Chevrolet Cavalier Recalls (1983)

6 recalls on file.

• Recall06E043000May 19, 2006
  FUEL SYSTEM, GASOLINE

  CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.

  Remedy

  HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).

• Recall87V165000October 26, 1987
  ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)

  INTERNAL CORROSION OF PULSAIR CHECK VALVE ASSEMBLY COULD PERMIT EXHAUST GAS TO MELT THE PLASTIC SHUT OFF VALVE AND DRAW VALVE PIECES INTO THE AIR CLEANER AND THROTTLE BODY.

  Remedy

  REPLACE PULSAIR CHECK VALVE AND SHUT OFF VALVE WITH NEWLY DESIGNED VALVES.

• Recall87V079000May 7, 1987
  SEATS

  THE METAL FLOOR PAN ANCHOR BAR COULD FATIGUE AND BREAK AROUND THE LEFT FRONT OUTER SEAT ADJUSTER STUD OF THE DRIVERS SEAT, ALLOWING THE STUD TO SEPARATE FROM THE FLOOR PAN ANCHOR BAR.

  Remedy

  INSTALL A REINFORCEMENT BRACKET ON THE FLOOR PAN ANCHOR BAR AT THE LEFT FRONT OUTER SEAT ADJUSTER POSITION OF THE DRIVERS SEAT.

• Recall83V105000October 13, 1983
  SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DIFFERENTIAL PROPORTIONAL VALVE

  THE BRAKE PROPORTIONER VALVES MAY BREAK AND SEPARATE FROM THE MASTER CYLINDER. THIS WOULD ALLOW BRAKE FLUID TO LEAK AND WOULD RESULT IN A PARTIAL LOSS OF THE BRAKE SYSTEM.

  Remedy

  THE DEALER WILL INSPECT AND, IF NECESSARY, REPLACE ALL SUSPECT VALVES.

• Recall83V042000April 19, 1983
  SUSPENSION:FRONT:CONTROL ARM:UPPER ARM

  THE LEFT FRONT SUSPENSION CONTROL ARM WHICH SUPPORTS THE FRONT WHEEL, BRAKE AND STEERING ASSEMBLY, MAY COME LOOSE AT ITS MOUNTING BRACKET. THIS IS DUE TO POSSIBLE INADEQUATE WELDING OF THE BRACKET.

  Remedy

  DEALER WILL INSPECT THE VEHICLE AND, IF NECESSARY, REPLACE THE LEFT FRONT SUSPENSION SUPPORT ASSEMBLY AT NO COST.

• Recall82V096000October 7, 1982
  FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS

  POSSIBLE FUEL LEAKAGE COULD OCCUR AT THE THROTTLE BODY INJECTION FUEL FEED PIPE CONNECTION ON THE INVOLVED VEHICLES.

  Remedy

  THE FUEL FEED LINE FITTING BOLT AND TWO WASHERS WILL BE REPLACED BY THE DEALER AT NO COST TO OWNER.