GMC Sierra Complaints (2025)

179 consumer complaints on file.

#11720880February 27, 2026
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
The contact owns a 2025 GMC Sierra 1500. The contact stated that while the defroster was activated to clear the windshield, the blower vents on the passenger’s side started making an abnormal hissing sound, and air produced by the blower motor decreased and was inadequate to clear the windshield. There was no warning light illuminated. The contact stated that the failure occurred while there was light snow covering the hood and on the outside vents underneath the windshield. The contact had taken the vehicle to a local dealer several times, and the dealer was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 3,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11720526February 25, 2026
ENGINE, ELECTRICAL SYSTEM
The contact owns a 2025 GMC Sierra 1500. The contact stated that while stopped at a traffic light, the gear shifter was shifted to park(P) and the vehicle stalled. The message "START Engine" was displayed. The vehicle was restarted, and the Auto START/STOP feature was disabled by pressing the "A" inside an orange circle. The contact stated that on another occasion while reversing into the driveway, the vehicle stalled. The message "START Engine" was displayed on the screen. The dealer was contacted; however, the vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired and the failure persisted. The manufacturer was not notified of the failure. The failure mileage was approximately 16,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11719889February 23, 2026
ENGINE
2025 GMC Sierra 6.2 L V8 engine failed by locking up or seizing. Heard pinging / knocking sounds while driving 3 miles from my home to the dealer. Engine shut off without warning, vehicle shifted to Neutral. Coasted to a stop, attempted to restart the engine, would only crank. Dealer diagnosis is that the engine will need to be replaced. Sounds just like the 2021 - 2024 GM recall for this same engine. Vehicle has 11,670 miles on it. Safety risk: Loss of ALL power while driving. No Warning lamps or messages prior to engine failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11719572February 21, 2026
ENGINE
was driving truck and reduced acceleration drive with care comes up on dash pull over shut truck off start truck warning gone in 30sec back on and repeat drive off again then truck shut off while driving and try to start again and the dash went black motor did not turn over then tried again and same thing called tow company and had towed to dealership. dealership said it had 2 pages of codes and now needs a new motor........ no estimated time on getting my truck back
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11718850February 18, 2026
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING, FORWARD COLLISION AVOIDANCE: WARNINGS
Car flashes "service driver assist system". Took to dealer and they referenced PIT6455 which states GM is still investigating the issue. Truck was returned to me - very concerning to have truck saying driver assist needs to be serviced and GM is unable to service it!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11718238February 16, 2026
ELECTRICAL SYSTEM
This happens many times, at random intervals, and sometimes it does not happen at all, but I would say about 33% of the time, it happens. When you put the vehicle into reverse, the side mirrors will lower slightly, so that its easy to see the ground, or parking lines, etc. When you then go back to park or forward gear, the mirrors are supposed to go back to the position they were earlier. The original starting point. But that's the problem, many times, they do not go back to the starting position and you must then push the preset buttons to make them go back to your desired view angle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11718159February 15, 2026
POWER TRAIN
The truck keeps wanting to engage two gears acceleration and deceleration and still is happening i have taken it to the dealership an they can not find a problem took it home an its happening again so now its back at the shop now I'm waiting to hear back from them so this is the second time to the dealership
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11717926February 13, 2026
ENGINE, FUEL/PROPULSION SYSTEM, UNKNOWN OR OTHER
Component / System Failure The exhaust system, specifically the exhaust manifolds and previously the EGR system components, appear to have failed or malfunctioned, allowing exhaust gases to enter the passenger cabin. The dealer initially replaced the EGR cooler diverter on December 23, 2025. However, the condition persisted. On February 3, 2026, cracked exhaust manifolds were identified by the dealership, and a major front-end teardown was advised to complete the repair. The vehicle is currently available for inspection upon request. ⸻ How Safety Was Put at Risk The malfunction allowed exhaust gases, including carbon monoxide, to enter the passenger cabin during vehicle operation. Carbon monoxide readings inside the cabin reached up to 50 parts per million (ppm) while driving. Carbon monoxide is a toxic gas that can cause: •Headaches •Dizziness •Impaired concentration •Nausea •Vision disturbances Because carbon monoxide is odorless and colorless, this presents a significant safety risk, particularly at highway speeds where driver alertness is critical. The exposure occurred while operating the vehicle in normal driving conditions. This created a potential risk of driver impairment and increased risk of collision. ⸻ Has the Problem Been Reproduced or Confirmed? Yes. The vehicle was presented to the dealership three times for the same exhaust intrusion concern: •December 16, 2025 •December 29, 2025 •February 3, 2026 During the February 3 visit, the dealership confirmed cracked exhaust manifolds requiring major disassembly for repair. The carbon monoxide readings were observed during vehicle operation. The exhaust odor and intrusion symptoms were consistently present following the first attempted repair. ⸻ Has the Vehicle Been Inspected by Manufacturer or Others? The vehicle has been inspected by the authorized dealership on multiple occasions. Two manufacturer customer care cases were opened.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11717554February 12, 2026
ENGINE
2025 GMC Sierra 1500 has had 2 engine failures since purchase date June 2025. Engine failed on a road trip with my family, leaving me stranded for hours. After the problem being resolved, engine failed once again after 5 months. On the dash it said loss of power and wouldn’t crank to turn ON
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11715737February 5, 2026
POWER TRAIN, ENGINE
I was driving and the engine abruptly stalled. The truck self-shifted to Neutral. Once stopped, I shifted to Park to attempt a restart. It would not crank. I was on a 2-lane road so I did not have a shoulder. Once I realized it would not restart I tried to shift to Neutral so I could push it to a subdivision road about 50 yards away only to find out my transmission has no ability to shift to Neutral (the dealer confirmed this later). So I was stuck on the road for hours just over the crest of a hill with people coming up on me and my family at 50mph. It was a windy 10 degrees so we could not wait on the side of the road where we would have been safer. This is how people get killed; being stopped where people can't see you and do not expect you to be stopped. Why can I not get the truck off the road? If this happened on an 8-lane highway how would I get to a shoulder, even after traffic had stopped behind me? On top of all that, the problem with the truck ended up being an engine bearing failure (per the dealership service dept) that is a known problem with this engine and truck build date. General Motors needs to proactively diagnose and get these engines replaced before someone gets hurt. There is a TSB issued for the bearing issue but when I asked my dealer about it a month ago, before the failure, they acted like they knew nothing about it and told me to bring it in if I hear noises. If they had offered to check the crankshaft endplay when I asked about it ( as the TSB suggests), I may not have gotten stranded and my family's safety put at risk. There were no warning lamps, and no strange noises before the engine seized. My fuel economy had decreased by about 20% in the last month but that may be from cold weather operating conditions. I have a separate electrical issue that I've been chasing down and I assumed this stall condition was related to that. But the dealer confirmed this was a bearing failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11714433January 30, 2026
SERVICE BRAKES
The truck automatically engages the parking brake ONLY when on an incline, never at any other time. I am so used to engaging the parking brake at all other times I also engage it when on an incline. The problem is the truck DISENGAGES the brake automatically after I've engaged it. This has happened multiple times when I've been towing a large boat on a launch ramp or towing my heavy 5th wheel. I can be fully exited from the truck and 10 ft away when it disengages and I watch it lurch forward. Simple answer would be for me to not engage the brake on an incline, but its a total habit all the time so I never remember to not engage it on an incline. This is a dangerous feature that needs to be removed ASAP. Thank you
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11714116January 29, 2026
ENGINE
Burning an unusual amount of oil. Have seen several instances of blue smoke in the exhaust. Have had to add over a quart of oil twice in less than 6500 miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11713989January 28, 2026
ELECTRICAL SYSTEM, STEERING
Heated steering wheel reaches temps of 137 - 143 degrees. Should have the ability for the owner to select a lower temperature setting the same as the heated seats.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11714073January 28, 2026
ELECTRICAL SYSTEM, ENGINE, FUEL/PROPULSION SYSTEM
Vehicle electrical propulsion system became inoperable creating a hazard to occupants in a temperature control required climate Vehicles visual control showing speed and all other information went completely black while vehicle was in motion.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11711937January 19, 2026
ENGINE
I have the 6.2 L87 with the 10 speed transmission in my 2025 Sierra. At cold start, when auto stop restarts the truck, when the truck downshifts under 20 mph down to 12 mph the engine or transmission makes a chirping/squeak/squeal sounds. Several repair attempts have been made, parts replaced. According to GM and their “field engineer” this is a “normal characteristic of the dfm system”. They claim that it has to do with ignition timing. Not my first dfm truck, but it is the first to make this noise. There is not very many components in “the dfm system” that can make a metal on metal squeak/chirp/squeal sound other than lifters/pushrods, but the noise could be coming from the transmission/bell housing area. I am fairly certain this is an early warning sign of engine or transmission failure. Truck currently has 7,800 miles. If this was an actual “normal behavior” for this engine, all of them would make the same noise. But out of 7 other trucks with the same engine and transmission that i have started/drove, none of them made the noise. It has made this noise since i purchased it brand new. A Gm field engineer “looked” at the truck 3 weeks ago, and I still have not received any paperwork on what they actually did when diagnosing it. Not a single document from the dealership or GM, regarding the 4 days that my truck was at the dealership on the 4th repair attempt. Gm technical service bulletin I was referred to by the dealership is 22-NA-218 Will update this complaint when failure occurs.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11711646January 17, 2026
POWER TRAIN, ENGINE
I bought my truck new in June 2025. On the night of December 29, 2025, with around 9,300 miles on the odometer, I began to hear a knocking sound coming from the engine while I was driving it back to my house from my mother's house. The sound got progressively louder and louder. The truck eventually displayed a "reduced acceleration drive with care" warning. I thought catastrophic engine failure was imminent and did not believe I could make it home. I called my in-laws (they were closer to my location than my house), agreed to park it there overnight, and thankfully made it to their house. The next day the truck was towed to the GMC dealership. A week later, GMC diagnosed this issue as a thrust bearing/crankshaft issue and agreed to replace the entire engine. A crankshaft issue in a new diesel engine should not occur, yet it did. My vehicle is currently being repaired, so the dealership said they had no repair records to provide me. This is the link to the video of the sound it was making after I made it to the in-laws: [XXX] I had just dropped off my [XXX] child with my mother about twenty minutes earlier. I was extremely close to being stranded on the side of the highway at night in the December cold with a [XXX] baby. Thankfully, that did not happen, but it was a close call. My cousin also has had a similar issue with the exact same make and model of his truck. I believe this engine is not being manufactured according to the design specifications and it is a danger to the public until the manufacturing issue with the supplier is adequately corrected. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11711411January 16, 2026
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, VEHICLE SPEED CONTROL
Cruise control activates at speeds below 2 mph which frequently happens while turning or parking. The cruise control activates by a toggle on the left spoke of the steering wheel which can be easily bumped while doing low speed maneuvers like parking. When bumping the toggle the cruise indicator shows a set speed of 15mph and the vehicle surges forward trying to attain that speed. Since this occurs while maneuvering to park, it creates a dangerous situation if anyone is nearby and you are unable to react in time. This is an ongoing problem that can be duplicated at will.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11711558January 16, 2026
ENGINE
Driving at highway speed engine lost most power (limp mode), was able to get to an exit at low speed with flashers on but was creating a hazard on busy interstate. Dealer diagnosed truck needs new 3.0 liter duramax engine per GM TSB 25-NA-307, bad thrust bearing.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11710304January 12, 2026
ENGINE
With approximately 5,200 miles on my new vehicle, received an error message on the dash while driving on 1/8/2026 that read “Reduced acceleration; Drive with care”. I immediately took the vehicle to a local GM dealership and was informed on 1/9/2026 that due to a faulty thrust bearing (covered under the non-mandatory technical service bulletin 25-NA-307), the entire engine sustained a catastrophic failure and that the engine “tanked itself” and “grenaded itself”. Driving with the reduced acceleration mode active is beyond frightening as it’s very difficult to navigate traffic intersections in time to avoid oncoming traffic. It was also noted that it other cases where this faulty part causes the engine to totally fail, the vehicle becomes unusable at that point. I was informed that a replacement motor is not expected from General Motors for at least 2-3 months as this is becoming a more prevalent issue with certain 2025 Sierra’s with the 3.0 Duramax diesel motor.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11710058January 10, 2026
SUSPENSION, UNKNOWN OR OTHER
Had a minor wreck was to be two weeks to then it had to have a new frame they said it coun't be repair if a minor wreck can do this much damage there is a problem with subpar frames that any sudden stops or turns
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0

← Back to GMC Sierra