Ford Expedition Service Bulletins (2020)

177 manufacturer communications on file.

• May 12, 2021•Document ID: 10194413

  Service Bulletin/Repair Instructions
  ELECTRICAL SYSTEM; COMMUNICATION:MANUFACTURER TELEMATICS

  Mfr Comm. #:

  SSM 49795

  Date Added:

  June 1, 2021

  Manufacturer:

  FORD

  Summary

  Some 2018-2021 Ford and Lincoln vehicles may not be able to perform remote commands via the FordPass/LincolnWay App due to an erroneous deep sleep message. If the vehicle has been driven within 14 days and the battery state of charge is above 9.5 volts when the deep sleep message set, this is an erroneous message. Starting and running the vehicle will clear the message and allow the remote commands to function again. Inform customers that engineering is currently working on a solution for this condition that will be released via an over the air (OTA) update that is expected in June 2021. Replacement or reprogramming of the telematics control unit (TCU)/gateway module (GWM) will not resolve this condition. Monitor OASIS for additional information and schedule service appointments for customers once the repair becomes available.

  Associated Products (60)

  2021 Ford Bronco Sport2021 Ford Edge2021 Ford Expedition2021 Ford Explorer2021 Ford F-1502021 Ford F-2502021 Ford F-3502021 Ford F-4502021 Ford F-5502021 Ford Mustang2021 Ford Ranger2021 Lincoln Aviator2021 Lincoln Corsair2021 Lincoln Nautilus2021 Lincoln Navigator2020 Ford Edge2020 Ford Expedition2020 Ford Explorer2020 Ford F-1502020 Ford F-250+ 40 more
  Associated Documents

  • DownloadMC-10194413-0001.pdf↗
• April 28, 2021•Document ID: 10191521

  Service Bulletin/Repair Instructions
  BACK OVER PREVENTION:SOFTWARE

  Mfr Comm. #:

  SSM 49756

  Date Added:

  May 3, 2021

  Manufacturer:

  FORD

  Summary

  Some 2018-2021 vehicles supported by FDRS may not list a software update for a module under the SW Updates tab although an SSM or TSB is published for a software update. This may be due to the module already being at the latest software level. A later software level may have been programmed at the assembly plant, during a previous dealer visit or by an over the air (OTA) update for vehicles that have automatic updates enabled in the SYNC system settings. To review a vehicle's OTA update history, visit the Connected Vehicle > OTA Dashboard tab in OASIS. Information about the OTA Dashboard can be found on FMCDealer.com when performing a search on OTA History Job Aid.

  Associated Products (57)

  2021 Ford Bronco Sport2021 Ford Edge2021 Ford Escape2021 Ford Expedition2021 Ford Explorer2021 Ford F-1502021 Ford F-2502021 Ford F-3502021 Ford F-4502021 Ford F-5502021 Ford Mustang2021 Ford Mustang Mach-E2021 Ford Ranger2021 Ford Transit2021 Lincoln Aviator2021 Lincoln Corsair2021 Lincoln Nautilus2021 Lincoln Navigator2020 Ford Edge2020 Ford Escape+ 37 more
  Associated Documents

  • DownloadMC-10191521-0001.pdf↗
• April 15, 2021•Document ID: 10191176

  Service Bulletin/Repair Instructions
  ENGINE AND ENGINE COOLING

  Mfr Comm. #:

  TSB 21-2119

  Date Added:

  May 4, 2021

  Manufacturer:

  LINCOLN

  Summary

  Some 2017-2020 F-150 2018-2020 Expedition/Navigator vehicles built on or before 31-Oct-2019 and equipped with a 3.5L EcoBoost engine may exhibit a ticking/tapping or rattle type noise from the top front cover area of the engine on initial start-up after a cold soak of 6 hours or more that may last for 2-5 seconds. This may be due to a worn variable cam timing (VCT) unit. To correct the condition, follow the Service Procedure steps to replace the VCT units.

  Associated Products (10)

  2020 Ford Expedition2020 Ford F-1502020 Lincoln Navigator2019 Ford Expedition2019 Ford F-1502019 Lincoln Navigator2018 Ford Expedition2018 Ford F-1502018 Lincoln Navigator2017 Ford F-150
  Associated Documents

  • DownloadMC-10191176-0001.pdf↗
• April 7, 2021•Document ID: 10191067

  Service Bulletin/Repair Instructions
  POWER TRAIN

  Mfr Comm. #:

  SSM 49724

  Date Added:

  May 3, 2021

  Manufacturer:

  FORD

  Summary

  Some 2018-2021 Expedition/Navigator vehicles equipped with electronic limited slip differential (ELSD) rear axle may exhibit an illuminated powertrain malfunction (wrench) indicator with diagnostic trouble code (DTC) P0932:17. Check the condition of the wiring harness and connections at the ELSD and the differential control module rear (DCMR). If no problems are found, clear the DTC and test drive. If the condition returns, refer to Workshop Manual (WSM), Section 308-07A.

  Associated Products (8)

  2021 Ford Expedition2021 Lincoln Navigator2020 Ford Expedition2020 Lincoln Navigator2019 Ford Expedition2019 Lincoln Navigator2018 Ford Expedition2018 Lincoln Navigator
  Associated Documents

  • DownloadMC-10191067-0001.pdf↗
• March 29, 2021•Document ID: 10189610

  Service Bulletin/Repair Instructions
  ELECTRICAL SYSTEM

  Mfr Comm. #:

  SSM 49708

  Date Added:

  March 31, 2021

  Manufacturer:

  FORD

  Summary

  Some 2018-2019 F-150/F-Super Duty/Expedition/Navigator and 2020 Explorer/Aviator vehicles may exhibit a 'Trailer Connected' or 'Trailer Disconnected' message in the vehicle's message center with no trailer attached to the vehicle. To address this condition, reprogram the trailer module (TRM) using the appropriate Ford diagnostic scan tool. For claiming use causal part 19H332 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual.

  Associated Products (24)

  2020 Ford Expedition2020 Ford Explorer2020 Ford F-1502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford Transit2020 Lincoln Aviator2020 Lincoln Navigator2019 Ford Expedition2019 Ford F-1502019 Ford F-2502019 Ford F-3502019 Ford F-4502019 Ford F-5502019 Lincoln Navigator2018 Ford Expedition2018 Ford F-1502018 Ford F-250+ 4 more
  Associated Documents

  • DownloadMC-10189610-0001.pdf↗
• March 25, 2021•Document ID: 10189581

  Service Bulletin/Repair Instructions
  ELECTRICAL SYSTEM

  Mfr Comm. #:

  SSM 49690

  Date Added:

  March 31, 2021

  Manufacturer:

  LINCOLN

  Summary

  For 2018-2021 EcoSport/Expedition/Navigator, 2019-2021 Ranger/Transit Connect, 2020-2021 Escape/Explorer/SuperDuty/Transit/Aviator/Corsair, 2021 Bronco Sport/F-150/Mustang/Mach-E the Workshop Manual (WSM) diagnostics may direct to replace a module on vehicles that use Ford Diagnosis and Repair System (FDRS). First, an FDRS session must be created on the vehicle prior to removing the faulted module. Once the session is started, run the Programmable Module Installation and replace the module only when instructed by FDRS. Installing a new module prior to starting a scan tool session may result in incomplete module configuration with DTCs U2100, U2101 and/or U2200. Once a session has been started, continue to follow normal WSM procedures to repair the vehicle.

  Associated Products (40)

  2021 Ford Bronco Sport2021 Ford Ecosport2021 Ford Escape2021 Ford Expedition2021 Ford Explorer2021 Ford F-1502021 Ford F-2502021 Ford F-3502021 Ford F-4502021 Ford F-5502021 Ford Mustang2021 Ford Mustang Mach-E2021 Ford Ranger2021 Ford Transit2021 Ford Transit Connect2021 Lincoln Aviator2021 Lincoln Corsair2021 Lincoln Navigator2020 Ford Ecosport2020 Ford Escape+ 20 more
  Associated Documents

  • DownloadMC-10189581-0001.pdf↗
• February 23, 2021•Document ID: 10188010

  Service Bulletin/Repair Instructions
  ELECTRICAL SYSTEM; POWER TRAIN

  Mfr Comm. #:

  SSM 49618

  Date Added:

  March 3, 2021

  Manufacturer:

  FORD

  Summary

  Some 2018-2021 F-150, Expedition, Navigator, Transit, Aviator and Explorer vehicles may exhibit an illuminated MIL with DTC P025A And/Or DTC U0109 stored in the powertrain control module (PCM). This may be due to an intermittent or partial disconnect of the harness to the fuel pump control module (FPCM) connector, connector pin push-outs or loose/corroded grounds. Inspect FPCM connector, applicable grounds(F-150- G401, Expedition/Navigator- G403, Transit- G401, 2018-2019 Explorer G302, 2020-2021 Explorer/Aviator- G407) and confirm FPCM connector (F-150- C4336, Expedition/Navigator- C433, Transit- C433, 2018-2019 Explorer C3239, 2020-2021 Explorer/Aviator- C4033) is fully seated prior to performing PC/ED diagnostics or replacing any components.

  Associated Products (21)

  2021 Ford Expedition2021 Ford Explorer2021 Ford F-1502021 Lincoln Aviator2021 Lincoln Navigator2020 Ford Expedition2020 Ford Explorer2020 Ford F-1502020 Ford Transit2020 Lincoln Aviator2020 Lincoln Navigator2019 Ford Expedition2019 Ford Explorer2019 Ford F-1502019 Ford Transit2019 Lincoln Navigator2018 Ford Expedition2018 Ford Explorer2018 Ford F-1502018 Ford Transit+ 1 more
  Associated Documents

  • DownloadMC-10188010-0001.pdf↗
• February 3, 2021•Document ID: 10187930

  Service Bulletin/Repair Instructions
  EQUIPMENT

  Mfr Comm. #:

  SSM 49541

  Date Added:

  March 3, 2021

  Manufacturer:

  FORD

  Summary

  Some 2018-2020 Ford and Lincoln vehicles equipped with TCU and WiFi Hotspot, May display Vehicle Hotspot feature not enabled on this vehicle when attempting to enter the Hotspot menu. When using the FordPass/Lincoln Way application, the customer may receive a message saying Wi-Fi has been disabled from this vehicle. Check the vehicle specifications or vehicle build information for the mfal code on the PTS website (Detailed Vehicle Specifications). If mfal = WAFAC or WAFAB do not replace the TCU, engineering is currently investigating this condition. Inform customers Ford is developing a software fix that is expected in early March. In the interim, let the customer know they can continue to drive the vehicle and schedule a follow-up appointment with the customer for early March. Monitor OASIS for updates.

  Associated Products (69)

  2020 Ford Ecosport2020 Ford Edge2020 Ford Escape2020 Ford Expedition2020 Ford Explorer2020 Ford F-1502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford Fusion2020 Ford Mustang2020 Ford Ranger2020 Ford Transit2020 Lincoln Aviator2020 Lincoln Continental2020 Lincoln Corsair2020 Lincoln MKX2020 Lincoln MKZ2020 Lincoln Nautilus+ 49 more
  Associated Documents

  • DownloadMC-10187930-0001.pdf↗
• January 5, 2021•Document ID: 10186563

  Service Bulletin/Repair Instructions
  EQUIPMENT

  Mfr Comm. #:

  SSM 49426

  Date Added:

  February 4, 2021

  Manufacturer:

  FORD

  Summary

  Some 2020 Ford and Lincoln vehicles may exhibit the vehicle locator feature display the vehicle location incorrectly when using the Ford Pass/Lincoln Way mobile app. Customers may report that the vehicle location that is displayed is the Ford manufacturing facility were the vehicle was assembled, yet all other features work as intended. This may be due to the vehicle location not updating since assembly. If all other Ford Pass/Lincoln Way features work correctly except for the vehicle location, open the customer connectivity settings on the SYNC display and verify that the location setting is enabled. If the setting is currently enabled, disable and then re-enable the feature. If the vehicle location is still displayed incorrectly in the app, follow Workshop Manual section 415-00 for further diagnosis.

  Associated Products (20)

  2020 Ford Ecosport2020 Ford Edge2020 Ford Escape2020 Ford Expedition2020 Ford Explorer2020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford Fusion2020 Ford Mustang2020 Ford Ranger2020 Ford Transit2020 Ford Transit Connect2020 Lincoln Aviator2020 Lincoln Corsair2020 Lincoln MKX2020 Lincoln MKZ2020 Lincoln Nautilus2020 Lincoln Navigator
  Associated Documents

  • DownloadMC-10186563-0001.pdf↗
• December 22, 2020•Document ID: 10184782

  Service Bulletin/Repair Instructions
  EQUIPMENT; ELECTRICAL SYSTEM; WHEELS

  Mfr Comm. #:

  SSM 49418

  Date Added:

  January 4, 2021

  Manufacturer:

  FORD

  Summary

  Some 2020 Expedition/Navigator vehicles built on or after 19-Oct-2020 and equipped with four-wheel drive will keep the integrated wheel end (IWE) hubs engaged under all operating conditions. Although the IWE vacuum solenoid is still present, these vehicles may not be equipped with an electrical connector for the IWE vacuum solenoid. This is a characteristic of the vehicle. Do not attempt any repairs for this condition.

  Associated Products (2)

  2020 Ford Expedition2020 Lincoln Navigator
  Associated Documents

  • DownloadMC-10184782-0001.pdf↗
• November 24, 2020•Document ID: 10183394

  Service Bulletin/Repair Instructions
  ENGINE AND ENGINE COOLING; EQUIPMENT

  Mfr Comm. #:

  SSM 49355

  Date Added:

  December 4, 2020

  Manufacturer:

  FORD

  Summary

  Some 2015-2020 F-150 and 2018-2020 Expedition/Navigator vehicles equipped with a 3.5L/2.7L EcoBoost engine and four-wheel drive (4WD) may exhibit an intermittent grinding type noise while driving in two-wheel drive (2WD), most commonly on acceleration. This noise could appear to be turbocharger related. After engineering analysis of returned turbochargers that have been replaced for this condition, no concerns were identified with the turbochargers. The grinding type noise may be related to the 4WD system integrated wheel ends (IWE). To aid in diagnosis, shift the vehicle to 4WD and attempt to verify the condition. If the grinding noise no longer occurs with the vehicle in 4WD a IWE vacuum system and/or mechanical fault may be present.

  Associated Products (12)

  2020 Ford Expedition2020 Ford F-1502020 Lincoln Navigator2019 Ford Expedition2019 Ford F-1502019 Lincoln Navigator2018 Ford Expedition2018 Ford F-1502018 Lincoln Navigator2017 Ford F-1502016 Ford F-1502015 Ford F-150
  Associated Documents

  • DownloadMC-10183394-0001.pdf↗
• November 6, 2020•Document ID: 10183405

  Service Bulletin/Repair Instructions
  EQUIPMENT; ELECTRICAL SYSTEM; ELECTRICAL SYSTEM:ADAS:HUD:CAMERA/SENSOR

  Mfr Comm. #:

  20B39

  Date Added:

  December 5, 2020

  Manufacturer:

  FORD

  Summary

  Certain 2020 Model Year Multiple Vehicle Lines Front View and Center High Mount Stop Lamp Camera Improper Function In some of the affected vehicles, insufficient electrical conductivity within the Printed Circuit Board (PCB) internal to the camera may lead to intermittent front view or Center High Mount Stop Lamp (CHMSL) camera operation. This could result in a blank or distorted image from the front of the vehicle or of the truck bed Dealers are to replace the front view camera or the CHMSL camera following the dealer bulletin technical information. This service must be performed on all affected vehicles at no charge to the vehicle owner.

  Associated Products (9)

  2020 Ford Edge2020 Ford Expedition2020 Ford F-1502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford Transit2020 Lincoln Nautilus
  Associated Documents

  • DownloadMC-10183405-0001.pdf↗
• October 29, 2020•Document ID: 10181931

  Service Bulletin/Repair Instructions
  ELECTRICAL SYSTEM:SOFTWARE; POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

  Mfr Comm. #:

  SSM 49292

  Date Added:

  November 4, 2020

  Manufacturer:

  FORD

  Summary

  Some 2018-2020 Ford and Lincoln vehicles may exhibit inoperative remote features via the Ford Pass/Lincoln Way mobile app, incomplete user authorization, no modem electronic serial number (ESN) displayed or DTCs U2100 and/or B156D in the telematics control unit (TCU). These symptoms may persist even after performing a TCU software update and/or replacement. To correct this condition, start a new session with the latest version of the appropriate diagnostic scan tool and perform a PMI on the TCU. If issues persist, open a hotline assistance request and include the IDS version (if applicable) used to perform the PMI and the Authorization Status PID value in the TCU datalogger. For claiming use causal part 14H092 and applicable labor times in Section 10 of the Service Labor Time Standards (SLTS) Manual.

  Associated Products (49)

  2020 Ford Edge2020 Ford Expedition2020 Ford F-1502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford Fusion2020 Ford Mustang2020 Ford Ranger2020 Lincoln Aviator2020 Lincoln Continental2020 Lincoln Corsair2020 Lincoln MKX2020 Lincoln MKZ2020 Lincoln Nautilus2020 Lincoln Navigator2019 Ford Edge2019 Ford Escape2019 Ford Expedition+ 29 more
  Associated Documents

  • DownloadMC-10181931-0001.pdf↗
• October 26, 2020•Document ID: 10181913

  Service Bulletin/Repair Instructions
  EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL; ELECTRICAL SYSTEM:SOFTWARE

  Mfr Comm. #:

  SSM 49284

  Date Added:

  November 4, 2020

  Manufacturer:

  FORD

  Summary

  Some 2018-2020 Ford and Lincoln vehicles equipped with TCU and WiFi Hotspot, May display Vehicle Hotspot feature not enabled on this vehicle when attempting to enter the Hotspot menu. When using the FordPass/Lincoln Way application, the customer may receive a message saying Wi-Fi has been disabled from this vehicle. Check the vehicle specifications or vehicle build information for the mfal code. If mfal = WAFAC or WAFAB do not replace the TCU, engineering is currently investigating this condition. Inform customers Ford is developing a software fix that is expected in early January. In the interim, let the customer know they can continue to drive the vehicle and schedule a follow-up appointment with the customer for early January. Once the update becomes available, contact the customer and confirm the service appointment is going forward. Monitor OASIS for updates.

  Associated Products (71)

  2020 Ford Ecosport2020 Ford Edge2020 Ford Escape2020 Ford Expedition2020 Ford Explorer2020 Ford F-1502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford Fusion2020 Ford Mustang2020 Ford Ranger2020 Ford Transit2020 Ford Transit Connect2020 Lincoln Aviator2020 Lincoln Continental2020 Lincoln Corsair2020 Lincoln MKX2020 Lincoln MKZ+ 51 more
  Associated Documents

  • DownloadMC-10181913-0001.pdf↗
• October 26, 2020•Document ID: 10181912

  Service Bulletin/Repair Instructions
  ELECTRICAL SYSTEM:SOFTWARE; EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

  Mfr Comm. #:

  SSM 49283

  Date Added:

  November 4, 2020

  Manufacturer:

  LINCOLN

  Summary

  Some 2017-2020 Ford and Lincoln vehicles equipped with a telematics control unit (TCU) may exhibit incomplete user authorization, inoperative remote features and/or a message stating the system cannot access the Lincoln/FordPass Connect feature in the application due to being a fleet vehicle. Replacing the TCU will not resolve this condition. Engineering is currently investigating this condition. Inform customers Ford is developing a software fix that is expected in early January. In the interim, let the customer know they can continue to drive the vehicle and schedule a follow-up appointment with the customer for early January. Once the update becomes available, contact the customer and confirm the service appointment is going forward. Monitor OASIS for updates.

  Associated Products (19)

  2020 Ford Ecosport2020 Ford Edge2020 Ford Escape2020 Ford Expedition2020 Ford Explorer2020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford Fusion2020 Ford Mustang2020 Ford Ranger2020 Ford Transit2020 Lincoln Aviator2020 Lincoln Corsair2020 Lincoln MKX2020 Lincoln MKZ2020 Lincoln Nautilus2020 Lincoln Navigator
  Associated Documents

  • DownloadMC-10181912-0001.pdf↗
• October 20, 2020•Document ID: 10181924

  Service Bulletin/Repair Instructions
  ELECTRICAL SYSTEM

  Mfr Comm. #:

  TSB 20-2363

  Date Added:

  November 5, 2020

  Manufacturer:

  FORD

  Summary

  Some 2019 MKZ, 2019-2020 EcoSport/Mustang/Continental/Fusion/F-150/Transit Connect/Ranger/Edge/Nautilus and 2020 Escape/Corsair/Aviator/Explorer/Expedition/Navigator/F-Super Duty vehicles with SYNC 3 may experience various SYNC performance related concerns. To correct the condition, follow the Service Procedure.

  Associated Products (37)

  2020 Ford Ecosport2020 Ford Edge2020 Ford Escape2020 Ford Expedition2020 Ford Explorer2020 Ford F-1502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford F-6502020 Ford F-7502020 Ford Fusion2020 Ford Mustang2020 Ford Ranger2020 Ford Transit Connect2020 Lincoln Aviator2020 Lincoln Continental2020 Lincoln Corsair2020 Lincoln Nautilus+ 17 more
  Associated Documents

  • DownloadMC-10181924-0001.pdf↗
• October 16, 2020•Document ID: 10181917

  Service Bulletin/Repair Instructions
  WHEELS; EQUIPMENT; ELECTRICAL SYSTEM

  Mfr Comm. #:

  TSB 20-2307

  Date Added:

  November 5, 2020

  Manufacturer:

  LINCOLN

  Summary

  Some 2003-2020 Expedition/Navigator and 2006-2020 F-150 vehicles equipped with TOD transfer cases may exhibit grinding/clicking/ratcheting noise from the front wheel area. This may be due to partial engagement of the integrated wheel ends (IWE). To correct this condition, follow the Service Procedure steps to remove and cap the vacuum supply line.

  Associated Products (51)

  2020 Ford Expedition2020 Ford F-1502020 Lincoln Navigator2019 Ford Expedition2019 Ford F-1502019 Lincoln Navigator2018 Ford Expedition2018 Ford F-1502018 Lincoln Navigator2017 Ford Expedition2017 Ford F-1502017 Lincoln Navigator2016 Ford Expedition2016 Ford F-1502016 Lincoln Navigator2015 Ford Expedition2015 Ford F-1502015 Lincoln Navigator2014 Ford Expedition2014 Ford F-150+ 31 more
  Associated Documents

  • DownloadMC-10181917-0001.pdf↗
• September 25, 2020•Document ID: 10180428

  Service Bulletin/Repair Instructions
  ENGINE AND ENGINE COOLING

  Mfr Comm. #:

  SSM 49210

  Date Added:

  October 6, 2020

  Manufacturer:

  FORD

  Summary

  Some 2009-2020 Ford and Lincoln vehicles equipped with turbochargers may exhibit an oil leak from the turbocharger oil supply or return tubes, O-rings or 6.7L pedestal gasket. Although oil may collect on the turbocharger, it is very rare for a turbocharger to leak oil. To isolate the source of the leak, refer to Workshop Manual (WSM), Section 303-00 General Information > Diagnosis and Testing > Engine > Engine Oil Leaks - Fluorescent Oil Additive Method procedure. When an oil leak is present at a turbocharger oil supply or drain tube, remove the affected oil tube and inspect for damage, and replace the O-ring seals, pedestal gasket or oil tube as required. Refer to WSM, Section 303-04. For claiming, use the affected oil tube or pedestal gasket as the causal part and applicable labor operations in Sections 6 and 9 of the Service Labor Time Standards (SLTS) Manual.

  Associated Products (150)

  2020 Ford Edge2020 Ford Expedition2020 Ford Explorer2020 Ford F-1502020 Ford Fusion2020 Ford Mustang2020 Ford Ranger2020 Ford Transit2020 Ford Transit Connect2020 Lincoln Aviator2020 Lincoln Continental2020 Lincoln Corsair2020 Lincoln MKX2020 Lincoln MKZ2020 Lincoln Navigator2019 Ford Edge2019 Ford Escape2019 Ford Expedition2019 Ford Explorer2019 Ford F-150+ 130 more
  Associated Documents

  • DownloadMC-10180428-0001.pdf↗
• September 15, 2020•Document ID: 10180531

  Service Bulletin/Repair Instructions
  ENGINE AND ENGINE COOLING

  Mfr Comm. #:

  TSB 20-2315

  Date Added:

  October 2, 2020

  Manufacturer:

  FORD

  Summary

  Some 2017-2020 F-150 2018-2020 Expedition/Navigator vehicles built on or before 31-Oct-2019 and equipped with a 3.5L EcoBoost engine may exhibit a ticking/tapping or rattle type noise from the top front cover area of the engine on initial start-up after a cold soak of 6 hours or more that may last for 2-5 seconds. This may be due to a worn variable cam timing (VCT) unit. To correct the condition, follow the Service Procedure steps to replace the VCT units and update the powertrain control module (PCM) calibration with revised VCT parameters.

  Associated Products (10)

  2020 Ford Expedition2020 Ford F-1502020 Lincoln Navigator2019 Ford Expedition2019 Ford F-1502019 Lincoln Navigator2018 Ford Expedition2018 Ford F-1502018 Lincoln Navigator2017 Ford F-150
  Associated Documents

  • DownloadMC-10180531-0001.pdf↗
• September 9, 2020•Document ID: 10180340

  Service Bulletin/Repair Instructions
  ELECTRICAL SYSTEM:SOFTWARE; BACK OVER PREVENTION: CAMERA SYSTEM; ELECTRICAL SYSTEM

  Mfr Comm. #:

  TSB 20-2301

  Date Added:

  October 1, 2020

  Manufacturer:

  FORD

  Summary

  Some 2019 MKZ, 2019-2020 Mustang/Continental/Fusion/F-150/Transit Connect/ Ranger/Edge/Nautilus and 2020 Escape/Corsair/Aviator/Explorer/Expedition/ Navigator/F-Super Duty vehicles with SYNC 3 may experience various SYNC performance related concerns. To correct the condition, follow the Service Procedure.

  Associated Products (26)

  2020 Ford Edge2020 Ford Escape2020 Ford Expedition2020 Ford Explorer2020 Ford F-1502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford Fusion2020 Ford Mustang2020 Ford Ranger2020 Ford Transit Connect2020 Lincoln Aviator2020 Lincoln Continental2020 Lincoln Corsair2020 Lincoln Nautilus2020 Lincoln Navigator2019 Ford Edge2019 Ford F-150+ 6 more
  Associated Documents

  • DownloadMC-10180340-0001.pdf↗