch will slip causing a sudden loss of acceleration and shaking of the vehicle. Hyundai calls this a "judder". This causes a safety issue to myself and others because of the unexpected sudden loss of power. If this occurs while crossing another street or pulling out into traffic, it could lead to a collision. I took the vehicle in to Hyundai to have it fixed. They claim to have performed what they called a "judder test" and said that the car passed the test and didn't need any repairs. There have been no warning lights or codes. It is clear to me that Hyundai's testing procedure is inadequate to detect the issue, probably just so they don't have to pay for as many repairs.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11528957June 26, 2023
ENGINE, UNKNOWN OR OTHER
My issue was that I would press the gas pedal, but once I got to 20 mph the engine would stop giving power and I couldn’t get up to speed. My top speed was 30 mph, even though I would give it gas to speed up. This was the worst after I would come to a stop at a traffic light. As I pressed the gas to gain speed, it would struggle to gain speed in the middle of the intersection, causing the cars behind me to be frustrated and aggressively tailgate. I was able to find a parking lot, parked and turned the car off for approximately 20 minutes. After that I turned the car back on, I went for a test drive and there was no problem at all. When this all happened no warning lights came on. Very concerned that this will happen again, as I have no clue what triggered this incident. I have reported this to my dealer, but as this just happened today nothing has been inspected.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11528861June 26, 2023
POWER TRAIN
Upon pulling onto a street, the vehicle lost power. Pressing on the gas pedal provided no power or faster RPM's. No warning lights were activated. I pulled in and out of two different side streets with very little power. Parked and shut off the vehicle. Restarted and the power returned. This is very unsafe as I was pulling out on a busy street and was unable to accelerate faster than 20 mph. Contacted the dealership and they cannot see the vehicle for nearly a month from now.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11526766June 13, 2023
ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
The most major problem that occurred on 2-3 different occasions is that the emergency braking system activated for no reason on one occasion, almost causing a Rear end collision with a person behind me. No one to my sides, and in front of me on all of the occasions. Headlights on the automatic, setting on a bright sunny day, will turn off and on no change in lighting which annoys other drivers because they think I’m flashing them. After starting the car in Drive the first time I break and then go to accelerate there’s a delay in the acceleration. as well as other times while driving. Today, the back up camera didn’t shut off when shifting into drive like it normally does it didn’t go off until I went into parking pushed the radio button. I’m pretty sure it’s a computer issue
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11526470June 11, 2023
POWER TRAIN
As I was driving the call 4 times has turned off in the middle of the road. An error message pops up and stays to put the car in neutral and to push the start button to start it. This has nearly caused an accident because it happens when I am driving . The vehicle also threw out error code P023600 Twice and had the check engine light on. The service department has not been able to recreate the issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11526281June 9, 2023
POWER TRAIN
coolant temperature gauge keeps fluctuating between midpoint and cold. engine light is on. dealership has no remedy.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11526080June 8, 2023
TRAILER HITCHES
The contact owns a 2023 Hyundai Santa Cruz. The contact received notification of NHTSA Campaign Number: 23V181000 (Trailer Hitches) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Hyundai Santa Cruz