Ford Transit Service Bulletins (2021)
134 manufacturer communications on file.
- December 1, 2022•Document ID: 10228846Service Bulletin/Repair InstructionsCOMMUNICATION:MANUFACTURER TELEMATICS
- Mfr Comm. #:
- SSM 51228
- Date Added:
- January 5, 2023
- Manufacturer:
- FORD
SummarySome 2020-2023 Ford and Lincoln vehicles equipped with a telematic control unit (TCU) may exhibit inoperative remote features via Ford Pass/Lincoln Way mobile app, incomplete user authorization, and/or modem electronic serial number (ESN) could not be displayed in the center display screen. To correct this condition prior to programming, remove the TCU fuse for 5-minutes then reinstall. Delete all previous session files for the vehicle. Start a new Ford Diagnosis and Repair System (FDRS) session. Perform a TCU provisioning and Program the TCU to the latest FDRS version level. If the concern is still present, follow normal diagnostics in Workshop Manual (WSM), Section 415-00. Refer to PTS OASIS home page for TCU version identification. For claiming, use causal part 14G229 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (22)2023 Lincoln Aviator2022 Ford Bronco Sport2022 Ford Escape2022 Ford Explorer2022 Ford Maverick2022 Ford Mustang2022 Ford Ranger2022 Ford Transit2022 Ford Transit Connect2022 Lincoln Aviator2022 Lincoln Corsair2021 Ford Bronco Sport2021 Ford Escape2021 Ford Expedition2021 Ford Explorer2021 Ford Mustang2021 Ford Ranger2021 Ford Transit2021 Ford Transit Connect2021 Lincoln Aviator+ 2 moreAssociated Documents - November 21, 2022•Document ID: 10226939Service Bulletin/Repair InstructionsPOWER TRAIN:DRIVELINE:DRIVESHAFT; UNKNOWN OR OTHER; POWER TRAIN
- Mfr Comm. #:
- TSB 22-2444
- Date Added:
- December 2, 2022
- Manufacturer:
- FORD
SummaryThis article supersedes TSB 22-2271 to update the vehicle model years affected. Some 2015-2023 Transit vehicles equipped with rear wheel drive (RWD), single rear wheel (only), and U-joints at the transmission flange and rear driveshaft may experience a boom/hum/moan noise from the rear while driving. This noise is most noticeable at highway speeds: 112-121 km/h (70-75 mph) for 4.10 axle ratio 121-128 km/h (75-80 mph) for 3.73 axle ratio 136-145 km/h (85-90 mph) for 3.31 axle ratio The noise may also be present to a lesser degree at roughly half of the noted speeds. This may be due to a 2nd order driveline frequency transmitted through the rear driveshaft, rear axle and into the body through the leaf springs. To correct the condition, follow the Service Procedure to install a driveshaft torsional damper. NOTE: The torsional damper will not resolve a vibration.
Associated Products (3)Associated Documents - November 1, 2022•Document ID: 10226726Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 51168
- Date Added:
- November 29, 2022
- Manufacturer:
- FORD
Summary2015-2023 Transit vehicles equipped with DRW have a high mount rear marker lamp that does not illuminate with the stop lamps. This lamp assembly may appear to be a stop lamp but is intended to illuminate with the parking lamps only. This information is available in Workshop Manual Section 417-01. The JDDAB feature code description, found under OASIS additional information, is common between single rear wheel and DRW vehicles, and incorrectly reflects stop functionality when applied to DRW units.
Associated Products (3)Associated Documents - October 13, 2022•Document ID: 10224334Service Bulletin/Repair InstructionsUNKNOWN OR OTHER; COMMUNICATION:MANUFACTURER TELEMATICS
- Mfr Comm. #:
- SSM 51131
- Date Added:
- October 19, 2022
- Manufacturer:
- FORD
SummarySome 2020-2022 Ford and Lincoln vehicles equipped with a telematic control unit (TCU) may exhibit inoperative remote features via Ford Pass/Lincoln Way mobile app, incomplete user authorization, and/or modem electronic serial number (ESN) could not be displayed in the center display screen. To correct this condition prior to programming, remove the TCU fuse for 5-minutes then reinstall. Delete all previous session files for the vehicle. Start a new Ford Diagnosis and Repair System (FDRS) session. Perform a TCU provisioning and Program the TCU to the latest FDRS version level. If the concern is still present, follow normal diagnostics in Workshop Manual (WSM), Section 415-00. Refer to PTS OASIS home page for TCU version identification. For claiming, use causal part 14G229 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (22)2023 Lincoln Aviator2022 Ford Bronco Sport2022 Ford Escape2022 Ford Explorer2022 Ford Maverick2022 Ford Mustang2022 Ford Ranger2022 Ford Transit2022 Ford Transit Connect2022 Lincoln Aviator2022 Lincoln Corsair2021 Ford Bronco Sport2021 Ford Escape2021 Ford Expedition2021 Ford Explorer2021 Ford Mustang2021 Ford Ranger2021 Ford Transit2021 Ford Transit Connect2021 Lincoln Aviator+ 2 moreAssociated Documents - August 31, 2022•Document ID: 10219146Service Bulletin/Repair InstructionsSTRUCTURE:BODY:DOOR
- Mfr Comm. #:
- TSB 22-2305
- Date Added:
- September 1, 2022
- Manufacturer:
- FORD
SummarySome 2020-2022 Transit vehicles may experience intermittent operation of the power sliding door (PSD) which may not open/close properly. It can still be closed manually. Diagnostic trouble code (DTC) U201A may or may not be present in the door control module H (DCMH). The PSD may partially actuate with each press of the remote, dash button, or door handle actuation. To correct the condition, follow the Service Procedure to replace the latch, install conical washers and adjust the door.
Associated Products (2)Associated Documents - August 11, 2022•Document ID: 10218620Service Bulletin/Repair InstructionsEQUIPMENT; STRUCTURE:BODY:DOOR
- Mfr Comm. #:
- TSB 22-2321
- Date Added:
- August 23, 2022
- Manufacturer:
- FORD
SummarySome 2015-2022 Transit vehicles may experience a snap, click and/or pop noise from the door check when opening/closing the front door(s). This may be due to a cracked/broken door check and/or fastener. To correct the condition, follow the Service Procedure to inspect/replace the front door check and/or fastener.
Associated Products (2)Associated Documents - August 2, 2022•Document ID: 10217832Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- SSM 50988
- Date Added:
- August 15, 2022
- Manufacturer:
- FORD
SummarySome 2018-2021 F-150 3.3L, 2020-2021 Explorer 3.3L, and 2020-2021 Transit 3.5L may experience an illuminated low oil pressure and malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P0521 stored in the powertrain control module (PCM) after a short block or long block replacement. This may be due to a design change of the engine oil pressure (EOP) sensor, which is not backwards compatible. To correct the condition, transfer the sensor from the original engine or replace the EOP sensor with GN1Z-9D290-D.
Associated Products (3)Associated Documents - July 29, 2022•Document ID: 10216837Service Bulletin/Repair InstructionsSEATS
- Mfr Comm. #:
- TSB 22-2263
- Date Added:
- August 1, 2022
- Manufacturer:
- FORD
SummarySome 2019-2021 Transit vehicles built on or before 11-Feb-2021 may experience a front seat cushion sagging. To correct this condition, follow the Service Procedure to replace the suspension mat assembly and install additional webbing strap assemblies to the seat frame.
Associated Products (1)Associated Documents - July 28, 2022•Document ID: 10216958Service Bulletin/Repair InstructionsEQUIPMENT:MECHANICAL
- Mfr Comm. #:
- SSM 50971
- Date Added:
- August 2, 2022
- Manufacturer:
- FORD
SummarySome 2020-2021 Transit vehicles equipped with factory keyless entry remote may exhibit a broken flip-key at the base of the fob. For customers that may require a more robust key due to high key cycle activity, a mechanical key (Rotunda part numbers: pre-cut 164-R8290, uncut 164-R8289) can be programmed to the vehicle and used in conjunction with the original fob that has the broken flip-key for the remote keyless entry functions. A broken key can still be replaced with the current service part, which is a like-for-like replacement. To program the keys, refer to Workshop Manual (WSM), Section 419-01B.
Associated Products (1)Associated Documents - July 7, 2022•Document ID: 10215619Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- TSB 22-2271
- Date Added:
- July 11, 2022
- Manufacturer:
- FORD
SummaryThis article supersedes TSB 22-2175 to update the Issue, Action, and Service Procedure. Some 2015-2022 Transit vehicles equipped with rear wheel drive (RWD), single rear wheel (only), and U-joints at the transmission flange and rear driveshaft may experience a boom/hum/moan noise from the rear while driving. This noise is most noticeable at highway speeds: 112-121 km/h (70-75 mph) for 4.10 axle ratio 121-128 km/h (75-80 mph) for 3.73 axle ratio 136-145 km/h (85-90 mph) for 3.31 axle ratio The noise may also be present to a lesser degree at roughly half of the noted speeds. This may be due to a 2nd order driveline frequency transmitted through the rear driveshaft, rear axle and into the body through the leaf springs. To correct the condition, follow the Service Procedure to install a driveshaft torsional damper. NOTE: The torsional damper will not resolve a vibration.
Associated Products (2)Associated Documents - June 22, 2022•Document ID: 10214830Service Bulletin/Repair InstructionsSEAT BELTS
- Mfr Comm. #:
- SSM 50874
- Date Added:
- June 30, 2022
- Manufacturer:
- FORD
SummarySome 2015-2022 Transit vehicles may exhibit front seat safety belts that do not extend or retract properly or may exhibit an abnormal noise. Verify if the vehicle has been modified, in particular if a bulkhead partition between the front seats and cargo area has been added to the vehicle. Fasteners or holes in the lower b-pillar are indicators that the seat belt retractor mechanism could have been compromised. If diagnostics lead to retractor replacement, inspect for drill or screw holes in the retractor housing. Damage to the seat belt retractor caused by a vehicle modifier is not warrantable.
Associated Products (2)Associated Documents - June 8, 2022•Document ID: 10214158Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 50841
- Date Added:
- June 17, 2022
- Manufacturer:
- FORD
SummarySome 2018-2022 F-150, Expedition, Navigator, Transit, Aviator and Explorer vehicles may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P0627, P025A, P025B, P00C6, P008A and/or U0109 stored in the powertrain control module (PCM). This may be due to an intermittent or partial disconnect of the harness to the fuel pump control module (FPCM) connector, connector pin push-outs, damaged pins/terminals, or loose/corroded grounds. Inspect FPCM connector, applicable grounds (F-150 - G401, Expedition/Navigator - G403, Transit - G401, 2018-2019 Explorer G302, 2020-2022 Explorer/Aviator - G407) and confirm FPCM connector (F-150 - C4336, Expedition/Navigator - C433, Transit - C433, 2018-2019 Explorer - C3239, 2020-2022 Explorer/Aviator - C4033) is fully seated prior to performing PC/ED diagnostics or replacing any components.
Associated Products (12)Associated Documents - June 8, 2022•Document ID: 10213730Service Bulletin/Repair InstructionsENGINE; EQUIPMENT:OTHER:LABELS; FUEL SYSTEM, GASOLINE
- Mfr Comm. #:
- 21L04
- Date Added:
- June 10, 2022
- Manufacturer:
- FORD
SummaryCertain 2020-2021 Model Year Transit Vehicles Equipped with a 3.5L Ecoboost Engine - Fuel Filler Door E85 Label Removal .In all of the affected vehicles, the fuel tank filler door may incorrectly have an E85 fuel label installed on units that are not rated for E85 fuel. The use of E85 fuel in vehicles not rated for E85 fuel may cause a lean condition along with a Malfunction Indicator Lamp (MIL) and a P0172 Diagnostic Trouble Code (DTC). Continued driving with E85 fuel may lead to drivability symptoms including hard to start, rough idle, stalling, hesitation, surging, or lack of power.
Associated Products (1)Associated Documents - May 24, 2022•Document ID: 10212957Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 50804
- Date Added:
- June 1, 2022
- Manufacturer:
- FORD
SummarySome 2013-2023 Ford or Lincoln vehicles with modems activated through FordPass or LincolnWay may experience 12 volt battery drain symptoms when the customer uses non-Ford/Lincoln phone applications as an alternate channel to access vehicle commands such as door lock/unlock, remote start, vehicle location, etc. The battery drain may be caused by excessive calls for data through the vehicle network keeping it in an activated state. Recommend that the customer uninstall the app to ensure this is not contributing to battery symptoms experienced. Advise the customer that unaffiliated third-party app developers do not work directly with Ford to adhere to security, vehicle communication, and privacy requirements.
Associated Products (31)2023 Ford E-3502023 Ford E-4502022 Ford Bronco2022 Ford E-3502022 Ford E-4502022 Ford Edge2022 Ford Escape2022 Ford Expedition2022 Ford Explorer2022 Ford F-1502022 Ford Maverick2022 Ford Mustang2022 Ford Transit2022 Lincoln Aviator2022 Lincoln Corsair2022 Lincoln Nautilus2022 Lincoln Navigator2021 Ford Bronco2021 Ford E-3502021 Ford E-450+ 11 moreAssociated Documents - May 17, 2022•Document ID: 10211953Service Bulletin/Repair InstructionsENGINE
- Mfr Comm. #:
- 21L04
- Date Added:
- May 19, 2022
- Manufacturer:
- FORD
SummaryCertain 2020-2021 Model Year Transit Vehicles Equipped with a 3.5L Ecoboost Engine - Fuel Filler Door E85 Label Removal - In all of the affected vehicles, the fuel tank filler door may incorrectly have an E85 fuel label installed on units that are not rated for E85 fuel. The use of E85 fuel in vehicles not rated for E85 fuel may cause a lean condition along with a Malfunction Indicator Lamp (MIL) and a P0172 Diagnostic Trouble Code (DTC). Continued driving with E85 fuel may lead to drivability symptoms including hard to start, rough idle, stalling, hesitation, surging, or lack of power.
Associated Products (1)Associated Documents - May 5, 2022•Document ID: 10211706Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- TSB 22-2175
- Date Added:
- May 12, 2022
- Manufacturer:
- FORD
SummarySome 20152022 Transit vehicles equipped with rear wheel drive (RWD), single rear wheel only, and a U-joint at the transmission flange and rear driveshaft may experience a boom/hum/moan noise or vibration from the rear while driving. This noise or vibration is most prevalent at highway speeds: * 112-121 km/h (7075 mph) for 4.10 axle ratio * 121-128 km/h (75-80 mph) for 3.73 axle ratio * 136-145 km/h (85-90 mph) for 3.31 axle ratio The noise or vibration may also be present to a lesser degree at roughly half of those speeds. This may be due to a 2nd order driveline frequency transmitted through the rear driveshaft, rear axle and into the body through the leaf springs. To correct the condition, follow the Service Procedure to install a driveshaft torsional damper.
Associated Products (2)Associated Documents - April 28, 2022•Document ID: 10210850Service Bulletin/Repair InstructionsTIRES:SIDEWALL
- Mfr Comm. #:
- SSM 50733
- Date Added:
- May 3, 2022
- Manufacturer:
- FORD
SummarySome 2021 and 2022 Ford and Lincoln vehicles may experience a tire sidewall wavy/indentation appearance in the radial direction on one or both sidewalls. Sidewall wavy/indentation appearance is a common cosmetic characteristic of radial tire construction and will not affect the performance of the tire.
Associated Products (33)2022 Ford Bronco2022 Ford Bronco Sport2022 Ford E-3502022 Ford E-4502022 Ford Edge2022 Ford Escape2022 Ford Expedition2022 Ford F-1502022 Ford Maverick2022 Ford Mustang2022 Ford Ranger2022 Ford Transit2022 Ford Transit Connect2022 Lincoln Aviator2022 Lincoln Corsair2022 Lincoln Nautilus2022 Lincoln Navigator2021 Ford Bronco2021 Ford Bronco Sport2021 Ford E-350+ 13 moreAssociated Documents - April 22, 2022•Document ID: 10210806Service Bulletin/Repair InstructionsPARKING BRAKE
- Mfr Comm. #:
- SSM 50720
- Date Added:
- May 3, 2022
- Manufacturer:
- FORD
Summary2020-2022 Transit vehicles equipped with the push down parking brake lever operate differently than the standard parking brake. When the push down parking brake is engaged by pulling the lever upward to its fullest extent, the lever can then be lowered and raised without the parking brake becoming disengaged. To disengage the parking brake, the button must be pressed and held when the lever is in the most upward position, prior to lowering the lever. Refer to the Owner's Manual for additional information.
Associated Products (2)Associated Documents - April 14, 2022•Document ID: 10210419Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; STRUCTURE:BODY:DOOR
- Mfr Comm. #:
- SSM 50699
- Date Added:
- April 20, 2022
- Manufacturer:
- FORD
SummarySome 2019-2022 Transit vehicles may experience intermittent operation of the power sliding door (PSD) which may not open/close properly. It can still be closed manually. Diagnostic trouble code (DTC) U201A may or may not be present. The PSD may partially actuate with each press of the remote, dash button, or door handle actuation. Check and adjust the door strikers/hinges as needed per the Workshop Manual (WSM), Section 501-03 > General Procedures. If sliding door adjustments do not resolve the concern, the problem is likely related to the latch. If necessary, replace the latch and reassess before considering other actions. Engineering is aware of the issue and is currently investigating. Continue to monitor OASIS for updates.
Associated Products (2)Associated Documents - April 6, 2022•Document ID: 10210242Service Bulletin/Repair InstructionsPOWER TRAIN; ELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 50661
- Date Added:
- April 13, 2022
- Manufacturer:
- LINCOLN
SummarySome 2018-2022 F-150, Expedition, Navigator, Transit, Aviator and Explorer vehicles may exhibit an illuminated MIL with Diagnostic Trouble Codes (DTCs) P025A, P025B, P00C6, P008A and/or U0109 stored in the powertrain control module (PCM). This may be due to an intermittent or partial disconnect of the harness to the fuel pump control module (FPCM) connector, connector pin push-outs or loose/corroded grounds. Inspect FPCM connector, applicable grounds (F-150- G401, Expedition/Navigator- G403, Transit- G401, 2018-2019 Explorer G302, 2020-2022 Explorer/Aviator- G407) and confirm FPCM connector (F-150- C4336, Expedition/Navigator- C433, Transit- C433, 2018-2019 Explorer C3239, 2020-2022 Explorer/Aviator- C4033) is fully seated prior to performing PC/ED diagnostics or replacing any components.
Associated Products (12)Associated Documents