Chevrolet Silverado Complaints (2021)

989 consumer complaints on file.

#11712216January 20, 2026
POWER TRAIN:AUTOMATIC TRANSMISSION:FLUID/LUBRICANT:VALVES/VALVE BODY
The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while driving at various speeds, the vehicle jerked unexpectedly. The check engine warning light was illuminated. The vehicle was taken to a local dealer, where it was diagnosed, and determined that the valve body needed to be replaced. The vehicle was not repaired due to parts not being available and the VIN not being included in a recall. In addition, the part was ordered at the owner's expense. The manufacturer was made aware of the failure. The failure mileage was approximately 145,565.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11711797January 19, 2026
SEAT BELTS
I am submitting a safety complaint regarding a vehicle restraint system failure. I was involved in a collision with a deer. During the incident, the seat belt pretensioner activated; however, the seat belt did not properly restrain me. I experienced forward movement despite the pretensioner activation. The airbags did not deploy. Because pretensioner activation is intended to lock and tighten the seat belt during a collision, I am concerned that the restraint system failed to function as designed. This raises concerns about occupant safety and the ability of the seat belt system to provide protection in future crashes. I am submitting this complaint to document a potential safety defect and request review of this restraint system failure.“After reporting the seat belt restraint failure to General Motors, I was informed that because I was not injured, no action would be taken and no further review would occur.” Thank you for your attention to this matter.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11711815January 19, 2026
ENGINE, FUEL/PROPULSION SYSTEM, POWER TRAIN
first issue was around April-May 2025 when my engine started knocking and burning fuel. Warning light came on and it went right in to the dealer where I have all my maintenance done. They determined that it due to (2) faulty fuel injectors and I had them replaced at that time. In December of 2025 my engine started doing the same thing as before with the knocking and burning fuel and reduced speeds when on the highway so again it went into the dealer. It has since been in there and first was told it was the fuel injector again. They priced out the one was bad and I asked them to replace the remaining 6 fuel injectors so I didn't have this issue again in the near future. They did and the vehicle had the same issues going on. During the next inspection it was determined that the engine needed new rocker arms. These were replaced but this also did not solve the problem and the vehicle would not pass the regeneration on the engine. During the next inspection it was determined that we needed to replace a cylinder and one of the valves. After this was complete they were still having issues and then I was told that the Piston was bad and there are (2) bad valves so I need an entire engine replacement. My truck only has 130,000 miles and has been in the shop for almost 2 months last year from engine issues and it has had all maintenance completed at he same dealership with Records.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11711951January 19, 2026
ENGINE, POWER TRAIN
Component that failed: The valve train system failed due to collapsed lifters in the GM 5.3L L84 engine. The lifter failure caused internal camshaft damage requiring major repair. The failed components were removed by the Chevrolet dealership and should be available through the repair facility if inspection is requested. Safety risk: The engine failure caused a sudden and severe loss of power while driving. The vehicle would not accelerate beyond approximately 45 mph on a 65 mph roadway while en route to the dealership, creating an unsafe speed differential. When attempting to accelerate to pass another vehicle on a two lane road, the engine backfired and immediately throttled back, making it unsafe to complete the pass. The check engine light illuminated at the exact moment the vehicle lost power during the passing attempt. This sudden propulsion loss during an active maneuver created a hazardous driving condition. Dealer confirmation: An authorized Chevrolet dealership diagnosed collapsed lifters which damaged the camshaft and confirmed this as a known failure pattern in GM L84 engines. Inspection by others: Vehicle was inspected and repaired by the dealership. No accident occurred, so no police or insurance inspection was involved. Warnings or symptoms: No prior warning lights appeared before the passing event. The check engine light came on during the failure while accelerating. Additional context: This failure aligns with widely documented lifter collapse defects in GM 5.3L L84 truck engines. The breakdown was not caused by maintenance or wear and tear but by premature internal component failure known across this engine platform.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11711982January 19, 2026
ENGINE
Dealer did the L87 6.2 Recall (basically changed the oil to 0w-40). Based on the “clean bill of health” we towed our Imagine trailer to Tucson. Stayed for 3weeks over Thanksgiving and then started back home. We then towed it back home to Fort Collins and when we reached Denver the check engine light came on and within seconds the engine stopped. We had to coast off the freeway and ended up on an interstate interchange ramp (blind and dangerous). The motor was seized completely. Oil pressure and temps were all normal before the engine stopped. Oil was super HOT when I checked it. After a big adventure dealing with getting the truck and trailer to a safe place via a tow from OnStar, they towed the truck to the nearest dealer. I had to rent a UHaul truck to tow the trailer home (another 80 miles or so) with wife, two dogs and myself crammed in the cab. The dealer got Chevy to cover the engine replacement but I was out $200 for the trailer tow to safety and another $200 for the U-Haul rental. Chevy would not cover that.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11711703January 18, 2026
POWER TRAIN
The powertrain transmission system, specifically the torque converter, failed on my 2021 Chevrolet Silverado at approximately 66,000 miles. The vehicle was taken to and inspected by a GM-authorized dealership, Pellegrino Chevrolet, on January 7, at which time the dealership diagnosed a failed torque converter and formally recommended a full transmission replacement due to the risk that metal debris from the failed converter may have contaminated the transmission; the vehicle and affected components are available for inspection upon request. This failure presents a safety risk due to the potential for loss of power, unpredictable drivability, delayed or failed acceleration, or sudden transmission malfunction, and this vehicle is my family’s primary transportation and is used to transport three child car seats. The problem has been confirmed by the GM-authorized dealership and additionally reviewed by four independent mechanics, all of whom advised that replacing only the torque converter would be insufficient. The vehicle has been inspected by the dealership and documented under General Motors Case #87048318; it has not been inspected by police or insurance representatives at this time. Prior to diagnosis, the vehicle exhibited abnormal transmission behavior and drivability symptoms consistent with torque converter failure, which prompted inspection and worsened leading up to the dealer diagnosis.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11711763January 18, 2026
ENGINE
I have a 2021 Chevy Silverado 6.2 engine. The recall that has been sent out for most of those engines I have experience the same damage to my truck engine. Connecting rod/ crankshaft engine failure. But my vin is not in the system for the recall. Can someone have a engineer look into more of these engines especially my engine vin. I was driving and all of sudden my dash lite up saying I have reduce steering. Took it to the shop and I was told that my engine needs major repairs. I have a really nice truck and it can be a show truck and for the engine to just go out because of bad manufacturer parts is not right I also had my kids with me. Please help
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11711764January 18, 2026
ENGINE
Most mornings after starting truck and driving off, it appears to be a hesitation or brief loss of power. Issue has been present for several years. It's hard to determine if it's engine or transmission issue. Truck is available for inspection. It usually occurs when leaving house in the morning so there is no safety issue because it happens within the first minute of driving. No warnings, cannot recreate issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11711772January 18, 2026
ENGINE
Warning lights came on at approximately 46000 miles. Brought to dealer for faulty lifters. One week later they decided that the lifters had damaged the cam and now the dealer wants to replace the motor.. Unfortunately for us the dealer has no car that we can use, so we had to rent a vehicle. Hopefully it will be ready in 2 weeks. That will make it four weeks with out a vehicle
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11711637January 17, 2026
ENGINE
On 4/19/24 I was driving at highway speed. The engine started to knock and the check engine light came on. I was fortunate enough to be extremely close to my local Chevrolet dealership and made it there before the engine failed. The truck had 38633 miles on it. They found damaged engine components and repaired only the broken parts. Was under warranty. Truck is still ticking to this day. Took it in for this noise and they said nothing was wrong.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11710866January 14, 2026
POWER TRAIN, ELECTRICAL SYSTEM
1- Tailgate keeps opening by itself. It has opened while driving down the highway and things fell out of back of my truck almost causing an accident. It has opened while sitting in my driveway after I have turned the truck off and gone inside. I have reported this to a dealer they said my vin is not on the recall list. I would like my VIN added since it is obviously an issue with the Silverado's. 2- I recently has to bring my truck to the dealer for the transfer case sounding like there were bolts in a blended and a pinging sound by the bell housing while in park. They stated it was the front axle and fixed it saying it was a power train thing. The noise is back and now out of warranty.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11710750January 13, 2026
ENGINE
Complete engine failure and it just outside the recall. This is unacceptable and needs fixed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11710411January 12, 2026
ENGINE
The contact owns a 2021 Chevrolet Silverado 1500. While the contact's wife was driving at an undisclosed speed, the engine seized. The low engine power warning light was illuminated. The vehicle was towed to the dealer, where it was diagnosed with engine failure. The contact was informed that the engine failure was the result of no oil in the vehicle. The contact was informed that there was no oil on the dipstick when checked. The contact stated that the failure had occurred shortly after an oil change was performed on September 9, 2025, at Walmart. In addition, the contact stated that there was no evidence of an oil leak. The contact was informed that the engine needed to be replaced. The vehicle was repaired. The contact referenced an unknown recall with a similar failure description; however, the VIN was not associated. The manufacturer was not made aware of the failure. The failure mileage was approximately 62,248.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709900January 9, 2026
LATCHES/LOCKS/LINKAGES:TAILGATE:LOCK
The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while driving at an undisclosed speed, the tailgate became inoperable and unexpectedly unlatched and lowered. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 65,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709950January 9, 2026
ENGINE
I have a Chevrolet Silverado 1500 with the 6.2L engine. I received the recall notice about the loss of propulsion due to a crankshaft issue. The safety of myself, family, friends and coworkers who ride with me on an everyday basis were put at risk because of the faulty engine. I brought my truck in for an oil change in August 2025. I had the Team Chevrolet dealership in Las Vegas Nevada do a telescopic inspection to see if my particular engine had the recall issue. It was discovered the engine did have the recall issue and was kept by the dealership for roughly two and a half months. Chevrolet has confirmed this is a major issue and is affecting roughly 600,000 people. There was no sign of the issue before the telescopic inspection but since the engine has been replaced I have now had three separate issues with misfiring cylinders on the new engine. The plugs and wires have been replaced twice and has not resolved the issue. When the misfires have occurred there were error codes, check engine light notification, and engine sputtering. This again has endangered the safety of myself, family members, friends, and coworkers who ride in my truck on a daily basis. This is now going on four months of issues that keep persisting and I am very concerned that both the manufacturer Chevrolet and the Team Chevrolet dealership are not taking the proper steps in order to solve this very serious issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11710021January 9, 2026
POWER TRAIN
Not sure of exact date I believe it was right before Thanksgiving. The truck started shuttering and vibrating. It feels like we are driving on a gravel road. the manual said to change transmission fluid between 45,000 and 60,000 so we took it to the dealer. that is what we did hoping that would fix the problem. but it did not so we took it back and they kept it for 3 weeks they said no codes came up and they said the tires needed balancing so we let them do that but the problem is still there. they say there is no recall on it . we did some research and found information stating Chevy is having problems with the transmission. as of now we only have 45,608 miles on it. It is riding worse now.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709352January 7, 2026
ENGINE, POWER TRAIN
The contact owns a 2021 Chevrolet Silverado 1500. The contact received notice of an unknown recall in approximately July 2025. The contact stated that while driving at approximately 65 MPH, the vehicle stalled. The vehicle was towed to a dealer, where it was diagnosed that the engine needed to be replaced, and the failure was associated with the recall. The contact was also advised that the parts were not yet available. The contact stated that the vehicle remained with the dealer for three months and was repaired when the parts became available. The contact stated that two days after the repair, while driving at an undisclosed speed, the vehicle vibrated and hesitated. The vehicle was taken back to the same dealer where it was diagnose,d and determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, and three cases were filed. The failure mileage was 81,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709387January 7, 2026
ENGINE
The coolant control valve has failed, my vin isn’t a part of the special coverage for this bad part ( though the same part and model is covered)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709026January 6, 2026
ENGINE, POWER TRAIN
2021 Silverado 19,000 miles no indication of failure at a busy intersection about to go thru intersection and engines started knocking, multiple check engine lights on. Luckily got thru the intersection and to my place of residence which was very close by. Truck was towed to Chevy dealer. Dealer found 3 bent push rods, 3 bad valves. This engine had the lifters fail completely out of the blue. Oil changed at the dealer, meticulously maintained. Dealer only replaced the faulty bank of lifters due to mileage, seriously if it was under 16,000 they would replace all of them. This is unacceptable. This truck left me almost stranded in a busy intersection, lucky I knew well enough to keep going versus getting T-boned. I just think GM needs to do something about this. Now fast forward to 41K and I'm at the dealer same symptoms except this time my warranty is running up soon and being forced into an extended warranty. There are plenty of online claims, chat rooms, posts, etc to warrant this as a safety issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709149January 6, 2026
ENGINE AND ENGINE COOLING, POWER TRAIN
The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The contact stated that since the purchase of the vehicle, the transmission had failed three times. The transmission had been replaced three times in the past. The second time the transmission failed at approximately 40,000 miles. The contact related the most recent failure of the check engine warning light to the fuel pump driver control module. The manufacturer was not made aware of the failure. The failure mileage was approximately 169,800.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Silverado