Toyota Highlander Complaints (2021)

550 consumer complaints on file.

#11591720May 31, 2024
SERVICE BRAKES
When decelerating from a speed of approximately 25 mph on a downward slope of about 5 degrees, and applying the brakes, a number of things occur: 1) There is a 1-2 second delay in the braking action. 2) When applied the braking action is less than expected for certain brake pedal pressure, which causes the driver to increase the brake pedal pressure 3) When the brake pedal is initially depressed, the speed of the vehicle experiences a slight upward speed bump before the braking action is applied, which is 'light' as described in 2). This behavior is transient. Most of the time, it does not happen. It happens often enough to be of concern.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11591478May 30, 2024
SERVICE BRAKES
The vehicle hesitates during right turns, creating a hazardous, potentially dangerous, situation. From research I understand this is a known issue when transitioning between battery and gasoline propulsion. Research indicates this is a known situation, Toyota T-SB-0059-23. However, the TSB expires at the termination of the vehicle 3 years/36 months warranty. As a safety issue, in my opinion this problem should be addressed, regardless of vehicle age or mileage.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11591060May 28, 2024
UNKNOWN OR OTHER
The sun roof on this car spontaneously combusted. I was able to pull up many other complaints regarding the same issue on this car. This needs to be recalled. My [XXX] baby could have had shattered glass had we not had it closed. These sun roofs need to be recalled and inspected! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11589082May 16, 2024
ENGINE, VEHICLE SPEED CONTROL
While accelerating onto the freeway the vehicle suddenly loses power creating a serious safety issue. A check-engine light comes on but the safefy issue is that the vehicle goes into a power loss mode ON THE FREEWAY. A truck nearly rear-ended me the first time it happened. Toyota Service was unable to duplicate and so said National Toyota advised them to release the vehicle back to me. The same issue happened to my boyfriend and his son - total loss of power while accelerating onto the freeway. Then a mechanic recreated the issue 5 additional times (usually in the dawn hours when traffic was light due to safety concerns). Was unable to find the cause of the issue but a loss of power in a vehicle is as serious a concern as an unwanted acceleration. I am frustrated that Toyota is not taking this seriously.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11587925May 9, 2024
AIR BAGS
The contact owns a 2021 Toyota Highlander Hybrid. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11586829May 3, 2024
AIR BAGS
The contact owns a 2021 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11583748April 18, 2024
UNKNOWN OR OTHER
I had been driving for about 20 minutes at approximately 50-55 MPH when the check engine light came on. Seconds later, the red hybrid malfunction message displayed and I lost the ability to accelerate. I was able to pull over and I saw grayish smoke and flames coming from under the hood on the right side. I exited the vehicle and called 911. It took moments from the start to being completely engulfed in flames. Several loud pops or explosions happened during this period. The police and fire department arrived and extinguished it.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11582367April 11, 2024
UNKNOWN OR OTHER
We were driving across the Texas panhandle at the posted speed limit of 75 mph. It was about noon, the outside temperature was about 60 fahrenheit & there was a cross wind of about 30 mph. There were no vehicles in front of me & the closest approaching vehicle was a good half mile away. No vehicles had recently driven past us from the approaching lane. There was a sudden explosion above us & through the 1-2" gap in the motorized retractable sunshade of our moonroof, I could see broken glass. Through that gap, some glass fragments fell in on us. I pulled over to stop, got out & inspected the roof, & the front glass panel was completely shattered & 75% gone. Many of the fragments were on the sunshade & I removed those. Going at about 40 mph we went to the closest small town where a mechanic removed some residual loose glass, vacuumed as much off the shade as he could, & patched the hole with cardboard held in place by duct tape so we could get home for a repair. If the shade had not been almost closed, we would have been showered with glass with risk of bodily & eye injury.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11581000April 3, 2024
STRUCTURE, AIR BAGS
The contact owns a 2021 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V720000 (Structure) and 23V865000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11580376April 1, 2024
UNKNOWN OR OTHER
I have noticed that my vehicle tends to jolt forward as I’m applying the brakes to come to a complete stop.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11579843March 28, 2024
STRUCTURE:BODY:BUMPERS
light impact caused bumper to disconnect from my 2021 highlander. The bumper retainer clips came off. The lower valence clips are stuck and cannot be detached without damaging the lower valence.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11579527March 26, 2024
EXTERIOR LIGHTING
The contact owns a 2021 Toyota Highlander. The contact stated while driving at night at approximately 35 MPH, the low-beam headlights appeared to shine directly into the eyes of drivers in the opposite lane. The contact stated that other drivers would flash their high-beam headlights. The contact stated that he had checked at night by observing the low beam lights aiming point and he saw that they appeared to be aimed high. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed and was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 20,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11579454March 26, 2024
AIR BAGS, STRUCTURE
The contact owns a 2021 Toyota Highlander. The contact received notification of NHTSA Campaign Numbers: 23V720000 (Structure) and 23V865000 (Air Bags) however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that the lower end of the front bumper had become loosened, and the contact was concerned that the lower part of the bumper might detach. The failure mileage was approximately 55,000. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11577596March 15, 2024
STRUCTURE
The contact owns a 2021 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V720000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11570995February 9, 2024
STRUCTURE
The contact owns a 2021 Toyota Highlander Hybrid. The contact received notification of NHTSA Campaign Number: 23V720000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11570440February 6, 2024
STRUCTURE:BODY
Recall has been open for a long time and I am preparing for a military PCS move and must have this fixed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11569512February 2, 2024
STRUCTURE:BODY
Front lower and upper bumper covers. While driving the covers become detached from each other placing the vehicle at risk and other drivers at risk as the components will separate from the car potentially causing damage to the vehicle/tires/etc. or other vehicles in proximity to the car. The dealer has acknowledged this is a known issue but indicates they have no solution. The vehicle was purchase from Pat Lobb Toyota of McKinney Texas on 1/22/2024 and delivery taken on 1/23/2024. They indicate that they inspected the vehicle and found no risk. There are no warnings when this is happening.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11568941January 31, 2024
UNKNOWN OR OTHER
Driving back from lunch with a friend we heard a pop and loud shattering sound as my sunroof glass exploded for no apparent reason. I called the dealer where I purchased the car 40 days ago with every extended warranty that I could. Toyota denied the claim stating that there was not any bulletins stating material defect and that the glass was not part of any warranty and I will have to file an insurance claim.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11568711January 30, 2024
SERVICE BRAKES, VEHICLE SPEED CONTROL, FUEL/PROPULSION SYSTEM
While depressing the brake pedal the vehicle continues to accelerate before finally slowing to a stop. This happens on bumpy road surfaces as well as level road surfaces. There were no warning lights, alarms or messages prior to or during the failure. This issue started around 35,000 mileage and has progressively gotten worse to current day. (Current mileage as of 1/29/2024 is 54,346.) This issue would cause the vehicle to potentially rear end a vehicle you are following or propel the vehicle into an intersection typically controlled by a traffic signal or device. Local dealer has said there is nothing wrong as they could not replicate the issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11568160January 27, 2024
EXTERIOR LIGHTING
The headlights of the Toyota Highlander are too bright for other drivers. When driving at night, I am constantly flashed because the drivers think the highbeams are turned on when in fact, the lights are too bright for their visibility.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Highlander