Chevrolet Silverado Complaints (2003)

2,092 consumer complaints on file.

#10836694February 17, 2016
STRUCTURE:BODY, SERVICE BRAKES, ELECTRICAL SYSTEM
BRAKE LINES, GAS LINE, TRANSMISSION FLUID LINES ALL RUSTED/CORRODED BEGINNING AT UNDER 50,000 MILES. * HAD NEAR ACCIDENTS AS THE BRAKE LINES BLEW WHILE DRIVING ON A HIGHWAY AND WAS DECELERATING IN AN ATTEMPT TO COME TO A STOP..PEDAL WENT TO THE FLOOR, I CONTINUED ON (FOOT OFF THE GAS) UNTIL THE TRUCK SLOWED DOWN ENOUGH ON IT'S OWN, SHIFTED INTO LOW GEAR & WAS ABLE TO COME TO A STOP AND GET TOWED. * SHORTLY AFTER BRAKE LINE INCIDENT, THE SAME THING WITH THE GAS LINE, RUSTED/CORRODED AND LEAKED GASOLINE WHEN IGNITION WAS ON AND PUMP WAS RUNNING... TOWED * A FEW ,MONTHS LATER, I WAS PARKING THE TRUCK AND FLUID STARTED SPEWING FROM UNDER THE TRUCK - AFTER CLOSE EXAMINATION I DETERMINED IT WAS TRANSMISSION FLUID, THE LINES HAD RUSTED/CORRODED - AGAIN,TOWED. * REAR BUMPER ROTTED OUT COMPLETELY BEFORE HITTING 35,000 MILES- I HAD IT REPLACED, NOW THE WHEELS AND SIDE QUARTER PANELS AND EVERYTHING IN BETWEEN ARE ALSO ROTTING OUT. * CURRENTLY THE DASH LIGHTS/PANEL WILL INTERMITTENTLY BEGIN TO FLASH - THE WHOLE DASH GOES BLANK, LIGHTS OFF, THEN THEY COME BACK ON, WHILE DRIVING! **MY MECHANIC RECENTLY TOLD ME AFTER STATE INSPECTION, THAT THE FRAME IS THE NEXT THING TO GO, IT IS RUSTING OUT MORE THAN EXPECTED FOR A VEHICLE OF IT'S AGE/LOW MILEAGE. PERSONALLY, I FEEL THAT INFERIOR PRODUCTS WERE USED WHEN THE TRUCK WAS MANUFACTURED ONLY BECAUSE I HAVE ANOTHER CHEVROLET PRODUCT WITH TWICE THE MILEAGE AND 6 YEARS OLDER WITH BARELY ANY RUST/ROT/CORROSION.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10823608February 1, 2016
SERVICE BRAKES
FRONT BRAKE LINES RUSTED THROUGH AND SPILLED BRAKE FLUID WHILE MOVING AT SLOW SPEED. HAD FRONT BRAKE LINES REPLACED. SIX MONTHS OR SO LATER, REAR BRAKE LINES RUSTED THROUGH AND SPILLED BRAKE FLUID WHILE MOVING AT SLOW SPEED. HAD REAR BRAKE LINES REPLACED. ABS IS NOW CONTAMINATED AND IS CAUSING STOP TIME DELAY, ESPECIALLY AT HIGH SPEED. ALMOST CRASHED ON SEVERAL OCCASIONS WHERE MY HEART DROPPED TO MY STOMACH. DECIDED NOT TO DRIVE TRUCK ANYMORE UNTIL I CAN REPLACE THE ENTIRE BRAKE SYSTEM WITH RUST FREE COMPONENTS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10821900January 23, 2016
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM, VEHICLE SPEED CONTROL
VEHICLE WILL SUDDENLY DECREASE POWER AND THE MESSAGE "ENGINE POWER REDUCED" SHOWS ON MESSAGE DISPLAY. FIRST TIME WAS 9/8/2012. LAST TIME WAS FEB 24, 2015. HAS DONE THIS AT 25 MPH ON A CITY STREET, 35 MPH CITY STREET TWICE, AND 55 MPH ON HIGHWAY. SUPPOSEDLY REPAIRED THREE TIMES. AM AFRAID TO USE VEHICLE AS USUALLY TOW 5TH WHEEL AND DO NOT WANT IT TO DO THIS WHILE TOWING.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10821714January 22, 2016
SERVICE BRAKES
CLEANING & MAINTENANCE, INCLUDING UNDERBODY CLEANING, HAS BEEN PERFORMED RELIGIOUSLY ON MY TRUCK REGARDLESS OF MILEAGE. TOOK IT IN FOR AN OIL CHANGE & WHEN IT WAS PUT UP ON THE RACK, THE MECHANIC SAW THAT THE BRAKE LINES WERE RUSTED OUT. I WAS SHOCKED SINCE IT HAS BEEN WELL MAINTAINED AND WAS EVEN MORE SO WHEN TOLD IT WOULD BE ANYWHERE FROM $900-$1,700 TO REPLACE THE LINES. HE SAID THE LINES COULD FAIL WITHOUT ANY PRIOR WARNING WHILE DRIVING. RESEARCHING, I FOUND THIS IS AN ISSUE GM HAS BEEN AWARE OF, HOWEVER INSTEAD OF THEIR ADDRESSING THE MANUFACTURING PROBLEM, THEY PUT THE RESPONSIBILITY ONTO THE OWNERS. LIKE MYSELF, I'M SURE OTHERS ARE DRIVING TOTALLY UNAWARE OF THE BRAKE LINE FAILURE ISSUE SINCE THERE HAS BEEN NO RECALL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10820131January 14, 2016
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM, POWER TRAIN
SOUND COMING FROM TRANSMISSION WHEN PUSH ON GAS,NO POWER ON RIGHT SIDE GEAR LIGHT DOESN'T WORK I SERVICE 4 WD IT'S TELL ME TO SERVICE I START UP IT'S PICKS WHICH GEAR (STATIONARY) DOOR ON RIGHT STOP WORKING LOST ALL POWER.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10820061January 13, 2016
ELECTRONIC STABILITY CONTROL (ESC)
WITH MY 03 CHEVY SILVARADO 2500 HD THIS REDUCED POWER ENGINE LIGHT COMES ON.SHUTS THE VEHICLE OFF TO 30 MPH.THIS HAPPENS ON A REGULAR BASIS.DOES NOT MATTER WHERE YOUR DRIVING.ESPECIALLY ON A HIGHWAY.THE TRUCK WILL JERK ONE WAY OR THE OTHER THEN U HAVE NO SPEED NO CONTROL FOR A LITTLE BIT .VERY DANGEROUS.HAVE TO PULL OVER WHEN YOU GAIN CONTROL SHUT THE TRUCK OFF.THEN WAIT ABOUT A COUPLE MINUTES THEN START THE TRUCK AND OFF IL GO.HAPPEN ABOUT 5-6 TIMES A DAY NOW.THIS PROBLEM CAN NOT BE FIXED,EVEN IF YOU GO TO A DEALER THEY WILL REPLACE ALL THE SENSORS FOR THE THROTTLE YOU WILL SPEND A SMALL FORTUNE AND THE PROBLEM STILL PERSISTS.THIS IS A SERIOUS PROBLEM AND A VERY DANGEROUS PROBLEM AND HAPPENS TO MANY OF THESE TRUCKS.LOOK IT UP ON YOUTUBE OR GOOGLE IT.IM VERY SURPRISED NOT TO SEE THIS ON THE COMPLAINT BOARD.PLEASE IF YOU HAVE THIS PROBLEM POST IT SO IT CAN BE RECALLED.I TRAVEL WITH MY DOG ALL THE TIME AND IF SOMETHING HAPPENS TO HIM IT WOULD BE VERY TRAUMATIC TO ME.WHAT IF YOU HAVE CHILDREN OR GUESTS IN YOUR TRUCK.ITS WRONG THAT THIS ISSUE IS NOT BEING ADDRESSED.I HAVE COMPLAINED TO THIS COMPANY AND ALSO TO CHEVROLET TO NO AVAIL.IM WORRIED SOMEONE HAS TO BE HURT BAD OR KILLED TO HAVE THIS MATTER TAKEN SERIOUSLY.WOW THE TRUCK HAS A RECALL FOR THE TAILGATE WIRES.THE BUMPERS ARE CRAPP AND RUSTY JUNK BUT NO RECALL THERE AS WELL.PLEASE TAKE THIS SERIOUS AND ALL COMPLAIN ABOUT IT CAUSE THIS IS VERY DANGEROUS.I HATE THIS AND I REFUSE TO SPEND MONEY ON SOME DEFECT IN THE ELECTRICAL SYSTEM.THIS NEEDS TO BE RECALLED AN ABSOLUTE MUST.I KNOW IM NOT THE ONLY ONE SO PLEASE POST YOUR COMPLAINTS ABOUT THIS REDUCED ENGINE POWER LIGHT THAT RANDOMLY COMES ON WITHOUT WARNING.I KNOW YOU WOULD NOT WANT TO BE TOWING WITH THIS PROBLEM.ALSO YOU WILL NOT BE ABLE TO RESELL THIS VEHICLE HONESTLY.YOU WILL HAVE TO LIE TO SOMEONE AND IF THEY GET HURT OR YOU GET SUED THAT WILL NOT BE GOOD.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10819561January 11, 2016
SERVICE BRAKES
REAR DRIVER SIDE BRAKE IN RUPTURED WHILE PULLING A LOADED TRAILER. LUCKILY IT WAS AT A SLOW SPEED. THIS COULD HAVE BEEN TRAGIC OR POSSIBLE DEADLY FOR ME AND MY CHILDREN IF I HAD BEEN ON WINDING BACK ROADS ON HAD A FULLY LOADED TRAILED BEHIND ME.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10818554January 6, 2016
STRUCTURE:BODY, SERVICE BRAKES, ELECTRICAL SYSTEM
AT ABOUT 80,000 MILES BRAKE FAILURE DUE TO RUSTED THROUGH BRAKE LINES.A LEAKING FUEL LINE WAS REPLACED DUE TO RUST. GROUNDING CABLE TO THE ENGINE BLOCK NEEDED TO BE REPLACED DUE TO EXCESSIVE CORROSION. EXHAUST SYSTEM FROM ENGINE BLOCK TO TAIL PIPE HAS BEEN REPLACED, INCLUDING BOTH MANIFOLDS, DUE TO RUST. THE FRONT AND REAR BUMPERS ARE RUSTING THROUGH. NONE OF THESE DEFECTS HAVE RESULTED IN ANY ACCIDENTS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10817711January 4, 2016
ELECTRICAL SYSTEM
WHILE DRIVING, THE HEATER BLOWER STOPPED WORKING AND I SMELLED BURNING PLASTIC OR INSULATION. I PULLED OVER AND FIGURED OUT IT WAS COMING FROM UNDER THE DASH. LOGICALLY I PULLED THE BOTTOM COVER OFF FROM BELOW THE BLOWER ASSY.(FORMER MECHANIC). SMELL WAS COMING FROM PLUG HARNESS AND RELAY. MELTED WIRE INSULATION AND MELTED PLASTIC FROM PLUG HARNESS(OBVIOUS SHORT). I WAS NEAR AN AUTO PARTS STORE AND CHECKED TO SEE IF THEY HAD THIS WIRING PLUG ASSY. AND THEY INFORMED ME THAT THEY DID AND THIS WAS AN ISSUE THAT GM HAD AND THERE HAD BEEN A SAFETY RECALL ON THIS. IT'S WINTER AND I NEEDED A DEFROSTER! ROADSIDE FIX, BUT THIS COULD HAVE BEEN MUCH WORSE. CONTACTED GM AND THEY INFORMED ME THAT THIS WAS NOT THEIR PROBLEM BECAUSE THE VIN NUMBER WASN'T PART OF THEIR RECALL. GM CASE # 8-174060432. NOT DROPPING THIS, THIS COULD HAVE GOTTEN WORSE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10809621December 11, 2015
SERVICE BRAKES
WHEN DRIVING ON A CITY STREET, BRAKE PEDAL WENT TO FLOOR - HAD NO BRAKES, HAD TO RELY ON PARKING BRAKE. ONE BRAKE LINE, FROM PROPORTIONING VALVE TO ABS UNIT HAD BLOWN. ALL BRAKES FAILED. UPON LOOKING, THE BRAKE LINES RUNNING ON TOP OF THE FRAME RAIL NEAR THE DRIVER'S SIDE FRONT TIRE WERE DETERIORATING FROM RUST.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10809545December 10, 2015
SEAT BELTS
TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 2500 HD. WHILE SITTING IN THE REAR SEAT, THE SEAT BELTS WERE TOO LONG RESULTING IN THE PASSENGER NOT BEING RESTRAINED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 175,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10808829December 7, 2015
ELECTRICAL SYSTEM, ENGINE
AT RANDOM TIMES WHILE DRIVING OR TURNING, NO MATTER THE WEATHER OUR TRUCK RANDOMLY DIES. SHIFTING INTO NEUTRAL SHE ALWAYS STARTS BACK UP RIGHT AWAY.HOWEVER DUE TO NOT KNOWING WHEN IT WILL HAPPEN, IT DOES ON CITY STREETS AT 25MPH AND HAD ON THE HIGHWAY AT 75MPH. WE ARE UNSURE STILL AT THE MOMENT THE CAUSE OR SOLUTION. WE HAVE HAD 4 EPISODES OF THIS DANGEROUS PROBLEM STARTING THIS YEAR ONLY, 2015 .
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10807335November 29, 2015
SERVICE BRAKES
I WAS LUCKY TO SEE A SPOT OF FLUID ON MY DRIVEWAY. FIGURED IT WAS BRAKE FLUID SO I HAD MY WIFE PUMP THE BRAKES WHILE I LOOKED FOR THE LEAK. WHEN SHE PUSHED DOWN HARD THE LINE BUSTED AND I LOST ABOUT ALL MY BRAKE FLUID. I'VE INSPECTED MY LINES AND THEY ARE ALL RUSTED. I HAVE THE TRUCK IN THE SHOP NOW TO REPLACE ALL BRAKE LINES. ONLY 127000 MILES ON THE TRUCK.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10806763November 25, 2015
SERVICE BRAKES
BRAKE LINES RUPTURED UNDERNEATH DRIVER SIDE OF VEHICLE. VEHICLE WAS MOVING SLOWLY SO I WAS ABLE TO STOP. BRAKE PEDAL WENT TO FLOOR.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10806153November 23, 2015
SERVICE BRAKES
BRAKE LINE RUPTURE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10794519November 17, 2015
SERVICE BRAKES
BRAKE LINES RUST OUT COMPLETELY
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10790172November 13, 2015
SERVICE BRAKES
THE FRONT TO REAR BRAKES CORRODED TO THE POINT WHERE THEY BLEW OUT WHEN THE BRAKES WERE APPLIED WHILE DRIVING ON THE HIGHWAY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10788515November 5, 2015
SERVICE BRAKES, FUEL/PROPULSION SYSTEM
ON OCTOBER 22,2015 WHILE DRIVEING ON INTERSTATE 75 THE FUEL PUMP STOPPED FUNCTIONING AND RESULTING IN A NEAR DISASTEROUS SITUATION.RESULTS $751.81 REPAIR COST PLUS TOW. THEN ONE WEEK LATER,OCTOBER 29 2015 AT WILMINGTON PIKE AND INERTSTATE 675 RED LIGHT MY BRAKE LINES BURST AND I NARROWLY AVOIDED A WRECK. REPAIR COST $870.17 .I WAS NOT NOTEAFIDE OF ANY RECALL. SO BE FAIR WARNING IF I HAD KNOWN OR BEEN I WOULD HAVE FIXED IT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10787381October 30, 2015
SERVICE BRAKES
WITHIN THE LAST YEAR 3 BRAKE LINES HAVE BROKE. THE FIRST TIME 2 BROKE, AND DUE TO ITS AGE I DID NOT THINK ANYMORE ABOUT IT, THEN THE THIRD JUST BROKE, THE MECHANIC SAID HE HAS NEVER SEEN SO MANY BROKEN BRAKE LINES, ANOTHER CUSTOMER WAS HAVING THE SAME PROBLEM. TODAY I WAS TALKING TO MY NEIGHBOR AND HE JUST BROKE A BRAKE LINE ON HIS 2002 FORD TRUCK. ITS LIKE BOTH GM AND FORD BOUGHT THE SAME LOW GRADE BRAKE LINES IN THE EARLY 2000`S AND NOW THEY ARE FAILING.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10786948October 29, 2015
FUEL/PROPULSION SYSTEM, ENGINE
TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE ENGINE STALLED AND THERE WAS AN ABNORMAL NOISE. THE CONTACT WAS A CERTIFIED MECHANIC AND DIAGNOSED THAT THE FUEL INJECTOR FAILED. THE VEHICLE WAS RESTARTED AND THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 186,444.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Silverado