Chevrolet Cavalier Complaints (2004)

330 consumer complaints on file.

#10442249January 3, 2012
VISIBILITY
TL* THE CONTACT OWNS A 2004 CHEVROLET CAVALIER. THE CONTACT STATED THAT THE FRONT DRIVER AND PASSENGER SIDE WINDOWS COULD ONLY BE CLOSED PARTIALLY. THE REAR DRIVER AND PASSENGER WINDOWS COULD NOT BE OPENED OR CLOSED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO LOCATED THE FAILURE AT THE DOOR MOTOR AND REGULATOR. THE MOTORS AND THE REGULATORS WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 83,000 AND THE CURRENT MILEAGE WAS 90,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10441771December 30, 2011
ELECTRICAL SYSTEM
MY SPEEDOMETER STOPPED WORKING. APPARENTLY I'M NOT THE ONLY ONE THIS HAS HAPPENED TO. I'VE BEEN READING A FORUM ON HTTP://WWW.CARCOMPLAINTS.COM/CHEVROLET/CAVALIER/2004/ACCESSORIES-INTERIOR/SPEEDOMETER_STOPPED_WORKING.SHTML AND BETWEEN THE MILEAGE RANGE OF 30,000 AND 50,000 THIS HAS HAPPENED TO SIGNIFIGANT AMOUNT OF PEOPLE BY NO FAULT OF THEIR OWN. THIS IS EXTREMELY DANGEROUS FOR PEOPLE WHO HAVE NO WAY TO AFFORD GETTING IT FIXED AND CHEVROLET SHOULD BE LIABLE TO FIX THIS ISSUE. THEY CANNOT EXPECT TO CHARGE UPWARDS OF $500.00 TO REPAIR SOMETHING THAT WAS POORLY MANUFACTURED. *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10436212November 17, 2011
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
THE SPEEDOMETER SHOWS INCORRECT SPEED WHILE MOVING OR SPEED WHILE PARKED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10435290November 11, 2011
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS, ELECTRICAL SYSTEM
THE POWER WINDOWS DON'T WORK . THE GAUGES DON'T WORK ONLY GAUGE THAT'S WORKS IS THE TACHOMETER FROM MY RESEARCH THESE ARE TWO COMMON PROBLEMS WITH THESE CAVALIERS THE WINDOWS IS MORE OF A CONVENIENCE PROBLEM BUT THE GAUGES NOT WORKING IS A SAFETY PROBLEM CHEVROLET SHOULD HAVE TO MAKE THIS RIGHT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10434410November 6, 2011
VEHICLE SPEED CONTROL, UNKNOWN OR OTHER
I HAVE HAD MULTIPLE PROBLEMS WITH THE SPEED ODOMETER IN THIS CAR. I CAN SEE BY SEVERAL COMPLAINTS ON CARCOMPLAINT.COM I AM ONLY 1 OUT OF SEVERAL HUNDRED. IT WILL SOMETIMES SAY I AM GOING 100 WHEN I AM GOING 25. IT WILL SOMETIMES STAY STUCK ON 55 WHEN I AM AT A COMPLETE STOP. I NEVER KNOW HOW FAST I AM GOING. THIS IS VERY DANGEROUS AND COULD RESULT IN AN ACCIDENT OR EVEN DEATH OF ME OR SOMEONE ELSE. THIS IS VERY EXPENSIVE TO HAVE REPLACED AND BY OTHER PEOPLES COMPLAINTS TO ME IT SOUNDS LIKE A DAD PART PRODUCED BY GM. I FEEL THAT GM SHOULD RECALL THESE AND HAVE THEM REPLACED BEFORE IT RESULTS IN A DEATH OF SOMEONE. I WILL NEVER BUY ANOTHER GM VEHICLE IF THEY DON'T RECALL THESE PARTS AND REPLACE THEM SINCE THERE ARE SO MANY PEOPLE OUT THERE WITH THE SAME PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10433525October 29, 2011
ELECTRICAL SYSTEM
SPEEDOMETER FIRST BEGAN TO MALFUNCTION, FOLLOWED BY ALL OTHER GAUGES. NO GAUGES WORK PROPERLY NOW. SPEED IS UNKNOWN, RPMS IS UNKNOWN, AMOUNT OF GAS IN TANK IS UNKNOWN, PROPER FUNCTION OF ENGINE IS UNKNOWN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10433122October 28, 2011
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 2004 CHEVROLET CAVALIER. THE CONTACT WAS ENTERING AN ON-RAMP AND SLIGHTLY APPLIED THE BRAKES WHEN THE VEHICLE ABNORMALLY ACCELERATED. THE CONTACT PULLED OVER ONTO THE SHOULDER AND WAS FORCED TO SHIFT THE VEHICLE INTO PARK WHILE THE VEHICLE WAS STILL MOVING IN ORDER TO STOP THE VEHICLE COMPLETELY. THE MANUFACTURER WAS NOT CONTACTED. THE DEALER WAS MAKING AN ATTEMPT TO ASSIST THE CONTACT WITH DIAGNOSING AND REPAIRING THE DEFECT. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 117,379 AND THE CURRENT MILEAGE WAS 117,460.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10430395October 16, 2011
VEHICLE SPEED CONTROL, ENGINE AND ENGINE COOLING
CAR WILL ACCELERATE ON IT'S OWN USUALLY OCCURS WHILE SLOWING DOWN OR WHILE MAKING A TURN PRESSING THE BRAKE HARD SLOWS THE CAR BUT IT CONTINUES TO APPLY POWER WHAT STOPS THE ENGINE FROM CONTINUING TO ACCELERATE IS TO PUSH THE CLUTCH IN, AT THE MOMENT THE ENGINE WILL ACCELERATE TO 6500 RPM THEN RETURN TO NORMAL LIKE IT IS COMPLETING SOME CYCLE. IT IS VERY DANGEROUS IN THE WINTER. WE HAVE EXPECTED A RECALL BUT NOTHING. I CAN GUARANTEE A LAWSUIT IF MY WIFE AND KIDS ARE INJURED. THIS IS A TRUE CASE OF SUDDEN ACCELERATION THAT THE FEDS CAN INVESTIGATE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10429608October 12, 2011
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL, VEHICLE SPEED CONTROL, ELECTRICAL SYSTEM
SPEEDOMETER STUCK AT 60MPH. ITS NOT THAT OLD OF A CAR AND ONLY HAS 58 THOUSAND MILES ON IT THIS SHOULD BE A RECALL WITH ALL THE PEOPLE COMPLAINING THE SAME THING HAPPENED WITH THE LOW MILES RIDICULOUS! *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10428724October 4, 2011
FUEL SYSTEM, GASOLINE, ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
AS SOON AS THIS CAR REACHED @50,000 MILES, THE SPEEDOMETER AND FUEL GAUGES STOPPED WORKING. UPON CHECKING WITH A CHEVROLET DEALER, I WAS INFORMED THAT THE ENTIRE DASHBOARD NEEDS TO BE DISMANTLED AND NEW GAUGES INSTALLED BY AN OUTSIDE SOURCE, WHEREUPON CAR IS RETURNED TO DEALERSHIP AND ODOMETER IS RESET TO CORRECT MILEAGE. COST IS APPROXIMATELY $400.00 AND UP. UPON RESEARCH, I FOUND THIS TO BE A COMMON COMPLAINT. THIS IS A SAFETY HAZARD BECAUSE YOU CANNOT TELL HOW FAST YOU ARE DRIVING AND IF YOU HAVE ENOUGH FUEL. ALSO, FUEL GAUGE NEEDLE GOES HAYWIRE WHEN I FILL UP. THE NEEDLE GOES INTO THE GAUGE THAT TELLS YOU IF YOUR CAR IS RUNNING HOT - PREVENTING THAT NEEDLE FROM OPERATING PROPERLY. TO MY KNOWLEDGE NO RECALL HAS BEEN ISSUED REGARDING THESE PROBLEMS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10425840September 17, 2011
UNKNOWN OR OTHER, POWER TRAIN
REPLACED DEFECTIVE SHIFTER CONTROL CABLE. I HAVE A 2004 CHEVY CAVALIER, 4 CYLINDER ENGINE, MILEAGE: 40,850.I AM THE ORIGNIAL OWNER, PURCHASED IT NEW FROM CHEVROLET. I BECAME AWARE OF THE DEFECT WHEN I CAME OUT OF WORK AND WENT TO MY PARKED CAR, STARTED THE CAR, AND WHEN I SHIFTED MY AUTOMATIC TRANSMISSION LEVER, THE CAR WOULD NOT MOVE. NONE OF THE GEARS WERE WORKING. I HAD TO CALL A TOW TRUCK AND WAIT OVER TWO HOURS AND HAD IT TOWED TO A CHEVROLET DEALER 10 MILES AWAY FOR DIAGNOSIS AND REPAIR. IT COST ME OVER $400.00 TO GET IT REPAIRED BY THE CHEVROLET DEALER. I ASKED CHEVROLET IF THERE WAS A RECALL ON THE SHIFTER CONTROL CABLE AND HE SAID THERE WAS NONE THAT HE KNEW OF. I SEARCHED THE INTERNET FOR SOME INFORMATION ON THE SHIFTER CONTROL CABLE AND FOUND NUMEROUS COMPLAINTS ON THE SAME THING HAPPENING TO THEM WITH THE SAME TYPE CAR. THIS CAR SHOULD BE RECALLED BY GENERAL MOTORS - CHEVROLET DIVISION. THIS IS A VERY DANGEROUS THING TO HAPPEN TO ANYONE. I COULD HAVE BEEN ON THE ROAD OR PARKED ON A HILL WHICH MIGHT HAVE CAUSED HARM TO ME OR ANY OTHER DRIVER OF MY CAR. *TT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10424030September 7, 2011
ENGINE AND ENGINE COOLING, VEHICLE SPEED CONTROL
WHEN DRIVING MY CAR AT TIMES, IT WILL ACCELERATE ON IT'S OWN, CAUSING IT TO RUN RPMS INTO THE RED, NEED TO SHUT CAR OFF SO IT DOES NOT EXCEL ON IT'S OWN. THIS HAS ONLY HAPPENED A FEW TIMES.. VERY DANGEROUS, THE 1ST TIME WAS IN DEC, 2010 IN AN ICE STORM, SO I THOUGHT IT WAS JUST A FLUKE AND IT WAS FROZEN NOW IT IS IN THE 80S AND IT DID IT YESTERDAY SEPT 6TH 2011 WHAT IS CAUSING THIS??? IS IT A DEFECT??? ANYONE ELSE HAVE THIS??? *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10421204August 23, 2011
VEHICLE SPEED CONTROL
GAS PEDAL ASSEMBLY COMING LOOSE FROM 2004 CHEVY CAVALIER WITH 70K MILES. NO PART AVAILABLE IN THE US. GM STOPPED MAKING THIS ASSEMBLY. THIS HAPPENED AT FREEWAY SPEEDS. GM WILL NOT HELP ME. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10419675August 16, 2011
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL, ELECTRICAL SYSTEM
WELL I HAVE A 2004 CHEVY CAVALIER AND THE SPEEDOMETER DOESN'T WORK. I WOULD GET OIL CHANGES AND TIRES ROTATED AND NOTICE SMALL DIFFERENCES THEN OUT OF NO WERE IT JUST WOULD NOT WORK. IT STUCK ON 110 AND THE TEMP IS OFF TOO. ALSO IT DOES NOT TELL YOU HOW MUCH GAS YOU HAVE. OVER ALL THE WHOLE BOARD SEEMS TO BE NOT WORKING. I HAVE HAD THIS PROBLEM FOR AT LEAST TWO YEARS PEOPLE TELL ME THEY DONT KNOW WHAT IT IS OTHERS TELL ME IT COST 700- 900 DOLLARS TO FIX. *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10416800August 2, 2011
VEHICLE SPEED CONTROL, ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
I HAVE A 2004 CHEVY CAVALIER AND THE SPEEDOMETER STICKS. IT SAY"S I AM DOING 80MPH WHEN I AM ACTUALLY DOING 40MPH. AND WHEN I AM PARKED IT SAY"S I AM DOING 50MPH. *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10415586July 29, 2011
ENGINE AND ENGINE COOLING
MY 2004 CHEVY CAVALIER HAS SUFFERED A NUMBER OF DEFECTS SINCE ITS PURCHASE. WHILE THEY DID NOT RESULT IN ANY COLLISIONS OR INJURIES, THEY EASILY COULD HAVE. AT 10,211 MILES (8/31/2004) THE WATER PUMP FAILED; LUCKILY, THIS WAS COVERED UNDER WARRANTY, AND THE PUMP, ALONG WITH SEVERAL SEALS AND GASKETS WERE REPLACED. AT 29,522 MILES (5/23/2005), WHITE SMOKE BEGAN BILLOWING OUT OF THE EXHAUST. MULTI CHEVROLET IN UNION, NJ DISCOVERED THAT A CYLINDER HEAD WAS DEFECTIVE, THE HEAD GASKETS WERE CRACKED, AND THE TIMING CHAIN NEEDED TO BE REPLACED. THESE REPAIRS WERE AGAIN COVERED BY THE WARRANTY AT 48,241 MILES (6/9/2006), THE INSTRUMENT CLUSTER AND A SUSPENSION BEAM FAILED. LUCKILY, WE HAD PURCHASED AN EXTENDED WARRANTY, AND THE REPAIRS WERE AGAIN COVERED. FINALLY, AT 74,000 MILES (5/10/10), THE VEHICLE SUFFERED CATASTROPHIC ENGINE FAILURE. LUCKILY, MY SON [XXX] WAS DRIVING ON A LOCAL ROAD, AND WAS ABLE TO PULL OVER SAFELY. AFTER HAVING THE VEHICLE TOWED, [XXX], SERVICE MANAGER OF BILL DEFOUW CHEVROLET IN LAFAYETTE, INDIANA, INFORMED US THAT EVERY LIFTER WAS BROKEN AND EVERY VALVE WAS BENT, AND THE PISTONS WERE IRREPARABLY DAMAGED AS WELL. BECAUSE THE VEHICLE IS OUTSIDE OF WARRANTY, GM HAS REFUSED TO REPLACE THE ENGINE, AND WE CANNOT AFFORD TO DO SO OUT OF POCKET. WE ARE REPORTING THIS IN CASE OTHER BUYERS OF THIS MODEL/YEAR OR LATER HAVE EXPERIENCED ISSUES, AND ARE CURRENTLY DRIVING UNSAFE VEHICLES. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10413088July 15, 2011
ELECTRICAL SYSTEM, EQUIPMENT:ELECTRICAL
MY 2004 CHEVROLET CAVALIER GAUGES QUIT WORKING. I HAVE BEEN ONLINE AND DONE SOME RESEARCH AND I AM NOT THE ONLY ONE WITH THIS PROBLEM. THEY HAVE MANY PEOPLE THAT HAVE COMPLAINED ABOUT IT. PLEASE DO A RECALL SO WE CAN GET THIS PROBLEM FIXED. ONCE MY WARRANTY OF 30 DAYS WAS UP THAT'S WHEN EVERYTHING QUIT WORKING. *TT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10410711July 6, 2011
ELECTRICAL SYSTEM
OWN 2004 CHEVY CAVALIER WITH 62,000 MILES ON IT. AT 25,000 MI THE INSTRUMENT PANEL STOPPED WORKING CORRECTLY I CONTACTED GM AND WAS TOLD TO TAKE CAR TO DEALER AND HAVE IT CHECKED AT A COST OF 100.00 AND IF IT WAS A CLUSTER THEY MIGHT PAY FOR REPAIRS. THE SPEEDOMETER NEEDLE GOES OVER PAST 110 MI WHEN I AM DOING 20 MPH, THE GAS GAUGE WILL SIT ON EMPTY WHEN THERE IS A HALF TANK, I DID SOME RESEARCH AND FOUND OUT THAT GM RECALLED TRUCKS WITH THIS PROBLEM BUT DID NOT INCLUDE CARS, THIS HAD TO BE DONE BEFORE 70,000 MILES. I THINK THEY SHOULD RECALL CARS AND FIX THE PROBLEM AT ONCE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10410117June 30, 2011
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
I HAVE A 2004 CHEVY CAVALIER AND ONE BY ONE ALL THE GAUGES HAVE STOPPED WORKING. IN DOING SOME RESEARCH I HAVE FOUND THIS IS A VERY COMMON PROBLEM WITH THIS MAKE AND MODEL. IT IS A SAFETY ISSUE NOT TO HAVE A SPEEDOMETER!! I ALSO DO NOT HAVE AN RPM GAUGE, GAS GAUGE OR HEAT GAUGE. THERE NEEDS TO BE A RECALL!!!!! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10409381June 29, 2011
VEHICLE SPEED CONTROL
ACCELERATOR STUCK ON 2004 CHEVY CAVALIER. ENGINE WAS WIDE OPEN AND GAS PEDAL WAS DOWN TO FLOOR. GOT CAR OFF ROAD WITH NO INCIDENT. CABLE WAS FOUND TO BE FRAYED FROM CORROSION AND STUCK INSIDE HOUSING. CALLED GM AND RECEIVED NO ASSISTANCE . THEY SAID VEHICLE WAS OUT OF WARRANTY. REPLACE WITH NEW CABLE AT REPAIR SHOP. THIS SHOULD NEVER HAPPEN ON A MODERN ERA VEHICLE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Cavalier