Mercury Milan Complaints (2011)

192 consumer complaints on file.

#11556225November 21, 2023
STEERING
The contact owns a 2011 Mercury Milan. The contact stated while driving 25 MPH, she heard an abnormal sound coming from the front-end of the vehicle, and the contact became aware that the electronic power steering was not functioning properly. The "Service Power Steering Now" and "Service Advance Track" messages were displayed. Additionally, the traction control warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 15V34000 (Steering) however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 186,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11530130July 3, 2023
STEERING
The power steering is out and the car is very hard to turn and control. The recall has been confirmed by the dealer but it appears that they cannot fix due to my vin number not showing a recall for the power steering control module.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11524433May 30, 2023
STEERING
The contact owns a 2011 Mercury Milan. The contact stated that while driving approximately 40 MPH, the power steering failed while accelerating to merge onto the highway. The vehicle veered off the roadway. The contact pulled over to avoid a crash. The contact stated that the steering angle sensor fault message was displayed on the instrument panel. The contact had the vehicle towed to the dealer who stated that the power steering failed. The failure was related to NHTSA Campaign Number: 15V340000 (Steering) however, their VIN was not included. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 212,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11514790March 31, 2023
STEERING
The contact owns a 2011 Mercury Milan. The contact stated that while driving at an undisclosed speed, excessive force was needed to steer the vehicle. The contact stated that the power steering fault warning light was illuminated. The contact stated that the failure recurred, and the steering wheel seized. The vehicle was towed to a local dealer, where it remained awaiting the diagnostic test and repair. The VIN was not included in NHTSA Campaign Number: 15V340000 (Steering). The manufacturer was made aware of the failure and advised to file a complaint with the NHTSA Hotline. The approximate failure mileage was 150,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11508396February 21, 2023
STEERING
Power steering locked on me while driving
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11508134February 20, 2023
STEERING
power steering doesn't work some or all the time. Pulling over and turning the car off is no longer working to reset.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11507900February 17, 2023
STEERING
Loss of power steering and steering assist light comes on. The local dealership diagnosed it needing the power steering gear assembly replaced which they stated was a recall on the vehicle but then stated the codes they entered into Ford rejected the recall approval. Recall # 15N01
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11496916December 11, 2022
STEERING
While driving normally, suddenly my power steering turned off on the highway and SERVICE Advancetrac and SERVICE Power steering came in with no warning or dashboard indicator lights. This caused serious driving issues and I was barely able to get home safely. This issue was addressed in the 2015 15S18 recall but the issue is still there.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11488921October 12, 2022
STEERING
The contact owns a 2011 Mercury Milan. The contact stated that upon the start of the vehicle, the power steering assist failed to operate as needed as the "service power steering" warning message appeared on the instrument panel. The contact stated that her vehicle was placed under NHTSA Campaign Number:15V340000(Steering) and was previously serviced by a dealer. The contact took the vehicle back to the dealer where she was informed that the recall had expired and that they could not offer any more assistance. The manufacturer was also notified of the failure and was given the same information as the dealer. The vehicle had yet to be repaired. The failure mileage was approximately 89,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11466349May 27, 2022
AIR BAGS
RE: Safety Recall Notice 21S12 / NHTSA Recall 21V-158 ISSUE: "In the event of a crash that causes deployment of the driver airbag, the driver airbag inflator in your vehicle may explode." RISK: "If an airbag inflator explodes, sharp metal fragments could strike the driver or other occupants causing serious injury or death." MY COMPLAINT: I received this notice from Ford Motor Co. in APRIL 2021. Today is May 27, 2022, and the manufacturer has failed to remedy this situation or even to contact me with a possible resolution date for this situation. My life and safety as the only driver of this vehicle is seriously at risk every time I am on the road. This is a most egregious situation and I demand immediate repair. CONCLUSION: I need to know exactly what is being done by the NHTSA and the manufacturer to fix this problem immediately. Sincerely, [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11447237January 12, 2022
STEERING
My vehicles electric power assisted steering failed. Luckily my 8o year old wife was not at the wheel at the time! Ford is aware of the EPAS problem but earlier refused to correct the problem before it entered full failure mode! Dash Panel warning was displayed after the steering went into failure mode.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11433795September 21, 2021
STEERING
The contact's girlfriend owns a 2011 Mercury Milan. The contact stated that upon start-up of the vehicle, excessive effort was needed to steer the vehicle without warning; however, the power steering assist would return after a few minutes of driving. Recently, the contact stated that the power steering assist failed with the power steering assist fault warning light illuminated on the instrument panel. The contact had called the manufacturer and was referred to the local dealer for assistance. The contact took the vehicle to the dealer where he was informed that the vehicle was not included in NHTSA Campaign Number: 15V340000 (Steering) and that the warranty on the vehicle for the power steering was expired. The vehicle was not repaired and remained in the possession of the dealer. The failure mileage was approximately 80,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11431348September 1, 2021
SERVICE BRAKES, HYDRAULIC
The contact owns a 2011 Mercury Milan. The contact stated that while his great-nephew was driving at an unknown speed, the brakes failed. The contact stated that the brake warning light was illuminated. The driver pumped on the brake pedal until the vehicle stopped. The contact took the vehicle to the local dealer, where it was diagnosed with needing the brake master cylinder, hydraulic module, and brake filler cap to be replaced. The vehicle was repaired. The manufacturer had been informed of the failure. The failure mileage was 126,077.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11418020May 21, 2021
STEERING
The electric power steering assist is failing. The car is becoming more difficult to steer and makes an intermittent grinding noise when turning the wheels. The problem is most noticeable at low speeds when making turns.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11398261February 28, 2021
STEERING
WHILE DRIVING DOWN THE STREET MY POWER STEERING COMPLETELY GAVE OUT AND IT SAYS A WHOLE BUNCH OF STUFF ON THE DASH. I ALMOST WRECKED THE CAR BECAUSE IT VEERED OFF TO THE RIGHT. LUCKILY I WAS ABLE TO PULL OVER AND TOW THE CAR HOME.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11396784February 18, 2021
STEERING
TL* THE CONTACT OWNS A 2011 MERCURY MILAN. THE CONTACT STATED WHILE DRIVING 20 MPH, THE STEERING WHEEL CEASED AND MADE IT DIFFICULT TO STEER THE VEHICLE. THE CONTACT STATED THAT THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO PRICE FORD OF TURLOCK (5200 N GOLDEN STATE BLVD, TURLOCK, CA 95382) TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE STEERING RACK AND PINON NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED SEVERAL TIMES HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 23,000. THE VIN WAS NOT AVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11323895May 8, 2020
ENGINE, STEERING
WHILE DRIVING THE VEHICLE A WARNING CAME ON STATING POWER ASSIST FAILURE. CAR HAD MANUAL STEERING ONLY. THE FIRST TIME IT HAPPENED IT WENT AWAY WHEN THE CAR WAS RESTARTED. NO SUCH LUCK THIS TIME, WARNING STAYS ON AND NO POWER STEERING. LUCKILY I WAS ON STRAIGHT ROADS BOTH TIMES. I SEE THERE WAS A RECALL ON THIS BUT THE DEALERSHIP SAYS THERE IS NONE??
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11319880March 31, 2020
STEERING
DUE TO THE RECALL OF THE STEERING GEAR WE HAD IT REPAIRED OCT 10 2018. THE VEHICLE HAD 94,430 MILES AND QUALIFIED UNDER THE RECALL. THE CAR HAS BEEN DRIVEN 15,311 MILES AND THE SAME PART NEEDS TO BE REPLACED. WHEN I ASKED IF THE PART HAS A WARRANTY I WAS TOLD 1 YR OR 12,000 MILES,SO THE REPAIR WOULD BE 1800.00. I ASKED IF THE SAME REPAIR WAS DONE WHAT KIND OF WARRANTY WOULD THERE BE. 2 YRS OR 50,000 MILES. MY CONCERN IS WHY THE RECALL PART IS ONLY WARRANTED FOR 12,000 AND THE NEW REPAIR WARRANTY IS 50,000. DID FORD INSTALL AN INFERIOR PART ON MY RECALL? THE VERY DANGEROUS RECALL PART THAT WAS PUT ON MY CAR LASTED BARELY OVER 15,000 MILE. I FIND THIS VERY ALARMING TO THINK THAT LIKE I THERE ARE THOUSANDS OF PEOPLE DRIVING AN UNSAFE CAR PUTTING THEMSELVES AND OTHER ON THE ROADS AT RISK OF INJURY OR DEATH! YOU CANNOT STEER THE CAR WHEN THE PART FAULTS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11289885December 18, 2019
STEERING
AS I WAS DRIVING A LOW TRACTION WARNING LIGHT CAME ON AND THEN THE STEERING BECAME IMPOSSIBLE WHILE PULLING INTO MY DRIVEWAY AND WENT THROUGH OUR GRASS LEAVING RUTS IN IT. APPARENTLY ONCE THE POWER STEERING WENT OUT AND A WARNING SIGN CAME ON IN VEHICLE IT NOW WILL NOT GO OFF AND ITS IMPOSSIBLE TO TURN. THERE IS A RECALL ON CERTAIN VIN CARS OF OUR MAKE, YEAR AND MODEL HOWEVER NOT SPECIFICALLY OURS. IT IS OBVIOUS IT IS DUE TO THE SAME FAULTY POWER STEERING COMPUTER THING.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11281448November 20, 2019
STEERING
GETTING POWER STEERING ASSIST CODE. WAS ABLE TO TURN CAR OFF AND RESTART AND IT WOULD CLEAR THUS ALLOWING THE STEERING WHEEL TO TURN AS EXPECTED. BUT NOW IT WON'T CLEAR. LUCKY I WAS ABLE TO DRIVE CAR FROM 7-ELEVEN TO WORK WHICH WAS NOT TOO FAR FROM MY JOB. WHEN LOOKING UP ISSUE ON LINE I CAME ACROSS RECALL, BUT WHEN I LOOKED UP MY VIN IT SAYS THERE ARE NO RECALL FOR MY VEHICLE!!! THIS IS EXTREMELY DANGEROUS, AND CAN'T UNDERSTAND HOW SO MANY CARS ARE EXPERIENCING THE SAME PROBLEM YET RECALL IS NOT BEING HONORED. AGAIN AT HIGH SPEEDS THIS IS VERY DANGEROUS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Mercury Milan