Ford E-450 Complaints (2025)
3 consumer complaints on file.
- #11752798July 25, 2026WHEELS
Three original equipment Hankook Dynapro HT tires developed belt-related failures at approximately 6,000 miles of use during a road trip in June 2026. On [XXX], while driving in Tennessee, we noticed a vibration that gradually increased in intensity. We stopped for inspection at C&D Tire & Service in Athens, TN, which found a "bad belt" in the left-front tire at an odometer reading of 5,649 miles. The tire was replaced and retained. The following day, [XXX], the vibration returned and worsened. We stopped at Bill Morgan Tire in Lexington, KY, which found a "severe belt rupture" in the left-rear outer tire and noted that the right-front original equipment tire was "showing signs" of a similar condition. The work order noted all five removed tires had a little over 6,000 miles of use and approximately 12/32" tread remaining. The worst of the tires was retained. Two independent tire dealers, in two different states, identified belt-related abnormalities in three original equipment tires within approximately 24 hours. Given that we were hundreds of miles from home and continuing on interstate highways, we replaced all remaining tires for safety. We have retained two of the removed tires, which show visible belt deformity, and they are available for inspection. No crash, injury, or loss of vehicle control occurred; the vibration was noticed and addressed before any tire failed catastrophically while underway. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Crash:
- No
- Fire:
- No
- Injuries:
- 0
- Deaths:
- 0
- #11679474August 8, 2025ENGINE, POWER TRAIN, UNKNOWN OR OTHER
2025 E-450 Safety Recalls* Main control valve body or transmission replacement Recall incomplete INVESTOR REPORTING FOR "amber alert" for all 2025 E-450, as this vin shows NO ACTIVE RECALLS. Yet our factory engineers have issued this RECALL. PLEASE BROADCAST.....
- Crash:
- No
- Fire:
- No
- Injuries:
- 0
- Deaths:
- 0
- #11655655April 19, 2025POWER TRAIN, POWER TRAIN:DRIVELINE:DRIVESHAFT
The component that failed was the driveline on our RV. Specifically, the driveline was installed at an incorrect angle, which caused excessive vibrations and loud noises while driving at highway speeds. The improper driveline angle posed a serious safety risk to my family and others on the road. The vibrations were severe enough to affect vehicle handling and stability, especially at higher speeds. There was also concern that the continued stress could lead to mechanical failure or component separation, which could result in loss of control or debris on the roadway. The issue has been confirmed by a Ford RV technician, who verified that the driveline angle was outside manufacturer specifications. The vibrations could be consistently reproduced during test drives. The vehicle has not been inspected by the manufacturer, police, or insurance representatives at this time. There were no warning lamps or dashboard messages, but noticeable symptoms—including a strong vibration through the floor and loud droning noises—began immediately upon first highway use and persisted until inspection revealed the driveline misalignment.
- Crash:
- No
- Fire:
- No
- Injuries:
- 0
- Deaths:
- 0