Chrysler PT Cruiser Complaints (2005)

256 consumer complaints on file.

#10168478September 17, 2006
TIRES:SIDEWALL
ON THE INCIDENT DATE, I WAS TRAVELING ON THE FREEWAY AT ABOUT 78 MILES AN HOUR (IDAHO FREEWAY SPEED LIMIT IS 75). THE OUTSIDE SIDEWALL OF THE LEFT FRONT TIRE COMPLETELY DISINTEGRATED CAUSING THE TIRE TO COME COMPLETELY APART. IT WAS LITERALLY FILLED WITH ASH FROM THE RUBBER. THE TIRES ARE ON A 2005 PT CRUISER CONVERTIBLE TOURING EDITION AND HAD ONLY 19000 MILES ON THEM. THEY HAVE ALWAYS BEEN MAINTAINED WITH 36 OR MORE POUNDS OF AIR AND THE AIR PRESSURE HAS BEEN CHECKED MUCH MORE OFTEN THAN NORMAL DUE TO THE FACT THAT THEY ALWAYS LOOKED LOW. I HAD JUST CHECKED THE AIR IN THEM TWO DAYS BEFORE. ABOUT 15 MILES PRIOR TO THE TIRE EXPLODING, THE CAR HAD A VERY DISTINCT PULL TO LEFT WHICH I ATTRIBUTED INITIALLY TO WIND LOAD FROM THE SIDE OF THE CAR, APPARENTLY IT WAS NOT WIND. THESE TIRES ARE A DEATH TRAP WAITING TO HAPPEN. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10168324September 15, 2006
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS
FUEL INJECTOR O RINGS COME LOOSE CAUSING INJECTORS TO TAP. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10168327September 15, 2006
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS
O RINGS ON FUEL INJECTORS CAME OFF, CAUSING INJECTORS TO TAP. CHRYSLER WILL NOT TOUCH IT. THEY KEEP SAYING THE INJECTORS ARE SUPPOSED TO TAP! I WENT TO 4 CHRYSLER DEALERSHIPS, AND 3 SAID IT`S NORMAL, AND ONE SAID THEY COULDN'T HEAR THE TAP. I WENT TO 3 OTHER MECHANICS ( NON CHRYSLER) AND THEY ALL SAID IT`S NOT NORMAL, AND TO GET IT FIXED RIGHT AWAY. BUT CHRYSLER WILL NOT ADMIT THERE`S ANYTHING WRONG, AND THEY REFUSE TO FIX IT. BECAUSE OF THAT, I HAVE TO GET A DIFFERENT CAR! AFTER THE WARRANTY RUNS OUT, I WON`T BE ABLE TO AFFORD TO FIX THE PROBLEM! I WOULDN'T RECOMMEND ANY CHRYSLER PRODUCT TO ANYONE! *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10167910September 11, 2006
ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES
DT*: THE CONTACT STATED WHILE MOVING FROM A STOP SIGN AT 10 MPH ON NORMAL ROAD CONDITIONS, FIRE WAS NOTICED COMING OUT OF THE HOOD. THE CONTACT EVACUATED THE VEHICLE. THE FIRE DEPARTMENT WAS PRESENT TO EXTINGUISH THE FIRE HOWEVER, THE VEHICLE WAS DEEMED A TOTAL LOSS. THE FIRE DEPARTMENT DETERMINED A SHORT CIRCUIT FROM THE BATTERY CABLE WAS THE SOURCE OF THE FIRE. THERE WAS NO POLICE REPORT TAKEN. THE DEALERSHIP NOR THE MANUFACTURER WERE CONTACTED.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10166994August 29, 2006
TIRES:TREAD/BELT
DT*: THE CONTACT STATED THE ORIGINAL TIRES OF THE VEHICLE HAD VERY THIN TREAD BELT AND A VERY SMALL NAIL CAUSED A PUNCTURE. THE TIRES ALSO WOULD NOT GRIPPED ON WET PAVEMENT AT ANY SPEED, CREATING SAFETY RISK DURING RAINY WEATHER. DUE TO THE POOR QUALITY OBSERVED ON THOSE TIRES BY THE CONTACT THE TIRES WERE ROTATED EVERY 3000 MILES. THE DEALERSHIP ADVISED THE CONTACT TO REPLACE ALL TIRES AT ONLY 19000 MILES. THE TIRES MANUFACTURER DID NOT WARRANTY IN RELATIONS TO MILEAGE. THE TIRES WARRANTY PROVIDED REFERRED ONLY TO PERFORMANCE AND HANDLING. GOODYEAR MANUFACTURED THE EAGLES SS. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10166711August 28, 2006
ENGINE AND ENGINE COOLING
DT*: THE CONTACT STATED THE ENGINE LIGHT CONTINUED TO ILLUMINATE AND THE ENGINE STALLED AT VARIOUS SPEEDS. THE VEHICLE HAS BEEN TO THE DEALERSHIP FOUR TIMES. THE DEALERSHIP REPLACED THE PCM MODULE TWICE. THE DEALERSHIP REPLACED FOUR SPARK PLUGS AND VARIOUS WIRING TWICE, BUT THE PROBLEM PERSISTED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10166265August 22, 2006
VISIBILITY:GLASS, SIDE/REAR
DT*: THE CONTACT STATED WHILE DRIVING 45 MPH ON NORMAL ROAD CONDITIONS, THE DRIVER SIDE BACK TRIANGLE WINDOW BLEW OUT INCLUDING THE FRAME. THE VEHICLE DRIVING BEHIND MANEUVERED TO AVOID BEING HIT BY THE FLYING WINDOW. THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHO REPLACED THE MISSING WINDOW.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10164829August 7, 2006
VEHICLE SPEED CONTROL, AIR BAGS:FRONTAL
DT*: THE CONTACT STATED WHILE THE VEHICLE WAS STOPPING AFTER DRIVING 10 MPH THROUGH A PARKING LOT WITH BRAKE PRESSURE APPLIED, THE VEHICLE LURCHED FORWARD INTO A CONCRETE PILLAR AND THE FRONT AIRBAGS DID NOT DEPLOY. THE CONTACT WAS WEARING A SEAT BELT AND SUSTAINED MINOR INJURIES. MODERATE DAMAGE WAS SUSTAINED TO THE FRONT OF THE VEHICLE. THE POLICE WERE ON THE SCENE AND A REPORT WAS TAKEN. THE VEHICLE WAS TOWED TO A DEALER WHO WAS UNABLE TO DETERMINE A FAILURE OR DEFECT. THE MANUFACTURER WAS ALERTED. UPDATED 09/15/06. *JB UPDATED 9/20/2006 - *NM
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10163164July 22, 2006
POWER TRAIN:AXLE ASSEMBLY, TIRES
CAR HAD SHAKE IN FRONT THROUGH STEERING WHEEL AND RT. FLOORBOARD. CHANGE TIRES AND WHEELS. CHANGES TIRES TWICE. REPLACED LEFT FRONT AXLE WITH SINGLE AXLE. REPLACED SAME AXLE WITH TWO PIECE AXLE. STILL HAS SHAKE IN IT. FACTORY TECH SAID LIVE WITH IT. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10162087July 11, 2006
EXTERIOR LIGHTING:FOG LIGHTS:SWITCH
FOG LAMPS REMAIN ON WHEN SWITCH IS IN THE OFF POSSITION. THIS PROBLEM HAS BEEN IDENTIFIED IN MANY "PT" FORUMS ON THE INTERNET. THE SOLUTION IS THE REPLACEMENT OF THE MULTIFUNCTION SWITCH THAT CONTROLS ALL THE LIGHTS.*NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10160761June 26, 2006
ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
WHILE DRIVING MY TURN SIGNALS AND WINDSHIELD WIPERS STOP WORKING. TOOK IT IN TO THE DEALER AND THEY SAID IT WAS A BLOWN FUSE. THEY REPLACED THE FUSE AND AWAY WE WENT. THIS HAS HAPPENED 3 TIMES ALTOGETHER WITHIN THE LAST 2 MONTHS, AND THE DEALER CAN'T FIND THE PROBLEM. WHAT ACTIONS DO I TAKE NEXT? THIS IS A SAFETY HAZARD WHEN I HAVE TO TURN SIGNALS OR WIPERS ESPECIALLY WHEN IT IS RAINING. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10152884March 16, 2006
SUSPENSION:REAR
VIBRATION IN REAR END OF VEHICLE; VEHICLE DRIFTS TO RIGHT; EXCESSIVE/UNEVEN TIRE WEAR SINCE NEW. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10147830January 16, 2006
ELECTRICAL SYSTEM, ENGINE AND ENGINE COOLING
THE DEFECTS IN MY VEHICLE ARE PRIMARILY RELATED TO THE ELECTRICAL SYSTEM FAILING RESULTING IN THE ENGINE SHUTTING OFF. ALL OF THE POWER GOES OUT; THE ENGINE DIES AND COMES BACK ON AFTER EITHER A FEW MOMENTS OR A FEW MINUTES. DURING THIS TIME THE VEHICLE IS VERY DIFFICULT TO STEER AND NEAR IMPOSSIBLE TO BRAKE. THIS OCCURS INTERMITTENTLY, ON MULTIPLE OCCASIONS WHILE AT SPEED ON THE INTERSTATE. TO DATE (1/16/2006) THIS HAS OCCURRED 18 TIMES ON MY VEHICLE. THE DEALERSHIP HAS TOLD ME ON MANY OCCASIONS THAT THEY ARE NOT CONFIDENT ON WHAT IS CAUSING THIS PROBLEM. THIS CONDITION HAS BEEN WITNESSED BY OTHERS. I BOUGHT THIS CAR NEW IN APRIL 2005. I BEGAN HAVING PROBLEMS WITH IT AT AROUND 12000 MILES IN SEPTEMBER 2005. THIS PROBLEM IS STILL PRESENT AND DC DOES NOT KNOW WHAT IS CAUSING IT. THEY OFFERED A SIMILAR 2005 PT BUT REFUSED TO BUY THE VEHICLE BACK. FROM WHAT I HAVE FOUND SO FAR, THERE HAVE BEEN 9 SIMILAR OCCURRENCES OF THIS AND NONE HAVE BEEN SOLVED. THEREBY, I REFUSED TO TAKE ANOTHER 2005 PT CRUISER. I DO NOT HAVE ANY CONFIDENCE IN THE CAR SO IT SITS PARKED WHILE I MUST CONTINUE TO MAKE PAYMENTS WHILE THIS MATTER GOES THROUGH THE COURTS. THEY ALSO STATED THAT THEY WERE ONLY ATTEMPTING WHAT DAIMLER CHRYSLER DIRECTED THEM TO DO. THE DEALERSHIP HAS ATTEMPTED TO FIX THIS PROBLEM WITH NO SUCCESS ON FOUR OCCASIONS (10/06-10/07, 10/20-10/24, 10/24-10/28, 11/07-11/17). THE DEALERSHIP PROMISED TO MAKE NECESSARY PART REPLACEMENTS AND THEN DRIVE IT ONE TO TWO HUNDRED MILES AFTER. THEY DID NOT DO EITHER. THEY SAID THAT THEY DO NOT HAVE THE MANPOWER TO HAVE SOMEONE DRIVE IT SEVERAL HUNDRED MILES TO REPLICATE THE PROBLEM. MOST TIMES THE CAR IS ON THE HIGHWAY FOR SEVERAL HOURS BEFORE IT DIES. I HAVE GIVEN THE DEALERSHIP PLENTY OF OPPORTUNITIES TO FIX THIS PROBLEM. THIS IS A VERY SERIOUS AND SEVERE SAFETY ISSUE FOR BOTH ME AND OTHER DRIVERS ON THE ROAD. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10147767January 14, 2006
ENGINE AND ENGINE COOLING
WHILE DRIVING IN CITY I NOTICED A KNOCKING IN THE ENGINE. I PULLED OVER AND SAW OIL POURING OUT OF FRONT OF ENGINE. I SHUT ENGINE OFF. AT NO TIME DID OIL PRESSURE WARNING LIGHT COME ON. CALLED AAA AND HAD CAR TOWED TO NEAREST CHRYSLER DEALER. DEALER DIAGNOSED PROBLEM AS BLOWN CAMSHAFT SEAL. REPLACED SEAL BUT WHEN RUNNING ENGINE STILL MADE KNOCKING SOUNDS. WAITED FOR ENGINE SPECIALIST TO COME BACK FROM VACATION. HE SAID ENGINE NEEDED TO BE REPLACED AND HE WOULD CONTACT CHRYSLER. CHRYSLER INSISTED ENGINE BE TORN DOWN TO IDENTIFY SOURCE OF PROBLEM. PROBLEM WAS CRANKSHAFT THRUST BEARING BROKEN IN HALF ALLOWING CRANKSHAFT TO MOVE LATERALLY FORCING OUT CRANKSHAFT SEAL, HENCE ALL THE OIL, AND MORE EXTENSIVE DAMAGE TO OTHER ENGINE COMPONENTS. I REQUESTED A "CRATED" ENGINE BE INSTALLED. DEALER SAID NONE AVAILABLE. AT PRESENT WAITING FOR DELIVERY OF CYLINDER HEAD. CAR HAS BEEN IN THE SHOP 20 DAYS. MILEAGE AT TIME OF INCIDENT: 3,541 MILES. FORTUNATELY THIS FAILURE DID NOT OCCUR AT HIGHWAY SPEEDS WHERE THE RESULT COULD HAVE BEEN MUCH WORSE. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10148617January 10, 2006
ENGINE AND ENGINE COOLING
2005 CHRYSLER PT CRUISER ENGINE LIGHT FLASHED AND CAR STALLED WHILE DRIVING. *TS THE ENGINE LIGHT ILLUMINATED ON 3 SEPARATE OCCASIONS. SEVERAL REPAIRS WERE MADE, BUT THE CONSUMER CONTINUED TO EXPERIENCE PROBLEMS. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10145038December 12, 2005
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER
DT: THE CONTACT STATES WHILE TRAVELING AT 50-55 MPH THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALERSHIP, THEY STATED THE PROBLEM WAS WITH THE TURBO AND IT WAS REPAIRED. HOWEVER, THE VEHICLE WAS FLOODED BY HURRICANE WILMA AND WAS TOTALED. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10144160December 1, 2005
SERVICE BRAKES, HYDRAULIC
I HAVE A CHRYSLER 2005 PT CRUISER. IT HAS BEEN THE SHOP FOUR TIMES NOW FOR THE SAME THING. ON NOV. 5, 2005 THE BRAKES FAILED, THE CAR ACTED LIKE IT WAS STUCK IN GEAR. IT WENT TO THE SHOP BY WRECKER. I GOT THE CAR BACK ON NOV 9, 2005 NO PROBLEM WAS FOUND WITH THE CAR, WAS TOLD IT RUNS BEAUTIFUL. ON NOV. 30, 2005 GOING HOME STOPPING IN TRAFFIC THE BRAKES FAILED AGAIN, ALMOST HIT A TRUCK IN FRONT OF ME. IT IS RIGHT NOT SETTING AT A CHRYSLER DEALERSHIP AND THEY CALLED ME THIS MORNING AND SAID THE CAR IS RUNNING FINE AND NO PROBLEM WAS FOUND. THIS CAR IS VERY UNSAFE. I HAVE RODE AROUND FOR A WEEK WITH A CO-PILOT IN IT AND NOTHING SHOW UP ON THAT. I HAVE LOST OVER 100 MILES PER TANK IN GAS MILEAGE. NO CHRYSLER DEALER CAN SEEM TO FIND WHAT IS WRONG WITH THIS CAR. WHAT CAN I DO. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10144158December 1, 2005
VEHICLE SPEED CONTROL
I AM WRITING TO ASK HAS THERE HAVE BEEN ANY REPORTS OF THE 2002 PT CRUISER HAVING AN ACCELERATION PROBLEM? ON 11/30/2005 AS I WAS MAKING A U-TURN WHEN MY CAR ACCELERATED AT A HIGH RATE OF SPEED THAT CAUSED ME TO HIT A CURB AND BLEW OUT MY RIGHT FRONT TIRE, IT ALSO LEFT ME IN A DISORIENTED STATE OF MIND. I HAD NO CONTROL OVER THAT CAR UNTIL IT HIT THE CURB. PLEASE AT YOUR EARLIEST CONVENIENCE CAN YOU LET ME KNOW IF THERE HAS BEEN OTHER REPORTS OF THIS. *JB
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#10143259November 19, 2005
EQUIPMENT:APPLIANCE:AIR CONDITIONER, ELECTRICAL SYSTEM
I HAVE A COMPLAINT ABOUT THE AIR CONDITIONER IN MY 2005 PT CRUISER TOURING EDITION. WHEN I USE THE AIR OR THE HEAT OR DEFROST I CAN SMELL SOUR SMELL COMING FROM THE VENTS. I TOOK IT TO THE DEALER SERVICE DEPARTMENT, THEY CHECKED IT AND TOLD ME THE AIR CONDITIONER HAD MOISTURE BUILT UP IN IT. THEY TOLD ME THEY WOULD HAVE TO CLEAN AND DEODORIZE IT BUT THEY WOULD HAVE TO ORDER THE CLEANER AND DEODORIZER AND THE EQUIPMENT TO FIX IT. I CALLED THEM BACK THE FOLLOWING WEEK THEY SAID THEY HAD EVERYTHING TO FIX IT, BUT WHEN I RETURNED ON NOVEMBER 11, 2005 THEY STILL DID NOT HAVE ALL OF THE EQUIPMENT TO FIX IT. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10139128October 9, 2005
ENGINE AND ENGINE COOLING:ENGINE, FUEL SYSTEM, GASOLINE
I PURCHASED NEW,2005 PT CRUISER IN EL PASO, TX. RETURNED CAR FOR SERVICE AT 3 WEEKS WITH ENGINE PROBLEMS- MISSING, MISFIRE. DEALER SAID NOTHING WRONG & RESET COMPUTER. RETURNED CAR FOLLOWING WEEK- ENGINE USED 1/2 QT OIL IN ONE WEEK. COULD SMELL GAS WHILE DRIVING CAR. DEALER SAID NOTHING WRONG. I SPOKE WITH SALES MANAGER AND TRIED TO RETURN CAR. THEY SAID NO, THIS WAS NORMAL. THEY SAID CARS COULD USE OIL IN FIRST MONTH OF USAGE. THEY SAID THIS WOULD NEVER HAPPEN AGAIN. I WAS BEING TRANSFERRED TO DALLAS FOLLOWING WEEK, THEY SAID NO PROBLEM, IF ANYTHING WAS WRONG GO TO DEALER IN DALLAS. SEPT- CAR USED 1/2 QT OIL AGAIN, GAS/OIL SMELL GETTING STRONGER WHILE DRIVING- EFFECTING MY ASTHMA. RETURNED CAR TO DEALER FOR SERVICE- SERVICE SAID OIL USAGE NORMAL FOR UP TO ONE YEAR. SERVICE SAID THAT CHRYSLER WOULD NOT DO ANYTHING ABOUT ISSUE UNTIL CAR WAS USING 1 QT OIL EVERY 500 MILES. SERVICE DID OIL CHANGE. SERVICE STARTED OIL USAGE REPORT ON CAR AND SAID TO BRING CAR IN EVERY 500 MILES FOR CHECK. I DROVE CAR 500 MILES AND CHECKED OIL. SERVICE HAS OVERFILLED OIL LEVEL AND IS 1/4 INCH OVER THE FILL LINE. RETURNED TO SERVICE AND THEY REFUSED TO CHECK OIL AND SAID THAT I NEEDED APPOINTMENT AND WOULD NEED TO LEAVE CAR AGAIN. CAR TO GO TO SERVICE FOR FOURTH TIME ON MONDAY, OCT 10. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chrysler PT Cruiser