Chevrolet Malibu Complaints (2004)

1,582 consumer complaints on file.

#10463404June 28, 2012
STEERING
THE POWER STEERING LOCKS UP FOR APPROXIMATELY 5 TO 10 SECONDS. IT OCCURS AT SLOW SPEEDS ON SURFACE STREETS, HIGH SPEEDS ON THE INTERSTATE, GOING FORWARD AND EVEN WHEN I'M IN THE MIDST OF A TURN. THE CHECK ENGINE LIGHT WILL FLASH, THE LIGHTS FLASH ON AND OFF AND THE NOTICE BELL RINGS "DING, DING, DING." WHEN IT FINALLY STOPS THE, IF ITS SUMMER THE AC WILL STOP FUNCTIONING UNTIL I STOP AND RESTART THE CAR. IT IS A VERY SCARY 5 TO 10 SECONDS AND I'M VERY FORTUNATE TO HAVE NOT CAUSED AN ACCIDENT AS OF YET. THIS HAS ALSO COMPROMISED THE EASE OF THE POWER STEERING WHEN IT HAS NOT LOCKED UP. PARKING IS VERY DIFFICULT AS THE TURNING RADIUS AND NOT GOOD AND ITS JUST DIFFICULT TO MANEUVER THE CARS STEERING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10463128June 26, 2012
STEERING
WHEN STARTING MY CAR, THERE WAS A WARNING CHIME AND THE MESSAGE "POWER STEERING" APPEARED ON MY DRIVER'S INFORMATION CENTER. WHEN I PUT MY VEHICLE IN GEAR THERE WAS A LOSS OF POWER STEERING CAPABILITIES AND IT WAS VERY DIFFICULT TO DRIVE WITHOUT THE POWER STEERING ENABLED. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10463190June 26, 2012
STEERING
I WAS DRIVING AND I HEARD A DING,I LOOKED DOWN AT MY GAUGES AND THE STEERING LIGHT WAS ON. AFTER THAT I NOTICED THE POWER STEERING WAS NOT THERE. I THEN SHUT OFF MY CAR AND LET IT SIT AND THEN STARTED IT. THE STEERING WAS BACK ON BUT I DON'T WANT MY LIFE OR ANY OTHERS LIVES AT RISK. UPDATED 07/05/12 *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10462512June 21, 2012
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT THE VEHICLE EMITTED A STRONG GASOLINE FUEL ODOR. THE CONTACT INSPECTED THE VEHICLE AND FOUND THAT THE FUEL NECK ONLY HAD ONE HOSE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 59,198 AND THE CURRENT MILEAGE WAS 69,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10462005June 17, 2012
SEATS
FOR THE SECOND TIME MY DRIVERS SEAT HAS BROKEN ON THE RIGHT HAND SIDE AT A WELD JOINT ON THE FRONT CROSS ROD. THE FIRST TIME IT FAILED AROUND 30,000 MILES AND THE SECOND TIME AROUND 71,000 MILES. THIS IS A COMMON PROBLEM, A SAFETY ISSUE AND NEEDS A RECALL. NOT ONLY IS CHEVROLET GETTING AWAY WITH THIS, BUT THE FIX IS COMPLETE SEAT FRAME REPLACEMENT THAT COST THE CONSUMER ABOUT $1000. CHEVY WINS AGAIN AS THEY GET TO SELL A DEFECTIVE PART AT A PROFIT. A GREAT DEAL FOR CHEVY UNTIL I BUY MY NEXT CAR. TIME TO DO THE RIGHT THING AND DO A RECALL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10461702June 14, 2012
STEERING
STARTING SOON AFTER PURCHASE, SEVERAL TIMES SINCE (APPROX 3-15 TIMES A WEEK DEPENDING ON SEASON). POWER STEERING SHUTS OFF RANDOMLY. IF DONE WHILE TURNING, IT WILL REQUIRE EXTRA FORCE AND CONCENTRATION TO KEEP ON COURSE. MOST TIMES ISSUE CANNOT BE RESET FOR FULL DURATION OF TRAVEL (15 MIN - 3HRS), THIS IS DONE BY SHUTTING OFF VEHICLE, AFTER STOPPING ON SIDE OF ROAD, AND RESTARTING. USUALLY OCCURS WHEN WARM, EITHER FROM SUNNY DAY FOR FIRST START OR WINTER ONCE HEATER IS WARM. MANY CLOSE CALLS! *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10461716June 14, 2012
STEERING
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT THE DRIVER WAS DRIVING 40 MPH WHEN THE STEERING WHEEL SEIZED. THE POWER STEERING LIGHT AND CHECK ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL WHEN THE FAILURE OCCURRED. THE DRIVER STOPPED AND SHUT OFF THE VEHICLE. THE STEERING WHEEL FUNCTIONED AS NORMAL UPON RESTART. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 160,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10461690June 13, 2012
STEERING
DRIVING APPROX 20 MILES PER HOUR WHEN TURNING LEFT AT AN INTERSECTION AND THE VEHICLE SERVICE LIGHT CAME ON, POWER STEERING MESSAGE DISPLAYED ON THE INFORMATION CONSOLE AND THE POWER STEERING STOPPED WORKING. THE UNEXPECTED LOSS OF POWER STEERING CAUSED THE VEHICLE TO ENTER INTO THE SHOULDER OF THE ROAD. THE POWER STEERING SYSTEM WORKED AFTER TURNING THE CAR OFF AND THEN BACK ON. HOWEVER THE POWER STEERING LIGHT CONTINUED TO SHOW ON THE INFORMATION PANEL. THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR REPAIR AND THE STEERING COLUMN WAS REPLACED. NO FURTHER INFORMATION MESSAGE CONCERNING THE POWER STEERING HAS BEEN SEEN SINCE THE REPAIR. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10461103June 9, 2012
ELECTRICAL SYSTEM, ENGINE, ELECTRICAL SYSTEM:IGNITION
SINCE PURCHASING THE VEHICLE (USED), THERE HAVE BEEN MORE THAN 12 INSTANCES WHERE THE CAR CUTS OUT WHILE DRIVING. THIS HAS OCCURRED AT SPEEDS AS HIGH AS 55 MPH. THERE IS A TOTAL LOSS OF POWER AND THE CAR MUST BE BROUGHT TO A ROLLING STOP OUTSIDE OF THE TRAFFIC FLOW. ALSO, THERE HAVE BEEN WEEKLY INSTANCES OF THE CAR FAILING TO START. THIS HAS SINCE INCREASED TO DAILY. THE KEY WILL ONLY START THE IGNITION WHEN THE DASH LIGHTS (BATTERY, OIL, ETC) ARE ON, AND THEY ARE ON AND OFF COMPLETELY AT RANDOM. SOMETIMES I HAVE TO WAIT UP TO 10 MINUTES WITH THE KEY PARTIALLY TURNED BEFORE THE LIGHTS COME ON AND I CAN TURN IT THE REST OF THE WAY AND START THE CAR. THE OTHER ELECTRICAL ISSUE THAT HAS HAPPENED IS THAT THE BLOWER FAN HAS GONE ON AND OFF AND THE POWER WINDOWS HAVE GONE ON AND OFF. *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10460837June 6, 2012
STEERING
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 35 MPH, THE POWER STEERING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT STATED THAT THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 208,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10459825May 28, 2012
SEATS
WAS BACKING OUT OF PARKING SPACE AND HEARD A METALLIC CLANK FROM UNDER THE DRIVER SEAT. THE SEAT TIPPED BACK AND TO THE RIGHT, AS IF THE RIGHT REAR CORNER OF THE SEAT IS NO LONGER SUPPORTED. THE CAR IS NOT SAFE TO DRIVE, AS THE SEAT MOVES AROUND FREELY AND WOULD NOT BE AS SAFE IN AN ACCIDENT. AFTER A VERY SHORT INTERNET SEARCH, I FOUND THIS IS A VERY COMMON PROBLEM TO THIS MODEL AND YEAR. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10459678May 25, 2012
STEERING
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 5 MPH, THE POWER STEERING WARNING LIGHT ILLUMINATED BUT THE POWER STEERING ASSIST WAS NOT AFFECTED. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTICS. THE MECHANIC ADVISED THE CONTACT THAT THE BATTERY COULD POSSIBLY HAVE BEEN CAUSING THE FAILURE. THE BATTERY WAS REPLACED BUT THE FAILURE PERSISTED. THE VEHICLE WAS NOT FURTHER REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 119,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10459175May 21, 2012
STEERING
I PURCHASED MY VEHICLE BRAND NEW IN AUGUST 2004. THE POWER STEERING WENT WHILE I WAS TURNING ON TO A STREET IN I BELIEVE DECEMBER 2004. IT WAS TAKEN TO THE DEALERSHIP AND THE STEERING COLUMN WAS SUPPOSEDLY REPLACED. A COUPLE OF MONTHS LATER, THE SAME THING HAPPENED AGAIN. WHEN I TOOK THE CAR TO THE DEALERSHIP AGAIN, I QUESTIONED WHY IT WAS NOT RECALLED AT THE TIME, SINCE THIS WAS THE SECOND TIME IT HAPPENED. I WAS ADVISED THAT IT WAS A BAD BATCH OF STEERING BOOTS AND THERE WERE NOT ENOUGH PROBLEMS TO REPLACE THEM. AGAIN, THE STEERING COLUMN WAS SUPPOSEDLY REPLACED. ALL SEEMED TO BE FINE UNTIL I BELIEVE DECEMBER 2010. THE STEERING WENT AGAIN. I CONTACTED THE DEALERSHIP AND GM TO SEE WHAT COULD BE DONE. I WAS ADVISED THAT MY PROBLEM HAD BEEN TAKEN CARE OF IN 2004/2005 AND THERE WAS NOTHING THEY COULD DO. I TOOK THE CAR TO A LOCAL MECHANIC WHO HAD TO REPLACE EVERYTHING ONCE AGAIN. THIS TIME IT COST ME OVER $1500. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10458258May 13, 2012
SEATS
THE DRIVERS SEAT RIGHT SIDE DROPPED SUDDENLY. MY INSPECTION REVEALED A WELD TO A STRUCTURAL MEMBER FAILED. THE STRUCTURAL MEMBER ACTUALLY FAILED IN THE WELD HEAT AFFECTED ZONE. THE WALL THICKNESS OF THE STRUCTURAL MEMBER WAS A TUBE WITH INADEQUATE WALL THICKNESS FOR THE DESIGN. I AM A CIVILIAN NUCLEAR ENGINEER FOR THE DOD (NAVY) AND CAN SEND A DIGITAL IMAGE OF THE FAILED PART. IT APPEARS FROM AN INTERNET SEARCH THAT THIS IS NOT AN UNCOMMON FAILURE AS I WOULD EXPECT FROM MY INSPECTION. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10458191May 12, 2012
SEATS
THE DRIVER SEAT LEANS DUE TO THE FACT THAT THE WELDS BREAK. THE FRONT AND THE REAR SUPPORTS BROKE. I HAVE READ THIS HAPPENS TO MOST OF THE SEAT. THEY DON'T MAKE A REPLACEMENT FRAME AND THEREFORE WANT ME TO BUY A WHOLE SEAT AT A COST OF 800 JUST FOR THE SEAT. SO HERE I AM TO SAY THIS ISN'T RIGHT AND I'D LIKE TO HAVE THIS FIX AT THERE EXPENSE SINCE THEY WANT TO MAKE ME BUY THE WHOLE THING AND NOT JUST A FRAME. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10456627April 26, 2012
STEERING
I WAS DRIVING AND THE POWER STEERING FLASHED ON DASHBOARD. AFTER THAT MY STEERING WHEEL LOCKED UP. I HAD TO PULL OVER CAUSE I COULD TURN STEERING WHEEL AT ALL. I TURNED MY CAR OFF AND RESTARTED THE STEERING WHEEL WAS BACK TO NORMAL. I AM UNDERSTANDING WHY THIS IS NOT A RECALL THIS VERY MUCH A SAFETY CONCERN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10456000April 21, 2012
SEATS, SEAT BELTS
THE WELDS ON THE DRIVER SEAT FRAME BREAK. I FIRST NOTICED THIS IN FEBRUARY 2010 WHEN MY SEAT WOULD RAISE AT AN ANGLE. RECENTLY I WAS CLEANING MY CAR AND I NOTICED THE SEAT BELT WAS NOT ATTACHED SECURELY. THE WELD HOLDING THE SEAT BELT TO THE SEAT FRAME HAD CRACKED AND BROKEN FREE. I FOUND A USED SEAT AND WHEN IT WAS DELIVERED, THIS SEAT HAD THE SAME EXACT PROBLEMS, MULTIPLE WELDS ON THE SEAT FRAME THAT ARE CRACKED AND BROKE. THIS FRAME IS CRITICAL TO THE SAFETY OF THE DRIVER. THIS WEBSITE SHOWS THAT THERE ARE MANY MORE COMPLAINTS OF REGARDING THE SAME DEFECT. HTTP://WWW.ARFC.ORG/COMPLAINTS/2005/CHEVROLET/MALIBU_MAXX/SEATS/PROBLEM.ASPX THERE ARE MORE PLACES ONLINE TALKING ABOUT THIS VERY ISSUE. MY CAR HAS 55000 MILES ON IT. I AM 150LBS. THESE WELDS SHOULD NOT BE BREAKING SO EASY, AND SO PREMATURELY. *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10455375April 16, 2012
STEERING
TL* THE CONTACT OWNS A 2004 MALIBU MAXX. THE CONTACT STATED THAT WHILE TURNING AT 3 MPH, THE STEERING WHEEL SEIZED AND WAS DIFFICULT TO MANEUVER. THE VEHICLE WAS STOPPED AND SHUT OFF. THE STEERING WHEEL FUNCTIONED AS NORMAL UPON RESTART. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHERE THEY STATED THAT THE STEERING COLUMN NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 89,000 AND THE CURRENT MILEAGE WAS 89,050.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10454851April 11, 2012
STEERING
MY WIFE WAS DRIVING DOWN THE ROAD AND ALL OF A SUDDEN THERE WAS NO POWER STEERING. SHE WEIGHS 110 POUNDS AND COULD NOT STEER IT AT ALL. WHAT IF SHE WAS GOING 70 MPH? I HAVE READ ALL OF THE COMPLAINTS BUT GMC DECIDES NOT TO RECALL THIS YEAR BUT RECALL 2005? THAT IS A AWFUL WAY OF DOING BUSINESS. HOW MANY PEOPLE HAVE TO BE INJURED OR DIE BEFORE THEY FIX THIS? I WANT ANSWERS BECAUSE THIS IS NOT A COUPLE OF PEOPLE THAT IT HAPPENS TO. THIS IS CRAP! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10454777April 10, 2012
STEERING
THIS WAS APPROXIMATELY THE FIRST TIME SINCE WE HAD THE PROBLEM FIXED UNDER THE WARRANTY WHEN WE FIRST PURCHASED THE VEHICLE. THE POWER STEERING JUST WENT OUT ON MY WIFE WHILE SHE WAS MAKING A LEFT TURN INTO A PARKING LOT AND DIDN'T HAVE FULL CONTROL OF THE CAR AND ALMOST GOT INTO AN ACCIDENT. IT HAS SINCE HAPPENED TO MY DAUGHTER ONCE ABOUT THREE WEEKS AFTER MY WIFE'S EXPERIENCE. NOW IT JUST HAPPENED TO MY WIFE AGAIN ON 4-10-12 AT MILEAGE 144216 APPROX. THIS TIME SHE WAS IN THE PARKING LOT AND IT WENT OUT CAUSING HER TO NOT HAVE COMPLETE CONTROL AGAIN JUST MISSING GETTING INTO AN ACCIDENT. IT DOES COME BACK ON AFTER TURNING OFF THE VEHICLE AND LETTING IT SIT. MY MAIN CONCERN IS THAT IT JUST GOES OUT WITHOUT ANY WARNING AND DOESN'T ALLOW THE DRIVER TO HAVE COMPLETE CONTROL OF STEERING THE CAR BECAUSE IT IS EXTREMELY HARD TO STEER WITHOUT THE POWER STEERING IF THEY CAN STEER IT AT ALL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Malibu