Ford F-350 Complaints (2019)

467 consumer complaints on file.

#11463653May 6, 2022
STEERING
The steering linkage damper fail. Yes it is available. Pulling a boat trailer on the 40 and had significant unstable steering. But was able to slow down and regain control. Yes confirmed by a dealer. No warning lights but we requested replacement at dealership last week and was told that it was fine and they would not replace unless it completely failed. Started A couple weeks previous to dropping at dealership.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11463317May 4, 2022
STEERING, SUSPENSION, UNKNOWN OR OTHER
The Famous Ford Death Wobble....comes and goes mainly when running speed limit on hwy and come to a bridge or hump in road...feels like your going to loose control...sometimes its so bad have to pull over..It puts myself and employees at risk plus could easily put others in danger.... Have contact ford dealer....first time took in they said tech couldnt get it to do it have another appointment because it seems to be happening more and more...just getting upset paying this much for a truck and there is so recall yet to fix...common problem its all over the internet, no lights of any kind and yes available for inspection. Truck has done it here and there since 15000 miles and only has 34000 on it now
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11463343May 4, 2022
STEERING, SUSPENSION
On several occasions while driving at highway speeds (60 and above) the vehicle begins to violently shake after crossing over uneven pavement such as expansion joints or rough spots, ( Death Wabble) The only way to stop the shaking is to slow down to about 20 mph. Doing this in the middle of freeway traffic is extremely dangerous and quite alarming. After the first couple of times the dealer replaced the steering dampening system 6months ago,, it solved the problem for a time but it has now begun again. The vehicle has only 33,000 miles on it, unfortunately this is the 2nd ford f-350 I have had this problem with the first one was a 2012, the dealer had rebuilt the front end twice to try and solve the problem both time it worked for awhile and then returned. When I traded it in for the new 2019 i was assured ford no longer had the problem. This issue seems to be very common with these trucks and Ford should address the issue before there are serious accidents as a result of this issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11463062May 2, 2022
UNKNOWN OR OTHER
UNKNOWN. Death wabble!!! Very scarry, I am concerned that this wabble is going to cause a serious accident and injury to me and others on the road. Also, serious damage to my truck.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11463111May 2, 2022
STRUCTURE:BODY:TAILGATE
The contact owns a 2019 Ford F-350. The contact stated while driving approximately 5 MPH, the tailgate opened automatically. There were no warning lights. The vehicle was taken to the local dealer and diagnosed with a faulty tailgate. The tailgate was rewired; however, the failure reoccurred consistently. The manufacturer was not notified of the failure. The approximate failure mileage was 44,473.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11459797April 6, 2022
SUSPENSION
“Death Wobble” Several times I have had a mild bump in the road and almost completely lost control of the truck. The entire truck begins vibrating violently and I have to break hard to regain control.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11458012March 23, 2022
SUSPENSION
Driving the truck, 2019 F350 with 9935 miles, at over 60 MPH on a highway and striking two or more small bumps, like on a bridge entry. The whole steering wheel shakes violently and I cannot hold it. The front end of the vehicle shakes as well and feels like it is coming apart. I have to slow down to 20 MPH or less to get the shaking to stop. I am an ASE mechanic and I have never seen something like this. It is like the front end "harmonizes" with the shaking and will not stop at speed. The situation is extremely dangerous as I cannot hold the wheel because of the violent shaking and to slow down and stop in traffic is also dangerous. I cannot imagine if I was towing something...SO DANGEROUS! I looked online and found the exact written symptoms and in videos. They call the the "front end death wobble". It appears to be a known issue and Ford has not done a recall. I cannot believe I paid $60k plus for a truck and it has less than 10k miles and feels like it is coming apart when the shaking happens. When the wheels shake I cannot control the steering at all. At 60 plus MPH this is EXTREMELY dangerous and can cause an accident very easily. I am attempting to get into the dealer but they say they can't see it until May? No warning lamps come on and once the vehicle slows and the shaking stops it "acts fine" until you are going highway speed and hit another bump. This has happened twice now. All similar circumstances. PLEASE HELP!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11457209March 18, 2022
WHEELS
Rims crack around air stem. Airing up tires daily. Dealership welded 1 rim to stop wheel leak. We have a Dually truck 4 of the wheels cracked and leak. We fill tires with air daily.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11456479March 13, 2022
SUSPENSION, STEERING
My truck has a front suspension problem, known as "death wobble." I tried to search death wobble on the Ford website, but did not find any results. I was traveling on an interstate highway yesterday, when I encountered some bumps in the road surface. Upon hitting the bumps my truck started to violently shake (oscillate) in the front end and would not stop till the truck went from about 60 mph to 40 mph. Meanwhile I was in the middle of traffic traveling on the interstate with cars/trucks behind and on either side of my truck. Luckily there was no collision. This happened three times yesterday, while I was driving my family. My family was visible shaken by these occurrences. Yesterday's occurrences were the 7th or 8th time this has happened. The first started around 5000 or so miles. I have been driving this vehicle with this problem. I have not yet scheduled an appointment with a Ford dealer but, will do so in the coming weeks. I have another complaint. I have a transient sensor problem, which occurs once every few weeks, for no apparent reason. I will be driving the truck and all of a sudden, I will get a series of messages including these: service advance track check brakes hill decent not available pre-collision not available The brakes continue to operate, but the other features are not available, as far as I can tell. While I did like this truck when I first receive it, now I feel that either Ford needs to fix this truck or give me my money back.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11455834March 9, 2022
SUSPENSION
The contact owns a 2019 Ford F-350. The contact stated that while driving approximately 60 MPH, the vehicle experienced the death wobble. The failure recurred while driving approximately 50 MPH. The vehicle was taken to the local dealer however, the mechanic was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 30,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11455350March 5, 2022
SUSPENSION
My truck developed a severe steering problem. It is called the “Death Wobble” and is a harmonic vibrating and shaking of the front end and steering wheel. While traveling down highway 93 near Kingman AZ we experienced the first episode. It starts when the truck crosses over an uneven joint in the pavement or something like that. It happens while going about 65 MPH and starts vibrating and gets continually worse and shakes. The only way to stop it is to slow down to 50 MPH. A couple hours later it did it again on Highway 10 just south of Phoenix. The car behind me almost rear ended me while I was braking hard to get rid of the Death Wobble. TOn the road to Corpus Christie, it did the Death Wobble three times. Two were relatively minor, but one was a hard shaking that really scared us. On the return trip we had an episode that made us both think we were going to die. We were going from Kerrville TX to Las Cruces NM. We were on Highway 10 near Sierra Blanca on a downhill going into a valley. The truck was in cruise control to keep the downhill speed constant. We hit three uneven pavement joints that were close together. The three jolts started violent shaking in the front end. It was hard to hold the steering wheel straight. Suddenly the cruise control went to wide open throttle. I was on the brakes already but now the truck was picking up speed. The brakes had little to no effect on slowing us down. Now at 75 MPH I am pressing the cruise control to turn it off but it does nothing. 80 MPH and I’m trying tow-haul, shut off cruise control, parking brake, but still gaining speed. Finally, I put the truck in neutral and we started to get under control and slow down. I gradually eased onto the shoulder of Highway 10 and rolled to a stop. The Engine is still running wide open at 3800 RPM. I shut off the engine and took a few deep breaths I have never been in such an out-of-control situation in my life. We were both scared to death. On the the trip we had nine more episodes.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11455191March 4, 2022
SUSPENSION
The front end suspension system , and it is available for inspection. The vehicle will not stay in one lane when crossing any uneven surfaces, potholes, or road transitions. Upon contact the wheels will bounce, skip, and turn immediately and sharply and can be felt on the steering wheel. Corrections have to be made with a tight grip on the wheel or the car will in fact turn sharply, and it has. This is in itself will cause a life threatening accident, especially when hauling large trailers as is expected of this vehicle, to include total loss of business and personal property in equipment being hauled. The problem has not been preproduced or confirmed, yet. It is currently at the independent mechanic shop to inspect and execute preventative repairs. The issue has occurred more than once while I have been driving the truck, every time the surfaces aforementioned come into contact. Component has not been inspected by manufacturer, police, or insurance, yet. We are executing preventative repairs prior to an accident as a result of this issue that has been reported to be lethal or a total loss as a result. I have found that this very issue commonly found in large trucks and Jeeps. There are no warning lamps or lights to indicate the experienced "wobble". The symptoms started only one week after purchasing the truck with only approximately 53,000 miles on it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11454897March 2, 2022
SUSPENSION
Driving down the road on highway hit a slight bump and the whole front end started bouncing (death wobble). Vehicle was uncontrollable and had to come to a complete stop before vehicle front end would stop bouncing. Took to dealer and they replaced the steering damper. I don’t know if this fixed it yet but everything I am reading says it only fixes it for a short period then it comes back. This would suggest there is a different issue that is causing the damper to fail. I only have 11000 miles in vehicle and only used for highway use.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11454692March 1, 2022
LATCHES/LOCKS/LINKAGES:TAILGATE:LOCK
The contact owns a 2019 Ford F-350. The vehicle had previously been serviced under the Manufacturer Campaign Number: 19S48. The contact stated that while hauling a trailer, there was an abnormal sound coming from the vehicle, and the contact noticed that the tailgate had unexpectedly opened. The vehicle was taken to the dealer. The dealer took pictures of the vehicle and forwarded them to the manufacturer. The vehicle was not repaired. The manufacturer was made aware of the failure but declined the tailgate replacement since the damage happened after the recall was repaired. The failure mileage was approximately 42,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11453279February 21, 2022
STEERING, SUSPENSION
While driving straight down the freeway at about 60mph I drove across an expansion joint and the front of the vehicle began to vibrate violently. I had to slow down quickly to 40mph before it returned to a controlled vehicle. This also happened one time previously while passing over rough pavement in a construction zone at a speed closer to 45mph and it dissipated more quickly, because of lower speed in my opinion. This vehicle has almost always had an erratic reaction to rough pavement at highway speeds, but prior to these two occurrences it has been manageable. My safety and others was put at risk because I had a vehicle that I could not control and I had to brake suddenly in high speed traffic to regain control. The vehicle traveling beside me on the freeway was very anxious to get me to pull over and was making all kinds of gestures trying to show what he had seen. There were no warning lights, symbols or alarms. The vehicle is still under warranty and is currently at the dealership for service. Based on my research it is doubtful they will be able to make a long term fix. this is something that should definitely receive a recall not and federal oversite to insure the safety of hundreds of thousands of trucks.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11452068February 15, 2022
STEERING
Massive vibration/wobbling front end occurred on freeway 15 San Diego Dec., 28, 2021. Had to pull over and stop in the shoulder. Massive vibration/wobbling continued. Took into Ford Penske with mileage 39,304 on Jan 13, 2022: Ford Penske replaced steering damper. Unsure if the original factory installed damper is still available for inspection upon request at Penske? My wife and my safety and others on the 15 freeway were for sure put at risk. Then on Jan 28, 2022 the wobble and vibration returned while traveling from San Diego to Utah. I had to take the truck to Provo Larry Miller Ford and they replaced the tires which only had 35,000 on them and also replaced again the steering damper! This problem has been re-confirmed by the Ford Provo dealership. The check engine light also came on - Provo Ford diagnosed as a steering/suspension/vibration problem condition. I am now taking (Feb., 2022) to Off-Road Warehouse to have a much higher quality steering damper installed and 4 high quality shocks. Conclusion: the vibration/wobbling has caused extreme risk to my wife and me; this will be the 4th damper installed; caused pre-mature wear on the tires (they only lasted 35,000 miles - the tires cost $2,200). The new tires installed by Provo Ford cost - $1,279.80.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11451150February 9, 2022
SUSPENSION
I was driving the 2019 Ford F-350 XLT ( 027506.7 miles on odometer) on I 94 highway west of Detroit at highway speeds (65-70 mph). Highway had rough/spalling pavement due to winter freeze cycles. Vehicle hit rough patch of highway and vehicle started to violently started to shake and wobble while at the same time steering control of the vehicle was minimal and non responsive. I was able to slow down and eventually get the vehicle off on the shoulder of the highway where the shaking and wobble eventually stopped at slow speed. The incident of shake, wobble and loss of control was repeated on the east bound lane returning to my residence (different stretch of highway mileage). Again this loss of control due to the violent shaking and wobble required slowing down to well below posted speed and getting on to the shoulder of the highway. It took approximately between a quarter to one half of a mile to regain control of the vehicle and have the shaking/ shudder stop. In my view this imposes an extreme safety hazard.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11450276February 3, 2022
SUSPENSION, STEERING
Whenever I hit a bump the front end starts wobbling. The steering wheel shakes. This has been known as the "death wobble". You have to come to a complete stop for it to quit. This can cause accidents as it happens at random times. It has happened on four different occasions thus far.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11449779February 1, 2022
STEERING
For the 2nd time in 14 months my truck experienced violent steering oscillation after driving over an expansion joint on a highway bridge at 65 MPH. My truck was repaired after the 1st occurrence by replacing the steering dampener, I'm currently waiting to get my truck into the dealership to address this issue again. It gives me pause to think of what would happen if i was towing my 5th wheel camper & this issue presented its self.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11449366January 29, 2022
SEAT BELTS:FRONT
Seat belt locks and will not allow movement while driving causing the driver to be pinned against the seat under normal driving conditions.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-350