Toyota Highlander Complaints (2021)

550 consumer complaints on file.

#11620010October 15, 2024
POWER TRAIN
Regarding Toyota TSB T-SB-0008-21, ‘Whine or Grind Noise From the Transmission’, issued February 2021: Some 2021 model year Avalon, Highlander, and Camry vehicles equipped with UA80E or UA80F transmissions may exhibit a whine or grind noise from the transmission. This condition may be caused by an issue with the front carrier assembly pinion shafts. This is a widespread problem with these specified transmissions. The noise generally starts around 60-70k miles, just outside the warranty period. Toyota knowingly continued to sell vehicles with these defective transmissions. Repair estimates range from $8.5k-$13k.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11619981October 15, 2024
AIR BAGS
The contact owns a 2021 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V865000 (AIR BAGS) however, the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11619112October 10, 2024
AIR BAGS
The contact owns a 2021 Toyota Highlander Hybrid. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11619196October 10, 2024
POWER TRAIN
Transmission failure at 70,000 miles waited 3 months for replacement transmission.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11619178October 10, 2024
AIR BAGS
SAFETY RECALL 23TA15 (Interim Notice 23TB15) was issued December 20, 2023 - almost one year ago. Toyota does not yet have a remedy for this potentially serious safety issue. For several months, Toyota's website has had the following verbiage regarding this "Toyota estimates the remedy can be available in Quarter 3, 2024, but this is subject to change based on parts availability." I cannot continue to drive people with this potentially serious safety issue. When will a remedy be available?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11618826October 9, 2024
STRUCTURE:BODY
Water leaking into the A pillar where airbags are located due to faulty seals in roof rails.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11618505October 7, 2024
POWER TRAIN
My wife’s Highlander started whining under acceleration. I am not a trained mechanic but know enough about vehicles that I k ew it was the transmission. I checked Google for 2021 Highlander complaints and found hundreds of them. The vehicle has 90k on it but luckily we bought the extended warranty through Toyota. I took the vehicle in for service and told them the transmission was whining and needed replaced and would be covered under my warranty. They looked at me strange and said ok sure, we’ll check it out. 4 hours later they called to confirm I needed a new transmission. They estimate it to take be 4 weeks before they receive the transmission. Apparently so many being replaced they are on back order. Luckily we bought our vehicle as a “Certified Pre-Owned” so we get a loaner the entire time. Just sad to see Toyota quality going down hill like it has.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11617952October 3, 2024
STRUCTURE
See attached document for complaint.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11615982September 23, 2024
Chest Clip, Buckle, Harness
Chest clip is magnetic and can be opened by child without using the buttons to open. No longer staying closed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11615821September 22, 2024
POWER TRAIN
I WAS COMING HOME FROM WORK AND THE BREAK SYSTEM FAIL AND THEN I WAS COMING TO SA STOP LIGHT I WAS ABLE TO BREAK SLOWLY AND I WAS ABLE TO GO INTO SHELL GAS STATION GOT OFF TO PUT GAS AND THE STARTED TALKING TO TAKE IT TO THE NEAR DEALER TOYOTA .I GOT OFF THE VECHICLE PUT GAS AND WHEN I STARTED TO TURN ON I WOULD TURN ON AT ALL I DO T KNOW I GAVE IT SOME GAS AND I WAS ABLE TO TURN IT ON BUT THE MOTER WAS SHAKING AND IT WAS STALING ON ME. THE H AND COLD GAUGE WAS STUCK NOT MOVING ETHIER. THAT FAN FROM THE MOTER STOP WORKING AS WELL I WAS ABLE TO TURN IT ON AND I DRO E IT TO MY MOTHERS HOUSE AND LEFT IT THEIR GOT A TOWTRUCK ON THE JULY 28 2024 TO TAKE IT TO THE DEALERSHIP I HAD TO PAY THE TOW TRUCK AND UNTILL KNOW I HAVENT GOT MY REFUND BACK BECAUSE I HAD TOWNIG WITH THE VECHICLE WHEN I PURCHASED IT. ITS 2 MONTHS OUT I STILL HAVENT GOTTEN MY TRANSMISSION OR GOTTEN FIX AND THE VECHICLE HAD THE EXTENDED WARRANTY AS WELL IT HAS 71,700 ML ON IT AND I ALSO HAVE TO PAY THE RENTAL VECHICLE AS WELL. TOYOTA DOENT WAST TO PAY AT ALL FOR THE RENTAL VECHICLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11615432September 19, 2024
STRUCTURE, AIR BAGS
The contact owns a 2021 Toyota Highlander Hybrid. The contact received notifications of NHTSA Campaign Numbers: 23V720000 (Structure) and 23V865000 (Air Bags); however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11615387September 19, 2024
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
[XXX], while driving on a [XXX], my 2021 Highlander Platinum unexpectedly shut down without ANY prior warning or indication of a malfunction. This abrupt failure put my safety, as well as that of my passengers and other motorists, at considerable risk. As a longtime Toyota customer, I have always valued the reputation of Toyota vehicles for their reliability and safety. However, this incident has significantly shaken my confidence in that reputation. I trusted that my vehicle, particularly one as recent as the 2021 Highlander, would perform safely and effectively in all driving conditions. The complete and sudden failure of the vehicle on a busy highway is not only unacceptable, but also alarming. I now find myself questioning whether I can continue to rely on this vehicle or the brand itself. After having the vehicle towed from obstructing a busy lane of traffic, the battery was jump started to get the car running again. I had NEVER had ANY issues with battery and all regular services had been completed at a Toyota Service Center, but several codes appeared on the dashboard after this incident advising the vehicle be taken to a dealer. Vehicle was taken to Toyota Service Center [XXX] for a diagnostic check, but they couldn’t find any error codes or issues with the vehicle. I contacted Toyota to thoroughly investigate this matter and address the underlying issue that caused the shutdown, so that I can regain confidence in its safety and dependability. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11615316September 19, 2024
UNKNOWN OR OTHER
Sunroof shattered while vehicle was parked. Nothing touched the vehicle. We were just sitting in the car when it happened.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11614292September 12, 2024
STRUCTURE
The contact's mother owns a 2021 Toyota Highlander Hybrid. The contact stated while driving 70 MPH out of town, another driver informed the contact that the front bumper had detached. The contact pulled over to the side of the road and inspected the vehicle. The contact continued driving to the destination. The vehicle was taken to the dealer, where the contact was referred to an autobody repair shop. The vehicle was taken to the autobody repair shop, where the repair was performed ineffectively. The contact later received notification of NHTSA Campaign Number: 23V720000 (Structure). The vehicle was taken to the dealer, where the recall repair was performed. The vehicle was repaired. The manufacturer was notified of the failure and denied reimbursement for the repairs performed by the autobody repair shop because the failure occurred prior to the recall. The failure mileage was approximately 27,300.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11614197September 12, 2024
POWER TRAIN
A whine developed while accelerating on the highway. The whine continued any time I accelerated higher than about 35 mph. I suspected it was the transmission and Toyota confirmed I was right. I need a whole new transmission. At 59,000 miles, my Highlander is still under power train warranty. However, my car was diagnosed July 9 and I am still waiting for the part to come in at the dealership more than 2 months later. I was told verbally that I would be able to still drive the car while waiting, but I don't feel safe doing so.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11614133September 12, 2024
VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR
I just bought this 2021 Highlander XSE & the drivers side mirror vibrates above 30mph. I feel this makes it very hard to see properly especially on the interstate traveling 70mph & trying to get a clear view of the roadway & cars around me. I took the car to my local Toyota dealer & was told this is a common problem among the new design with the Highlander’s. I do not feel safe not being able to see properly.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11613152September 6, 2024
POWER TRAIN
Transmission/differential - Took my car in around 80k miles for a routine transmission service. I got my car back and it started making a whining noise when you accelerate. Never did I get a code, check engine light nothing. Took it back to get looked it since the sound never went away. I am being told it needs a new transmission. I was told my car transmission was too hot for them to even look at after sitting for 24hr parked! I have read and done a lot of research that this is a common issue and never has been recalled. Even a shortage now on transmissions with so many needing them now! My car is only 3 years old and won’t be covered.. this should have been recalled and or known to buyers before purchasing if it was known to have issues early 2021…
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11611701August 29, 2024
SERVICE BRAKES
The vehicle is a hybrid. While traveling downhill at a speed around 35 mph with light brake pressure, the vehicle feels like it lurches forward a second or so before returning to braking. It has occurred since we purchased the vehicle new in 2021. It has happened multiple times in a variety of scenarios but it occurs most consistently in the downhill scenario described above.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11611560August 29, 2024
AIR BAGS
The contact owns a 2021 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11610404August 23, 2024
STRUCTURE, AIR BAGS
The contact owns a 2021 Toyota Highlander. The contact received notifications of NHTSA Campaign Numbers: 23V720000 (Structure) and 23V865000 (Air Bags); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated while driving 65 MPH, there was an abnormal sound coming from the front end of the vehicle and it felt like the front tires had struck an object on the highway. The contact stopped the vehicle and observed that the lower half of the front bumper had detached and was on the road surface. The contact called a local dealer and was informed that the parts were not yet available. The vehicle was not repaired. The failure mileage was approximately 31,000. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Highlander