Ford Ranger Complaints (2001)

527 consumer complaints on file.

#10372312December 24, 2010
STRUCTURE:FRAME AND MEMBERS
2001 FORD RANGER 4X4 EXTENDED CAB - FRAME IS COMPLETELY RUSTED OUT IN THE REAR AND HAS HOLES RUSTED THROUGH IN THE FRONT WHERE SUSPENSION PARTS ARE MOUNTED. FRAME RUSTED OUT COMPLETELY AT REAR SPRING MOUNTS THEY BROKE LOOSE WENT UP AND HIT BED ONE SIDE POKED HOLE IN BED. I CALLED FORD AND ASKED IF THEY WOULD DO ANYTHING ABOUT IT AS TOYOTA HAS RECENTLY RECALLED TRUCKS THAT HAVE THE SAME PROBLEM. THEY SAID THEY WERE NOT. IF I WOULD HAVE BEEN DRIVING 70 MPH ON AN INTERSTATE WHEN THE REAR BRACKETS BROKE LOOSE SOMEONE COULD HAVE BEEN KILLED. THIS IS A SERIOUS PROBLEM AND SHOULD BE ADDRESSED AS TOYOTA HAS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10369441December 7, 2010
STRUCTURE:FRAME AND MEMBERS
TL* THE CONTACT OWNS A 2001 FORD RANGER. THE CONTACT STATED THAT THE VEHICLE FRAME WAS CRACKED AND COMPLETELY RUSTED DUE TO CORROSION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND DEALER WHERE THEY ADVISED THAT THE FRAME COMPLETELY RUSTED. ALSO, THE TECHNICIAN RECOMMENDED THE VEHICLE NOT BE DRIVEN DUE TO A POTENTIAL SAFETY HAZARD. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE FAILURE MILEAGE WAS 42,000. UPDATED 01/31/11 *BF UPDATED 03/16/11
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10368651December 2, 2010
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL, STRUCTURE:FRAME AND MEMBERS, SUSPENSION:REAR
TL* THE CONTACT OWNS A 2001 FORD RANGER XLT. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED THAT THE REAR WHEELS WERE SITTING LOWER TO THE GROUND THAN USUAL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE REAR SUSPENSION WAS REPAIRED. A FEW YEARS LATER, THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR FACILITY TO BE INSPECTED WHERE THE CONTACT WAS INFORMED THE ENTIRE UNDERCARRIAGE WAS SEVERELY CORRODED. IN ADDITION, THE HINGES WHICH HELD THE FUEL TANK TO THE FRAME WERE SEVERELY CORRODED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 67,000 AND THE CURRENT MILEAGE WAS 104,000. UPDATED 01/25/11*LJ THE VEHICLE ALSO HAD AN EVAP LEAK.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10363348October 29, 2010
UNKNOWN OR OTHER
THE FRAME JUST IN FRONT OF THE REAR TIRES ON BOTH SIDES IS GETTING THIN WITH SMALL HOLES IN IT. ALSO THE CROSSMEMBER BEHIND THE TRANSFER CASE THAT HOLDS THE FRONT GAS TANK SUPPORT IS ROTTED OUT PRETTY BAD AND SHOULD BE REPLACED. THE REAR LEAF SPRING SHACKLES ARE GETTING PRETTY THIN AND WILL NEED TO BE REPLACED SOON.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10361526October 21, 2010
STRUCTURE:FRAME AND MEMBERS, SERVICE BRAKES, HYDRAULIC
IN 2001 PURCHASED A NEW FORD 2001 XLT RANGER FROM A DEALERSHIP. IN MARCH/APRIL 2009, AT 76,000 MILES IT BECAME NECESSARY TO REPLACE THE ENTIRE REAR BRAKELINE SYSTEM DUE TO ROT. IN DEC /JAN 2009 THE BED OF THE TRUCK AND THE REAR BUMPER BECAME LOOSE. IN THE EARLY SPRING OF 2010 THE REAR BUMPER FELL OFF IN MY HANDS. THE VEHICLE WAS SET FOR SERVICE AT AN AUTO REPAIR SHOP. UPON INSPECTION THE FRAME AND BED ATTACHMENT, LEAF SPRINGS AND FRAME ATTACHMENTS, MAIN FRAME, WERE CORRODED AND ROTTED WITH VISIBLE HOLES. THE VEHICLE WAS DEEMED UNSAFE TO DRIVE. THE REPAIRS HAVE NOT BEEN UNDERTAKEN BECAUSE A SUITABLE REPLACEMENT FRAME IS UNAVAILABLE AND REPAIRS AT THIS TIME ARE UNAFFORDABLE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10359529October 7, 2010
SERVICE BRAKES, HYDRAULIC
TL*THE CONTACT OWNS A 2001 FORD RANGER. THE CONTACT TOOK THE VEHICLE INTO AN AUTOMOTIVE CENTER FOR A ROUTINE OIL CHANGE. THE MECHANIC SHOWED THE CONTACT WHERE THE METAL ON THE CALIPER WAS DETERIORATING AND FLAKING OFF. THE CONTACT HAD NO PRIOR PROBLEMS WITH THE BRAKES BEFORE BEING INFORMED BY THE MECHANIC. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE VIN WAS UNAVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 44,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10356728September 21, 2010
VEHICLE SPEED CONTROL
TL*THE CONTACT OWNS A 2001 FORD RANGER XLT. WHILE DRIVING APPROXIMATELY 20-30 MPH THE VEHICLE BEGAN ACCELERATING, THEN IT STOPPED AND BEGAN ACCELERATING AGAIN. THE ACCELERATED CONTINUED TO OCCUR INTERMITTENTLY. THE CONTACT WAS NOT CERTAIN IF ANY LIGHTS ILLUMINATED ON THE DASHBOARD. HE DROVE ONTO THE EMERGENCY LANE AND WAITED 30 SECONDS AND THE VEHICLE BEGAN TO FUNCTION NORMALLY. THE CONTACT STATED THAT HE NEVER TURNED THE ENGINE OFF DURING THE FAILURE. THE FAILURE OCCURRED TWICE. THE VEHICLE WAS PREOWNED AND IT WAS PURCHASED IN JULY 2009. THE FAILURE WAS NOT DIAGNOSED BY A LOCAL MECHANIC OR AN AUTHORIZED DEALER. THE FAILURE MILEAGE WAS 119,000 AND THE CURRENT MILEAGE WAS 123,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10354829September 10, 2010
FUEL SYSTEM, GASOLINE
WHEN TRYING TO FILL THE GAS TANK, THE OVERFLOW SYSTEM(?) DOESN'T WORK PROPERLY. YOU CANNOT HAVE HARDLY ANY PRESSURE OR, AS YOU FILL, THE GAS SPEWS OUT OF THE TANK BEFORE THE SAFETY FEATURE ON GAS PUMPS CAN TURN OFF. GAS SPEWS DOWN THE SIDE OF THE VEHICLE, OUT ONTO THE GROUND, ONTO MY HAND, ONTO MY FEET. THIS CREATES A COMBUSTION POSSIBILITY AT THE GAS TANK AS WELL AS THE GAS PUMP. THIS OCCURS ABOUT 99% OF THE TIME WHEN I TRY TO PUT GAS INTO THE TANK. IT DOESN'T MATTER HOW FULL THE TANK IS. THIS IS AN ONGOING PROBLEM. I'VE BEEN TOLD THAT THE ONLY WAY THAT IT CAN BE FIXED IS BY DROPPING THE GAS TANK. I'VE ALSO BEEN TOLD IT IS OCCURRING IN OTHER, NEWER FORD PICKUPS. DUE TO THE POSSIBILITY OF FIRE, THIS SHOULD BE INVESTIGATED. THANK YOU. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10354106September 7, 2010
STRUCTURE:FRAME AND MEMBERS
I HAVE A 2001 FORD RANGER, WHICH NOW HAS 96000 MILES ON IT. I PURCHASED IT NEW. AT APPROXIMATELY 90000 MILES, THE REAR SPRING SHACKLES ROTTED OFF OF THE FRAME. I WAS DRIVING WHEN THIS HAPPENED, AND THE TRUCK BED DROPPED DOWN ON TO THE SHACKLE EAR WITH A TU=HUD AND SHOOK THE TRUCK. THE SPARE TIRE STORAGE HOUSING HAS ALSO RUSTED AWAY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10352339August 27, 2010
FUEL SYSTEM, OTHER
CORRODED SUPPLY AND/OR RETURN GASOLINE LINE LEAKING GASOLINE IN LARGE VOLUMES, RESULTING IN DANGER OF FIRE AND/OR EXPLOSION. VEHICLE TOWED TO REPAIR CENTER, AWAITING A NEW LINE TO BE TRANSFERRED FROM ONE DEALER TO ANOTHER BECAUSE THE FORD WAREHOUSE HAS ZERO LINES IN STOCK. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10348321August 9, 2010
STRUCTURE:FRAME AND MEMBERS
RUST ON THE FRAME OF MY TRUCK HAS RESULTED IN THE TRUCK NEED A NEW FRAME OR I WILL HAVE TO JUNK THE TRUCK. STARTED IN 2009 THE BUMPER FELL OFF AND I HAD TO PUT STEEL ON THE END OF THE FRAME TO SUPPORT THE BUMPER . IN 2010 THE SPRING HANGER BROKE AND I WAS TOLD THAT THE FRAME WAS GONE , FROM THE BACK WHEELS TO THE BUMPER. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10344752July 22, 2010
STRUCTURE:FRAME AND MEMBERS
TL*THE CONTACT OWNS A 2001 FORD RANGER. THE CONTACT DETECTED THAT THE MAIN FRAME EXHIBITED LARGE HOLES, BROKE AND WAS COVERED WITH AN EXCESSIVE AMOUNT OF RUST. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR INSPECTION. THE TECHNICIAN STATED THAT THE FRAME WAS FAULTY AND POORLY DESIGNED. THE REAR SPRING MOUNTS WERE REPLACED AS A RESULT OF THE RUST CORROSION. THE FAILURE MILEAGE WAS 83,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10344453July 21, 2010
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
TL*THE CONTACT OWNS A 2001 FORD RANGER. WHILE DRIVING APPROXIMATELY 60 MPH EXTREME PRESSURE WAS APPLIED TO THE BRAKE PEDAL. THE CONTACT STATED THAT OCCASIONALLY YOU CAN FEEL THE BRAKE PEDAL PULSATE WHEN THE ANTI LOCK BRAKING SYSTEM ENGAGED BUT THE BRAKES DID NOT PULSATE. THE VEHICLE BEGAN TO SLOW DOWN INSTEAD OF COMING TO A STOP. THE CONTACT STATED THAT THE FAILURE OCCURRED SEVERAL TIMES. THE VEHICLE WAS NOT EXAMINED TO DETERMINE THE CAUSE OF FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 36,800.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10343002July 13, 2010
AIR BAGS:FRONTAL
WAS IN A TRAFFIC ACCIDENT YESTERDAY IN WHICH A CAR RAN A LIGHT AND HIT ME ALMOST HEAD ON. I WAS DRIVING A 2001 FORD RANGER XLT. I WAS STOPPED WAITING FOR THE GREEN LIGHT ARROW TO GO. WHEN THE ARROW CHANGED I PROCEEDED TO TURN. 1/2 INTO MY TURN I WAS HIT AT A SPEED OF ABOUT 50 MPH. PROBLEM WAS MY AIRBAG DID NOT DEPLOY. *TR
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10336010June 13, 2010
POWER TRAIN:MANUAL TRANSMISSION
I WAS DRIVING MY 2001 FORD RANGER DOWN THE ROAD, I PUSHED IN THE CLUTCH TO CHANGE GEARS AND SOMETHING POPPED. MY CLUTCH PEDAL WAS NOW INCAPABLE OF ACTUATING THE CLUTCH TO CHANGE GEARS OR PUT IT IN GEAR AFTER I PUT IT IN NEUTRAL. I HAD TO JERK THE GEARSHIFT OUT OF GEAR INTO NEUTRAL AND STOP AS TRAFFIC HAD STOPPED FOR A RED LIGHT. WE HAD TO PUSH THE TRUCK OUT OF THE WAY OF TRAFFIC. AFTER EXAMINING THE ENGINE COMPARTMENT, I SAW THAT THE CLUTCH HYDRAULIC LINE THAT ATTACHES TO THE CLUTCH MASTER CYLINDER HAD POPPED OFF. THE ROLL PIN THAT SECURES THAT PARTICULAR CONNECTION HAD WORKED ITSELF LOOSE AND ALLOWED THE LINE TO POP OFF. THE NEXT DAY I REMOVED THE CLUTCH MASTER CYLINDER, RESERVOIR, AND HYDRAULIC LINE. ALL THE PARTS WERE STILL GOOD, SO I BENCH BLED THE ASSEMBLY, INSTALLED, AND BLED THE CLUTCH SLAVE CYLINDER. UPON FURTHER INVESTIGATION, I READ THAT FORD HAD ISSUED A TECHNICAL SERVICE BULLETIN REGARDING THIS EXACT PROBLEM AND ISSUED A FREE FIX IF A CUSTOMER HAS THIS PROBLEM AND THE TRUCK IS UNDER WARRANTY. WELL, MY TRUCK ISN'T UNDER WARRANTY AND FIXING IT MYSELF WAS A HASSLE. I DON'T NEED MY CLUTCH PARTS FAILING LIKE THIS WHEN I'M CROSSING AN INTERSECTION NOR DOES ANYONE ELSE. IT'S A MAJOR DISTRACTION THAT CAN CAUSE AN ACCIDENT. EVEN IF THIS PROBLEM DOESN'T QUALIFY AS A RECALL ISSUE, THEY COULD AT LEAST MAIL ME A COTTER PIN WITH A LETTER TELLING ME TO LOOK OUT FOR THIS PROBLEM. THE TSB NUMBER IS 01-24-1 DATED 10/01/2001. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10325263April 13, 2010
EQUIPMENT, AIR BAGS
2001 FORD RANGER WET ROAD HYDROPLANNED STRIKING CONCRETE BARRIER DRIVER SIDE TWICE AIRBAG DID NOT DEPLOY. *TR
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10319888March 15, 2010
STRUCTURE:BODY:DOOR
TL*THE CONTACT OWNS A 2001 FORD RANGER. THE DOORS WARNING LIGHTS REMAINED ILLUMINATED INDICATING THAT THE DOOR WAS AJAR. THE FORD DEALER WAS CALLED AND STATED THAT THEY ARE NOT REPAIRING THE VEHICLE BECAUSE THERE WERE NO RECALLS OR VALID WARRANTIES RELATED TO THE FAILURE. A LOCAL MECHANIC REPAIRED THE VEHICLE. THE FAILURE MILEAGE WAS 34,000 AND THE CURRENT MILEAGE WAS 170,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10316276March 3, 2010
VEHICLE SPEED CONTROL, POWER TRAIN:AUTOMATIC TRANSMISSION, FUEL SYSTEM, GASOLINE
INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) I WAS DRIVING MY FORD RANGER, (2001 XLT AUTOMATIC TRANSMISSION) IN AN ATTEMPT TO WARM UP THE TRUCK AS THE TRANSMISSION HAD BEEN ACTING UP AS IT WAS NOT SHIFTING AS WELL AS IT SHOULD INTO HIGHER GEARS. THE TRUCK WAS HAVING TROUBLE GOING PAST 10-15 MPH BEFORE SHIFTING GEARS AND WAS GOING MUCH SLOWER THAN NORMAL. AS I DROVE AROUND THE PARKING LOT WHERE I WORK TO WARM UP THE TRUCK, IT WAS NOT GOING AS FAST AS NORMAL AND IT WARMED UP IN ABOUT 20 MINUTES. I CHECKED THE TRANSMISSION FLUID AND IT WAS AT A NORMAL LEVEL. I TURNED OFF THE TRUCK AND CHECKED THE OIL WHICH WAS IN THE NORMAL RANGE. I PROCEEDED TO GO TO QT AND GET SOME GAS AND ON MY WAY BACK TO WORK, I WENT TO STOP AT A RED LIGHT AND WAS ALMOST STOPPED WHEN THE ENGINE STARTED REVVING UP AND TOOK OFF AT A VERY HIGH RATE OF SPEED WHILE MY FOOT WAS PUSHING THE BRAKE PEDAL DOWN AS HARD AS I COULD. I THEN COULD NOT SLOW IT DOWN AT THE NEXT LIGHT ENOUGH TO MAKE THE RIGHT TURN SAFELY. I HAD TO MAKE A U TURN WITH BOTH FEET ON THE BRAKES AND AFTER PUTTING THE TRUCK IN NEUTRAL AND PUSHING THE EMERGENCY BRAKE, I HAD TO PUT THE TRUCK INTO NEUTRAL AND CUT OFF THE ENGINE TO TURN INTO THE PARKING LOT WHERE I WORK. I THOUGHT MAYBE I HAD HIT THE ACCELERATOR BY ACCIDENT AND HAD A CO-WORKER WATCH AS I CRANKED UP THE TRUCK IN NEUTRAL. THE TIRES WERE SPINNING LIKE CRAZY AND THE RPMS WERE WAY UP. I HAD TO TURN THE CAR OFF QUICKLY AS WITH THE PARKING BRAKE ON AND BOTH FEET ON THE BRAKES, IT FELT LIKE THE TRUCK WAS GOING TO TAKE OFF AT ANY TIME. MY TRUCK IS PARKED WITH THE CHECK ENGINE LIGHT ON AND I AM SCARED TO GET NEAR THE [XXX] THING. I HAVE A CALL INTO MY MECHANIC NOW. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10310867February 16, 2010
POWER TRAIN:AUTOMATIC TRANSMISSION
TRANS SHIFT PROBLEM 1ST TO 2ND SHIFT HARD SHIFT STARTED ABOUT 3 MONTHS AGO 2001 FORD RANGER 4X4 ,STARTED ONLY DOING IT ON COLD STARTS NOW DOES IT ALL THE TIME COLD OR HOT HAVE TO LET OFF ACCELERATOR TO GET TO SHIFT OR MANUALLY SHIFT FROM SHIFT LEVER.OVERDRIVE LIGHT FLASHES AS SOON AS IT SLAMS INTO GEAR ,TRANS SLIP. FORD HAS HAD ON GOING PROBLEMS WITH TRANS. BEEN A AUTO TECH FOR FORD FOR MANY YEARS ITS TIME TO HAVE FORD LOOK AT THE ON GOING PROBLEMS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10302334January 26, 2010
VEHICLE SPEED CONTROL, ENGINE AND ENGINE COOLING
TL*THE CONTACT OWNS A 2001 FORD RANGER. WHILE APPROACHING A STOP SIGN, THE ENGINE WOULD IDLE VIOLENTLY AND ACT AS IF IT WOULD CONTINUE TO ACCELERATE. THE CONTACT HAD TO DEPRESS THE BRAKE PEDAL WITH EXTREME FORCE IN ORDER TO PREVENT THE VEHICLE FROM MOVING FORWARD. THE DEALER COULD NOT DETERMINE THE REASON BEHIND THE FAILURE. SEVERAL REPAIRS, UNKNOWN TO THE CONTACT WERE MADE TO THE VEHICLE; HOWEVER, TO DATE, THE FAILURE PERSISTS. THE FAILURE MILEAGE WAS 130,000 AND THE CURRENT MILEAGE WAS 140,000. UPDATED 02/23/10. *LJ THE CONSUMER ALSO STATED THE ENGINE WOULD STALL. UPDATED 08/12/10
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Ranger