Ford Escape Complaints (2005)

1,584 consumer complaints on file.

#10427690September 27, 2011
SERVICE BRAKES, HYDRAULIC, ELECTRONIC STABILITY CONTROL (ESC), ELECTRICAL SYSTEM
THE VEHICLE WAS PARKED AND WOULD NOT START. I RECEIVED WARNINGS ON THE DASH AND THE INFORMATION PANEL STATING TO SLOW TO A STOP AND SERVICE THE BRAKES. I WAS ABLE TO START THE VEHICLE AFTER DISCONNECTING THE BATTERY AND EVERYTHING OPERATED NORMALLY. AFTER GETTING HOME AND RUNNING DIAGNOSTICS EVERYTHING CAME BACK NORMAL. LATER THAT DAY THE VEHICLE WOULD NOT START AGAIN WITH THE SAME WARNINGS AND IT WAS MORE AND MORE DIFFICULT TO GET THE VEHICLE WORKING AGAIN. I ALSO NOTICED THAT THE 12V BATTERY SEEMED TO BE LEAKING SO I INSPECTED AND CLEANED IT. THE NEXT DAY (MONDAY) I BROUGHT THE VEHICLE TO THE FORD DEALER AND EXPLAINED THE PROBLEMS INCLUDING THE LEAKING BATTERY. THE DEALER REPLACED THE 12 V BATTERY UNDER WARRANTY AND SAID MY PROBLEMS SHOULD BE FIXED BUT THEY WOULD CHECK FOR FAULT CODES. THE DEALER FOUND ADDITIONAL PROBLEMS WITH THE ABS BRAKE SYSTEM BUT COULD NOT IMMEDIATELY DIAGNOSE THE CAUSE. THE CAR WAS LEFT FOR ANOTHER DAY AND EVENTUALLY I WAS TOLD THAT IT WAS MOST LIKELY THE HYDRAULIC CONTROL UNIT (HCU) WITH WAS APPROXIMATELY A $4500 PART. I HAVE READ STORIES ONLINE THAT THIS IS A FAIRLY COMMON PROBLEM WITH THIS MODEL YEAR ESCAPE HYBRID AND FORD IS AWARE OF THE ISSUE BUT NOT DOING ANYTHING TO CORRECT IT OTHER THAN MAKING THE OWNERS BUY $4500 REPLACEMENT PARTS. *TT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10424395September 8, 2011
SERVICE BRAKES, HYDRAULIC
ABS LIGHT AND BRAKE LIGHT WENT ON HEARD A BEEP AND HAD NO BRAKES WHAT SO EVER . I EVENTUALLY STOPPED BY ENTERING THE CAR IN TO NEUTRAL AND HITTING THE EMERGENCY BRAKE. TURNED THE CAR OFF AND WHEN I TURNED ON AGAIN IT WENT AWAY, MY MECHANIC SAYS ITS GOING TO COST $1000 MASTER CYLINDER NEEDS TO BE REPLACED. THANKS FORD FOR YOUR ASUPPORT WITH THIS OBVIOUS ISSUE YOU NEED TO ADDRESS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10424171September 7, 2011
SERVICE BRAKES, HYDRAULIC
PURCHASED 2005 FORD ESCAPE IN MARCH 2007 WITH ABOUT 80K MILES. WITHIN THE MONTH, THE ABS LIGHT BEGAN TO INTERMITTENTLY COME ON. IT IS NOW SEPTEMBER 2011 AND THE PROBLEM STILL OCCURS AND HAS NOT BEEN SOLVED. HAD OBD II DIAGNOSTIC CODES TESTED. NO CODES FOUND WHILE LIGHT IS ON OR OFF. MANUALLY TURNING OFF THE LIGHT IS ONLY TEMPORARY. THERE ARE NO PHYSICAL PROBLEMS WITH THE BRAKES. FORD SHOULD HAVE THIS RECALLED. PLEASE NOTE THAT WHEN ABS LIGHT IS ON, THERE IS CLICKING THAT CAN BE HEARD AND FELT THROUGH THE BRAKE PEDAL WHILE BRAKING. THE VEHICLE IS SLOW TO STOP. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10424009September 6, 2011
ENGINE AND ENGINE COOLING
CATALYTIC CONVERTERS AND FLEX PIPE THE CATALYTIC CONVERTERS HAVE BEEN DIAGNOSED AS HAVING SIGNIFICANT RESTRICTION TO CAUSE DRAMATIC POWER LOSS TO THE VEHICLE WHILE DRIVING. THIS CONDITION CAUSES ABNORMAL BACK PRESSURES IN THE EXHAUST SYSTEM WHICH ALSO CAUSES MULTIPLE MISFIRES AND SETS THE CHECK ENGINE LIGHT. THE FLEX PIPE IS ALSO DEFECTIVE AND LEAKS. I HAVE OWNED MANY FORD VEHICLES THROUGH THE YEARS. ONE WAS A 1994 LINCOLN TOWN CAR WITH OVER 400,000 MILES. ANOTHER WAS A 1998 TOWN CAR WITH OVER 200,000 MILES. NEVER ONCE DID I HAVE TO REPLACE ANYTHING ON THE EXHAUST SYSTEM,ESPECIALLY CATALYTIC CONVERTERS (THE MOST EXPENSIVE PART IN THE SYSTEM). THIS IS UNACCEPTABLE AND A RECALL NEEDS TO BE INITIATED TO RESOLVE THIS. NOT ONLY IS THIS A SAFETY AND MORAL ISSUE BUT AN ENVIRONMENTAL ON AS WELL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10422884September 1, 2011
LATCHES/LOCKS/LINKAGES
I HAVE A 2005 FORD ESCAPE. WITHIN 12 HOURS BOTH MY REAR DOORS' LATCHES BROKE. THE CAR HAS BEEN WELL TAKEN CARE OF, REGULAR MAINTENANCE, NO ACCIDENT, ETC. OCCURRED TO MAKE THIS HAPPEN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10422826August 31, 2011
SUSPENSION, POWER TRAIN, STEERING
LOUD SQUEAKY NOISE FROM RIGHT FRONT END. TOOK TO MECHANIC. THEY SAY BOTH FRONT GREASE BOOTS ARE CRACKED WHICH ALLOWS DIRT, DUST, ETC. TO GET IN AND UP AROUND THE BALL JOINTS AND TIE ROD ASSEMBLIES. THE RIGHT FRONT BALL JOINT HAD GONE BAD DUE TO THIS BOOT CRACK SO WE HAD TO REPLACE IT. THEY RECOMMEND REPLACING BOTH TIE RODS, BOOTS AND BALL JOINTS, BUT WE COULD ONLY AFFORD TO REPLACE THE BALL JOINT THAT WAS BAD AT THIS TIME BECAUSE WE JUST SPENT $3350 PUTTING A NEW TRANSMISSION IN THE CAR. THIS VEHICLE HAS LESS THAN 50,000 MILES ON IT. UNBELIEVABLE!!!! WHAT IS FORD BUILDING THESE CARS WITH??? I SUSPECT THE CHEAPEST PARTS THEY CAN GET REGARDLESS OF THEIR QUALITY SO THEY CAN MAKE MORE MONEY. IN THE MEANTIME THE AVERAGE WORKING FAMILY HAS TO PAY TWICE FOR A VEHICLE'S PARTS THAT SHOULD NOT GO BAD SO QUICKLY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10418575August 11, 2011
ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 15 MPH, THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSTICS, WHERE THE MECHANIC STATED THAT THE HARD DRIVE IN THE ENGINE CONTROL MODULE FAILED AND THE ENGINE CONTROL MODULE WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10418612August 11, 2011
POWER TRAIN:AUTOMATIC TRANSMISSION
COMPLETE TRANSMISSION FAILURE ON 2005 FORD ESCAPE. THERE WAS NO PRIOR WARNING. WHILE DRIVING IS NORMAL TRAFFIC AT 35 MILES PER HOUR THE CAR STARTED LURCHING, JUMPING AND MAKING ALL KINDS OF AWFUL METALLIC GRINDING SOUNDS. VEHICLE CAME TO A COMPLETE STOP AND WOULD NOT MOVE FORWARD OR IN REVERSE. I TRIED AGAIN A FEW MINUTES LATER AND WAS ABLE TO MOVE THE VEHICLE IN JUMPS AND JERKS AROUND A CORNER TO GET IT OFF OF A MAIN STREET. TRANSMISSION REPAIR GUY SAID IT IS A COMPLETE FAILURE. I HAVE PICTURES OF THE BROKEN PARTS. THIS VEHICLE HAS LESS THAN 50,000 MILES ON IT. WE STILL OWE $10,000 ON IT AND ARE NOW TOLD THAT IT WILL COST $3350.00 FOR A NEW TRANSMISSION. OF COURSE FORD ISN'T WILLING TO HELP WITH THIS COST EVEN THOUGH IT IS OBVIOUS TO ANYONE RESEARCHING IT THAT FORD IS AWARE OF THE FAULTY TRANSMISSIONS THEY ARE USING. BY THE WAY THIS VEHICLE WAS MAINTAINED WITH REGULARLY SCHEDULED MAINTENANCE AND I HAVE THE RECORDS TO PROVE IT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10417028August 4, 2011
SEAT BELTS
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT THE DRIVER SIDE SEAT BELT WOULD NOT UNLATCH WHICH PREVENTED THE CONTACT FROM EXITING THE VEHICLE. THE CONTACT HAD TO CUT THE SEAT BELT IN ORDER TO EXIT THE VEHICLE. THE DEALER DIAGNOSED THAT THE SEAT BELT SENSOR NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 59,850 AND THE CURRENT MILEAGE WAS 60,000. THE VIN WAS UNAVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10417102August 4, 2011
UNKNOWN OR OTHER
I TOOK MY 2005 FORD ESCAPE HYBRID TO THE DEALER ON AUG. 4TH/2011 FOR 30K MAINTENANCE AT A COST OF $715 + $100 COUPON. IMMEDIATELY UPON PICKING UP THE VEHICLE, I NOTICED AN UNUSUAL SLUGGISHNESS ABOUT IT. I DRIVE VERY LITTLE, SO IT TOOK A FEW MORE DAYS (8/4) FOR THE CAR TO BREAK DOWN. IT WAS RUSH-HOUR TRAFFIC, AND CARS WHIZZED BY ME WITH KAMIKAZE MANEUVERS IN A PSYCHOTIC URGE TO PASS ME, AS MY VEHICLE WAS ONLY GOING A FEW MPH. AS THE FREEWAY BEGAN TO RISE, MY CAR SLOWED DOWN EVEN MORE. I THOUGHT IT WAS GOING TO ROLL BACKWARD. I THOUGHT I WAS GOING TO DIE AND KILL OTHERS. IT WAS A NIGHTMARE. I HAD TO FEVERISHLY PUMP THE GAS PEDAL TO GET IT TO THE DEALERSHIP. TODAY (8/4/11) THEY CALLED TO TELL ME THAT THE THROTTLE BODY HAD GONE BAD. I LOOKED IT UP ONLINE, AND IT'S NOT A PART THAT 'GOES BAD'...BUT IT DOES REQUIRE CLEANING. UNFORTUNATELY MAINTENANCE OF THE THROTTLE BODY IS NOT A PART OF FORD'S MAINTENANCE PROTOCOL. I READ MANY OTHER HARROWING STORIES OF PEOPLE WHO HAD NEAR MISSES BECAUSE OF THROTTLE BODY MALFUNCTION. AT LEAST A COUPLE OF PEOPLE EVEN HAD WRECKS. EVENTUALLY SOMEONE IS GOING TO GET KILLED. I DIDN'T EVEN KNOW THERE WAS SUCH A PART IN A CAR...I AM NOT A MECHANIC, BUT IF I PAY HUNDREDS OF DOLLARS FOR ROUTINE MAINTENANCE, I DO EXPECT A MECHANIC TO TAKE CARE OF THE PROBLEM! IT WAS HORRIBLE AND VERY FRIGHTENING. I'M JUST GLAD THAT I DIDN'T HURT ANYONE. FORD NEEDS TO REALIZE THAT THIS PROBLEM WILL EVENTUALLY RESULT IN A FATALITY. I HAVE COMPLAINED TO THE FORD MOTOR CO. COMPLAINT LINE, SO HOPEFULLY THEY WILL LISTEN TO US. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10416460August 1, 2011
WHEELS:LUGS/NUTS/BOLTS/STUDS, WHEELS
2005 FORD ESCAPE. FORD DEALER SERVICE FOR OIL CHANGE, ROTATE TIRES AND BRAKE INSPECTION NOTED FRONT BRAKE PADS NEEDED REPLACED. DECLINED SERVICE, (PRICE) ABLE TO CHANGE FRONT PADS OURSELVES. WE COULD NOT REMOVE WHEEL LUG NUTS. (THE SAME DAY) CHECKED TORQUE AND FOUND DEALER HAD OVER TIGHTENED THE LUG NUTS TO OVER 150 LBS. WITH MUCH EFFORT REMOVED LUG NUTS AND CHANGED FRONT BRAKE PADS. RETURNED TO DEALER TO COMPLAIN AND REQUEST ALL NEW WHEEL STUDS. ALTHOUGH THEY COULD NOT REMOVE THE REAR LUG NUTS WITH THE WRENCH SUPPLIED WITH THE ESCAPE THEY DENIED REPLACING THE WHEEL STUDS. I BELIEVE THE FAILURE WITH WHEEL STUDS ON FORD PRODUCTS IS A DEALER SERVICE PROBLEM. QUESTION: HAVE THE FAILURES ALL HAPPENED AFTER DEALER SERVICE? *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10414696July 22, 2011
ELECTRICAL SYSTEM
THE PCM MODULE ON THE FORD ESCAPE DIES DURING OPERATION. WHILE DRIVING IN MID TRANSIT THE CAR DIED, AND WOULD NOT RESTART IN THE MIDDLE OF THE ROAD. I HAVE HEARD OTHER STORIES OF PEOPLE DRIVING ON THE HIGHWAY, AND HAVING THIS PROBLEM HAPPEN TO THEM GOING 60,70, AND EVEN 80 MPH. MINE WAS ONLY GOING ABOUT 30, AND NO CARS WERE BEHIND ME. THE MODULE HAS BEEN REPLACED TWICE, AND COULD BE EXTREMELY DANGEROUS IF DIED ON A BUSY HIGHWAY OR INTERSTATE. *TT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10412270July 14, 2011
ENGINE AND ENGINE COOLING:ENGINE
WHILE OUT OF TOWN SUNDAY JULY 10TH 2011, 300 MILES FROM HOME MY 2005 FORD ESCAPE CAUGHT ON FIRE, OD 90046. WE GOT IN THE CAR STARTED IT UP AND THEN WHEN LOOKING AT THE MAP I LOOKED UP AND SMOKE WAS POURING OUT FROM UNDER THE HOOD. AS I JUMPED OUT THE DOOR CAME BACK AND GOUGED MY NOSE OPEN. WHILE BLEEDING ALL OVER THE PLACE I OPENED THE HOOD AND POURED WATER OVER THE FIRE. THE CAR HAD CAUGHT ON FIRE JUST UNDER THE REAR SIDE OF THE INTAKE MANIFOLD. AFTER EXTINGUISHING THE FIRE, I CALLED THE LOCAL SANTA MARIA FORD DEALER, WHO ONLY OFFERED OUR SERVICE DEPARTMENT WILL BE OPEN TOMORROW. I HAD THE VEHICLE TOWED TO THE DEALER THAT DAY AND WHILE THERE DECIDED TO HAVE MY WIFE LOOK AT A NEW CAR. REGARDLESS OF THE FACT THAT I PUT THE FLAMES OUT EARLY AND I AS A MAINTENANCE OFFICER WITH 24 YEARS EXPERIENCE I COULD HAVE FIXED THE CAR, I WANTED MY WIFE TO HAVE A NEW CAR SO WHEN I LEAVE HER BEHIND FOR MY NEXT DUTY STATION IN THE MARINE CORPS AND DEPLOY, I WOULD NOT HAVE ANY WORRIES. THE SALES EXPERIENCE WAS WHAT I EXPECTED BUT MY BIGGEST ISSUES WERE THAT, ALTHOUGH THE SERVICE DEPARTMENT WAS CLOSED, OUT OF LUCK, YEA RIGHT, THE SERVICE MANAGER STOPPED BY TO WORK ON HIS RV AND ASSISTED IN THE APPRAISAL OF MY 2005 ESCAPE THEN LEFT BEFORE I KNEW HE WAS THERE. DUE TO THE FORD DEFECT, FIRE DAMAGE, THEY OFFERED MY $2,000 FOR A TRADE IN. I TALKED THEM INTO AROUND $4,200. I HAD A CAR THAT COST ME $28,000 SIX YEARS AGO AND DUE TO A DEFECT I GOT AROUND $4,200 FOR IT IN GREAT SHAPE, EXCEPT THE VERY SMALL FIRE DAMAGE> LUCKILY WE HAD THE FIRE IN A PARKING LOT NOT WHILE ON A BACK ROAD, OFF ROAD, TRAFFIC JAM. FROM RESEARCH EARLIER ESCAPE MODELS HAVE A HISTORY OF ENGINE FIRES, AND SOME OF THE LATER, BUT NOTHING TO DATE ON THE 2005. FORD CORPORATE HAS YET TO CONTACT ME ABOUT MY COMPLAINT, I AM ASKING THEM TO ACKNOWLEDGE THE PROBLEM AND HOPE THEY WOULD COMPENSATE ME FOR THE LOST VALUE IN MY TRADE IN DUE TO SOME TYPE OF OBVIOUS DEFECT IN THEIR PRODUCT. CASE # [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10410299July 2, 2011
POWER TRAIN:AUTOMATIC TRANSMISSION
THIS COMPLAINT IS FOR A 2005 FORD ESCAPE. WHILE DRIVING AS ABOUT 45MPH, SUDDENLY THE CAR TURNED OFF, I IMMEDIATELY PUT IT ON NEUTRAL AND TUNED THE KEY AND IT STARTED UP AGAIN. ABOUT 10 SECONDS LATER IT DID THE SAME THING. I PARKED THE CAR, TURNED IT OFF AND ON AND IT STARTED MISFIRING AND THE CHECK ENGINE LIGHT TURNED ON. THE VERY NEXT MORNING I TOOK THE CAR IN FOR A CHECK UP TO A CERTIFIED MECHANIC IN WHICH I WAS TOLD THAT THE COILS AND SPARK PLUGS NEEDED TO BE REPLACED. THE PARTS WERE ORDERED AND INSTALLED BUT STILL THE MISFIRE WAS PRESENT. THE INVESTIGATION CONTINUED AND AFTER THE SYSTEM WIRING DIAGRAM FIG. 43: 3.0L ENGINE PERFORMANCE CIRCUIT PAGE 5 OF 5 FOR 2005 FORD ESCAPE, COIL ON PLUG 3 ( C ) WIRE CONNECTION TO PCM SLOT 24 CDE NOT RESPONDING. THIS VEHICLE HAS HAD ONLY ONE OWNER AND A VERY SYSTEMATIC MAINTENANCE THROUGHOUT IT?S LIFE SO FAR. ONLINE I HAVE FOUND SEVERAL COMPLAINTS ABOUT THE SAME EXACT THING AND ALL ADVISED THAT THE PCM WAS NON-FUNCTIONING. FORD HAS HAD ISSUES WITH THESE PARTS IN THE PAST BUT NO RECALL HAS BEEN MADE. PCM SHOULD BE REPLACED BY FORD. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10410217July 1, 2011
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
TL* THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. THE CONTACT STATED THAT THE BRAKE WARNING LIGHT ILLUMINATED ON THE DASHBOARD. WHEN THE BRAKE WAS IT WENT TO THE FLOOR AND THE CONTACT COULD HEAR A GRINDING NOISE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE ANTI BRAKING SYSTEM COMPUTER FAILED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE VEHICLE WAS REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 67,137. UPDATED 08/31/11 *BF THE CONSUMER STATED HE HAD TO PUT THE VEHICLE IN NEUTRAL AND USE THE EMERGENCY BRAKE TO STOP THE VEHICLE. UPDATED 11/23/11
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10409548June 28, 2011
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
LETTER FROM SENATOR CASEY ON BEHALF OF CONSTITUENT RE CONCERNS ABOUT HER 2005 FORD ESCAPE *TGW THE CONSUMER BEGAN HAVING PROBLEMS WITH THE VEHICLE. WHEN SHE TOOK THE VEHICLE TO HER MECHANIC, HE HOOKED IT UP TO THE COMPUTER AND IT GAVE HIM A READING THAT THE CYLINDER WAS NOT FIRING, BUT HE THOUGHT THERE WAS MORE INVOLVED. AFTER FURTHER EXAMINATION, IT WAS DISCOVERED THE PCM WAS DAMAGED. THE PCM WAS SENT TO ANOTHER ESTABLISHMENT FOR REPAIR. THE TECHNICIAN AT THE ESTABLISHMENT INFORMED THE CONSUMERS MECHANIC THAT FORD RECOMMENDED THAT ALL SIX COILS AND SIX SPARK PLUGS BE REPLACED. THE PCM WAS RETURNED TO THE CONSUMERS MECHANIC. THE VEHICLE NEEDED TO BE REPROGRAMMED AT THE DEALERSHIP, BUT THE CONSUMER WAS UNABLE TO GET AN APPOINTMENT RIGHT AWAY. THE MECHANIC CALLED THE CONSUMER AND INFORMED HER, THAT INSTEAD OF THE ORIGINAL CIRCUIT B MISFIRING, CIRCUIT C WAS MISFIRING. THE PCM HAD TO BE SENT BACK TO BE REBUILT AGAIN. ALL OF THE COILS AND SPARK PLUGS HAD TO BE REPLACED AGAIN. AFTER THE VEHICLE WAS REPROGRAMMED AGAIN, CIRCUITS C,D AND E WERE MISFIRING. THE COILS AND SPARK PLUGS HAD TO BE REPLACED FOR A THIRD TIME. THE CONSUMER STATED THE PROBLEM IS DUE TO FAULTY ENGINEERING. THE PCM WAS PLACED BEHIND THE ENGINE COMPARTMENT WHERE A LOT OF HEAT WAS GENERATED FROM THE ENGINE AND IT INTERFERED WITH THE FREQUENCY OF THE PCM. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10407196June 16, 2011
ELECTRICAL SYSTEM
ON SEVERAL AT LEAST 12 OCCASIONS, WHILE DRIVING BETWEEN 30-65 MPH THE CAR (2005 FORD ESCAPE) STUBBLES AND THE THEFT LIGHT APPEARS. IN ONE CASE WE WERE ABOUT TO PASS A VEHICLE ON A TWO LANE HIGHWAY AND HAD TO BRAKE AND SWERVE SUDDENLY TO AVOID A HEAD-ON COLLISION. VEHICLE HAS BEEN TAKEN TO FORD SEVERAL TIMES AND NO CODES WERE FOUND AND THEY HAVE STILL NOT ADDRESSED THE PROBLEM. I DID SOME RESEARCH WHICH APPEARS THAT THE PCM IS LIKELY DAMAGED DUE TO A RF ISSUE WITH THE INCORRECT SPARK PLUGS BEING INSTALLED ON THE EARLY MANUFACTURED 2005 FORD ESCAPES. UNFORTUNATELY FORD WILL NOT DOING ANYTHING UNTIL THE COMPUTER ACTUALLY IS DESTROYED, WHICH ALSO FRIES THE COILS (APPROX. $3,000). DEALERSHIPS WILL NOT DO ANYTHING FOR US AND THE CORPORATE OFFICE TOLD US THE SAME. WE NOW HAVE A LOW MILEAGE VEHICLE THAT CANNOT BE TRUSTED SAFELY THAT CANNOT BE FIXED WITHOUT SPENDING $3,000+ FOR A PROBLEM THAT FORD HAS KNOWN ABOUT FOR SEVERAL YEARS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10406693June 13, 2011
UNKNOWN OR OTHER
AS DRIVING ON THE HIGHWAY, THE ENGINE SUDDENLY SHUT DOWN, AND WAS ABLE TO DRIVE TOWARDS THE SHOULDER. AFTER 5 MINUTES, I WAS ABLE TO RESTART THE ENGINE. TEN MINUTES LATER, IT HAPPENED AGAIN, STILL DRIVING THE HIGHWAY @60 MPH. LUCKILY, NO CARS WERE BEHIND, AND I WAS ABLE TO MOVE TO THE SHOULDER WITHOUT INCIDENT. THE FOLLOWING MONDAY, IT HAPPENED AGAIN, THREE TIMES . CAR WAS TOWED TO THE DEALER, I WAS TOLD THEY HAVE HAD ANOTHER CAR THE SAME MORNING, WITH EXACTLY THE SAME PROBLEM. DIAGNOSTICS: NEED TO REPLACE BOTH HIGH VOLTAGE TRACTION BATTERY COOLING FANS AND TO REPLACE MOTOR ELECTRONICS COOLING PUMP. WHEN DEALER SEARCHED FOR PARTS, THEY COULD NOT FIND ANY IN MN, BECAUSE APPARENTLY ALL DEALERS WERE HAVING THE SAME PROBLEM. IT WOULD TAKE SEVERAL DAYS UNTIL THEY WOULD GET THE PART FROM CA. FORD IS NOT WILLING TO RECOGNIZE THEY HAVE A PROBLEM WITH THE ENGINE AND BATTERY COOLING SYSTEM, ALTHOUGH IT HAS HAPPENED SEVERAL TIMES. FORD EVEN ISSUED TWO TECHNICAL SERVICE BULLETINS (TSB 08-24-5 AND TSB 09-17-7) ADDRESSING BOTH ISSUES. IT IS A VERY SERIOUS SAFETY ISSUE, GIVEN THE ENGINE SUDDENLY SHUTS DOWN ON THE HIGHWAY, AND THE CAR NEEDS TO BE MOVED RIGHT AWAY TOWARDS THE SHOULDER. CAR COULD BE HIT FROM BEHIND FROM ONCOMING TRAFFIC, GIVEN THE SUDDEN SPEED CHANGE, AND COULD CAUSE FATALITIES. DON'T WANT TO HAVE FOR ANOTHER FIRESTONE - FORD EXPLORER FIASCO.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10405300June 6, 2011
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
NOTHING LET UP TO THE FAILURE. CAR DIED WHILE PULLING OUT IN TRAFFIC. WAS TOLD IT WAS THE COIL PACKS GONE BAD. REPLACED THEM. THEN TOLD THE CATALYTIC CONVERTER BURN OUT WHEN THE COILS WENT. COME TO FIND OUT THIS IS A ISSUE FOR IS AWARE OF ON THE 2005 ESCAPE. I WAS ALMOST REAR ENDED WHEN THIS HAPPENED AND HAS A HARD TIME GETTING OFF THE ROAD. NO INDICATION IT WAS GOING TO STALL. THIS IS A SAFETY ISSUE ON THESE CARS. I HAVE ALREADY PUT OUT CLOSE TO $200.00 AND ITS STILL NOT FIXED. IT ALSO HAS BLOWN UP MY COMPUTER IN THE CAR. I WAS SCARED TO DEATH AND VERY LUCKY THAT I WAS NOT HIT. FORD IS AWARE OF THIS PROBLEM AND WILL DO NOTHING ABOUT IT. WHAT WILL IT TAKE FOR SOME ACTION TO BE TAKEN? SOMEBODY GETTING KILLED BEFORE FORD IS MADE TO DO SOMETHING WITH THIS ISSUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10405148June 4, 2011
ENGINE AND ENGINE COOLING
HIGHWAY DRIVEING 55 MPH JUST SHUT DOWN IN CENTER LANE PULLED OVER TO SHOULDER WARNING LIGHTS ON NO POWER RE STARTED IT WAS OK THIS WAS THE 2 TIME THIS HAS HAPENED IN 3 MO..
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Escape