Ford Ranger Complaints (2019)

271 consumer complaints on file.

#11733822April 26, 2026
SUSPENSION
Rear rear leaf spring broken/cracked completely and disconnected from vehicle. The vehicle was unsafe to drive as the axle was not not connected to the vehicle on one side. The defective component was inspected by Firestone Auto and submitted and approved by SilverRock automotive for warranty replacement and is currently at a Ford Dealership completing repairs because Firestone Auto failed to complete the repair properly. There were no warning lamps or messages and it the problem was only noticeable when the vehicle was on a lift or floor jack. The incident is unknown and it the broken part was poor design/materials.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11732372April 20, 2026
SUSPENSION
JULY 2024 THE RIGHT SIDE BACK LEAF SPRING WAS BROKEN. WAS REPLACED UNDER WARRANTY. APRIL 2026 THE LEFT SIDE BACK LEAF SPRING IS BROKE. WAITING TO HEAR FROM FORD IF IT WILL BE COVERED OR NOT. LEAF SPRINGS SHOULD NOT BE BREAKING. I DO NOT HAUL THINGS OR EVEN GO OFF ROAD WITH MY 2019 RANGER. IT HAS 74012.10 MILES ON IT NOW.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11731902April 17, 2026
POWER TRAIN
The contact owns a 2019 Ford Ranger. The contact stated that while driving at an undisclosed speed, the vehicle hesitated, and the transmission was shifting hard. Additionally, the vehicle vibrated abnormally while shifting from 1st to 3rd gear. The vehicle was taken to the dealer, where the TCM was reprogrammed, and various fluids were replaced; however, the failure persisted. The manufacturer was notified of the failure. The approximate failure mileage was 951.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11728932April 2, 2026
ELECTRICAL SYSTEM, ENGINE, SUSPENSION
On friday, march 27th, 2026. My 2019 ford ranger began shaking before the engine stalled. Warning lights for an engine check came on and my vehicle would not go above 20 mph after restarting. When pressing on the accelerator the engine would rev but the vehicle would not accelerate. I took the 2019 ford Ranger to a local Ford Dealership service center and they diagnosed the following problems (listed in full below).The cooling fan was at issue and multiple wires connecting my engine to the rest of the vehicle were melted off. The ford dealership said that this issue is extremely rare and they have never seen it before. After receiving this information from the dealership I discovered that the 2019 ford ranger has had several recalls with the areas at issue in my vehicle. The recalls are under number 25V685000 (Engine block heater), and 20V137000 (Fan). Here is the full diagnosis from the ford dealership attached below: VERIFIED CUSTOMER CONCERN FOUND VEHICLE TO HAVE CEL LIGHT ON, AND MULTIPLE WARNING LIGHTS PERFORMED DIAG AND FOUND SHORT CIRCUIT PRESENT. TRACED SHORT FOUND COOLING FAN CLUTCH FAILED AND HARNESS RUBBING IN CLUCH ASSEMBLY FOR COOLING FAN The fan lowers the temperature of the engine. The cooling fan motor is an electric motor that turns the fan blades. When the vehicle is in traffic or under heavy load, the engine relies on the fan to cool itself. Some vehicles may use multiple electric fans for better control of the cooling system. For the most part, electric cooling fans are controlled by the same computer that controls the engine. However, in some engines, the fans are turned on and off by a temperature-sensitive switch mounted in either the radiator or elsewhere in the cooling system. Spark Plug Replacement 4 Cylinder: 4 Cyl Tune Up The platinum spark plug is a type of spark plug. The platinum is a precious metal that is used in the composition of the spark plug. The center electrode is made of platinum.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726607March 24, 2026
AIR BAGS, ELECTRICAL SYSTEM, SEAT BELTS
Restraints indicator lamp warning. Air bag warning is on due to a problem with the front passenger side airbag. The front passenger airbag may not function.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726465March 23, 2026
SUSPENSION
both rear springs broken at the front eye mounts. the rear leaf springs hold the rear axle in place need I EXPLAIN MORE? I have not had the truck inspected, I have been in the automotive industry for over forty years. I first heard a noise from the springs when entering a parking lot and drove over a curb. No electronics attached to the springs.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11724978March 17, 2026
POWER TRAIN
The transmission failed prematurely (my point-of-view) at around 115,000 miles. A Ford dealer diagnosed and determined the transmission needed replaced. The vehicle was a 2019 Ford Ranger XL with a 10-speed automatic transmission. The transmission would get stuck in 2 gear, sometimes upshifting and sometimes downshifting. Driving highway speeds the speed needle would also drop to zero even though I was moving. They noted that solenoids were bad but replacement was needed. I had the transmission replaced with a new warrantied transmission but it was very expensive at $9,650. It did come with a 2-year warranty. That is half the value of the truck! This is the fourth Ford truck I have owned. I do use it as a truck and haul a few things around as projects dictate but do little towing, drive it reasonably, and do not take it off-roading. I have never had a transmission fail before. The Ford dealer, and three area shops, noted they see "a lot of 10-speeds" come in for transmission rebuild or replacement. As a now review many Ford forums I see many people with issues surrounding the durability of the 10-speed transmission.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11724320March 14, 2026
POWER TRAIN
Since owning the vehicle, I have experienced a range of serious transmission issues. These include harsh or delayed gear shifts, inconsistent downshifts, and transmission slipping. The vehicle also frequently jerks or lurches during gear changes. Of particular concern is the vehicle’s behavior during downshifting. At times, the transmission downshifts abruptly and causes the vehicle to lunge forward unexpectedly. This unpredictable behavior presents a significant safety concern, particularly in traffic situations where smooth and predictable vehicle response is essential. These transmission issues negatively affect the safety, drivability, and reliability of the vehicle and are not consistent with normal operation.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11724035March 13, 2026
POWER TRAIN
My transmission has failed at 131,000 miles on my vehicle. It roughly shifts into reverse and harshly shifts while in drive and the vehicle is in motion. My truck shakes while the transmission searches for gears and shifts slowly requiring extra power to move in normal operating conditions.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11723752March 12, 2026
AIR BAGS, SEAT BELTS
Airbags: passenger rear and front side airbags did not deploy after being struck on the passenger side by another vehicle. Seatbelts: were ineffective Vehicle was sold due to system failures and equipment issues. Safety: Head and body trauma due to non deployment. Inspection: Unknown No system messages before collision
Crash:
Yes
Fire:
No
Injuries:
3
Deaths:
0
#11723225March 10, 2026
POWER TRAIN
10th gear, gear ratio incorrect. CDF drum failure. Rough shifts from 3-4 struggles to shifts into park and reverse.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11723121March 9, 2026
SUSPENSION
Vehicle has around 50K miles and driver rear leaf spring corroded and broke, review of right rear leaf spring also showed corrosion and metal thinning. Truck has no off road time nor heavy loads in bed. I had to replce both springs at my cost even though Ford is aware of the 2019-2020 Ranger spring issues and refused to replace the springs. This is a serious safety issue that places the occupants and other drivers at risk. The mechanic said he’s replaced over a dozen broken leaf springs on model years 2019 and 2020. The manufacturer is being intentionally negligent and even the dealer parts counter agreed the springs are faulty, saying they sell quite a few regularly.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11720076February 24, 2026
ENGINE, POWER TRAIN
My truck experienced a P0302 misfire on the freeway, which caused it to shake immediately and made it very difficult to drive. I had it towed to the dealership, and they told me there was water in the spark‑plug wells, which was surprising since I live in Las Vegas, NV, where it rarely rains. My spark plugs were rusted as well as the cylinder head. After looking into it online, I discovered that Ford issued TSB‑23‑2011 for the Ford Ranger due to a windshield cowl leak that allows water to drip directly onto the engine. Their proposed fix is to install an engine cover, but that clearly doesn’t solve the issue since my truck already has the engine cover installed. Now I’m stuck paying for repairs caused by a design flaw that Ford never properly addressed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11719853February 23, 2026
UNKNOWN OR OTHER
he 2019 Ford Ranger the VIN [XXX] , the driver’s side AC only blows hot due to the climate control issue addressed in Fords service bulletin SSM 51313. This is a known issue with the early production model of the Ranger, hence the service bulletin SSM 51313. It is my belief that faulty parts were used on the early model Rangers and instead of a recall or extending the warranty on this issue only issued a service bulletin was put out. I am writing to have the Ford MOCO issue the proper recall or cover repairs under and extended warranty. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11713793January 27, 2026
POWER TRAIN, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
The vehicle is experiencing a severe power train failure involving erratic and violent gear selection. The transmission unexpectedly jumps from 2nd, 3rd, or 4th gear directly up to 7th or 8th gear, resulting in a total loss of acceleration. This is immediately followed by the transmission "slamming" down into lower gears, usually 1st or 2nd gear without driver input. This behavior is accompanied by a strong burning smell and a dashboard "wrench" warning light. The symptoms match the manufacturing defect documented in Ford TSB 24-2101 (CDF clutch drum). Diagnosis & Manufacturer Response: The issue began in October 2025 with a noticeable transmission shudder. I paid for two transmission flushes at Big O Tires to attempt to resolve the issue, but the mechanical failure has since escalated. When the "wrench" light appeared, an independent diagnostic computer was unable to retrieve an error code, as the light is a proprietary Ford powertrain indicator. Furthermore, the wrench light clears upon restarting the vehicle, despite the violent shifting and burning smell remaining. Ford Corporate agents claim there are "no known issues" and have refused to assist with towing, despite an active NHTSA Engineering Analysis (PE 24-001) regarding this exact 10R80 transmission. Safety Risk: This defect creates an extreme safety hazard. Violent downshifting into low gears at highway speeds can cause a loss of vehicle control or a rear-end collision. The burning smell indicates internal friction and fluid oxidation, posing an immediate fire risk or the potential for a catastrophic mechanical lock-up.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709896January 9, 2026
POWER TRAIN
The transmission stutters at sustained modest speed (25-45 mph). It was taken to the dealer, who determined it was affected by tsb 25-2134. This is a widely known issue and the dealer refused any servicing without payment. This should have been a recall, since hundreds of known issues in and out of warranty have occurred.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11708360January 2, 2026
POWER TRAIN
The automatic transmission and related transmission control system malfunctioned. The vehicle experienced improper shifting and loss of gears, including a condition in which 4th gear is disabled due to a failsafe logic triggered by the transmission control module. The vehicle and all affected components are currently available for inspection upon request and are at a Ford-authorized dealership. This malfunction posed a safety risk because the vehicle was unable to shift normally or maintain consistent acceleration. The unpredictable shifting and loss of gears could create hazardous situations when merging, accelerating, or driving at highway speeds, potentially endangering the driver and others. The problem has been reproduced and confirmed by a Ford dealership. After inspection and diagnostic testing, the dealership advised that the transmission requires replacement. The vehicle has been inspected by a Ford-authorized dealer. It has not been inspected by the manufacturer directly, police, or insurance representatives (UNKNOWN). Prior to the failure, warning messages and drivability symptoms were present. Specifically, the transmission control module detected an issue when attempting to shift into 4th gear, triggering a failsafe mode that disabled 4th gear for the remainder of the key cycle. These symptoms appeared before the full transmission failure and progressively worsened over time.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11706629December 22, 2025
UNKNOWN OR OTHER
2019 ford ranger, 74,000 miles On way to pick up girlfriends engagement ring…. The truck started jerking, loosing power, no engine light came on. Turned around to go home and drive about 8 miles under 45 mph.Then truck started jerking again , like transmission issue. Engine light and tool wrench came on. As I was pulling in driveway, truck went into “limp” mode. Had it towed to Gullo Ford Conroe. Now they are saying need new transmission due to Internal transmission failure! Shouldn’t Ford. Over this! Only 60,000 mile warranty.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11706172December 19, 2025
SUSPENSION
During a PA State inspection, a leaf spring was discovered to be broken.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11704505December 11, 2025
VISIBILITY/WIPER, ELECTRICAL SYSTEM, UNKNOWN OR OTHER
The climate control system on my 2019 Ford Ranger has a recurring failure that prevents the vehicle from properly adjusting temperature or directing air through the vents. The failure causes a constant clicking/snapping noise behind the dashboard, and the blend door does not move when the temperature is changed. This malfunction matches Ford’s published SSM 49264, which identifies a known defect in 2019–2020 Rangers built on or before 7/30/2020 and states that the entire HVAC housing assembly must be replaced. This issue creates a safety hazard because the truck cannot reliably defrost the windshield in cold or wet weather. Loss of defrosting capability severely limits visibility and makes safe operation of the vehicle difficult. The issue is reproducible every time the temperature is adjusted. The problem began when the vehicle was still within the original mileage window of the factory warranty, but the dealership did not repair it. Ford has confirmed the malfunction is caused by the blend door system, yet they have refused goodwill coverage for a repair that requires full dash removal and replacement of a known defective part. There were no warning lights, but the clicking noise and loss of temperature control began well before the warranty expired. The vehicle continues to experience the defect, and it poses an ongoing visibility and safety risk. Ford has acknowledged this exact failure mode in writing (SSM 49264), but has not issued a recall or safety campaign.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Ranger