GMC Sierra Complaints (2005)

448 consumer complaints on file.

#10481278October 20, 2012
ELECTRICAL SYSTEM
INSTRUMENT CLUSTER FAILURE, TACHOMETER, AND SPEEDOMETER ARE INOPERABLE, BUT ALL OTHER GAUGES, SUCH AS FUEL LEVEL, BATTERY METER, OIL PRESSURE, COOLANT TEMPERATURE, AND TRANSMISSION TEMPERATURE GAS ARE STILL FUNCTIONING. OWN ANOTHER 2005 1500 WITH 32,632 WHICH HAS JUST STARTED DOING THE SAME. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10480666October 16, 2012
STEERING
TL* THE CONTACT OWNS A 2005 GMC SIERRA 2500-HD. THE CONTACT STATED DURING A ROUTINE MAINTENANCE APPOINTMENT THE MECHANIC STATED THE POWER STEERING HOSE WAS LEAKING WHICH CAUSED HIM TO LOOSE POWER STEERING AND POWER BRAKING ABILITY. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT NHTSA RECALL CAMPAIGN ID NUMBER: 05V455000: STEERING: HYDRAULIC POWER ASSISTS: HOSE, PIPING, AND CONNECTIONS WAS RELATED TO THE FAILURE; HOWEVER, HIS VIN WAS NOT INCLUDED AND HE WOULD HAVE TO PAY FOR THE REPAIRS. THE MANUFACTURER WAS NOTIFIED BUT STATED THERE WAS A RECALL BUT HIS VIN WAS NOT INCLUDED; THEREFORE, IT WOULD BE AT HIS EXPENSE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 116,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10479707October 10, 2012
SERVICE BRAKES
BRAKE LINES ROTTED ON WAY TO GARAGE . *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10479265October 8, 2012
SEATS
DRIVER SEAT HEATER TURNS ON BY ITSELF CREATING AN EXTREMELY UNSAFE DRIVING CONDITION IN THE SUMMERTIME IN HIGH DENSITY TRAFFIC WITH SUN GLARE A PROBLEM AND AN INABILITY TO EFFECTIVELY TURN THE SEAT HEATER OFF. THIS PROBLEM HAS BEEN REVIEWED BOTH BY THE LOCAL CHEVROLET AND GMC DEALERS WITH THE ULTIMATE CORRECTIVE ACTION BEING TO DISCONNECT THE SEAT HEATING ELEMENTS. WHILE THIS ADDRESSES SAFETY FOR ME IT FALLS SHORT OF PROVIDING ME WITH A FUNCTIONING SEAT HEATER AS PURCHASED. ALSO THE CORRECTIVE ACTION DOES NOT GIVE CONSIDERATION TO A POTENTIALLY GENERAL EXISTING PROBLEM---WHICH IS THE MORE IMPORTANT REASON THAT I MAKE THIS REPORT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10478377October 2, 2012
SERVICE BRAKES
DRIVING THROUGH AN INTERSECTION AT 40 WHEN A ANOTHER VEHICLE MADE A LEFT TURN IN FRONT OF ME . I APPLIED MY BRAKES AND PEDAL WENT TO THE FLOOR . I SWERVED AND AVOIDED THE ON COMING VEHICLE . THE REAR HARD STEEL BRAKE LINE ABOVE THE FUEL TANK BURST DUE TO CORROSION . NO WARNING NO FLUID OR BRAKE LIGHT JUST A CATASTROPHE FAILURE OF LINE. UPON INSPECTION LINE IS NOT CORRODED ON THE FRAME RAIL BEFORE THE FUEL TANK JUST BEHIND THE TANK. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10476785September 24, 2012
SERVICE BRAKES
DEPRESSED BRAKE PEDAL TO STOP TRUCK AND PEDAL WENT STRAIGHT TO THE FLOOR. FRONT BRAKE LINES HAD RUPTURED DUE TO CORROSION. THIS TRUCK IS MY MAIN TOW VEHICLE AND I HAD A SMALL TRAILER ON WHEN THIS OCCURRED. MY TRUCK HAS NOT SEEN MUCH WINTER USE SINCE NEW AND I AM THE OWNER SINCE NEW. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10476589September 20, 2012
SERVICE BRAKES
TL* THE CONTACT OWNS A 2005 GMC SIERRA 1500 HD. THE CONTACT STATED THAT WHILE THE VEHICLE WAS BEING INSPECTED BY A PRIVATE MECHANIC IT WAS FOUND THAT THE BRAKE LINES WERE RUSTED. THE VEHICLE WAS ABLE TO BE DRIVEN TO AN AUTHORIZED DEALER WHERE IT WAS CONFIRMED THAT THE BRAKE LINES HAD FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE 66,533.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10474482September 10, 2012
SERVICE BRAKES
WHILE DRIVING DOWN A COUNTRY ROAD IN MY PICKUP TRUCK MY BRAKE LINES FAILED IN 2 SPOTS DUE TO RUST AND CORROSION. I WAS PULLING A TRAILER ALSO. VERY VERY DANGEROUS. LUCKY TO HAVE ACTED SO FAST IN USING THE EMERGENCY BRAKE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10473726September 4, 2012
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS, ENGINE AND ENGINE COOLING:ENGINE:DIESEL
TL* THE CONTACT OWNS A 2005 GMC SIERRA 3500. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE BRAKES WERE ENGAGED AND THE VEHICLE FAILED TO STOP. THE CONTACT MENTIONED THAT HE HAD TO ENGAGE THE EMERGENCY BRAKE IN ORDER FOR THE VEHICLE TO STOP. ALSO, THE CONTACT STATED THAT AFTER INSPECTING THE VEHICLE HE NOTICED OIL LEAKING. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE BRAKE LINES NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE FAILURE AND CURRENT MILEAGE WAS 42,000. UPDATED 10/24/12 *CN UPDATED 11/08/12
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10473252September 1, 2012
SERVICE BRAKES
AS I WAS LEAVING HOME MY HOME AND APPROACHING STOP SIGN, MY BRAKES GAVE OUT. I LOCATED AN AREA NEAR THE REAR LEFT AXLE WHERE THE BRAKE LINE WAS CORRODED AND BURST. INSPECTION OF THE BRAKE LINES SHOWS EXTENSIVE CORROSION ALONG THE ENTIRE LINES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10471545August 20, 2012
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS, SERVICE BRAKES
THE 2005 GMC 2500HD FWD (WELL MAINTAINED AND OILED TO PREVENT CORROSION) EXPERIENCED A FAILURE WHILE TOWING MY 24' PURSUIT FISHING BOAT (7200 LBS.) HOME FROM STURGEON POINT MARINA TO HAMBURG, NY 14075 (APPROXIMATELY 10 MILES) WITH "MINIMAL" STOPPING CAPABILITY AS THE DOT 3 BRAKE FLUID WAS BEING EXPELLED. I HAD TO FEATURE THE THROTTLE TO NEGOTIATE STOPPING SENARIOS WITHOUT ISSUE. AS OF 8/20/12, THIS VEHICLE IS WITH FUCCILLO CHEVROLET, INC. (GRAND ISLAND, NY) FOR OVERHAUL OF ENTIRE BRAKING SYSTEM; INCLUDING FUEL LINES. THE CERTIFIED TECHNICIAN SUGGESTED THE ENTIRE BRAKE LINES SYSTEM BE REPLACED ALONG WITH THE FUEL LINES DUE TO EXTREME CORROSION. ALL THIS WORK IS BEING PERFORMED SINCE THE EXCELLENT CONDITION OF THE VEHICLE.THE ESTIMATE FOR THIS WORK IS APPROXIMATELY $2250 TO REPLACE ALL LINES (BRAKE / GAS) AFFECTED BY SEVERE CORROSION. THIS CONDITION IS A RESULT OF POOR MATERIAL SELECTION NOT CAPABLE OF WITHSTANDING NORMAL WINTER CONDITIONS FOUND IN THE NORTHEAST. THE SAME STANDARDS SHOULD BE USED AS SELECTING EXHAUST SYSTEM MATERIAL. BRAKES CAN KILL YOU....EXHAUST SYSTEMS CAN NOT! FINAL NOTE: TRUCK DRIVEN 50 MILES PER WEEK TO WORK (10 MILES EACH DAY). DURING WINTER MONTHS, THE RESIDUAL SALT IS RINSED AS REQUIRED ON A WEEKLY BASIS (OR SOONER) TO PREVENT CORROSION. THIS TRUCK PRIOR TO WINTER DRIVING HAS HAD OIL APPLIED TO THE UNDERFRAME, APPARENTLY, THE BRAKE / FUEL LINE WHERE NOT ADEQUATELY TREATED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10471639August 20, 2012
ELECTRICAL SYSTEM
I BOUGHT MY GMC USED IN 2008 AND I HAD NO PROBLEMS UNTIL A JUNE OF 2012 WHEN MY SPEEDOMETER STARTED TO GET MY SPEED TOTALLY WRONG. AT TIMES IT WOULD SAY I WAS DRIVING OVER 120 MPH OR WHEN IN IDLE IT WOULD EVEN SAY THE SAME THING. THE SPEEDOMETER PICKS A DIFFERENT SPEED DAILY. JUST A FEW WEEKS AGO IN JULY OF 2012 MY GAS GAUGE WENT COMPLETELY OUT SO I HAVE NO IDEA HOW MUCH GAS IT LEFT IN MY TRUCK. I HAVE TO GUESS BY MILEAGE NOW IN HOPES THAT MY ELECTRICAL DOESN'T GO COMPLETELY OUT NOW. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10469546August 7, 2012
SERVICE BRAKES
VEHICLE WAS DRIVEN ON A DRIVEWAY AND THE BRAKE PEDAL LOST COMPLETE RESISTANCE AND WENT FLAT TO THE FLOOR. TOTAL BRAKE FAILURE OCCURRED WITHOUT ANY WARNING INDICATORS. INSPECTION OF THE METAL BRAKE LINES POSITIONED NEAR THE LEFT FRONT WHEEL REVEALED THAT ALL FOUR LINES SHOWED SEVERE SIGNS OF CORROSION AND ONE OF THE LINES HAD PRODUCED A HOLE THEREFORE LEAKING BRAKE FLUID. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10469452August 6, 2012
ENGINE
I FOUND 2 BROKEN EXHAUST MANIFOLD BOLTS ON MY 2005 SIERRA (70, 717 MILES), 1 ON EACH SIDE, 1 WAS ACTUALLY MISSING & THE OTHER WAS JUST HANGING THERE, I THEN WENT TO CHECK MY WIFE'S VEHICLE, A 2003 CHEVY TAHOE ( 90,420 MILES) & THAT ALSO HAS 2 MISSING , 1 FROM EITHER SIDE, YOU CANT IMAGINE HOW SICK I AM AT THIS POINT, BOTH OUR VEHICLES ARE IN NEED OF MAJOR REPAIRS, PLEASE TELL ME THAT GENERAL MOTORS WILL NEED TO RECALL THESE VEHICLES & MAKE THE NEEDED REPAIRS, SICK TO MY STOMACH & CASH STRAPPED, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10468287July 30, 2012
ENGINE
EXHAUST IN PASSENGER COMPARTMENT. SERVICE MAN INFORMED ME OF BROKEN BOLTS AND THAT I MUST REPLACE BOTH MANIFOLDS BEFORE NEXT INSPECTION. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10466852July 21, 2012
SERVICE BRAKES
BRAKE PEDAL WENT TO THE FLOOR. INSPECTION DISCOVERED THAT ALL THE VEHICLE BRAKE LINES WERE RUSTED, SOME TO THE POINT OF LEAKING BRAKE FLUID. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10465943July 17, 2012
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2005 GMC SIERRA 2500 HD. THE CONTACT STATED THAT THE SPEEDOMETER WOULD NOT PROVIDE ACCURATE SPEED RATES. THE SPEEDOMETER WOULD READ THAT THE CONTACT WAS TRAVELING 120 MPH WHEN THE CONTACT WAS ACTUALLY TRAVELING 60 MPH. THE CONTACT HAD NOT TAKEN THE VEHICLE TO THE DEALER FOR INSPECTION OR REPAIRS. THE CURRENT MILEAGE WAS 102,000 AND THE FAILURE MILEAGE WAS UNKNOWN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10463450June 28, 2012
AIR BAGS
TL* THE CONTACT OWNS A 2005 GMC SIERRA 1500. WHILE DRIVING APPROXIMATELY 45 MPH THE AIR BAG WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTICS. THE MECHANIC STATED THE AIR BAG SENSOR WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 51,800. ... UPDATED 08-07-12 *BF THE CONSUMER STATED HIS VEHICLE WAS REPAIRED. UPDATED 08/09/12
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10462558June 21, 2012
SERVICE BRAKES
WHILE APPLYING THE BRAKE TO SHIFT INTO DRIVE, THE BRAKE PEDAL "WENT TO THE FLOOR". PUMPED BRAES ONCE AND STILL NO PRESSURE. WAS ABLE TO HEAR THE LEAK UNDER THE DRIVER SIDE AND BRAKE FLUID WAS OBVIOUS UNDER THE TRUCK. INVESTIGATION REVEALED THE ONE OF THE LINES RUSTED THROUGH AT THE PLASTIC CLIP TO SECURE IT TO THE FRAME NEAR THE DRIVERS SIDE FLOOR BOARD. *TT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10460887June 7, 2012
SERVICE BRAKES
THE PROBLEM IS A TOTALLY RUSTED-OUT SET OF STEEL BRAKE LINES THROUGHOUT THE GMC TRUCK. THE BURST BRAKE LINE IS IN THE ENGINE COMPARTMENT. IT IS THE LINE THAT RUNS FROM THE ANTILOCK BRAKE DISTRIBUTION POINT (ATTACHED TO THE FRAME BENEATH THE DRIVER SEAT). IT RUNS ALONG THE FRAME, ABOVE THE FRAME RAIL AND PAST THE STEERING BOX, AND THEN MAKES A RIGHT TURN BENEATH THE RADIATOR TO THE PASSENGER SIDE OF THE TRUCK, WHERE IT EXITS INTO THE WHEEL WELL AND CONNECTS TO THE FLEXIBLE BRAKE HOSE ON THE PASSENGER SIDE. THE STEEL LINE BURST IN THE AREA ADJACENT TO THE STEERING BOX, SO THAT IT SPRAYS BRAKE FLUID ALL OVER THE STEERING BOX WHENEVER THE BRAKE PEDAL IS DEPRESSED. THIS QUICKLY EMPTIED THE RESERVOIR ON THE MASTER CYLINDER LEAVING ALMOST NO BRAKES AT ALL. THERE IS VERY MINIMAL BRAKING AVAILABLE WITH THE PEDAL FULLY DEPRESSED THE FLOOR. I INITIALLY EXAMINED THE SYSTEM TO SEE IF THERE IS ANY CHANCE OF A DO-IT-YOURSELF REPAIR BUT QUICKLY ABANDONED THAT IDEA. ALL OF THE BRAKE LINES ARE BADLY CORRODED AND COVERED WITH SCALE, SO THERE IS NO CHANCE OF CUTTING OUT THE BAD SEGMENT, DOUBLE FLARING THE ENDS, AND SPLICING-IN A SHORT SEGMENT TO REPLACE THE RUSTED-OUT PORTION OF THE BRAKE LINE. ALL OF THE BRAKE LINES THROUGHOUT THE TRUCK ARE BADLY RUSTED AND LIKELY WILL FAIL AGAIN IF LEFT IN PLACE (ACCORDING TO THE GMC SERVICE MANAGER). THE BRAKE LINE THAT FAILED BURST IN A PART OF THE ENGINE COMPARTMENT THAT WOULD SEEM TO NOT EVEN BE EXPOSED TO ROAD SALT, SINCE IT IS INSIDE THE ENGINE COMPARTMENT AND RELATIVELY SHIELDED FROM SALT SPRAY AND ROAD GRIME BY THE BODY, WHEEL WELL AND FRAME RAIL. THE DEALER SERVICE MANAGER IN MURPHY, NC ESTIMATES THAT IT WILL TAKE ONE OF HIS MECHANICS ALMOST A FULL DAY TO REMOVE ALL OF THE BAD BRAKE LINES AND FABRICATE REPLACEMENTS (THESE LINES ARE NOT AVAILABLE IN PREFABRICATED FORM FROM GMC. *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to GMC Sierra