GMC Sierra Complaints (2023)

567 consumer complaints on file.

#11651634March 30, 2025
ENGINE, POWER TRAIN
While driving my truck shut off and went into neutral. Truck restarted after cranking for a long time. Did the same thing within a mile and then started making knocking noises, turned off and would not restart. Completely dead on the road. Truck was towed to nearest dealership.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11651503March 29, 2025
ENGINE
The motor quit while traveling on the highway. There were no warning signs. No noises, lights, smoke, smell, etc. It just quit. I was able to steer closer to the side of the road while it coasted to a stop, but it was difficult. After the vehicle coasted to a stop and it would not restart. The electronics appeared to work (radio, signals, lights) but found that they would not turn off. It has been confirmed that the engine has completely failed by the dealer. No traffic was affected, but it could have been.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11651535March 29, 2025
ENGINE
While driving home from work, my engine, with only 20k miles on it, started to make noise. I immediately got off the highway at the next exit and as soon as I came to a stop the engine noise got even louder and the vehicle shut off. Was able to barely get it started but managed to get it off the road before it died again. Had it towed to my GMC dealership and have been advised that the engine is done and needs to be replaced. Seems to be a very common occurrence on GM vehicles with the 6.2 engine. Won’t have the truck back for minimum 6 weeks but still have to continue to make my $1000 payment for a truck with no working motor due to factory issues.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11651018March 27, 2025
WHEELS, UNKNOWN OR OTHER, POWER TRAIN
I was driving at approximately 25-30 MPH, accelerating from a stop light and I felt a clunk, heard a grinding noise and my back wheels locked up. It was snowy/icy conditions so the back end of my pick-up slid out to the right a little bit before the wheels unlocked and I was able to regain control. I could have slid off the road or into another vehicle had the wheels remained locked. The computer system then alerted me to a transmission issue and to reduce speed immediately and call for service. The pickup was then unable to shift out of 1st gear. The vehicle has been towed to a dealer and I have been informed the valve body in the transmission has to be replaced which is 8-12 weeks backorder.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11650910March 26, 2025
ENGINE
I was driving my truck on I-65 around 75mph and the engine just shut down. I had to maneuver the vehicle out of traffic onto the side of the interstate. It would not restart. I had it towed to my dealership and they told I experienced total engine failure. It was caused by internal bearing failure
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11650662March 26, 2025
ENGINE
GM 6.2L Engine shifted itself into neutral and shut down while my wife was alone driving 65mph on [XXX] in Tucson Arizona. No error messages or check engine signal, Vehicle Information Center advised pull over and push Start Button. Vehicle would not initially restart but did start within 5 minutes and my wife was able to limp along the 1/4 mile to the next off ramp to get off the highway. Local GMC Dealer confirmed the seized motor and immediately ordered a new GM motor. Vehicle is 18 mo's old with 26,500 miles and is sitting at the dealer. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11649954March 23, 2025
STEERING
What component or system failed or malfunctioned, and is it available for inspection upon request? Rubbing noise when turning the steering wheel. Truck has 8800 miles on it. How was your safety or the safety of others put at risk? Wasn’t able to fix on day diagnosed need to order parts. Only vehicle I have. When asked if I can continue to drive I was told if a problem arises to stop?!? Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. They confirm there is a steering gear issue. Parts in order. Was told it’s a big deal and will need it for several days to fix. 8800 miles on truck! Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others?no Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No warning lamps. Noticed it when turning into my garage at lower speeds.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11649679March 21, 2025
ENGINE
While driving on highway, during rush hour at [XXX], in the center lane of the highway the engine turned itself off and stopped running. Was traveling with traffic, approximately 70-75 mph, engine turned off the truck started deaccelerating rapidly. Was able to change to the right lane and pull over on to the side of the highway. Truck rolled roughly 100 yards and then stopped. The dashboard lights were on and gave the appearance the truck was running, but it was not. Could not restart the vehicle. Tow track came and had to drag the truck up to the truck bed and then shack it off - when taken to the dealership. Truck could NOT be put in neutral. Truck is current at the dealership. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11649440March 20, 2025
ENGINE, POWER TRAIN
I had my 6.2 engine replaced at 26,000 miles and the transmission rebuilt. The engine was contaminated with metal shavings and the transmission rebuilt for internal defects. The new engine is running fine but the reliability is a concern after reading about other customers having the same problems. My name is [XXX] . The engine replacement and transmission repair was done at Ed Martin GMC in Carmel Indiana. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11649567March 20, 2025
ENGINE
Was driving down the interstate at 70mph with cruise control on. The vehicle lunged forward and soon after a reduce power message appeared in the messages. I was able to avoid any incident with other vehicles and exited the highway with the motor was making loud noises. I parked the vehicle and called for roadside assistance. The vehicle had to be towed to the dealer, and I found out that the 6.2 liter V8 motor has metal in the oil and the entire engine needed to be replaced. The thrust bearing failed and required a full engine replacement. The vehicle has approximately 21,000 on it and is still under warranty, but it is a 3-6 month wait to get a replacement engine. I have searched the internet and found that there are many vehicles that are having similar issues with the 6.2 L V8 GM motor. It has been slightly over a month since the incident and have not received any updates.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11649584March 20, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2023 GMC Sierra 1500. The contact stated that while driving 70 MPH, the vehicle lost motive power. The check engine warning light illuminated after the failure had occurred. The vehicle was towed to the dealer, who determined that the engine had seized and needed to be replaced. The vehicle was not repaired. The contact related to the failure to NHTSA Action Number: PE25001 (Engine and Engine Cooling). The manufacturer was not made aware of the failure. The failure mileage was approximately 23,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11649194March 19, 2025
ELECTRICAL SYSTEM
The truck check engine lights came on, and I took it to a dealer. I was told the ECM was faulty, they replaced it, but it didn't fix the issue. I was then told the ONSTAR telematics unit was faulty. The truck has been down for 45 days, with no ETA on parts(several forms say 4-6 months). There is no guarantee that this will fix the CEL. The truck is inoperable at this time.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11649000March 18, 2025
POWER TRAIN, ELECTRICAL SYSTEM
While entering the highway from a downward slop exit ramp and towing a trailer, my truck shuddered hard and briefly locked up the rear axle. It immediately went into limp mode with a message that driving speed will be reduced. It also wouldn't shift past 5th gear. When the event took place, the OBD2 generated over 20 trouble codes. My local dealer advised I could drive it to them for repair. Upon dropping it off, they now advise it's NOT safe for driving and they have no eta on the parts to repair the issue. It's now been at the dealer for a week with no update. This is a well known issue that GM refuses to repair or provide a reasonable timeframe for repair. There are countless videos such as this one that show what happens when this takes place. [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11648711March 17, 2025
ENGINE, POWER TRAIN
With out any warning the truck stop running at stoplight an would not start back up. We could not move the truck out of the road and blocked traffic for almost 1 hour waiting for the tow truck and getting it loaded on the tow truck (truck would not go in to neutral). The truck is now at the Dealer and they are saying that the engine seized up and will need replaced.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11648325March 14, 2025
POWER TRAIN
2023 GMC Sierra 2500 AT4 with approximately 36,000 miles as of current. The vehicle has experienced three valve body failures to date. GMC dealerships have completed one GM remanufactured transmission replacement and an overhaul of the second transmission. The third valve body has now failed. A GMC transmission specialist confirmed transmission failure upon recent test drive on 2/24/2025. GMC dealership refuses to perform warranty repair as they are stating “a recall is being developed” therefore will not repair/replace current defective powertrain parts. I was given the vehicle back with the verbal disclaimer “it should be safe to drive but the rear wheels can lock up at highway speed so be aware.” The failure causes extreme harsh downshifting and what feels like a momentary rear wheel lock up. I have experienced this numerous times at lower speeds (<40mph). The check engine light does not come on.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11648347March 14, 2025
ENGINE
On Saturday March 1st I was driving East on I-10 in Florida when my trucks engine lost power. I managed to get over onto the shoulder of the road and got out of the flow of traffic. Very scared I was going to get hit before I could get off the interstate. Motor was making a terrible noise like the lifters let go. I was beside the interstate for about 3 hours trying to find a tow truck to come get me and the truck off the side of the interstate. I had the truck towed for about 60 mile to get it back home to the dealership. The truck has 26,000 miles on it and the dealership told me the motor was no good and that there is metal pieces in the oil pan. 2 weeks have past by and they can't tell me when they will receive a replacement motor. What am I supposed to do? $80,000 truck 2 years old and the motor is no good. Thanks
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11647809March 12, 2025
ENGINE
I own a 2023 GMC Sierra 1500 Denali Ultimate. The truck had about 19k miles on it when the engine seized while driving on the highway late at night in January. This was extremely dangerous as I was going 55mph over a bridge and lost the engine. I was stranded on an exit ramp unable to move. It was cold that week so it was 5 degrees. Onstar informed me that since the truck could not be shifted into Neutral that it would need dollies and a flat bed. They said they could get to me at 8am which was 9 hours from when the truck broke down. It was 5 degrees out and I had no heat sitting on the highway. I ended up calling a local tow company and they were able to get to me but I had to wait 3 hours. The truck was towed to the deal and they confirmed that the engine seized (it is a known problem) and it needs a new motor. They said there is a big back log of engines because many have this issue. I still have not provided a timeline for the truck to be repaired.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11648007March 12, 2025
STRUCTURE:BODY, ELECTRICAL SYSTEM
Tailgate opened/unlocked while parked during rain and light snow. The tonneau cover disguised that the tailgate was open (held it up just enough so it was not visable). The tailgate fell open while driving but went unnoticed. Several large and expensive items were lost out of the back of the truck which is used as a work truck for electrical services. This has happened twice on the roads. Now the tailgate is physically checked before driving to ensure it will not fall open. The incident was mentioned to the local GM dealer but we were told our model was not part of the recall. Our next call will be to GM directly to try to remedy the problem and hopefully recoup the items lost.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11647354March 10, 2025
ENGINE
During travel of the highway, the motor suddenly lost power and shut down with no warning lights or symptoms prior. Although I was able to get to the side of the road, the electronic shifter does NOT allow the vehicle to be put into Neutral. This is a known GM issue. This morning the dealer confirmed the engine needs replacement.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11647094March 8, 2025
ENGINE
I left my house & was driving my truck down the highway for about 2.5 miles. All of a sudden the engine locked up & the battery went dead. I barely coasted off the opposite side of the road where the closest side road is & a semi pasted shortly after. I felt very lucky my truck made it off on the side road instead being run over by the semi truck. I then had to call a weaker & have it towed to the local dealership that services GMC trucks. After 4 days I finally got the worst news, the truck needs a new 6.2 engine. My 2023 GMC Sierra AT4 with 38k miles had an engine that locked up & I was flabbergasted. I started searching this issue on the internet & couldn’t believe how common this is & nothing has been done about this. I would assume a recall from GM would be appropriate considering the sheer number of 6.2 liters engines having issues over & over. This is absolutely unacceptable. I could have been seriously injured or even worse killed by the negligence of GM on this issue. I get it, GM made a mistake with this 6.2 engine and it’s going to cost a lot of money but my research tells me this appears to have been happening for a few years. As I sit here today my truck is sitting in a dealer lot with a busted engine & a new one is on backorder. I am currently driving a dealer “loaner” Chevy trailerblazer. It could be weeks or months before I finally get word on another 6.2 engine replacement from GM. I own a small farm and do not have a truck to haul hay or feed for horses. Can the National highway administration please help me? I thought I was buying a dependable 2023 GMC sierra 1500 AT4 & instead bought a lemon. Apparently hundreds of thousands of other 6.2 liter engines like mine are a HUGE safety hazard & should be recalled. This seems like an open & shut case & after reading into the matter I can’t believe Gov. organizations like the National Highway safety administration has not did more and let GMs 6.2 liter engine contine on. What’s left to investigate?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to GMC Sierra