GMC Sierra Complaints (2005)

448 consumer complaints on file.

#10894924August 10, 2016
ENGINE, POWER TRAIN
CASTECH CYLINDER HEADS ON 2001 THROUGH 2006 5.3L VORTEC ENGINES ARE POROUS AND ALLOW ANTIFREEZE TO SEAP INTO THE OIL. THIS IS A SAFETY CONCERN AS IT CAN DESTROY THE ENGINE (OIL DOESN'T LUBRICATE CORRECTLY, SLUDGE BUILDUP) AND LEAVE SOMEONE, AT THE LEAST, STRANDED, AT THE WORST, IT CAN CAUSE A HUGE ENGINE FIRE. GM HAS BEEN AWARE OF THIS SINCE 2007. THEY ISSUED A BULLETIN DESCRIBING THE PROBLEM AND WHAT NEEDS TO BE DONE TO FIX, BUT NO RECALL. TO FIX EITHER THE CYLINDER HEADS NEED TO BE REPLACED ($2500) OR THE ENTIRE ENGINE NEEDS TO BE REPLACED ($5500). MY VEHICLE IS A 2005 GMC SIERRA 1500 SLE. ALSO THE PROBLEM HAS BEEN CONFIRMED BY A LICENSED MECHANIC. THE FOLLOWING IS A LINK TO THE GM ISSUED BULLETIN. HTTP://WW2.JUSTANSWER.COM/UPLOADS/BLUEGORILLA/2008-12-05_142924_COOLANT_LOSS_5.3.PDF
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10891900July 31, 2016
STEERING
STEERING COLUMN GOES OUT FOR THE SECOND TIME IN 117000 MILES AND RATTLES WHILE DRIVING. I UNDERSTAND THIS IS AN ON GOING THING WITH THIS MODEL AND OTHERS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10891490July 28, 2016
ENGINE
RECENTLY PURCHASED A 05 GMC SIERRA 1500 HD WITH 6.0 VORTEC ENGINE. IT HAS A NOTICEABLE TICKING AND AFTER CHECKING MY EXHAUST MANIFOLD BOLTS I FOUND THAT FOUR ARE BROKEN AND ALLOWING RAW EXHAUST FUMES INTO THE AIR. WITH THE BOLTS BREAKING THE MANIFOLD IS WARPED AND BROKEN. THIS IS ALL AT 94,000 MILES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10887533July 21, 2016
AIR BAGS
TL* TAKATA RECALL. THE CONTACT OWNS A 2007 (NA) GMC SIERRA 2500 HD. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V324000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10883754July 9, 2016
SERVICE BRAKES
TAKING VEHICLE OUT OF PARK BRAKE PEDAL WENT ALL WAY TO FLOOR BECAUSE STEEL LINE RUPTURED CAUSING MASSIVE LEAKAGE OF BRAKE FLUID, ROLLED OUT OF DRIVE WAY INTO STREET CUTTING WHEEL TO AVOID WRECK BEFORE COULD GET IN NEUTRAL AND ROLL TO STOP !
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10873901June 13, 2016
SERVICE BRAKES
WHEN BACKING OUT OF A LONG DRIVEWAY, THE BRAKE PEDAL SUDDENLY DROPPED TO THE FLOOR AND BRAKES DID NOT SLOW, STOP OR ENGAGE AT ALL. I PUMPED THE BRAKE SEVERAL TIMES WITH NO RESPONSE WHATSOEVER AND WAS ONLY ABLE TO STOP BY PULLING ONTO THE GRASS WHILE APPLYING THE EMERGENCY BRAKE. I FOUND ONE BRAKE LINE ON THE FRONT DRIVER SIDE HAD RUSTED THROUGH, BUT NONE OF THE OTHERS HAD A LEAK AND THE BRAKE FLUID WAS STILL FULL. WITH ONLY ONE BRAKE LINE DAMAGED I LOST ALL BRAKING POWER.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10872628June 5, 2016
ELECTRONIC STABILITY CONTROL (ESC), UNKNOWN OR OTHER
I DRIVE A 2005 SIERRA 1500 4 WHEEL DRIVE. WHILE DRIVING ON THE FREEWAY THE TRUCK WENT FROM NORMAL 2 WHEEL DRIVE (D ON THE STEERING COLUMN), INTO NEUTRAL. I DID NOTHING TO CREATE THIS ACTION . THE SITUATION WAS EXTREMELY DANGEROUS. I DID PULL OFF AFTER OTHER DRIVERS ALMOST CRASHED DUE TO MY IMMEDIATE DECREASE IN SPEED. ONCE STOPPED I ATTEMPTED TO USE THE STEERING WHEEL SHIFT LEVER TO PUT THE TRUCK IN DRIVE OR PARK. IT WOULD NOT SHIFT, EVEN WITH FOOT ON THE BREAK. I NOTICED MY 4 WHEEL DRIVE SELECTOR SWITCH WAS NOT ILLUMINATED. I PUSHED THE 2WD BUTTON AND IT MADE A TERRIBLE NOISE. I TRIED THE AUTO 4WD BUTTON AND THEN WAS ABLE TO MOVE THE STEERING LEVER BACK TO PARK AND THEN TO D FOR DRIVE. NOW WHEN I SLOW TO TURN THE TRUCK DROPS INTO LOW 4 WHEEL DRIVE WHICH MAKES THE TRUCK SLOW TO 10 MPH MAX. THIS COULD GET ANYONE KILLED EVEN IF INITIALLY ONE HAD PLENTY OF TIME TO TURN. THERE ARE 100S OF FORUMS ON THE INTERNET DEALING WITH EXACTLY THIS PROBLEM YET NOTHING IS BEING DONE. HOW MANY PEOPLE HAVE DIED BECAUSE OF THIS PROBLEM AND NOT HAD THE CHANCE TO TELL? HOW MANY MORE MUST DIE BEFORE ANYTHING IS DONE?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10864326May 11, 2016
ENGINE, POWER TRAIN
CONCERNING GM 706 CASTECH CYLINDER HEADS/GM TSB 06-06-01-019B I HAVE A 2005 GMC SIERRA WHICH HAS SLOWLY BEEN LEAKING COOLANT FOR ABOUT 6 MONTHS. I HAVE HAD IT LOOKED AT AND THE DEALER INFORMED ME THAT I HAVE A 706 CASTECH CYLINDER HEAD THAT IS NOTORIOUS FOR CRACKING AND LEAKING. THE DEALER TOLD ME THERE WAS COOLANT INSIDE MY OIL AND RECOMMENDED REPLACING THE ENGINE. AS I HAVE BEGUN RESEARCHING THIS ISSUE I REALIZE THESE CYLINDER HEADS AFFECT MILLIONS OF GM VEHICLES AND LOYAL CUSTOMERS. GM HAS ISSUED A TSB AND ARE AWARE OF THE ISSUE AT HAND AND IN MY, AND MANY OTHER CUSTOMERS THIS SHOULD HAVE BEEN A RECALLED ITEM. I AM CALLING ON GM TO FIX THIS ISSUE/MISTAKE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10861699April 27, 2016
ELECTRICAL SYSTEM, STEERING
FUEL GAGE,SPEEDOMETER BROKEN, OIL GAGE , BATTERY INDICATOR ETC ALL STOPPED WORKING. ALSO STEERING COLUMN HAS BEEN FIXED THREE TIMES AND BROKE AGAIN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10855602April 14, 2016
SERVICE BRAKES
BRAKE PEDAL WENT ALL THE WAY TO FLOOR. RUSTED THROUGH BRAKE LINE NEAR REAR DRIVER SIDE TIRE
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10854913April 11, 2016
ELECTRICAL SYSTEM
THE GEAR SHIFT INDICATOR LIGHT HAS GONE FROM DIM TO NO LIGHT AT ALL SO YOU CAN NOT SEE WHAT GEAR YOU ARE IN. THIS HAPPENS ANYTIME THE VEHICLE IS RUNNING.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10845746March 9, 2016
ELECTRICAL SYSTEM, POWER TRAIN
TL* THE CONTACT OWNS A 2005 GMC SIERRA 1500. WHEN THE VEHICLE WAS PLACED INTO GEAR, THE CONTACT NOTICED THAT THE GEAR SELECTOR WAS BARELY ILLUMINATED. THE FAILURE PROGRESSIVELY WORSENED AND THE CONTACT HAD TO MEMORIZE IN WHAT GEAR THE VEHICLE WAS PLACED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 138,000. UPDATED 06/15/16*LJ THE CONSUMER STATED THE LED SHIFT INDICATOR DISPLAY HAD FADED, AND HE WAS UNABLE TO DETERMINE WHAT GEAR THE VEHICLE WAS IN. UPDATED 06/22/16.*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10810735December 16, 2015
ENGINE
ENGINE EXHAUST MANIFOLD BOLTS BREAK OFF ON 2 DIFFERENT GM 1 TON TRUCKS. BAD/ FAILED VEHICLE EMISSIONS AND A HUGE REPAIR BILL FOR BOTH TRUCKS. 85,000 MILES ON BOTH VEHICLES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10808664December 6, 2015
SERVICE BRAKES
ON 11-30-2015 I LOST THE BRAKE SYSTEM WHILE DRIVING ON A CITY STREET. UPON INSPECTION I FOUND A RUPTURED BRAKE LINE FROM THE PRIMARY SIDE OF THE MASTER CYLINDER. THE BRAKE LINE HAD FAILED DUE TO CORROSION. INSPECTING OTHER BRAKE LINES, I FOUND OTHERS THAT HAD CORROSION WHERE PLASTIC CLIPS WERE USED TO LOCATE LINES. I HAVE OWNED THIS TRUCK SINCE NEW AND HAVE CARED FOR IT METICULOUSLY. THE TRUCK HAS 66,00 MILES ON IT. I HAVE NEVER OWNED ANY VEHICLE THAT HAD IT BRAKE LINES RUST THROUGH LIKE THIS. A MAJOR CATASTROPHE TO ME AND MY FAMILY WAS AVERTED BY PULLING OVER AT THE FIRST SIGN OF FAILURE. GM SHOULD BE HELD LIABLE FOR EVERY VEHICLE IT MANUFACTURED WITH POOR QUALITY MATERIALS THAT CAN CAUSE FAILURE TO THE SINGLE MOST IMPORTANT PART OF AN AUTOMOBILE, THE BRAKES. AS YOU CAN SEE FROM THE ATTACHED PHOTOS, THIS TRUCK IS NOT RUSTED ANYWHERE ELSE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10789524November 10, 2015
FUEL/PROPULSION SYSTEM
DRIVING 75MPH IN HEAVY HIGHWAY TRAFFIC THE CHECK ENGINE LIGHT CAME ON AND THE TRUCK LOST POWER AND SLOWED TO 40 MPH IN ABOUT 200 YARDS. WE ALMOST GOT HIT BY ALL THE TRAFFIC BEHIND AND AROUND US AS THIS HAPPEN WITHOUT ANY WARNING. WE GOT TO THE SIDE OF THE HWY AND I HAVE A SCANNER AND FOUND 2 CODES P0207 AND P2146. I GOT OUT AND CHECKED THE WIRING TO THE #7 INJECTOR AND DID NOT FIND ANYTHING. PLUGGED IT BACK IN CLEARED CODES ,ENGINE RAN FINE SO START DOWN THE ROAD AGAIN. AFTER 5 MILES IT DID IT AGAIN. IT TOOK ME 5 HOURS TO GO 90 MILES TO GET TO THE NEXT CITY. AT THE HOTEL I FOUND THAT GM HAS A TECH BULLETIN FOR THESE FAULTS AND IT WAS PUBLISHED IN 2008 AT LEAST. SO I WENT TO A DEALER AND WAS TOLD THEY WOULD CHARGE ME FOR THIS REPAIR. I WANT TO KNOW WHY GM DID NOT NOTIFY ME OF THIS KNOWN DEFECT IN 2008 SO I COULD HAVE THE TRUCK REPAIRED IN 2008? THIS DEFECT CAUSES THE TRUCK TO LOOSE SO MUCH POWER THAT IT WILL SLOW IN TRAFFIC WHICH COULD CAUSE AN ACCIDENT. WHY WOULD THIS NOT BE A RECALL THAT GM SHOULD PAY FOR ? GM TB NUMBER IS 05-06-04-047C WHICH TELLS YOU WHAT HAPPENS TO THE TRUCK WHEN THIS DEFECT HAPPENS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10786590October 28, 2015
ENGINE
ENGINE OIL LEAK ON OR AROUND REAR MAIN SEAL. AS OIL DRIPS WHILE DRIVING THE OIL LANDS ON THE EXHAUST PIPE AND BEGINS TO BURN. THIS LEAK LANDING ON THE EXHAUST WHILE HOT CAN CATCH ON FIRE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10782566October 15, 2015
FUEL/PROPULSION SYSTEM, POWER TRAIN
ISSUES WITH EMISSIONS SWITCH. CHECK ENGINE LIGHT WILL NOT GO OFF. ALSO 3 AND 4TH GEAR ARE COMPLETELY GONE OUT. I DO NOT TOW OR HAVE HAD ANYTHING EVEN REMOTELY HEAVY IN THIS TRUCK. IT'S A 2005 GMC SIERRA WITH ONLY 78,480 MILES ON IT. I AM NOT THE ONLY ONE HAVING ISSUES WITH THIS 4 SPEED TRANSMISSION. IT IS NOT HEAVY DUTY ENOUGH FOR THIS SIZE TRUCK. GM NEEDS TO RECALL ALL OF THESE TRANSMISSIONS. WHEN IT FIRST STARTED SLIPPING I LOST ALL POWER GOING DOWN THE ROAD AT ABOUT 55MPH. THE VEHICLE THAT WAS BEHIND ME SLAMMED ON HIS BRAKES TO AVOID HITTING ME. THIS PROBLEM WITH THE TRANSMISSION IS GOING TO KILL SOMEONE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10780242October 6, 2015
ELECTRICAL SYSTEM, EXTERIOR LIGHTING
THE RUNNING LIGHT SOCKETS BURNED OUT. I CAN SEND YOU THE BURNED OUT SOCKET BUT NEED AN ADDRESS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10779519October 3, 2015
STRUCTURE:BODY, FUEL/PROPULSION SYSTEM, STEERING
POWER STEERING HOSE HAS RUSTED AND BEGAN LEAKING. NOTICED A LOT OF UNDERCARRIAGE AND FRAME RUST ON THE WHOLE TRUCK.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10777928September 27, 2015
TIRES
TIRE IS SEPARATED BETWEEN TREAD THIS IS THE 2ND TIRE THAT HAS DONE THIS IN THIS LOT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to GMC Sierra