Pontiac Sunfire Complaints (1996)

201 consumer complaints on file.

#10129872August 19, 2005
LATCHES/LOCKS/LINKAGES
DT: THE DOORS OPENED BY THEMSELVES WHEN GOING AROUND THE CORNER. THREE OUT OF FOUR OF THE DOORS DO THIS. IF THE CONSUMER SLAMMED THE DOORS THEY WOULD LATCH PROPERLY. IT'S THE DOOR HANDLE ITSELF. THE CONSUMER BELIEVED THE PROBLEM WAS THE SPRING. *JB *SC
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10127927June 20, 2005
STEERING:RACK AND PINION
DEC 19, 2001 THE RACK AND PINION IN THE CONSUMER'S 1996 PONTIAC SUNFIRE FAILED. *NM THE CONSUMER THEN RECEIVED A RECALL IN THE MAIL AND REQUESTED REIMBURSEMENT WHICH WAS APPROVED. IN MARCH THE STEERING RACK AND PINION FAILED AGAIN TO THE POINT THE GEAR WAS STRIPPED AND THE HOUSING WAS CRACKED. THE CONSUMER REQUESTED A REFUND. *JB *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10116526April 7, 2005
SUSPENSION:FRONT:WHEEL BEARING
WHEEL BEARING SEEMS TO BE GOING BAD. THE MOTOR HAS BEEN JUMPING WHEN I TAKE OFF FROM A STOP LIGHT. I THINK THE MOTOR MOUNTS MIGHT BE BAD. THE CAR IS A 96 AND IT HAS 109,000 MILES ON IT. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10090239September 1, 2004
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
WHILE DRIVING ACCELERATOR PEDAL WAS STUCK AND WENT TO THE FLOOR. CONSUMER APPLIED THE EMERGENCY BRAKE AND WAS ABLE TO PULL OVER TO THE SHOULDER. THEN, HAD THE VEHICLE TOWED. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10081603July 9, 2004
ELECTRICAL SYSTEM
WHILE ON THE STREET VEHICLE WAS IN PARK AND THE KEY WAS TAKEN OUT OF THE IGNITION SWITCH. THEN, VEHICLE CAUGHT ON FIRE BEHIND THE STEERING WHEEL. BLACK SMOKE. AND LARGE FLAMES APPEARED. FIRE DEPARTMENT SHOW UP TO EXTINGUISH THE FIRE. DEALER NOTIFIED. *AK
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10073260May 27, 2004
UNKNOWN OR OTHER
MY INCIDENT IS NOT A FAILURE, BUT A CONSTANT PROBLEM. SINCE I BOUGHT THE CAR USED IN DECEMBER OF '03, THERE HAS BEEN MAJOR HESITATION WHEN IDLE OR ACCELERATING. IN FEBRUARY OF '04 MY FUEL PUMP DIED, LEADING ME TO ASSUME THIS WAS THE PROBLEM. I PURCHASED A NEW FUEL PUMP AND INSTALLED IT. I JUST HAD TO REPLACE MY FUEL PUMP AGAIN BECAUSE I WAS BEGINNING TO HEAR A HIGH-PITCHED SQUEAL FROM THE PUMP AND THE HESITATION HAD WORSTENED (MAY '04). THESE PROBLEMS ARE STILL THERE, LEADING FRIENDS TO BELIEVE THAT THIS IS A HEAD/HEAD GASKET PROBLEM INSTEAD OF A DIRECT FUEL SYSTEM PROBLEM. MY CAR HAS ALREADY STALLED IN TRAFFIC DUE TO THIS ON 4 DIFFERENT OCCASIONS (ALL WITHIN LESS THAN A WEEK SINCE THE FUEL PUMP REPAIRS). I AM NOW NOT ABLE TO USE MY CAR FOR MORE THAN SMALL ROUND TRIPS OUT OF FEAR OF MY CAR STALLING AND LEAVING ME STRANDED. *MR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10066074April 13, 2004
FUEL SYSTEM, OTHER:FUEL INJECTION SYSTEM
MY VEHICLE HAS A VERY STRONG GAS ODOR. THE PROBLEM IS WITH FUEL INJECTORS. MECHANIC STATES THE CAR COULD CATCH FIRE AND WILL NOT PASS INSPECTION. THE FUMES ARE SO STRONG IT CAUSES THE DRIVER TO FEEL ILL AND COMPLAINS OF HEADACHES AND COULD POSSIBLY BECOME DIZZY CAUSING DRIVER TO LOSE CONTROL OF CAR. VERY DANGEROUS!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10065566April 5, 2004
ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH
WHILE DRIVING 25 MPH THE VEHICLE CAUGHT FIRE UNDER THE GLOVE COMPARTMENT. DUE TO THE INTERIOR DAMAGE THE VEHICLE WAS TOTALED. THE CAUSE OF THE FIRE HAS YET TO BE DETERMINED. NO INJURIES REPORTED. PLEASE PROVIDE ADDITIONAL INFORMATION. *NM
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10062663March 20, 2004
ELECTRICAL SYSTEM:WIRING
I PURCHASED A 1996 PONTIAC SUNFIRE IN JULY OF 2003. I PREVIOUSLY OWNED A 1997 SUNFIRE AND DIDN'T HAVE ANY PROBLEMS LIKE THIS. THE MOST SERIOUS ISSUE IS WHEN I TURN MY HEADLIGHTS ON, THE FUSE BLOWS AND THE TAIL LIGHTS AND THE DASH LIGHTS (LIGHTS FOR SPEEDOMETER, TACHOMETER, FUEL AND TEMP GAUGE) DO NOT WORK. I ALMOST GOT INTO AN ACCIDENT WHEN MY LIGHTS AND DASH FAILED ME. WHEN I WAS TRYING TO REPLACE THE FUSE SPARKS FLEW OUT AND THE FUSES BLEW IMMEDIATELY. I FEEL IT IS A MANUFACTURER DEFECT. IT IS GOING TO COST ME A LARGE AMOUNT OF MONEY TO HAVE THIS FIXED. GM ALSO WONT GIVE ME THE TIME OF DAY WHEN I CALL AND COMPLAIN. I THINK THAT THERE SHOULD BE AT LEAST AN INVESTIGATION. ( * NUMBER OF FAILURES IS APPROXIMATE THERE ARE MORE. I THOUGHT IT WOULD BE FAIR TO STATE THE VERY LEAST AMOUNT I HAVE COUNTED.) ALSO MY VEHICLE HAS BEEN INOPERABLE FOR SEVERAL WEEKS. (THIS VEHICLE HAS 106,000 MILES ON IT) THANK YOU FOR YOUR TIME. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10050011January 23, 2004
ENGINE AND ENGINE COOLING:ENGINE
THE VEHICLE WAS PARKED AND THE CONSUMER NOTICED OIL WAS LEAKING FROM UNDERNEATH THE VEHICLE. THE CONSUMER HAD TAKEN THE VEHICLE TO THE DEALER FOR ANALYSIS AND THE MECHANIC NOTICED THAT THE HEAD GASKET NEEDED TO BE REPLACED DUE TO DETERIORATION. *AK THE VEHICLE HAD ALSO BEEN LOSING COOLANT FOR THE PAST YEAR AND EXHIBITED A COOLANT SMELL. *SC *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10070415January 15, 2004
AIR BAGS
I WAS A PASSENGER IN THE CAR, SO I DON'T KNOW SPECIFIC MILEAGE, OR VIN NUMBER. THE CAR HAD APPROXIMATELY 80,000 MILES ON IT. THE ACCIDENT OCCURRED ON JULY 5, 2002. IT WAS A FAIRLY LOW SPEED CRASH, MYE ESTIMATE IS WE WERE GOING ABOUT 30 MPH AT IMPACT. WE STRUCK THE CAR IN FRONT OF US. THE AIRBAG DEPLOYED IN MY FACE. I WAS WEARING MY SEAT BELT AND WAS NOT SITTING PARTICULARLY CLOSE TO THE AIRBAG. THE FORCE OF THE IMPACT FROM THE AIR BAG, BROKE MY NOSE AND RESULTED IN PERMANENT DAMAGE TO MY EYES. I WAS THE ONLY PERSON INJURED IN THE ACCIDENT.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10052526January 6, 2004
EXTERIOR LIGHTING:HEADLIGHTS:HIGH/LOW BEAM DIMMER SWITCH
THE HEADLIGHTS GO OUT UNEXPECTEDLY WHEN THE DIMMER SWITCH IS MOVED TO OR OPERATED IN LOW BEAM. FAULTY DIMMER SWITCH. I HAD TO PUT A PIECE OF PAPER IN THE SWITCH SO I WOULDN'T HIGH BEAM EVERYONE ON THE WAY HOME ONE NIGHT.*AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10049089December 3, 2003
ENGINE AND ENGINE COOLING:ENGINE
FAILURE OF HEAD GASKET AT LESS THAN 64,000 MILES. I UNDERSTAND THAT THIS IS A COMMON COMPLAINT WITH THE SUNFIRE MODEL ALTHOUGH THERE HAS BEEN NO OFFICIAL RECALL FOR THIS. *NLM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10048886November 30, 2003
ENGINE AND ENGINE COOLING
HEAD GASKET ON MY 96 PONTIAC SUNFIRE BLEW AND CAUSED MY CAR TO STALL IN TRAFFIC AND ALMOST CAUSED AN ACCIDENT WITH MY FAMILY ABOARD. MY CAR WENT FROM 195 OPERATING TEMP TO 260 WITH IN 1 MINUTE. THE CAR COULD HAVE CAUGHT FIRE AND CAUSED TREMENDOUS INJURIES.*AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10037080September 2, 2003
ELECTRICAL SYSTEM
CAR TURNS OVER BUT WILL NOT START.BROUGHT IT BACK TO DEALER AND THEY REPLACED THE CAMSHAFT SENSOR. GOT THE CAR BACK TWO DAYS LATER AND THE SAME THING HAPPENED. BROUGHT BACK TO DEALER AND THEY SAID IT WAS THE OEM SERCRITY SYSTEM. TOOK BACK AND ARE STILL HAVING PROBLEMS STARTING ALL THE TIME.*AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10037805August 28, 2003
ELECTRICAL SYSTEM:IGNITION
WHILE PUTTING THE KEY INSIDE THE IGNITION VEHICLE WOULD NOT START. DRIVER TOOK KEY OUT OF THE IGNITION AND STEERING COLUMN STARTED SMOKING. VEHICLE CAUGHT ON FIRE. CONSUMER CONTACTED DEALER. *AK
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10026652August 15, 2003
ELECTRICAL SYSTEM, ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
HEADLIGHTS GO OUT INTERMITTENTLY WHILE DRIVING. THIS HAS BEEN REPAIRED NUMEROUS TIMES, THE PROBLEM IS A SPLICE IN THE WIRING. *AK THE HIGH BEAMS WERE INOPERATIVE AND THE DAYTIME RUNNING LIGHTS FLASHED WHILE DRIVING. THE DEALER REPLACED THE INSTRUMENT PANEL CLUSTER. THE VACUUM ACTUATOR WAS STICKING WHICH CAUSED THE HEATER CONTROL NOT TO BLOW ON THE SETTING SELECTED. THE MUFFLERS HANGER BROKE AND THE BAFFLES WERE LOOSE WHICH CAUSED RATTLING AT IDLE. *SCC *NLM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10027189August 7, 2003
ELECTRICAL SYSTEM
WHEN THE CONSUMER ATTEMPTED TO START THE VEHICLE THE IGNITION FAILED TO TURN, WHEN ALL OF A SUDDEN SMOKE EMITTED FROM THE STEERING COLUMN. THE CONSUMER CONTACTED THE FIRE DEPARTMENT AND THEY DISCONNECTED THE CABLE AND BATTERY. THE KEY NO LONGER TURNED THE IGNITION, THE CAR WAS SENT TO THE DEALERSHIP , HOWEVER THEY REFUSED TO FIX THE VEHICLE, BECAUSE THEY CLAIMED THAT SMOKING OF A VEHICLE WAS NOT UNDER WARRANTY. THE FIRE DEPARTMENT HAD TO FAX THEM A NOTICE THAT IS WAS A FIRE. DEALER NOTIFIED. *AK *CB *JB
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10011186July 28, 2003
ELECTRICAL SYSTEM:IGNITION:SWITCH, EXTERIOR LIGHTING:HEADLIGHTS, ELECTRICAL SYSTEM:HORN, VISIBILITY:WINDSHIELD WIPER/WASHER
THE IGNITION SWITCH HAD A SHORT CIRCUIT WHICH CAUSED THE VEHICLE NOT TO START. AFTER THE IGNITION WAS REPAIRED IT STILL DIDN'T WORK PROPERLY. THE HEAD LIGHT (HIGH AND LOW BEAMS) FAILED. THE HORN FAILED. THE WIPER FAILED. *JB *CB *NLM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10020716May 29, 2003
ELECTRICAL SYSTEM, ENGINE AND ENGINE COOLING:EXHAUST SYSTEM, ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE, EXTERIOR LIGHTING, INTERIOR LIGHTING, SERVICE BRAKES, AIR, LATCHES/LOCKS/LINKAGES, POWER TRAIN:AUTOMATIC TRANSMISSION, SUSPENSION, SEATS:MID/REAR ASSEMBLY, VEHICLE SPEED CONTROL
-THE HORN ON 1996 PONTIAC SUNFIRE HAS QUIT WORKING AND BEEN REPAIRED THREE TIMES. THE PEOPLE AT THE SHOP SAID THAT IT WAS GETTING WET APPARENTLY EVERYTIME I WENT THROUGH WATER BECAUSE OF IT BEING POINTED DOWNWARD. -THE MUFFLER HAS BEEN FIXED THREE TIMES -THERE ARE MORE THAT I CAN NOT REMEBER RIGHT OFF HAND -THEIR IS AN ELECTRICAL PROBLEM WITH THE WHOLE CAR. THE LIGHT ON THE RADIO TIME AND STAION DISPLAY HAS NOT WORKED SINCE I BOUGHT IT, THE DRIVER'S REAR DOOR LIGHT HAS NOT COME ON, THE PASSENGER REAR WINDOW LETS DOWN BUT WILL NOT LET UP WHEN NEEDED SINCE RIGHT AFTER I GOT THE CAR, THE LIGHTS IN THE DASHBOARD GO ON AND OFF WITHOUT EVEN BEING TOUCHED, WHILE RIDING DOWN THE ROAD, THE WIDSHIELD WIPERS WILL JUST COME ON WITHOUT BEING TURNED ON AND THEN STOP HALFWAY DOWN IMPAIRING VISION, THE PASSENGER REAR TAIL LIGHT BLOWS ALL OF THE TIME, IT HAS NEVER STAYED WITH A BULB THAT WORKS, ETC. -THE VALVE COVER GASKET LEAKS AND HAS LEAKED SINCE I GOT IT -THE GAS LIGHT WILL NOT TELL YOU WHEN YOU ARE RUNNING LOW ON FUEL -THE RADIO WILL EAT YOUR TAPES SINCE I GOT THE CARTHE TRANSMISSION HAS BEEN REPLACE ON THE CAR WITH LESS THAN 80,000 MILES ON IT -THE RACK AND PINION HAD TO BE REPLACED A FEW YEARS AGO ALONG WITH THE COMPLETE BRAKE SYSTEM THE POWER STEERING HAS LEAKED FLUID AND WILL STOP TURNING IN THE MIDDLE OF A TURN. I HAVE ALMOST WRECKED ON IT SVERAL TIMES BECAUSE OF IT AND THE BRAKES. -THE AIR CONDITIONING COMPRESSOR WORKS WHEN IT GETS READY TO IF EVEN THEN AND HAS ALWAYS DONE THAT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Pontiac Sunfire