Toyota Highlander Complaints (2002)

301 consumer complaints on file.

#10504125March 22, 2013
POWER TRAIN
PULLED OUT OF WORK PARKING LOT ONTO MAJOR HIGHWAY AND HEARD LOUD CLUNK FROM ENGINE AREA. CAR STOPPED MOVING FORWARD SO I PULLED OFF TO SIDE. PUT CAR IN PARK AND ENGINE WAS STILL RUNNING. PUT CAR INTO DRIVE AND NOTHING HAPPENED. PUT CAR IN REVERSE AND NOTHING HAPPENED. LOUD METAL GRINDING NOISE COMING FROM ENGINE COMPARTMENT. TRANSMISSION SHOP SAID COMMON PROBLEM WITH THESE TRANSMISSIONS. COST TO REBUILD: $4,155. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10503623March 19, 2013
VISIBILITY
TL* THE CONTACT OWNS A 2002 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS OVER ROAD BUMPS, THE SUN VISOR WOULD FALL, CAUSING THE DRIVER'S VISION OF THE ROADWAY TO BECOME OBSCURED. THE VEHICLE WAS NOT INSPECTED BY A DEALER OR AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WAS APPROXIMATELY 166,000. *TR...UPDATED 05/08/13 *BF
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10502796March 14, 2013
VISIBILITY/WIPER
TL* THE CONTACT OWNS A 2002 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE DRIVER'S SIDE SUN VISOR BRACKET FAILED. THE SUN VISOR DETACHED FROM THE BRACKET AND OBSTRUCTED THE CONTACT'S VIEW OF THE ROADWAY. THE DEALER HAD PREVIOUSLY REPLACED THE SUN VISOR BRACKET HOWEVER, THE FAILURE WAS NOT CORRECTED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 70,000 AND THE CURRENT MILEAGE WAS 140,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10502013March 7, 2013
VISIBILITY/WIPER, STRUCTURE
DRIVER SIDE VISOR WILL NOT STAY IN PLACE, DROPS DOWN DUE TO VIBRATION. APPEARS TO BE A DESIGN FLAW. VISOR TOO HEAVY FOR ARMITURE, DEALERSHIP COST TO REPLACE APPROXIMATELY 800.00. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10496148February 2, 2013
FUEL/PROPULSION SYSTEM
TANK FOUND TO VERY RUSTED, AND SPLIT, ALONG WITH FASTENERS, SO THAT GAS WAS LEAKING WHILE PARKED. UNABLE TO DRIVE THE VEHICLE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10496167February 2, 2013
VISIBILITY/WIPER
SUN VISOR DOES NOT STAY IN POSITION. IT ROTATES DOWN TO A VERTICAL POSITION, OBSTRUCTING DRIVER'S VIEW AND WILL NOT STAY IN HORIZONTAL POSITION AGAINST CABIN CEILING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10490038December 25, 2012
VISIBILITY/WIPER
WHILE DRIVING BOTH SUN VISORS FALL UNEXPECTEDLY AND BLOCK VISION. THIS HAS BEEN A PROBLEM FROM THE GET-GO AND WE HAD THESE REPLACED ALREADY AND JUST OVER A YEAR LATER THE PROBLEM IS OCCURRING AGAIN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10487762December 8, 2012
EQUIPMENT ADAPTIVE/MOBILITY
I WAS IN THE FRONT PASSENGER SEAT. I PUT THE CAR CIGARETTE LIGHTER INTO ITS HOLDER AND INADVERTENTLY PRESSED IT IN ALL THE WAY. AFTER A FEW MINUTES IT FLEW OUT OF ITS SPACE, IT WAS ALL LITE UP AND FELL TO THE FLOOR OF THE CAR WHERE IT BEGAN TO BURN THE MAT. I PICKED IT UP AND GOT A 2ND DEGREE BURN ON MY FINGER. WE COULD NOT BELIEVE THAT IT HAPPENED SO WE PUT THE LIGHTER BACK IN THE HOLDER AND PRESSED IT IN. IT FLEW OUT AGAIN. *TR
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#10476652September 21, 2012
VISIBILITY/WIPER
THE DRIVER'S SIDE SUN VISOR WILL NOT STAY DOWN WHEN PUSHED INTO PLACE TO BLOCK BRIGHT SUN. INSTEAD, IT MOVES PARTIALLY BACK UP, THEREBY OBSCURING THE DRIVER'S VISION. THERE ARE NUMEROUS REPORTS OF THE SAME PROBLEM IN OTHER 2002 AND 2003 TOYOTA HIGHLANDERS. TOYOTA'S RESPONSE IS SIMPLY THAT THE CAR IS OUT OF WARRANTY, AND WE ARE WELCOME TO PAY $850 FOR A NEW VISOR (IT IS SO EXPENSIVE BECAUSE IT CONTAINS A GARAGE DOOR OPENER REMOTE CONTROL). THIS IS A SAFETY ISSUE. HERE IS MORE INFO FROM OTHERS WITH THE SAME PROBLEM HTTP://WWW.FIXYA.COM/CARS/T594661-HIGHLANDER_PROBLEM_SUN_VISOR. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10468232July 30, 2012
VISIBILITY/WIPER
THE SUN VISOR WILL NOT STAY IN THE UP POSITION. TOYOTA REPLACED THE VISORS UNDER WARRANTY AFTER THE FIRST OCCURRENCE. HOWEVER, THEY ARE NOT STAYING UP ANYMORE. THE DRIVERS SIDE VISOR FALLS DOWN WHEN DRIVING CREATING A SAFETY HAZARD. BOTH OF THEM FALL DOWN AT AN ANGLE WHICH COULD CAUSE HEAD INJURIES DURING A CRASH. IN DOING AN INTERNET SEARCH, IT APPEARS THIS IS AN ISSUE WITH MANY OTHER HIGHLANDERS. I WENT BACK TO TOYOTA AND THEY WOULD NOT REPLACE IT UNDER WARRANTY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10466033July 17, 2012
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2002 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE SECURITY SYSTEM FAILED AND CAUSED ALL OF THE DOORS TO LOCK. THE DOORS COULD NOT BE OPENED MANUALLY, CAUSING THE CONTACT TO BE TRAPPED IN THE VEHICLE DURING EXTREME HEAT. THE POLICE DEPARTMENT BROKE THE REAR WINDOW TO RELEASE THE CONTACT. THE CONTACT FELT CONSTANT WEAKNESS IN THE HEAD DUE TO THE EXTREME HEAT EXPOSURE. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO HAVE A DIAGNOSTIC TEST PERFORMED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 39,050 AND THE CURRENT MILEAGE WAS 39,106.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#10461678June 13, 2012
VISIBILITY/WIPER
TL* THE CONTACT OWNS A 2002 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE DRIVER AND PASSENGER SIDE SUN VISORS WOULD RELEASE DOWNWARDLY WITHOUT INTENT WHEN THE VEHICLE WAS STATIONARY OR IN MOTION. THE SUN VISORS WOULD BE PLACED IN THE UPWARD POSITION UPON RELEASING. THE FAILURE OCCURRED INTERMITTENTLY AND TEMPORARILY DISTORTED THE VISIBILITY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND AN INDEPENDENT MECHANIC, WHO BOTH STATED THAT THE ENTIRE SUN VISOR WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10460733June 5, 2012
ELECTRICAL SYSTEM, VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
THE HEATER WOULD NOT PROVIDE HOT AIR. I PUSHED IN ON THE SWITCH AND THE HEAT WOULD WORK AS LONG AS I HELD THE SWITCH PUSHED IN (NOT DESIGNED TO BE PUSHED - ROTARY SELECTOR). EVENTUALLY, EVEN PRESSING THE SWITCH IN WOULD NOT WORK. I WENT ON LINE AND FOUND A DISCUSSION BLOG THAT DISCUSSED MY EXACT ISSUE. I FOLLOWED THE RECOMMENDATION AND PULLED THE FACE COVER OFF, REMOVED THE CONTROL PANEL AND DISCOVERED EXACTLY WHAT HAD BEEN DESCRIBED - A BROKEN SINGLE STRAND WIRE THAT RAN TO THE BACK OF THE SWITCH. I ATTEMPTED TO MAKE THE REPAIR USING A MULTI-STRAND WIRE AS RECOMMENDED BECAUSE THE DEALER REPAIR OPTION WAS $1,000. THE HEATER APPEARS TO WORK -SLIGHTLY, BUT NOW I HAVE NO AC. I THINK THE CIRCUIT BOARD WAS DAMAGED BY THE SOLDERING IRON HEAT. BECAUSE WE LIVE IN THE SEATTLE AREA, THIS CAUSES ISSUES WITH THE WINDOW DEFOGGER AS WELL AS HAVING NO AC. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10459230May 22, 2012
VISIBILITY/WIPER
I HAVE A PROBLEM WITH THE SUN VISORS ON MY 2002 HIGHLANDER. THE VISORS SEEM OVERLY HEAVY AND DUE TO THE NORMAL VIBRATIONS IN THE CAR THEY FREQUENTLY FALL DOWN, WHICH IS QUITE DISCONCERTING WHEN DRIVING! I'VE TALKED TO TOYOTA BUT THEY MENTION THERE IS NO WAY TO ADJUST THE TENSION AND I'M GOING TO HAVE TO PAY 700.00 TO GET THEM FIXED. I'M CONCERNED AS IT LOOKS TO BE A DESIGN FAULT (I.E. BOTH VISORS ARE FALLING DOWN, DUE TO THE WEIGHT OF THE THINGS) AND I DON'T WANT TO PAY FOR NEW ONES TO BE IN EXACTLY THE SAME SITUATION IN 18 MONTHS TIME. I HAVE RESEARCHED THE PROBLEM ON THE INTERNET AAND MANY PEOPLE ARE REPORTING THIS PROBLEM WITH TOYOTA HIGHLANDERS. *TT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10459041May 20, 2012
VISIBILITY
DRIVER/S SIDE SUN VISOR WILL NOT STAY UP. WHILE DRIVING, IT SUDDENLY DROPS OBSCURING MY VISION AND PUTTING THE DRIVER AT EXTREME RISK FOR AN ACCIDENT (IMPAIRED VISION OF THE ROAD). THERE IS NO APPARENT WAY TO FIX THIS PROBLEM SHORT OF REPLACING THE SUN VISOR (ESTIMATED COST OF APPROX. $700 PER BLOGS). THIS PROBLEM HAS BEEN EXPERIENCED BY MANY OWNERS OF 2002 HIGHLANDERS AS EXEMPLIFIED VIA "COMPLAINT" POSTINGS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10458694May 16, 2012
SERVICE BRAKES, EXTERIOR LIGHTING
REAR-RIGHT BREAK LIGHT NOT WORKING. REPLACE BULB AND DID NOT WORK. CHECKED SOCKET AND ALL IS FINE BUT BREAK LIGHT STILL NOT WORKING. I HAVE RESEARCH THIS FOR A WHILE AND NO SOLUTION. THESE SEEMS TO BE A VERY COMMON PROBLEM AND TOYOTA DOES NOT HAVE A SOLUTION. DEFINITIVELY A SAFETY ISSUE. I ALREADY GOT A TICKET FROM POLICE FOR NOT HAVING THESE LIGHTS IN WORKING CONDITION.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10456515April 25, 2012
EXTERIOR LIGHTING
PASSENGER RIGHT REAR BRAKE INTERMITTENT. TOOK THE CAR TO MY LOCAL TOYOTA DEALER, THEY COULD NOT FIND THE PROBLEM. BULB, LIGHT SOCKET, WIRING, FUSE ALL CHECKED GOOD. THE ISSUE HAS NOT GONE AWAY. TODAY I WAS STOPPED BY A POLICE OFFICER BECAUSE OF MY PASSENGER BRAKE LIGHT NOT WORKING. I TOLD THE OFFICER ABOUT WHAT I DID TO RESOLVE THE ISSUE AND THAT I TOOK THE CAR TO THE TOYOTA DEALER AND THEY COULD NOT FIND OUT THE PROBLEM. AFTER EXPLAINING WHAT I DID TO RESOLVE THE ISSUE, THE POLICE OFFICER EXPLAINED TO ME THIS IS A SAFETY ISSUE AND THE BRAKE LIGHT NEEDS TO BE FIXED. I GOOGLED THE PROBLEM THIS EVENING AND FOUND 10 WEB SITES ALL HAVING THE SAME PROBLEM WITH THE PASSENGER RIGHT REAR BRAKE INTERMITTENT OR NOT WORKING. I FOUND ONE COMMON THREAD WAS THAT THE MAJORITY OF THE COMPLAINTS WAS ON THE 2002 MODEL AND A FEW ON 2003. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10452309March 19, 2012
VISIBILITY
THIS IS CLEARLY A DESIGN FLAW & POTENTIALLY DANGEROUS. THE SUN VISORS FAIL & DROP DOWN IN FRONT ON YOU, NO LONGER STAYING AT A PROPER ANGLE OR STAYING UP. I CUT ONE OPEN & FOUND THAT THE PIVOTING PIN IS COATED IN PLASTIC & HELD IN PLACE BY A METAL CLIP. OVER TIME THE PLASTIC CRACKS & FALLS OFF THE METAL PIN CAUSING THE LOSS OF THE REQUIRED FRICTION TO HOLD THE VISOR SECURELY IN PLACE. MY 1ST REPAIR WAS TO REFORM THE PIN WITH EPOXY, BUT THE FORCE FROM THE METAL CLIP WAS TOO MUCH AND IT FAILED IN A FEW MONTHS. THE NEXT FIX WAS TO CUT THE VISOR OPEN AGAIN & FORCE THE PART OF THE PIN STILL COVERED IN THE ORIGINAL PLASTIC COATING DEEPER INTO THE METAL CLIP. THAT REPAIR LASTED UNTIL NOW. THE REPLACEMENT PARTS ARE RIDICULOUSLY EXPENSIVE, BUT NOW I CAN NOT REPAIR IT AND NOT DOING SO WOULD BE A DRIVING HAZARD. FROM WHAT I HAVE READ ONLINE THIS IS A COMMON PROBLEM AND TOYOTA SHOULD HAVE DONE SOMETHING BY NOW. *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10448674February 15, 2012
AIR BAGS:FRONTAL
2002 TOYOTA HIGHLANDER. CONSUMER STATES AIR BAGS DID NOT DEPLOY DURING A COLLISION *TGW THE CONSUMER STATED A VAN PULLED OUT IN FRONT OF HUSBAND WHILE TRAVELING APPROXIMATELY 55 MPH. THE IMPACT WAS AT 45-50 MPH. THE CONSUMER'S HUSBAND HIT HIS HEAD ON THE STEERING WHEEL AND SUFFERED AMNESIA AND THE CONSUMER SUFFERED A NECK INJURY. *JB
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
0
#10448103February 15, 2012
VISIBILITY
DRIVER'S SIDE SUN VISOR KEEPS FALLING DOWN SUDDENLY WHILE DRIVING. WHILE SEARCHING ONLINE, I FOUND OUT THAT MANY 2002 HIGHLANDER OWNERS HAVE THE SAME PROBLEM. REPAIR IS TOO COSTLY. IT IS DEFINITELY A SAFETY HAZARD. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Highlander