Toyota 4Runner Complaints (2003)

696 consumer complaints on file.

#11205191May 2, 2019
UNKNOWN OR OTHER
THE FRAME ON MY 2003 4RUNNER IS COMPLETELY RUSTED BEYOND WHAT IS REASONABLE AND SAFE. I PURCHASED THE 4RUNNER NEW AND NOW I HAVE BEEN TOLD BY SEVERAL AUTO REPAIR SHOPS THE FRAME IS NOT SAFE TO DRIVE. SOME SHOPS REFUSE TO PUT THE 4RUNNER ON A LIFT IN FEAR THE FRAME WILL BREAK. THIS IS A SERIOUS ISSUE AND I FEAR FOR THE SAFETY OF MY FAMILY. I FEEL THIS RUST ISSUE IS THE FAULT OF TOYOTA TO NOT PREP THE FRAME TO RESIST CORROSION.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11205188May 2, 2019
UNKNOWN OR OTHER
THE FRAME ON MY 2003 4RUNNER IS COMPLETELY RUSTED BEYOND WHAT IS REASONABLE AND SAFE. I PURCHASED THE 4RUNNER NEW AND NOW I HAVE BEEN TOLD BY SEVERAL AUTO REPAIR SHOPS THE FRAME IS NOT SAFE TO DRIVE. SOME SHOPS REFUSE TO PUT THE 4RUNNER ON A LIFT IN FEAR THE FRAME WILL BREAK. THIS IS A SERIOUS ISSUE AND I FEAR FOR THE SAFETY OF MY FAMILY. I FEEL THIS RUST ISSUE IS THE FAULT OF TOYOTA TO NOT PREP THE FRAME TO RESIST CORROSION.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11204869April 30, 2019
STRUCTURE:BODY
OUR 2003 TOYOTA 4RUNNER HAS AN UNSAFE FRAME FROM COMPLETELY RUSTING THROUGH. THE REAR END OF THE VEHICLE, AFTER BEING INVOLVED IN A MINOR ACCIDENT COMPLETELY COLLAPSED IN ON ITSELF, BENDING THE 1/4 INCH STEEL SUPPORT BRACKET. THE FRAME SHOWS THE SAME TYPE OF RUST THROUGHOUT.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11204513April 29, 2019
UNKNOWN OR OTHER
HAD THIS VEHICLE FOR 4 MONTHS. LOW OWNER COUNT, AND 160K MILES WITH GOOD MAINTENANCE HISTORY. NOTICED A SLIGHT SWAY AT TIMES ON THE ROAD, SUSPECTED TIRES AND/OR ALIGNMENT. AFTER REPLACING AND SERVICING IT, IT WAS DISCOVERED THE FRAME IS ROTTED OUT EXTREMELY BAD FROM FRONT TO BACK. THE PASSENGER SIDE FRAME RAIL IS COMPLETELY OPEN ON THE BOTTOM FROM CORROSION, CAUSING STABILITY ISSUES AND NOW THE VEHICLE IS UNSAFE TO DRIVE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11204133April 27, 2019
STRUCTURE:BODY
THE ENTIRE FRAME IS RUSTED. THE FRONT SECTION HAS ROTTED THRU AND THE RIGHT SECTION HAS ROT THRU MORE THAN HALF WAY PASS THE MUFFLER AREA. ABOVE THE SPARE TIRE CARRAGE IS ROTTED AND THE TIRE CARRAGE IS SIEZED. I FOUND THIS WHILE JACKING UP THE TRUCK FOR AN OIL CHANGE AND HEAR THE FRAME CRUMBLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11204175April 27, 2019
STRUCTURE:BODY
EXCESSIVE FRAME RUST CAUSING VEHICLE TO FAIL SAFETY INSPECTION.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11203966April 26, 2019
STRUCTURE:BODY
I OWN A 2003 TOYOTA 4RUNNER THAT I PURCHASED NEW. THE VEHICLE HAS ~129K MILES AND WAS GARAGED KEPT TO 11/2015. IT RECENTLY FAILED PA STATE INSPECTION DUE TO A RUST HOLE IN A FRAME RAIL. SINCE 11/2015, THE VEHICLE IS DRIVEN LESS THAN 5K MILES A YEAR. PRIOR TO THIS EVENT, I HAVE NEVER OWNED A VEHICLE THAT EXPERIENCED A RUST HOLE IN THE FRAME. I DID SOME RESEARCH AND FOUND THAT FRAME RUST IN 4TH GENERATION 4RUNNERS IS AN ISSUE. AFTER LOOKING AT THE HOLE AND THE AMOUNT OF RUST ON THE FRAME IT IS OBVIOUS TO ME THAT MORE RUST HOLES WILL OCCUR. TOYOTA CREATED THIS PROBLEM AND HAS A MORAL AND ETHICAL OBLIGATION TO THEIR CUSTOMERS TO MAKE IT RIGHT! TOYOTA NEEDS TO OWN THE PROBLEM, NOT THEIR CUSTOMER! I TRULY BELIEVE THAT THE NHTSA NEEDS TO ISSUE A RECALL BECAUSE IT IS A SAFETY RELATED ISSUE AFFECTING THE STRUCTURAL INTEGRITY OF THE VEHICLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11203167April 23, 2019
STRUCTURE:BODY
THIS VEHICLE FAILED STATE SAFETY INSPECTION AT AN INDEPENDENT AUTO REPAIR CENTER DUE TO EXCESSIVE FRAME RUST. THEN HAD VEHICLE INSPECTED BY A LOCAL TOYOTA DEALER WHO INDICATED "NEEDS NEW FRAME - ALL ROTTED - THERE'S NO WHERE TO WELD." THE BODY OF THIS VEHICLE IS IN GREAT SHAPE BUT HAS BECOME A SAFETY HAZARD DUE TO FRAME RUST. THIS RUSTING ISSUE SEEMS VERY SIMILAR TO THAT OF THE TACOMA. TOYOTA ACKNOWLEDGES THE FRAME ISSUE ON THE TACOMA BUT HAS NOT DONE THE SAME FOR THE IDENTICAL PROBLEM WITH 4RUNNERS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11203012April 22, 2019
SUSPENSION
THE REAR AXLE ASSY MOUNT BRACKET RUSTED STRAIGHT THROUGH AND IT DOES A LOUD CLUNKY NOISE WHILE DRIVING. BROUGHT IT TO A BODY SHOP AND THEY SAID I HAVE TO CHANGE THE WHOLE ASSY, IT CANT BE FIXED. THE CAR WAS PURCHASED FROM DOWN SOUTH, THERES LITERALLY NO BODY RUST, BUT THE FRAME IS ALMOST ALL CHEWED AWAY. I ALSO CANT PASS NY INSPECTION UNTIL I GET IT FIXED, WHICH WILL COST MORE THAN I PAID FOR THE CAR.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11197131April 18, 2019
STRUCTURE:BODY, SUSPENSION
EXCESSIVE FRAME ROT. 4RUNNER SHOULD OF BEEN PART OF THE TACOMA RECALL AND IS ABSURD IT WAS NOT IN THE FIRST PLACE. MY WHOLE PASSENGER SIDE FRAME RAIL IS GONE. I HAVE HAD TO CONSTANTLY FIX WELD NEW METAL TO IT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11196767April 16, 2019
STRUCTURE:BODY
SIGNIFICANT FRAME RUST HAS COMPROMISED THE SAFETY OF THE VEHICLE. SEVERAL HOLES HAVE PERFORATED THROUGH THE FRAME AND IT HAS BEEN DEEMED UNSAFE TO DRIVE DUE TO FRAME RUST. TOYOTA NEEDS TO REPLACE THESE 4RUNNER FRAMES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11196777April 16, 2019
SERVICE BRAKES
MOVING VEHICLE AT SCHOOL PARKING LOT - 17 YEAR OLD DAUGHTER DRIVING ABOUT 3 MONTHS AFTER GETTING HER LICENSE. VSC TRAC ABS LIGHTS ALL CAME ON, A LOW TONE NOISE AND THE BRAKE PEDDLE WAS HARD AS A ROCK WHEN DEPRESSING.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11195276April 9, 2019
STRUCTURE:BODY
"TAKATA RECALL" MY 2003 TOYOTA 4RUNNER FAILED STATE INSPECTION TODAY FOR THE FIRST TIME EVER DUE TO EXTREME FRAME RUST. THE VEHICLE IS TOTALLY UNSAFE TO DRIVE BECAUSE OF RUSTED OUT HOLES IN THE METAL FRAME . YES, IF I DROVE OVER LARGE POTHOLE OR INVOLVE IN A COLLISION, THIS VEHICLE WOULD SEPARATE IN PIECES AND NOT TO MENTION WHAT LEVEL OF BODILY HARM YOU WOULD SUSTAIN . EVEN THOUGH MY ODOMETER READS 255,000+ MILES, THE ENGINE SEEMS TO BE ABLE TO RUN ANOTHER 200,000 PLUS MILES WITH NO ELECTRICAL OR MECHANICAL ISSUES AND BODY LOOKS FANTASTIC FOR THE YEAR. ON-THE-HAND VEHICLE FRAME BELOW IS IN HORRIBLE CONDITION, WITH HOLES RUSTED THROUGH THE METAL AND NO SIGNS OF ANY UNDER COAT PAINT PROTECTION (HATE TO LOSE SUCH A WONDERFUL VEHICLE). PLEASE ADD MY VEHICLE AND SAFETY CONCERNS TO THE LIST OF OTHER 4TH GENERATION TOYOTA 4RUNNERS OWNERS FACING THE SAME FRAME RUST ISSUE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11194431April 7, 2019
UNKNOWN OR OTHER
THE FRAME OF MY VEHICLE IS EXTREMELY RUSTED FOR IT'S AGE. EVERY COMPONENT ATTACHED TO THE FRAME IS OVERLY RUSTED AS WELL. IT IS SPREADING LIKE A VIRUS THROUGHOUT THE UNDER BODY. I AM BECOMING INCREASINGLY CONCERNED ABOUT HAULING, TOWING, OR EVEN DRIVING MY VEHICLE DUE TO THIS RUST. WITH ONLY 172,000 MILES, THIS SHOULD NOT BE OCCURRING. I HAVE BEEN KEEPING IT IN A GARAGE FOR THE PAST 5 YEARS BUT AS THE 2ND OWNER IT'S PROBABLY TOO LITTLE, TOO LATE. TOYOTA SHOULD RECALL THESE VEHICLES AS THEY DID SOME OTHER MODELS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11193789April 4, 2019
STRUCTURE:BODY
EXCESSIVE FRAME RUST IN MULTIPLE SPOTS ON FRAME ON BOTH SIDES AND ON CROSSMEMBER. THIS IS A WELL DOCUMENTED PROBLEM FOR THIS GENERATION OF 4RUNNER AND NEEDS TO BE ADDRESSED. MY VEHICLE HAS BEEN GARAGE KEPT SINCE NEW I AM THE ORIGINAL OWNER OF THE VEHICLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11193834April 4, 2019
SUSPENSION
FRAME ROT AND UNABLE TO PASS INSPECTION NEW EVEN THOUGH I HAVE KEPT THIS TRUCK IN PRISTINE CONDITION. IT IS A REAL SHAME THE DON'T USE BETTER STEEL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11192606March 30, 2019
STRUCTURE:BODY
MY FRAME IS RUSTING FROM THE INSIDE OUT. THERE'S A HOLE IN MY FRAME RIGHT ABOUT WHERE THE DRIVER SITS. I'M INCLUDING A PICTURE OF THE FRAME DAMAGE AND DOCUMENTS FROM TOYOTA INDICATING THE FRAME RUST AND DAMAGE (HIGHLIGHTED IN RED) FROM WHEN THEY INSPECTED IT. NOT SURE WHEN THIS STARTED HAPPENING, BECAUSE I BOUGHT THE 4RUNNER IN 2018. THE INSPECTION FROM TOYOTA ON 12/15/2017 IS THE ONLY THING I CAN FIND DOCUMENTING THE RUST/DAMAGE, BUT IT DEFINITELY STARTED LONG BEFORE THEN. THE TACOMA'S AND TUNDRA'S BOTH HAD THEIR FRAMES RECALLED... WHEN'S IT OUR TURN?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11191972March 27, 2019
STEERING, SUSPENSION, UNKNOWN OR OTHER
STRUCTURAL RUST TO FRAME. CRACKS AND HOLES AT WELDS AND ATTACHMENT POINTS OF SUSPENSION AND STEERING. FRAME IS DISINTEGRATING UNDER THE TRUCK, COMPLETE STRUCTURAL FAILURE IS IMMINENT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11192012March 27, 2019
STRUCTURE:BODY, SUSPENSION, UNKNOWN OR OTHER
EXCESSIVE AMOUNT OF FRAME RUST FOR A CAR THAT HAS BEEN GARAGE STORED IN MILD VANCOUVER BC CLIMATE. FRAME IS EXACT SAME AS TOYOTA TACOMA WHICH HAVE KNOWN FRAME RUST AND FRAME ROT, BUT NOT COVERED UNDER THE FRAME RECALL FROM TOYOTA
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11192035March 27, 2019
STRUCTURE:BODY
EXCESSIVE FRAME CORROSION
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota 4Runner