Hyundai Kona Complaints (2020)

189 consumer complaints on file.

#11729398April 6, 2026
ENGINE, UNKNOWN OR OTHER
Basically normal driving the car stalled. It slowed to a stall. I had to restart the car. This has happened a couple to times.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11728446April 1, 2026
UNKNOWN OR OTHER
On 3/29/26 my Kona caught fire while parked in the front left side of the engine and burned completely within eight minutes. This is not an electric car. Prior to that I drove the car all day with no incident. It was later in the evening around 5:40 PM. I had driven from my house to a restaurant which is about 6.8 miles from my house. I parked my car and then my son-in-law noticed that my engine was smoking. My husband went to check to see if it was the radiator, but he noticed that it was fire and we called [XXX] . I know there are no recalls for my car, but I wanted to report it to you. The car only had 44,900 miles on it and was only serviced by West Nyack Hyundai. The last service was on 1/19/26. If you have any questions, you can email me at [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11727112March 25, 2026
ENGINE
My car was taken in as a part of recall bulletin 203 for improperly heated piston rings treated pistons rings that result in premature engine failure and possible fire on 12/5/25. The knock sensor test was performed and the KSDS software was installed. On 3/12/26 my daughter who was on the way home from a trip called because her checking engine light started flashing and the engine was knocking. We had it towed to Hyundai and they are denying service under the recall stating improper codes yet one of the codes is P1327 KSDS detection which is related to the rod bearing failure the car currently has. They are trying to make me pay $4600 out of pocket plus the tow bill when this is directly related to the recall.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725552March 19, 2026
ENGINE, POWER TRAIN, STEERING
My 2020 Hyundai Kona (VIN: [XXX] ) has a persistent engine stalling safety defect that matches Recall 203 (22-01-042H, NHTSA Campaign 21V301000 – Nu 2.0L Atkinson Engine Inspection and Replacement). The recall addresses improperly heat-treated piston oil rings causing cylinder bore scuffing, accelerated oil consumption, abnormal knocking, and potential engine stall while driving (increasing crash/fire risk).I first brought the vehicle to Corona Hyundai for repeated stalling while driving. They performed the recall vibration inspection and software update (Campaign 974), stated the test passed, and declared the vehicle "fixed", safe and "good-to-go" Immediately after pickup, the stalling returned worse: approximately 60-80 miles later on XX near the XXX exit (four-lane high-speed highway), the engine completely stalled at 65 mph while merging for an exit. This caused vehicles and semi-trucks behind me to swerve dangerously and very nearly collide with me. The vehicle stalled four more times on the way to my destination in [XXX] .I then took it to the nearest dealer, Carlsbad Hyundai for safety reasons. They performed the vibration inspection again, which also "passed," yet the real-world symptoms would continue unchanged: accelerated oil consumption (I monitor the dipstick and refill regularly), sputtering, knocking noises, and complete engine stalls (dozens of incidents, especially on local roads and turns). The vehicle remains undrivable due to imminent stall risk while moving and putting myself, my passengers and other commuters at high risk of severe injury or death.Both dealers and Hyundai Customer Care (Case #XXX) have refused further action, stating the vibration test passed, they cannot duplicate the concern, and no additional claim can be submitted for engine replacement. Hyundai's TSB [XXX] requires only the vibration inspection; engine replacement is authorized if "NO PASS" – no separate oil consumption test or monitored drive INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11723633March 11, 2026
ENGINE
The contact owns a 2020 Hyundai Kona. While the contact’s son was driving the vehicle on the highway at an undisclosed speed, there was a knocking sound coming from the engine and the vehicle failed to stop as intended. The gear shifter was shifted into neutral(N) and restarted; however, the engine failed shortly afterwards, and the vehicle was unable to restart. No warning lights were illuminated. The vehicle was towed to an independent mechanic, where it was diagnosed with piston rings failure and low engine oil. The vehicle was not repaired. The manufacturer was notified of the failure, where it was confirmed that the VIN was included in NHTSA Campaign Number: 21V301000 (Engine); however, the recall repair was already performed. The approximate failure mileage was 108,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11722050March 4, 2026
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM, POWER TRAIN
While driving approximately 70 mph on I-10 in Louisiana late at night, my 2020 Hyundai Kona EV displayed a “Check EV System” warning while I was on the highway. There were no safe areas or emergency shoulders available to pull over, so I continued driving toward the nearest exit. Approximately 15 minutes after the warning appeared, as I attempted to exit the highway, the vehicle suddenly lost power and rapidly slowed. The vehicle came to a complete stop and could not accelerate, move forward, or reverse. This created a serious safety risk because the vehicle lost propulsion while traveling at highway speed. The vehicle had approximately 62,000 miles at the time of the incident. The vehicle was towed to Giles Hyundai where the dealership diagnosed an internal temperature sensor and resolver failure. Because these components are integrated into the drive system, the dealership replaced the entire traction motor assembly. The repair cost was approximately $9,000. The sudden loss of propulsion at highway speed created a dangerous situation for both the driver and surrounding traffic.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11715307February 3, 2026
ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: WARNINGS, ENGINE
many times a year, without warning, vehicle dash lights turn off and light up like a christmas tree, followed by fca warning sound and lights going off, and a loud mechanical thud. Lose engine throttle going highway speeds. This can occur at nearly any speed without warning. Car must be powered off and back on to get normalcy. This puts me, everyone in the car and everyone on the highway at risk. Dealership was not able to reproduce or pull error codes.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11708967January 5, 2026
POWER TRAIN
While driving under normal conditions, the vehicle’s dual-clutch transmission (DCT) failed to engage properly, causing a sudden and unexpected loss of propulsion. When the accelerator was pressed, the vehicle hesitated and did not respond as commanded, resulting in delayed or no acceleration. This occurred while driving in traffic at approximately 30 mph while trying to acceletate to merge onto highway and has happened multiple times. In some instances, the vehicle appeared to remain in gear but would not accelerate, and in other instances the transmission disengaged before re-engaging unpredictably. This created an unsafe situation, as the vehicle could not maintain speed or merge safely, significantly increasing the risk of a collision, especially in traffic or at intersections. The issue occurred without sufficient warning and continues to happen intermittently during normal driving.The vehicle was inspected by a dealership, which stated the condition is related to a clutch issue within the dual-clutch transmission and acknowledged it is a known issue affecting this transmission. The dealership further stated the issue would not be repaired because the vehicle is out of warranty.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699982November 17, 2025
ELECTRICAL SYSTEM
the headlights in this model Kona keep burning out after 9 months or so. I have replaced them multiple times in the last 5 years on both left and right sides. I use glove to put in the bulbs and are very careful not to let my hands touch the bulb. I have never had this happen with any other car I have owned. I suspect an electrical system issue, or perhaps wiring, but that is speculation. I have not had this inspected by the dealership. The latest date of failure is listed below.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699021November 12, 2025
POWER TRAIN, VEHICLE SPEED CONTROL
The timing system was repaired in February 2025. After similar symptoms of vehicle stalling, the check engine light came on Found a software update that needed to be completed to determine if engine needed replaced. Dealership has refused for seven weeks to complete the entire job of the update which includes running a diagnostic of codes. Instead, they have been arguing that the timing system needs replaced and not providing the codes from the safety software update. Obviously there's a much deeper issue if the timing system keeps breaking down.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11695903October 27, 2025
ENGINE
Vehicle suddenly began shutting off upon braking and/or acceleration at any speed, idling very hard, and/or barely starting or dying immediately after starting and making a very loud whining noise while driving on an interstate. A mechanic ran a diagnostic test on it and determined that it was a P1327 code and recommended it be taken to dealership for full engine failure. This particular code was known by Hyundai to occur on certain models and years, including Kona 2019-2021, as early as 2022 and while a recall campaign was initiated, no recall to date has been issued. No warning indicators on dash occurred in advance or even after the vehicle began malfunctioning (i.e., no check engine indicator, etc.). Vehicle is available at dealership upon request.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11695939October 27, 2025
ENGINE, POWER TRAIN
The vehicle has ~51K miles. It has been maintained according to the manufacturer's recommended repair schedule. At low speeds (<10 mph) or when coming from a full stop the vehicle hard shifts. When driving up inclines at low speeds (<10 mph), the vehicle shakes and stutters on the verge of shutting off. This happened twice on [XXX]. I experienced a full vehicle shut off on [XXX} while the vehicle was stationary, but shifted into drive . In August, the vehicle stuttered and shook before shutting off. I have reported three instances of this issue to my local Hyundai dealership. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11693682October 15, 2025
ENGINE
The engine shut down when the car stops at a red light or stop sign. There are metal shavings in the oil due to issues with the pistons.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11693239October 14, 2025
UNKNOWN OR OTHER
Car keeps stalling no matter what speed you're driving. Took the car to NTB and they said nothing is wrong with it. It continues to happen even in busy highways where someone almost ran into the back of me. Not safe to drive. Concerned as numerous forums suggest this is a problem with 2019-2021 Hyundai Konas.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11691257October 3, 2025
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER
The contact owns a 2020 Hyundai Kona. The contact stated that the vehicle was consuming an excessive amount of engine oil. There was no warning light illuminated. The vehicle was taken to a local dealer, where the vehicle was diagnosed, and the contact was informed that the turbocharger was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 65,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11690319September 29, 2025
ENGINE
I purchased a used 2020 Hyundai Kona with the Nu 2.0L engine. I drove the vehicle regularly without issue for several years, including two days before the incident. On the day of the incident, I attempted to start the vehicle but it ran irregularly. I shut off the vehicle after a few seconds and restarted. The vehicle stalled seconds after starting. On subsequent attempts it failed to start at all. I learned of Recall 203 (defective piston rings), which affects this model year and engine. I contacted Hyundai, who recommended I visit a dealer. Upon inspection, the dealer recommended engine replacement. Hyundai denied engine replacement under Recall 203, on the grounds that the recall was "closed" during an inspection in 2021 (prior to my ownership) despite the defective part not being replaced. This engine, with defective and recalled part, has now experienced sudden and unexpected failure. Hyundai has been uncooperative and I have been without a vehicle for nearly a month.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11688598September 20, 2025
ENGINE, POWER TRAIN, FUEL/PROPULSION SYSTEM
Ignition, speed and driving halts. I've had this Kona repaired a couple years ago and it took about 6-8mos to get my vehicle back, the this year 2025 the vehicle again is giving me problems. I thought of applying the lemon law however the week of the 6-8months being in the repair shop, I got the vehicle back, and the owner(mr. Crisostomo was very kind and understanding) so it made me be more patience nonetheless there's only so much he could do if he is not the one repairing the vehicle. I was offered carpets for my patience yet still have not gotten them and feel like a bother when I call to inquiry about them and it's not the service manager that I talk to , I feel otherwise. That could just be me, however I know good customer service if it's presence. For the actually year, I would need to check emails and records. But it's probably the year after so 2022 ( almost certain) now, This year, 2025.. I see that there is a recall that the dealership did not inform me. The vehicle is paid of last year, because I was going to relocate but that had changed. I found out about the recall cause my dad had died and step mother is using my other car so I'm using the Kona much more that 3 days a week. I keep dying out in one (1) day.. I died out twice. So I checked if there's a recall and there is. I would like my vehicle repurchased or credit for the amount purchased or I like a jeep 2 door ( is fine) as a recovery vehicle, thank you.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11685967September 9, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2020 Hyundai Kona. The contact stated that while operating the vehicle, there was a knocking sound coming from the engine compartment. The vehicle was taken to the local dealer, who replaced the turbocharger, but the failure persisted. The contact stated that the vehicle was consuming an excessive amount of engine oil. The vehicle was later examined by an independent mechanic who determined that the pistons were faulty. No further information was available. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failures. The contact was informed that the VIN was not included in NHTSA Campaign Number: 21V301000 (ENGINE). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 127,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11685669September 8, 2025
ENGINE
2020 Hyundai Kona wirh 22,000 miles, original owner, great condition(except oil usage). First consumption test used 3/4 qt. in 1,000 miles. Seems convenient that Hyundai says 1 qt & the dealership came up with 3/4 so there is no problem. BULL! No oil light came on to warn of low oil.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11685674September 8, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2020 Hyundai Kona. The contact stated that the vehicle was consuming an excessive amount of engine oil. The contact stated there was a pinging sound inside the vehicle. There were no warning lights illuminated. The vehicle was taken to the local dealer for a multi-point inspection, and it was confirmed that the oil level was extremely low. The contact stated that an oil consumption test was performed. The vehicle had consumed ¾ quarts of oil in a month. The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to seek legal assistance. The approximate failure mileage was 22,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Hyundai Kona