Saturn SL Complaints (1996)

287 consumer complaints on file.

#10169370September 27, 2006
STEERING:RACK AND PINION
RACK AND PINION STEERING FAILED COMPLETELY WHILE VEHICLE WAS IN OPERATION. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10160953June 28, 2006
PARKING BRAKE
I HAVE A 1996 SATURN SL1. ONE DAY I WENT TO PULL UP THE PARKING BRAKE AND FOUND THAT THE LITTLE BUTTON HAD POPPED OFF AND LANDED ON THE DASH, THE SPRING ENDED UP ON THE FLOOR. THE BUTTON IS PLASTIC AND ONE SIDE THAT LATCHED IN TO KEEP IT IN PLACE APPARENTLY BROKE. TO USE THE PARKING BRAKE I WOULD HAVE TO PUT THE SPRING AND BUTTON BACK ON AND ENGAGE THE BRAKE, THEN LET IT POP OFF AGAIN OR JUST TAKE IT OFF. I HAVEN'T BEEN ABLE TO REPLACE IT YET AS I UNDERSTAND THEY DON'T SELL JUST THE PART FOR THE 1996 SATURN. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10155070April 11, 2006
ELECTRICAL SYSTEM:HORN
HI, I HAVE A 1996 SATURN WITH VIN NUMBER [XXX] AND THERE IS A RECALL NHTSA RECALL NO. 98V307/ GM RECALL NO. 98C01 THAT APPLIES TO SATURNS OF MY MODEL BUILT FROM JULY 1995 TO FEBRUARY 1997. ACCORDING TO SATURN THE RECALL ONLY APPLIES TO VIN NUMBER RANGING FROM [XXX]TO [XXX], WHICH MY VEHICLES DOES NOT FALL. ACCORDING TO SATURN, HOWEVER, MY VEHICLE WAS BUILT 12/1995, WHICH WOULD BE DURING THIS PERIOD. SINCE THERE IS ONLY ONE PLANT FOR WHICH THE CAR COULD HAVE BEEN BUILT IT IS UNCLEAR HOW MY VIN NUMBER DOES NOT APPLY. IT SEEMS TO ME THAT I MAY NOT BE THE ONLY VEHICLE THAT FELL THROUGH THIS CRACK. MY HORN IS EXHIBITING THE EXACT FAILURE (HORN STICKING ON) THAT THE RECALL IS FOR. SATURN HAS REFUSED TO PAY FOR THE REPAIR OF THE PROBLEM. DO I HAVE ANY RECOURSE THROUGH THE NHTSA? THANKS. *JB UPDATED 07/16/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10141759November 4, 2005
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:FLOOR SHIFT
DT: THE CONTACT STATED GEAR SHIFTER BROKE. SHE HAD IT REPAIRED BY A MECHANIC. CURRENTLY, THE SHIFTER BROKE AGAIN. THIS RESULTED THE CONTACT'S VEHICLE BEING INVOLVED IN A CRASH. SHE SPOKE TO A MECHANIC. HE WAS COMING TO GET THE VEHICLE AND REPAIR IT. SHE HAS NOT SPOKEN TO SATURN OR GENERAL MOTORS.*AK
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10141769November 4, 2005
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:FLOOR SHIFT
DT: THE CONTACT STATED THE GEAR SHIFTER BROKE. SHE HAD IT REPAIRED BY A MECHANIC. THEN, THE SHIFTER BROKE AGAIN. THE CONTACT'S VEHICLE WAS INVOLVED IN AN ACCIDENT AS A RESULT OF THE FAILURE. THE AFOREMENTIONED MECHANIC WAS COMING TO PICK UP THE VEHICLE FOR REPAIRS.*AK
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10141773November 4, 2005
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS, EQUIPMENT
THE FUEL LINE IN THIS CAR IS EXPOSED AT THE BOTTOM OF THE CAR, AND TWICE NOW (ON 11/3/05 AND EARLIER IN 12/2003) THE FUEL LINE HAS RIPPED AND GASOLINE HAS SPILLED ONTO THE GROUND WHEN TRYING TO START THE CAR. THE GASOLINE SPILL OBVIOUSLY CREATES A SAFETY HAZARD. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10136873September 18, 2005
POWER TRAIN:MANUAL TRANSMISSION:FLOOR SHIFT ASSEMBLY
5 SPEED TRANSMISSION SHIFTER CONNECTION INSIDE CONSOLE BROKE OFF CAUSING CAR TO COME TO A FULL STOP IN THE MIDDLE OF THE ROAD. COULD NOT MOVE CAR AT ALL BECAUSE SHIFTER WAS NO LONGER CONNECTED TO THE SHIFTER CABLE. TRANSMISSION REMAINED IN NEUTRAL. PART TURNED OUT TO BE MADE OF PLASTIC AND COST ONLY $10 PLUS TAX.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10128421July 12, 2005
ENGINE AND ENGINE COOLING:ENGINE
1996 SATURN SL-1 CYLINDER HEAD CRACKED. A KNOWN DEFECT TO THE SATURN CORPORATION.$2400 TO FIX! MY "CHECK ENGINE SOON" LIGHT COMES ON OFTEN. SATURN FINDS NOTHING! HTTP://WWW.CARSURVEY.ORG/VIEWMORECOMMENTS_REVIEW_5215_1.HTML SIMPLY "GOOGLE" SATURN + CYLINDER + HEAD HTTP://WWW.CONSUMERAFFAIRS.COM/AUTOMOTIVE/SATURN_ENGINE.HTML
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10127838July 7, 2005
ENGINE AND ENGINE COOLING:ENGINE
THERE WAS A CLICKING SOUND IN THE ENGINE; WHEN I TRIED TO PRESS THE GAS IT JUST REVVED THE ENGINE BUT HAD A HARD TIME GETTING UP TO SPEED; I WAS DRIVING HOME WITH MY TWO DAUGHTERS; GOING ABOUT 30 MPH AND I HEARD A LOUD NOISE AND THEN STUFF FALLING UNDER MY CAR....THE CAR DIED. I PUSHED THE CAR ABOUT A BLOCK AND HALF TO MY HOUSE. MY CHILDREN AND I THEN WENT TO PICK UP THE PIECES OF THE ENGINE...ONE OF THE PISTONS HAD BLOWN OUT OF THE BLOCK. THERE WAS A HUGE WHOLE ON THE LOWER RIGHT OF THE ENGINE. I HAD SEVERAL MECHANICS COME LOOK AT IT AND THEY SAID IT WAS A "FREAK" ACCIDENT. THERE WAS STILL OIL IN THE ENGINE SO I HAD NOT RAN IT OUT OF OIL. THE NOISE JUST STARTED AND IMMEDIATELY THE ENGINE WAS BAD. I BOUGHT IT WITH 113000 MILES ON IT AND HAD IT ONLY A 6-8 WEEKS WHEN THIS HAPPENED. I HAD 117000 MILE ON IT WHEN IT BROKE DOWN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10115199March 15, 2005
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
WHILE APPLYING THE BRAKES THE PEDAL WENT TO THE FLOOR VEHICLE WAS UNABLE TO STOP ON ITS ON. DRIVER WAS ABLE TO STOP BY TURNING OFF THE VEHICLE FOR FIFTEEN MINUTES, THEN RESTARTED IT AND DROVE TO THE DEALER FOR INSPECTION. MECHANIC DETERMINED THAT ABS CONTROL UNIT SYSTEM NEEDED TO BE REPLACED. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10099742November 3, 2004
STEERING
REQUEST A DEFECT INVESTIGATION FOR POSSIBLE RECALL OF 1990-96 SATURN SL. *BF THE WRITER'S SON WAS KILLED IN AND ACCIDENT IN WHICH, PER WITNESS STATEMENTS, HER SONS VEHICLE VEERED SHARPLY LEFT AND HIT A TREE HEAD ON. THE CONSUMER BELIEVES SOME TYPE OF DEFECT CAUSED HER SON'S ACCIDENT. *NM
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
1
#10096151October 21, 2004
ENGINE AND ENGINE COOLING:ENGINE
FOR THE 4TH TIME, THE HEAD GASKET IS BLOWN AND THE HEAD IS WARPED. THIS IS THE RESULT OF A FACTORY DESIGN DEFECT IN THE ENGINE AND WAS REPAIRED THE FIRST TIME WITHOUT CHARGE BY SATURN. HOWEVER, THE REPAIRS DO NOT LAST AND THE HEAD BLOWS APPROXIMATELY EVERY 30,000 MILES. THERE IS NO ENGINE BUILT THAT SHOULD ONLY LAST 30,000 MILES! SATURN REFUSES TO HELP WITH THESE REPAIRS EVEN THOUGH THE CAR HAS BEEN DUTIFULLY MAINTAINED AND SERVICED AT THE SATURN DEALER. THE ESTIMATE FOR REPAIRS IS $2,140 WITH A RECOMMENDATION OF NEW RODS AND BEARINGS AT THIS TIME ALSO. WE HAD NEW RINGS, RODS AND BEARINGS IN EARLY 2002. IF SATURN ADMITTED TO THE DESIGN DEFECT THE FIRST TIME, AND IT CONTINUES TO OCCUR, SHOULDN'T SATURN BE HELD RESPONSIBLE FOR THE REPAIRS?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10096107October 20, 2004
ELECTRICAL SYSTEM:HORN
RECALL 98-V307. SATURN REFUSES TO REIMBURSE ME FOR A REPAIR THAT WAS OUTLINED IN THIS RECALL CAMPAIGN DUE TO THE FACT THAT MY VEHICLE FALLS OUTSIDE THE VIN RANGE. IF YOU LOOK AT THE RECALL DOCUMENTS, IT SHOWS VEHICLES ALL AROUND MY VIN BUT NOT MY VIN. I HAD THE TWO PARTS IN QUESTION REPLACED 5/20/03 DUE TO THE FACT THAT THE EXACT SAME SYMPTMS DESCRIBED IN THE RECALL OCCURED TO MY VEHICLE. THE HORN WOULD SOUND WITH NO ONE AROUND. I FINALLY HAD TO DISCONNECT THE HORN MANUALLY. I DO NOT KNOW EXACTLY WHEN IT FAILED BUT I HAD IT FIXED ON THAT DATE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10093683October 6, 2004
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
BEGINNING IN 2002 THE REAR DOORS ON 1996 SATURN SL2 BEGAN OPENING SPONTANEOUSLY WHILE DRIVING, FIRST THE PASSENGER SIDE, THEN THE DRIVER SIDE. THEY WOULD NOT RELATCH. WE USED BUNJI CORDS AND THEN FINALLY ROPE THROUGH PARTIALLY OPEN WINDOWS TO KEEP THEM FROM FLYING OPEN AT SPEED. REPEATED OPEN AND SHUTTING AND PLAYING WITH MECHANISM FINALLY GOT THEM TO LATCH AND KEEPING THEM LOCKED SEEMED TO HELP. RECENTLY THE DOOR ON PASSENGER SIDE WAS ACCIDENTALLY OPENED AND WOULD NOT LATCH AGAIN. SAME THING ON DRIVERS SIDE. ALTHOUGH WE GOT THEM LATCHED AND LOCKED AGAIN, NO PASSENGER OR CARGO IS SAFE IN THE BACK SEAT IF THOSE DOORS ARE UNLOCKED OR SOMETIMES EVEN WHEN LOCKED.*AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10081434September 13, 2004
TIRES:TREAD/BELT
WHILE DRIVING 65 MPH REAR PASSENGER'S SIDE TIRE TREAD SEPARATED. AS A RESULT THE REAR QUARTER PANEL AND BUMPER WERE SEVERELY DAMAGED. NO IMPACT REPORTED. *AK *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10090484September 5, 2004
POWER TRAIN:MANUAL TRANSMISSION, ENGINE AND ENGINE COOLING
PURCHASED THE SATURN SL1 IN SEPT 24 OF 2004 WITH 94,32 0MILES. I HAD THE OIL CHANGED THAT VERY SAME DAY. I 'VE KEPT UP ON ALL FLUIDS AND SERVICE RELIGIOUSILY. AT 96910 MILES THE CAR WOULD NOT GO INTO 1ST, 3RD OR REVERSE WITHOUT FORCE. ON 9/10/03 I HAD THE CLUTCH REPLACED AND THE SLAVE CABLE. THEN IS WHEN IT STARTED HAVING PROBLEMS OVERHEATING, MECHANIC DID TWO DIFFRENT DIAGNOSTIC TEST BOTH CAME BACK WITH NO CONCLUSIONS. THE CAR STILL HEATS UP EVERYDAY ,BUT I HAVE NO OTHER CAR TO DRIVE. THERE IS NO POWER IN THE CAR NOW AND THE OIL IS SLUDGE FILLED. I'VE PURCHASED TEMPERATURE SENDING UNITS, BOTH O2 SENSORS, THERMOSTAT, COOLANT,CLUTCH,RELAYS,ETC...TO TRY TO SOLVE THE PROBLEM OF THE OVER HEATING. PRETTY MUCH IT'S A MATTER OF TIME BEFORE I'M LIKE THE OTHER 1996 SATURN DRIVERS WHO WILL HAVE TO PAY THE $ 1000.00-2000.00 TO FIX MY HEAD GASKET THAT WAS A KNOWN FACTORY DEFECT. WHAT CAN WE DO. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10089045September 3, 2004
STEERING:LINKAGES:KNUCKLE:SPINDLE:ARM
MY SON WAS TRAVELING SOUTH ON THE GARDEN STATE PARKWAY @ 65MPN. SLOWED TO EXIT AT EXIT 105. AS HE ENTERED THE EXIT, HE FELT SOMETHING BREAK, LOST STEERING, AND THE CAR SHOT TO THE RIGHT, THE AIR BAGS DEPLOYED, AND THE RIGHT SIDE OF THE CAR SLID DOWN THE GUARD RAIL AND CAME TO A STOP JUST BEFORE IMPACTING A CONCRETE JERSEY WALL. THE INITIAL INSPECTION OF THE VEHICLE REVEALED THAT THE RIGHT SIDE SPINDLE HAD SNAPPED. THE ARM ON THE SPINDLE THAT THE TIE-ROD ATTACHES TO SNAPPED IN HALF. *AK
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10088294August 20, 2004
POWER TRAIN:MANUAL TRANSMISSION:FLOOR SHIFT ASSEMBLY
I WAS BACKING OUT OF A PARKING SPOT WHEN MY SHIFT WENT LOOSE. MY CAR WAS STUCK IN REVERSE. AFTER REMOVING THE CENTER CONSOLE IT WAS DETERMINED THAT MY SHIFTER BUSHING HOLDING THE CABLE TO MY SHIFTER BROKE OFF. I CONTACTED SATURN, BUT THEY INFORMED ME THIS PART IS ONLY PART OF A CABLE KIT WHICH SELLS FOR $169. SATURN WILL NOT SELL THE BUSHING ALONE. THE CABLE IS CURRENTLY BEING HELD ON WITH DUCT TAPE.*AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10089157August 18, 2004
ELECTRICAL SYSTEM:HORN
HORN ASSEMBLY WAS REPLACED 3 TIMES BECAUSE THE HORN FAILED TO FUNCTION WHEN ENGAGED. THERE WAS RECALL 98V307000 ON THIS ISSUE BUT THIS MODEL AND YEAR WAS NOT INCLUDED. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10088124August 18, 2004
ELECTRICAL SYSTEM:HORN, EQUIPMENT
I OWN A 1996 SATURN SL1 THAT I PURCHASED USED IN DECEMBER OF 2000. I HAVE BEEN HAVING PROBLEMS WITH MY HORN SINCE I BOUGHT IT. I HAVE HAD TO HAVE IT SERVICED TWICE AND THE HORN IS BROKEN FOR A THIRD TIME. I REPLACED A FUSE IN SPRING 2001, BECAUSE IT WENT OUT. IN DECEMBER OF 2002 THE HORN WENT OUT AGAIN, SO IN MAY OF 2003 HAD THE DEALER REPLACE THE ENTIRE HORN ASSEMBLY. THIS LASTED UNTIL OCTOBER OF 2003 WHEN MY HORN STARTED GOING OFF WILDLY IN THE MIDDLE OF THE NIGHT, CAUSING THE LOCAL POLICE TO RESPOND AND GIVE ME A WARNING FOR A NOISE VIOLATION. IN THE STATE OF LOUISIANA I AM REQUIRED TO HAVE AN OPERATIONAL HORN TO GET MY VEHICLE INSPECTED, WHICH IS CURRENTLY COSTING ME AN $66/YEAR IN REPLACEMENT. THIS SHOULD NOT BE CONSIDERED REGULAR MAINTENANCE. I WAS LOOKING ON THE INTERNET FOR PARTS TO FIX MY HORN AGAIN, WHEN I CAME ACROSS A RECALL NHTSA: 98V-307, GM RECALL: 98C301. THIS APPLIES ONLY TO THE SW MODELS OF THE 1996 SATURN LINE. WHY DOES THIS ONLY APPLY TO THIS MODEL? THE EQUIPMENT AND THE CONFIGURATION ARE ALMOST IDENTICAL, AND YOU WOULD NOT BELIEVE HOW MANY PEOPLE HAVE HAD PROBLEMS WITH THIS SPECIFIC COMPLAINT. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Saturn SL