Toyota 4Runner Complaints (2003)

696 consumer complaints on file.

#11290609December 21, 2019
STRUCTURE:BODY
FRAME IS COMPLETELY CORRODED. WE LIVE IN THE MIDWEST (CINCINNATI AREA) SO NOWHERE NEAR THE OCEAN. THE 4RUNNER HAS BEEN MATICULOUSLY MAINTAINED. WE HAVE RESEARCHED THIS ISSUE AND FOUND THESE MODELS' FRAMES WERE NOT PROPERLY COATED BEFORE SOLD...HENCE THE RUST. OUR LOCAL TOYOTA DEALERSHIP DEEMED IT UNSAFE TO DRIVE. THE VIDEO SPEAKS FOR ITSELF....WE ARE HOPING THERE IS A RECALL ON THIS AS THIS IS EXTREMELY DANGEROUS. VIDEO LINK TAKEN BY TOYOTA: HTTP://ISRE.US/6QTRKD
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11289522December 16, 2019
STRUCTURE:BODY
EXTREME RUST ON THE UNDERCARRIAGE EATING COMPLETELY THROUGH THE FRAME.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11287801December 8, 2019
SERVICE BRAKES
MY DAUGHTER RETURNED FROM WORK TWO DAYS AGO AND PARKED THE VEHICLE, SHE DID NOT NOTICE ANYTHING WRONG WITH ITS DRIVABILITY. THE NEXT MORNING SHE STARTED THE VEHICLE AND A LOUD WARNING TONE WAS BEING EMITTED FROM THE DASH. SHE ASKED ME TO LOOK AT IT AND I NOTICED THE BRAKE AND ABS WARNING LIGHTS WERE ON. I TRIED DEPRESSING THE BRAKE PEDAL AND IT WENT COMPLETELY TO THE FLOOR INSTANTLY. I TRIED BACKING UP THE VEHICLE TO SEE IF REPEATED BRAKING IN REVERSE WOULD PUMP UP THE BRAKES AS IT DOES ON SOME VEHICLES I HAVE OWNED. THAT DID NOTHING AND ALSO UNLIKE OTHER VEHICLES I HAVE DRIVEN, THE BRAKE FAILURE WAS TOTAL. THERE WAS LITTLE TO NO MANUAL BRAKING. TRAVELING IN REVERSE AT MAYBE 3 MPH TOOK FOUR TO FIVE SECONDS TO COME TO A STOP. HAD THIS OCCURRED AT 60 MPH ON THE RURAL ROADS WE LIVE ON, I DON'T THINK WE WOULD HAVE BEEN ABLE TO SAFELY STOP THE VEHICLE. I CAN'T UNDERSTAND WHY ANY CAR WOULD BE DESIGNED WHERE SOME KIND OF ELECTRICAL/COMPUTER FAILURE WOULD RENDER THE VEHICLE UNDRIVABLE INSTANTLY. THIS COULD HAVE BEEN A FATAL EVENT HAD IT OCCURRED AT HIGHWAY SPEEDS. IN SEARCHING THE INTERNET AND YOUR 7 PAGES OF BRAKE RELATED COMPLAINTS ON SPECIFICALLY 2003 4RUNNERS, THERE WERE OVERWHELMING ACCOUNTS OF THE BRAKES TOTALLY FAILING WHILE DRIVING, AND MANY ACCIDENTS REPORTED DUE TO THIS. THIS VEHICLE SHOULD BE REMOVED FROM THE ROAD IMMEDIATELY BEFORE FURTHER INCIDENT AND TOYOTA SHOULD MAKE OWNERS WHOLE DUE TO THIS SERIOUS DESIGN DEFECT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11287091December 5, 2019
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2003 TOYOTA 4RUNNER. THE CONTACT STATED THAT THE VEHICLE WOULD NOT PASS INSPECTION BECAUSE THE FRAME WAS CORRODED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11287004December 4, 2019
STRUCTURE:BODY, SUSPENSION
THE FRAME IS RUSTED AWAY BUT THE BODY IS PERFECT. PURCHASED AS IS. WAS NOT INFORMED IN WRITING ABOUT THE BAD FRAME
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11281181November 19, 2019
STRUCTURE:BODY
DURING A VISIT TO A BODY SHOP TO HAVE MY FUEL DOOR FIXED, I FOUND OUT THAT THE FRAME OF MY VEHICLE HAS SIGNIFICANTLY DETERIORATED DUE TO RUST. THERE ARE HOLES IN THE FRAME, WELDS THAT HAVE RUSTED COMPLETELY THROUGH, AND ONE OF THE TRANSMISSION MOUNTS IS GONE. I WAS TOLD BY THE BODY SHOP WHO REVIEWED THE FRAME, A SECOND BODY SHOP THAT I CONSULTED FOR A SECOND OPINION, AND MY LOCAL TOYOTA DEALERSHIP THAT MY VEHICLE IS NOT SAFE TO DRIVE AND SHOULD NO LONGER BE DRIVEN. ONE BODY SHOP SAID THAT THEY NORMALLY SEES THIS TYPE OF RUST ON VEHICLES THAT ARE 30-40 YEARS OLD! THEY ALSO SAID THAT THE ENTIRE FRAME AND ALL RUSTED PARTS WILL NEED TO BE REPLACED AND WOULD COST BETWEEN $12,000 AND $15,000 DEPENDING ON THE PARTS THAT NEED TO BE REPLACED. MY TRUCK ONLY HAS ABOUT 122,000 MILES ON IT, AND THE BODY, PAINT, AND INTERIOR ARE IMMACULATE! FORTUNATELY, HAVING MY 4RUNNER LOOKED AT PREVENTED A POTENTIAL ACCIDENT. I KNOW THAT THERE ARE SEVERAL CLASS ACTION LAWSUITS CONCERNING FRAMES THAT HAVE RUSTED OUT ON THE TUNDRA, TACOMA, AND THE SEQUOIA VEHICLES FOR WHICH TOYOTA IS PERFORMING REPAIRS AND REPLACEMENTS. THE 4RUNNER SHOULD ALSO BE INCLUDED BECAUSE THERE ARE NUMEROUS COMPLAINTS FOR THIS SAME PROBLEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11278306November 5, 2019
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2003 TOYOTA 4RUNNER. WHILE THE VEHICLE WAS UNDERGOING ROUTINE MAINTENANCE, SEVERE RUSTING AND CORROSION WAS DISCOVERED ON THE SUBFRAME OF THE VEHICLE. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. AN UNKNOWN DEALER WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 165,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11276975October 29, 2019
UNKNOWN OR OTHER
THE FRAME IS RUSTED WITH AREAS THAT NEED TO BE REPAIRED OR FRAME REPLACED. WHEN THE VEHICLE IS IN MOTION THE STEERING WHEEL MOVES BACK AND FORTH AFTER HITTING A BUMP. IT IS LIKE THE FRONT END IS LOSE. I HAVE HAD IT ALIGNED, SO IT IS NOT OUT OF ALIGNMENT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11269418October 18, 2019
SERVICE BRAKES
WHEN IN MOTION OR STOPPING, ON CITY STREETS OR THE HIGHWAY, TURNING INCLUDED, THE ABS SYSTEM MAKES EXCESSIVE NOSIES SUCH AS CHIRPING, SQUEAKING, AND GRINDING. CURRENTLY, THERE HAS NOT BEEN A CRASH OR INJURY AS A RESULT; HOWEVER, THERE IS DOCUMENTATION WITHIN TOYOTA SERVICE AND ONLINE FORUMS OF THIS ISSUE AND CONCERN AMONG 2003 MODELS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11268699October 15, 2019
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2003 TOYOTA 4RUNNER. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SHOOK AND VIBRATED. THE VEHICLE WAS TAKEN TO HERITAGE TOYOTA OWINGS MILLS (9801 REISTERSTOWN RD, OWINGS MILLS, MD) WHERE IT WAS DISCOVERED THAT THE SUBFRAME HAD EXPERIENCED SEVERE RUSTING. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 153,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11265391October 1, 2019
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2003 TOYOTA 4RUNNER. WHEN THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR ROUTINE MAINTENANCE, THE CONTACT WAS INFORMED THAT THE FRONT BUMPER AND THE FRAME WERE SEVERELY CORRODED WITH HOLES AND THE CORROSION PENETRATED THE RADIATOR SUPPORT, THE REAR PASSENGER SIDE TRAILING ARM, AND THE INTERIOR FRAME OF THE FRONT PASSENGER DOOR. THE MECHANIC ADVISED THE CONTACT THAT THE VEHICLE WAS UNABLE TO BE DRIVEN. THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 165,232.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11257979September 25, 2019
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2003 TOYOTA 4RUNNER. WHILE HAVING ROUTINE MAINTENANCE PERFORMED ON THE VEHICLE, THE INDEPENDENT MECHANIC INFORMED THE CONTACT THAT THE FRAME WAS RUSTED ON THE PASSENGER SIDE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 171,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11256670September 19, 2019
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2003 TOYOTA 4RUNNER. WHILE THE VEHICLE WAS UNDERGOING ROUTINE MAINTENANCE, THE INDEPENDENT MECHANIC NOTICED CORROSION ON THE REAR FRAME. THE VEHICLE WAS NOT REPAIRED. TOYOTA OF LA CROSSE (800 3RD ST S, LA CROSSE, WI 54601, (608) 793-7000) WAS CONTACTED AND INFORMED THE CONTACT THAT THEY WERE AWARE OF THE FAILURE AND TO BRING THE VEHICLE IN FOR A SECOND DIAGNOSTIC TEST. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS APPROXIMATELY 269,000.*PM*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11258093September 14, 2019
UNKNOWN OR OTHER
STRUCTURE COMPLAINT. FRAME , FRAME MOUNTING POINTS, AND SUSPENSION MOUNTING POINTS. HEAVY RUST. UPON MAINTENANCE DIAGNOSTICS FOR EVAP SYSTEM THE MECHANICS INDICATED SIGNIFICANT SERIOUS CORROSION PROBLEMS WITH THE FORWARD AND REARWARD SECTIONS OF THE FRAME. SIGNIFICANT AND DANGEROUS DETERIORATION TO MOUNTING POINTS FOR TRACK BARS, BRAKE LINE BRACKETS, AND OTHER SUSPENSION COMPONENTS. STRUCTURALLY THE FRAME IS QUESTIONABLE IN PLACES AND LIKELY HAZARDOUS TO CONTINUE DRIVING, RECOMMENDED THAT VEHICLE BE RETIRED AS IS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11254097September 9, 2019
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2003 TOYOTA 4RUNNER. WHILE THE VEHICLE WAS UNDERGOING A WHEEL ALIGNMENT, IT WAS NOTICED THAT THE FRAME WAS RUSTED. THE VEHICLE WAS TAKEN TO WHITE RIVER TOYOTA (802-299-2800, LOCATED AT 303 SYKES MOUNTAIN AVE, WHITE RIVER JUNCTION, VT 05001) WHERE IT WAS CONFIRMED THAT THE FRAME WAS RUSTED AND THE VEHICLE WOULD NOT PASS THE STATE INSPECTION. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 140,000. THE VIN WAS UNKNOWN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11254289September 9, 2019
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2003 TOYOTA 4RUNNER. WHILE THE CONTACT WAS PERFORMING ROUTINE MAINTENANCE ON THE VEHICLE, HE FOUND THAT THE VEHICLE'S FRAME WAS CORRODED WITH HOLES. THE CORROSION EXTENDED TO THE EXHAUST SYSTEM THAT CONNECTED TO THE MUFFLER. THE FUEL TANK COVER WAS ALSO CORRODED. THE VEHICLE WAS NOT TAKEN TO A DEALER TO BE REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11253801September 7, 2019
UNKNOWN OR OTHER
MY 2003 TOYOTA 4RUNNER IS SUFFERING FROM WIDESPREAD UNDERSIDE RUST. INCLUDING BUT NOT LIMITED TO THE FRAME, RADIATOR SUPPORT, SUSPENSION COMPONENTS, BRAKE LINES AND TOW HITCH.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11253818September 7, 2019
STRUCTURE:BODY
OUR 4RUNNER'S FRAME IS RUSTING AWAY AND TOYOTA REFUSES TO FIX THEIR MISTAKE. THE FRAME IS SIMILAR TO THE TACOMA THAT WAS RECALLED AND REPAIRED, SO I CONTACTED THEM AND WAS INFORMED THAT THEY WEREN'T GOING TO FIX OUR 4RUNNER THAT HAS THE SAME ISSUES. I WAS LESS THAN PLEASED WITH THEIR RESPONSE. THIS COULD'VE QUITE EASILY CAUSED A SEVERE ACCIDENT. LUCKILY MY MECHANIC CAUGHT IT IN TIME BEFORE THAT HAPPENED
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11253923September 7, 2019
STRUCTURE:BODY, UNKNOWN OR OTHER
FRAME IS GETTING LARGE RUST HOLES THROUGHOUT ENTIRE FRAME.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11252243August 29, 2019
ENGINE, SUSPENSION
TL* THE CONTACT OWNS A 2003 TOYOTA 4RUNNER. WHEN THE CONTACT ATTEMPTED TO START THE VEHICLE, IT WOULD NOT START. THE CONTACT MENTIONED THAT THE HEAD GASKET NEEDED TO BE REMOVED AND RE-INSTALLED IN ORDER TO START THE VEHICLE. ALSO, WHILE DRIVING VARIOUS SPEEDS, THE REAR OF THE VEHICLE SWAYED UNCONTROLLABLY TO THE LEFT AND RIGHT. THE VEHICLE WAS TAKEN TO BIG O TIRES (2245 STATE ST, NEW ALBANY, IN 47150, 812-949-0736) WHERE IT WAS DIAGNOSED THAT THE PASSENGER SIDE CONTROL ARM WAS FRACTURED AND THE DRIVER'S SIDE CONTROL ARM COULD FRACTURE AT ANY MOMENT. THE VEHICLE WAS TOWED TO MCCORMICK MOTOR SPORTS (1041 S 6TH ST, LOUISVILLE, KY 40203, (502) 584-1981) WHERE THE CONTACT WAS INFORMED THAT THE HEAD GASKET WAS CAUSING CYLINDER THREE TO MISFIRE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 217,500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota 4Runner